Ultrasound: Enhance the detachment of exosporium and decrease the hydrophobicity of Bacillus cereus spores

Inactivation of Bacillus cereus spores by ohmic heating: Efficiency and changes of spore biological properties

Bacillus cereus spores pose a significant concern during food processing due to their high resistance to environmental stress. Ohmic heating (OH) is an emerging and alternative heating technology with potential for inactivating such spores. This study evaluated the inactivation effects and the biological property changes of Bacillus cereus spores during OH treatments. OH effectively inactivated spores in milk, orange juice, broth, rice soup, and buffer solution in less time than oil bath heating (OB). A decrease in NaCl content improved spore inactivation at the same temperature. Spores were more sensitive to acid at 80-85 °C with OH treatment. Furthermore, OH at 10 V/cm and 50 Hz could reduce the spore resistance and inhibit an increase in spore hydrophobicity and spore aggregation. Both heating methods resulted in significant dipicolinic acid (DPA) leakage and damage to the cortex and inner membranes of the spores. However, OH at 10 V/cm and 50 Hz had the lowest DPA leakage and inflicted the least damage to the inner membrane. The damage to the spore's inner membrane was considered the primary reason for inactivation by OB and OH treatments. Still, OH at 10 V/cm and 50 Hz might also block the germination or outgrowth of treated spores or cause damage to the spore core.

Oil addition increases the heat resistance of Clostridium sporogenes spores in braised sauce beef: Perspectives from spore surface characteristics and microstructure

During thermal processing of braised sauce beef, the lipid content of circularly used sauce increased accordingly because of lipid migration from beef to sauce, which may impact the bacterial heat resistance in the products. This study aims to characterize the heat resistance of Clostridium sporogenes spores in braised sauce beef, and investigate the effects of oil on the spore surface characteristics and microstructure. The results indicated that the heat resistance of C. sporogenes spores in beef was significantly higher than that in sauce. Oil addition remarkably enhanced the spore heat resistance in sauce, with D95°C value three times more than that without oil added, and even higher than that in beef. The results of spore surface characteristics indicated that oil addition led to an increase of hydrophobicity and a decrease of zeta potential, which ultimately increased spore heat resistance. Microstructure analysis indicated that exosporium maintenance and cortex expansion induced by oil addition might contribute to the increase of spore heat resistance. This study has sufficiently verified the importance of oil content on the heat resistance of C. sporogenes spores, which should be taken into consideration when developing thermal processes for controlling the spores in food matrices.

Inactivation of Clostridium perfringens C1 Spores by the Combination of Mild Heat and Lactic Acid

Clostridium perfringens is a major pathogen causing foodborne illnesses. In this experiment, the inactivation effects of heat and lactic acid (LA) treatments on C. perfringens spores was investigated. Heat treatment (80 °C, 90 °C and 100 °C), LA (0.5% and 1%), and combined LA and heat treatments for 30 and 60 min were performed. Residual spore counts showed that the count of C. perfringens spores was below the detection limit within 30 min of treatment with 1% LA and heat treatment at 90 °C. Scanning electron microscopy and confocal scanning laser microscopy results showed that the surface morphology of the spores was severely disrupted by the co-treatment. The particle size of the spores was reduced to 202 nm and the zeta potential to −3.66 mv. The inner core of the spores was disrupted and the co-treatment resulted in the release of 77% of the nuclear contents 2,6-pyridinedicarboxylic acid. In addition, the hydrophobicity of spores was as low as 11% after co-treatment with LA relative to the control, indicating that the outer layer of spores was severely disrupted. Thus, synergistic heating and LA treatment were effective in inactivating C. perfringens spores.

Sporicidal mechanism of the combination of ortho-phthalaldehyde and benzyldimethyldodecylammonium chloride as a disinfectant against the Bacillus subtilis spores

Previous studies have shown that the combination disinfectant, Ortho-phthalaldehyde and benzyldimethyldodecylammonium chloride (ODB), can effectively kill a variety of microorganisms, such as Escherichia coli, Staphylococcus aureus, and Candida albicans. To observe the sporicidal ability and mechanism of ODB for spores, Bacillus subtilis spores were used as the research object in this experiment. TEM images revealed that ODB destroyed the integrity of the coat, cortex, and inner membrane of the spores after 0.5-h treatment, and the nuclear material was also broken and exuded after 4-h treatment. The broken structure led to the release of dipicolinic acid (DPA) in large amount. The results show that B. subtilis spores can be effetely killed by ODB through destroying the structure of the spores.

Hurdle enhancement of acidic electrolyzed water antimicrobial efficacy on Bacillus cereus spores using ultrasonication

This study evaluated the inactivation effect of ultrasonic treatment combined with acidic electrolyzed water (AEW) on Bacillus cereus spores. AEW treatment reduced the spores by 1.05-1.37 log CFU/mL while the sporicidal effect of ultrasound was minor. More strikingly, simultaneous ultrasonic and AEW treatments for 30 min led to 2.29 log CFU/mL reduction and thus, considered a synergistic effect. Flow cytometry combined with SYTO/PI staining analysis revealed that ultrasound hydrolyzed the cortex while the AEW partially damaged the integrity of the inner membrane. Scanning and transmission electron microscopies were used to characterize the ultrastructural changes. The detachment of the exosporium induced by ultrasound was the most apparent difference compared with the control group, and the electron density of spores appeared to be heterogeneous after treatment with AEW. These results indicated that combining ultrasound with AEW is a promising decontamination technology with potential uses in the food industry and environmental remediation.