Relationships between kernel vitreousness and dry matter degradability for diverse corn germplasm

Effects of exogenous α-amylases, glucoamylases, and proteases on ruminal in vitro dry matter and starch digestibility, gas production, and volatile fatty acids of mature dent corn grain

Two separate experiments were carried out to evaluate the effects of incremental doses of 10 exogenous endo-acting α-amylase and exo-acting glucoamylase; 1LAT (bacterial α-amylase), 2AK, 3AC, 4Cs4, 5Trga, 6Afuga, 7Fvga, and 10Tg (fungal α-amylases, glucoamylases, and α-glucosidase), 8Star and 9Syn (fungal amylase-mixtures; experiment 1) and three exogenous proteases; 11P14L, 12P7L, and 13P30L (bacterial proteases; experiment 2) on in vitro dry matter digestibility (IVDMD) and in vitro starch digestibility (IVSD) of mature dent corn grain using a batch culture system. Incremental doses of the exogenous enzymes (0, 0.25, 0.50, 0.75, and 1.00 mg/g of dried substrate) were applied directly to the substrate (0.5 g of ground corn, 4 mm) in sextuplicate (experiment 1) or quadruplicate (experiment 2) within F57 filter bags, which were incubated at 39 °C in buffered rumen fluid for 7 h. Rumen fluid was collected 2-3 h after the morning feeding from three lactating dairy cows and pooled. Cows were consuming a midlactation total mixed ration (TMR; 1.60 Mcal/kg DM and 15.4%; net energy of lactation and crude protein, respectively). Three independent runs were carried out for each experiment. Data were analyzed as a randomized complete block design using run as the blocking factor. Dose was used as a fixed factor while run was considered a random factor. Linear, quadratic, and cubic orthogonal contrasts were also tested. In experiment 1, enzymes 2AK, 3AC, and 10Tg did not increase (P > 0.10) IVDMD and IVSD, whereas 0.25 mg of enzymes 1LAT, 5Trga, and 8Star increased (P < 0.01) IVDMD by 23%, 47%, and 62% and IVSD by 35%, 41%, and 58%, respectively, compared with the control. Enzymes 4Cs4, 6Afuga, 7Fvga, and 9Syn linearly increased IVDMD and IVSD (P < 0.01). Greatest increases in IVDMD (82.9%) and IVSD (85.9%) resulted with 1 mg of 6Afuga compared to control. In experiment 2, the lowest dose of exogenous proteases 11P14L and 12P7L increased (P < 0.01) IVDMD by 98% and 87% and IVSD by 57% and 64%, respectively, whereas the highest dose of 13P30L increased (P = 0.02) IVDMD by 44.8% and IVSD by 30%, relative to the control. In conclusion, IVSD and IVDMD were increased by one α-amylase, certain glucoamylases, and all proteases tested, with the glucoamylase 6Afuga in experiment 1 and the neutral protease 12P7L in experiment 2, increasing IVDMD and IVSD to the greater extents. Future in vivo studies are required to validate these findings before these enzyme additives can be recommended for improving the digestibility of mature dent corn grain.

Effects of processing, moisture, and storage length on the fermentation profile, particle size, and ruminal disappearance of reconstituted corn grain

Our objective was to examine the effects of processing, moisture, and anaerobic storage length of reconstituted corn grain (RCG) on the fermentation profile, geometric mean particle size (GMPS), and ruminal dry matter disappearance (DMD). Dry corn kernels were ground (hammer mill, 5-mm screen) or rolled, then rehydrated to 30%, 35%, or 40% moisture, and stored for 0, 14, 30, 60, 90, 120, or 180 d in laboratory silos. Rolled corn had an increased GMPS compared with ground corn (2.24 and 1.13 mm, respectively, at ensiling). However, there was a trend for an interaction between processing and moisture concentration to affect particle size, with GMPS increasing with increased moisture concentration, especially in ground corn. Longer storage periods also slightly increased GMPS. Processing, moisture, and storage length interacted to affect the fermentation pattern (two- or three-way interactions). Overall, pH decreased, whereas lactic acid, acetic acid, ethanol, and NH3-N increased with storage length. RCG with 30% moisture had less lactic acid than corn with 35% and 40% moisture, indicating that fermentation might have been curtailed and also due to the clostridial fermentation that converts lactic acid to butyric acid. Ensiling reconstituted ground corn with 30% of moisture led to greater concentrations of ethanol and butyric acid, resulting in greater DM loss than grain rehydrated to 35% or 40% of moisture. Ammonia-N and in situ ruminal DMD were highest for reconstituted ground corn with 35% or 40% of moisture, mainly after 60 d of storage. Therefore, longer storage periods and greater moisture contents did not offset the negative effect of greater particle size on the in situ ruminal DMD of rolled RCG. Nonetheless, RCG should be ensiled with more than 30% moisture and stored for at least 2 mo to improve the ruminal DMD and reduce the formation of ethanol and butyric acid.

Variance of Zein Protein and Starch Granule Morphology between Corn and Steam Flaked Products Determined Starch Ruminal Degradability Through Altering Starch Hydrolyzing Bacteria Attachment

The current study investigated differences of γ-zein protein contents and starch granule characteristics between raw and steam flaked corns and their influences on ruminal starch hydrolyzing bacteria (SHB) attached to corn grain. Two types of raw (Corn1 and Corn2) and their steam-flaked products (SFCorn1 and SFCorn2) were applied to explore physiochemical structures and SHB attachment. SDS-PAGE was conducted to detect γ-zein protein patterns, scanning electron microscope, and small angle X-ray scattering were performed to obtain starch granule morphology, while crystallinity, DQ starch, and DAPI staining were applied to quantify SHB. The steam flaking process destroyed γ-zein proteins and gelatinized starch granules. The median particle size of Corn1 and Corn2 starch granules increased from 17.8 and 18.0 μm to 30.8 and 26.0 μm, but crystallinity decreased from 22.0 and 25.0% to 9.9 and 16.9%, respectively. The percentage of SHB attached to Corn1 residues decreased (p = 0.01) after 4 h incubation, but SHB attached to SFCorn1 residues increased (p = 0.03) after 12 h incubation. Thus, the differences of γ-zein proteins and starch granule physiochemical structures between raw and steam flaked corn played an important role in improving the rate and extent of starch ruminal degradation through altering the process of SHB attached to corn.

Using vibrational molecular spectroscopy with chemometrics as an analytical method to investigate association of degradation with inherent molecular structures in grain

Corn starch played a critical role in maintaining energy supply for high milk yield. The objectives of this research were to disclose the starch and carbohydrate-related biopolymers degradation in three newly developed corn lines (LM10, LM01 and LD999) during rumen incubation, and detect relationships between molecular structures and starch degradation. Attenuated Total Reflectance Fourier-transform Vibrational Molecular Spectroscopy (ATR-Ft/VMS) was applied to reveal molecular structure conformations that were associated with major nutrients macro-biopolymers. Line LM01 was greater (P < 0.01) in peak heights and areas of carbohydrate (CHO) related spectral than LM10 and LD999 (P < 0.01). Line LM01 had greater rumen degradable dry matter and starch than LM10 and LD999 (P < 0.05). During 48 h rumen incubation, absorbance intensities of CHO peak 1 and peak 3 decreased linearly (P < 0.01), but absorbance intensities of CHO peak 2 increased, non-structural CHO related spectral absorbance intensities decreased linearly (P < 0.01). Correlation analysis showed that CHO associated spectral were positively correlated to ruminal dry matter and starch degradability (P < 0.10). The results inferred that the molecular spectral features of newly developed corn lines played a more important role in determining starch degradability.

Effect of ensiling time and exogenous protease addition to whole-plant corn silage of various hybrids, maturities, and chop lengths on nitrogen fractions and ruminal in vitro starch digestibility

The objective of this study was to evaluate the effects of ensiling time and exogenous protease addition on soluble CP (% of CP), ammonia-N (% of N), and ruminal in vitro starch digestibility (ivSD) of whole-plant corn silage (WPCS) from 3 hybrids, 2 maturities, and 2 chop lengths. Samples from 3 nonisogenic hybrids [brown midrib containing the bm3 gene mutation (BM3), dual-purpose (DP), or floury-leafy (LFY)] at 2 harvest maturities [2/3 kernel milk line (early) or 7d later (late)] with 2 theoretical lengths of cut settings (0.64 or 1.95cm) on a forage harvester were collected at harvest, treated with or without exogenous protease, and ensiled in triplicate in vacuum heat-sealed plastic bags for 0, 30, 60, 120, and 240d. Thus, the experiment consisted of 120 treatments (3 hybrids × 2 maturities × 2 chop lengths × 2 protease treatments × 5 time points) and 360 mini-silos (3 replications per treatment). Vitreousness, measured by dissection on unfermented kernels on the day of harvest, averaged 66.8, 65.0, and 59.0% for BM3, DP, and LFY, respectively. A protease × maturity interaction was observed with protease increasing ivSD in late but not early maturity. Ensiling time × hybrid interactions were observed for ammonia-N and soluble CP concentrations with greater values for FLY than other hybrids only after 120d of ensiling. Ensiling time × hybrid or protease × hybrid interactions were not observed for ivSD. Measurements of ivSD were greatest for FLY and lowest for BM3. Length of the ensiling period did not attenuate negative effects of kernel vitreousness or maturity on ivSD in WPCS. Results suggest that the dosage of exogenous protease addition used in the present study may reduce but not overcome the negative effects of maturity on ivSD in WPCS. No interactions between chop length and ensiling time or exogenous protease addition were observed for ivSD.

Nutritive value of maize silage in relation to dairy cow performance and milk quality

Maize silage has become the major forage component in the ration of dairy cows over the last few decades. This review provides information on the mean content and variability in chemical composition, fatty acid (FA) profile and ensiling quality of maize silages, and discusses the major factors which cause these variations. In addition, the effect of the broad range in chemical composition of maize silages on the total tract digestibility of dietary nutrients, milk production and milk composition of dairy cows is quantified and discussed. Finally, the optimum inclusion level of maize silage in the ration of dairy cows for milk production and composition is reviewed. The data showed that the nutritive value of maize silages is highly variable and that most of this variation is caused by large differences in maturity at harvest. Maize silages ensiled at a very early stage (dry matter (DM) < 250 g kg(-1)) were particularly low in starch content and starch/neutral detergent fibre (NDF) ratio, and resulted in a lower DM intake (DMI), milk yield and milk protein content. The DMI, milk yield and milk protein content increased with advancing maturity, reaching an optimum level for maize silages ensiled at DM contents of 300-350 g kg(-1), and then declined slightly at further maturity beyond 350 g kg(-1). The increases in milk (R(2) = 0.599) and protein (R(2) = 0.605) yields with maturity of maize silages were positively related to the increase in starch/NDF ratio of the maize silages. On average, the inclusion of maize silage in grass silage-based diets improved the forage DMI by 2 kg d(-1), milk yield by 1.9 kg d(-1) and milk protein content by 1.2 g kg(-1). Further comparisons showed that, in terms of milk and milk constituent yields, the optimum grass/maize silage ratio depends on the quality of both the grass and maize silages. Replacement of grass silage with maize silage in the ration, as well as an increasing maturity of the maize silages, altered the milk FA profile of the dairy cows, notably, the concentration of the cis-unsaturated FAs, C18:3n-3 and n-3/n-6 ratio decreased in milk fat. Despite variation in nutritive value, maize silage is rich in metabolizable energy and supports higher DMI and milk yield. Harvesting maize silages at a DM content between 300 and 350 g kg(-1) and feeding in combination with grass silage results in a higher milk yield of dairy cows.

Common Prairie feeds with different soluble and insoluble fractions used for CPM diet formulation in dairy cattle: impact of carbohydrate-protein matrix structure on protein and other primary nutrient digestion

An experiment was conducted to investigate the relationship of carbohydrates molecular spectral characteristics to rumen degradability of primary nutrients in Prairie feeds in dairy cattle. In total, 12 different types of feeds were selected, each type of feed was from three different source with total 37 samples. Six types of them were energy-sourced feeds and the others were protein-sourced feeds. The carbohydrates molecular spectral intensity of various functional groups were collected using Fourier transform infrared attenuated total reflectance (ATR-FT/IR) spectroscopy. In the in situ study, the results showed that the rumen digestibility and digestible fractions of primary nutrients (DM, OM, NCP, and CP) were significantly different (P<0.05) among the feeds. The spectral bands features were significantly different (P<0.05) among the feeds. Spectral intensities of A_Cell, H_1415 and H_1370 were weakly positively correlated with in situ rumen digestibility and digestible fractions of DM, OM and NCP. Spectral intensities of H_1150, H_1015, A_1, and A_3 were weakly negatively associated with in situ rumen degradation of CP. Spectral intensities of A_1240 and H_1240, mainly associated with cellulosic compounds, were correlated with rumen CP degradation. The multiple regression analysis demonstrated that the spectral intensities of A_3 and H_1415 played the most important role and could be used as a potential tool to predict rumen protein degradation of feeds in dairy cattle. In conclusion, this study showed that the carbohydrates as a whole have an effect on protein rumen degradation, rather than cellulose alone, indicating carbohydrate-protein matrix structure impact protein utilization in dairy cattle. The non-invasive molecular spectral technique (ATR-FT/IR) could be used as a rapid potential tool to predict rumen protein degradation of feedstuffs by using molecular spectral bands intensities in carbohydrate fingerprint region.

Type of corn endosperm influences nutrient digestibility in lactating dairy cows

An experiment was conducted to evaluate the effect of type of corn endosperm on nutrient digestibility in lactating dairy cows. Near-isogenic variants of an Oh43 x W64A normal dent endosperm hybrid carrying floury-2 or opaque-2 alleles were grown in spatial isolation in field plots and harvested as dry shelled corn. Six ruminally cannulated, multiparous Holstein cows (67 +/- 9 d in milk at trial initiation) were randomly assigned to a replicated 3 x 3 Latin square design with 14-d periods; the first 11 d of each period were for diet adaptation followed by 3 d of sampling and data collection. Treatment diets that contained dry rolled vitreous-, floury-, or opaque-endosperm corn [33% of dry matter (DM)], alfalfa silage (55% of DM) and protein-mineral-vitamin supplement (12% of DM) were fed as a total mixed ration. The percentage vitreous endosperm was zero for floury and opaque endosperm corns and 64 +/- 7% for the vitreous corn. Prolamin protein content of floury and opaque endosperm corns was 30% of the content found in vitreous corn. Degree of starch access and in vitro ruminal starch digestibility measurements were 32 and 42% greater on average, respectively, for floury and opaque endosperm corns than for vitreous corn. Dry matter and starch disappearances after 8-h ruminal in situ incubations were, on average, 24 and 32 percentage units greater, respectively, for floury and opaque endosperm corns than for vitreous corn. Ruminal pH and acetate molar percentage were lower, propionate molar percentage was greater, and acetate:propionate ratio was lower for cows fed diets containing floury and opaque endosperm corns than for cows fed vitreous corn. In agreement with laboratory and in situ measurements, total-tract starch digestibility was 6.3 percentage units greater, on average, for cows fed diets containing floury and opaque endosperm corns than vitreous corn. Conversely, apparent total-tract neutral detergent fiber (NDF) digestibility was lower for cows fed diets containing floury and opaque endosperm corns compared with vitreous corn. The type of endosperm in corn fed to dairy cows can have a marked effect on digestion of starch and NDF. Feeding less vitreous corn increased starch digestion but decreased NDF digestion.

Hardness methods for testing maize kernels

Maize is a highly important crop to many countries around the world, through the sale of the maize crop to domestic processors and subsequent production of maize products and also provides a staple food to subsistance farms in undeveloped countries. In many countries, there have been long-term research efforts to develop a suitable hardness method that could assist the maize industry in improving efficiency in processing as well as possibly providing a quality specification for maize growers, which could attract a premium. This paper focuses specifically on hardness and reviews a number of methodologies as well as important biochemical aspects of maize that contribute to maize hardness used internationally. Numerous foods are produced from maize, and hardness has been described as having an impact on food quality. However, the basis of hardness and measurement of hardness are very general and would apply to any use of maize from any country. From the published literature, it would appear that one of the simpler methods used to measure hardness is a grinding step followed by a sieving step, using multiple sieve sizes. This would allow the range in hardness within a sample as well as average particle size and/or coarse/fine ratio to be calculated. Any of these parameters could easily be used as reference values for the development of near-infrared (NIR) spectroscopy calibrations. The development of precise NIR calibrations will provide an excellent tool for breeders, handlers, and processors to deliver specific cultivars in the case of growers and bulk loads in the case of handlers, thereby ensuring the most efficient use of maize by domestic and international processors. This paper also considers previous research describing the biochemical aspects of maize that have been related to maize hardness. Both starch and protein affect hardness, with most research focusing on the storage proteins (zeins). Both the content and composition of the zein fractions affect hardness. Genotypes and growing environment influence the final protein and starch content and, to a lesser extent, composition. However, hardness is a highly heritable trait and, hence, when a desirable level of hardness is finally agreed upon, the breeders will quickly be able to produce material with the hardness levels required by the industry.

Technical note: a method to quantify prolamin proteins in corn that are negatively related to starch digestibility in ruminants

Compared with floury or high-moisture corns, dry corn with a greater percentage of vitreous endosperm has been demonstrated to be negatively related to starch digestibility and milk yield of lactating dairy cows. Starch granules in corn are encapsulated by hydrophobic prolamin proteins that are innately insoluble in the rumen environment. Corn prolamin proteins are named zein, and laboratory methods to quantify zein exist but are seldom employed in ruminant nutrition because of their arduous nature. In this study, advances in cereal chemistry were combined with rapid turbidimetric methods yielding a modified turbidimetric zein method (mTZM) to quantify zein in whole corn. Ten dry corns containing unique endosperms were evaluated using the mTZM. Corns with flint, dent, floury, or opaque endosperms were found to contain 19.3, 11.3, 5.8, and 4.9 g of zein/100 g of starch, respectively. The ability of mTZM to differentiate corn endosperm types as defined by least significant difference was 2.6 g of zein/100 g of starch. Ten high-moisture corns of varying moisture content were also evaluated using the mTZM. Zein content of high-moisture corns as defined by mTZM ranged from 8.3 to 2.8 g of zein/100 g of starch with a least significant difference of 1.2 g of zein/100 g of starch. The mTZM determined that zein contents of high-moisture, floury, and opaque corns were markedly less than those of flint and dent dry corns, indicating that mTZM has the ability to quantify starch granule encapsulation by hydrophobic prolamin proteins in whole corn.