Transcutaneous immunization of domestic animals: opportunities and challenges

Effect of transcutaneous immunization with co-administered antigen and cholera toxin on systemic and mucosal antibody responses in sheep

Direct application of antigens to skin together with an adjuvant, a procedure called transcutaneous immunization (TCI), can induce systemic immune responses in mice, humans, cats and dogs. In previous studies we found that cholera toxin (CT) applied topically on unbroken skin induces systemic antibody and lymphocyte proliferative responses in sheep. The current study examined whether concurrent administration of CT and tetanus toxoid (TT) delivered transcutaneously could induce specific antibody responses to both antigens in sheep. Antibodies to both TT and CT were induced by TCI although antibody titres in serum to TT were higher in sheep receiving TT plus alum by intramuscular injection (n=5) than TT plus CT by TCI (n=5). The ratio of IgG1/IgG2 antibody to TT in serum was near unity, and the route of immunization, TCI versus injection, did not influence this ratio. In contrast, the ratio of IgG1/IgG2 antibody differed significantly between the two antigens, TT and CT, delivered by TCI, with a higher proportion of IgG1 antibody in serum to CT than TT. Antibody to TT was detected in lung washes from TCI and injection groups, with IgG1 predominating over IgG2 in both groups. IgA antibodies to CT and TT were detected in sera of CT and TT-immunized groups respectively but in lung washes IgA antibody to TT was detected only in the injection group. Results show that TCI induced systemic antibody responses to CT and the co-administered antigen TT, whereas no evidence was obtained for mucosal IgA responses following TCI.

Comparison of mucosal and systemic humoral immune responses after transcutaneous and oral immunization strategies

In order to compare the ability of transcutaneous and oral immunization strategies to induce mucosal and systemic immune responses, we inoculated mice transcutaneously with cholera toxin (CT) or the non-toxic B subunit of cholera toxin (CtxB), or orally with Peru2(pETR1), an attenuated vaccine strain of Vibrio cholerae expressing CtxB. In addition, we also evaluated dual immunization regimens (oral inoculation with transcutaneous boosting, and transcutaneous immunization with oral boosting) in an attempt to optimize induction of both mucosal and systemic immune responses. We found that transcutaneous immunization with purified CtxB or CT induces much more prominent systemic IgG anti-CtxB responses than does oral inoculation with a vaccine vector strain of V. cholerae expressing CtxB. In comparison, anti-CtxB IgA in serum, stool and bile were comparable in mice either transcutaneously or orally immunized. Overall, the most prominent systemic and mucosal anti-CtxB responses occurred in mice that were orally primed with Peru2(pETR1) and transcutaneously boosted with CT. Our results suggest that combination oral and transcutaneous immunization strategies may most prominently induce both mucosal and systemic humoral responses.

Topical immunization using nanoengineered genetic vaccines

DNA vaccines have been shown to elicit both broad humoral and cellular immune responses. Needle-free injection devices and the gene gun have been used to deliver these DNA vaccines to dendritic cells in the viable skin epidermis with some success. However, more cost-effective and dendritic cell (DC)-targeted immunization strategies are sought. To this end, a nanoengineered genetic vaccine for simple topical application was developed. Expressed beta-galactosidase was used as a model antigen. Plasmid DNA was coated on the surface of preformed cationic nanoparticles engineered directly from warm oil-in-water (O/W) microemulsion precursors comprised of emulsifying wax as the oil phase and CTAB as a cationic surfactant. Mannan, a DC ligand, was coated on the nanoparticles with and without entrapped endosomolytic agents, dioleoyl phosphatidylethanolamine (DOPE) and cholesterol. In-vitro cell transfection studies were performed to confirm transgene expression with these pDNA-coated nanoparticles. An in-vitro Concanavalin A (ConA) agglutination assay confirmed the presence of mannan on the surface of nanoparticles. The humoral and proliferative immune responses were assessed after topical application of these nanoengineered systems to the skin of shaved Balb/C mice. All pDNA-coated nanoparticles, especially the mannan-coated pDNA-nanoparticles with DOPE, resulted in significant enhancement in both antigen-specific IgG titers (16-fold) and splenocyte proliferation over 'naked' pDNA alone.

Transcutaneous immunization using colonization factor and heat-labile enterotoxin induces correlates of protective immunity for enterotoxigenic Escherichia coli

Enterotoxigenic Escherichia coli (ETEC) diarrheal disease is a worldwide problem that may be addressed by transcutaneous delivery of a vaccine. In several human settings, protective immunity has been associated with immune responses to E. coli colonization factors and to the heat-labile toxin that induces the diarrhea. In this set of animal studies, transcutaneous immunization (TCI) using recombinant colonization factor CS6 and cholera toxin (CT) or heat-labile enterotoxin (LT) as the adjuvant induced immunoglobulin G (IgG) and IgA anti-CS6 responses in sera and stools and antibody responses that recognized CS6 antigen in its native configuration. The antitoxin immunity induced by TCI was also shown to protect against enteric toxin challenge. Although immunization with LT via the skin induced mucosal secretory IgA responses to LT, protection could also be achieved by intravenous injection of the immune sera. Finally, a malaria vaccine antigen, merzoite surface protein 1(42) administered with CT as the adjuvant, induced both merzoite surface protein antibodies and T-cell responses while conferring protective antitoxin immunity, suggesting that both antiparasitic activity and antidiarrheal activity can be obtained with a single vaccine formulation. Overall, our results demonstrate that relevant colonization factor and antitoxin immunity can be induced by TCI and suggest that an ETEC traveler's diarrhea vaccine could be delivered by using a patch.

Simulated solar UVB exposure inhibits transcutaneous immunization to cholera toxin via an irradiated skin site in cattle

Transcutaneous immunization (TCI) is a new needle-free vaccination technology with the potential to reduce the risk of needle-borne disease transmission and carcass damage within the livestock industries. The principal antigen-presenting cell involved in TCI is thought to be the epidermal Langerhans cell. Langerhans cell function is inhibited by cutaneous ultraviolet-B radiation (UVB) exposure. Such exposure may inhibit TCI through sun exposed skin sites due to the phenomenon of local low dose photoimmunosuppression. TCI of cattle to cholera toxin (CT) resulted in the generation of a serum anti-CT-specific IgG(2) response. However, exposure of cattle to a sub-inflammatory dose of simulated solar UVB (2.43 x 10(3)J/m(2)) significantly (P<0.05) inhibited TCI to CT via irradiated skin sites.

Transcutaneous immunization: T cell responses and boosting of existing immunity

Transcutaneous immunization (TCI) is a novel immunization strategy by which antigen and adjuvant are applied topically to intact, hydrated skin to induce potent antibody and cell-mediated immune responses specific for both the antigen and the adjuvant. Using tetanus toxoid as a model antigen, we examined the T cell response to tetanus toxoid after topical immunization with a variety of adjuvants. TCI readily induced systemic antigen specific T cell responses with a mixed Th1/Th2 phenotype but with a Th2 bias. We also investigated whether priming by the intramuscular route, which is known to induce T cell memory, could be followed by a boosting immunization on the skin to induce secondary responses. TCI could augment existing immunity, but interestingly, this strategy induced potent responses only if the antibody titer was low at the time of TCI boosting. These and previous observations suggest that TCI follows known immunological principles that govern other routes of vaccine delivery. Furthermore, booster immunization using tetanus toxoid may provide a useful model for further development of important patch and formulation concepts for TCI, and act as an early candidate for validating product feasibility of TCI in humans.

Transcutaneous immunization with bacterial ADP-ribosylating exotoxins, subunits, and unrelated adjuvants

We have recently described a needle-free method of vaccination, transcutaneous immunization, consisting of the topical application of vaccine antigens to intact skin. While most proteins themselves are poor immunogens on the skin, we have shown that the addition of cholera toxin (CT), a mucosal adjuvant, results in cellular and humoral immune responses to the adjuvant and coadministered antigens. The present study explores the breadth of adjuvants that have activity on the skin, using diphtheria toxoid (DTx) and tetanus toxoid as model antigens. Heat-labile enterotoxin (LT) displayed adjuvant properties similar to those of CT when used on the skin and induced protective immune responses against tetanus toxin challenge when applied topically at doses as low as 1 microg. Interestingly, enterotoxin derivatives LTR192G, LTK63, and LTR72 and the recombinant CT B subunit also exhibited adjuvant properties on the skin. Consistent with the latter finding, non-ADP-ribosylating exotoxins, including an oligonucleotide DNA sequence, as well as several cytokines (interleukin-1beta [IL-1beta] fragment, IL-2, IL-12, and tumor necrosis factor alpha) and lipopolysaccharide also elicited detectable anti-DTx immunoglobulin G titers in the immunized mice. These results indicate that enhancement of the immune response to topical immunization is not restricted to CT or the ADP-ribosylating exotoxins as adjuvants. This study also reinforces earlier findings that addition of an adjuvant is important for the induction of robust immune responses to vaccine antigens delivered by topical application.