Enhanced hydrolysis and methane yield by applying microaeration pretreatment to the anaerobic co-digestion of brown water and food waste

Optimizing intermittent micro-aeration as a strategy for enhancing aniline anaerobic biodegradation: kinetic, ecotoxicity, and microbial community dynamics analyses

Groundwater and soil contamination by aromatic amines (AAs), used in the production of polymers, plastics, and pesticides, often results from improper waste disposal and accidental leaks. These compounds are resistant to anaerobic degradation; however, micro-aeration can enhance this process by promoting microbial interactions. In batch assays, anaerobic degradation of aniline (0.14 mM), a model AA, was tested under three micro-aeration conditions: T30, T15, and T10 (30, 15, and 10 min of micro-aeration every 2 h, respectively). Aniline degradation occurred in all conditions, producing both aerobic (catechol) and anaerobic (benzoic acid) byproducts. The main genera involved in T30 and T15 were Comamonas, Clostridium, Longilinea, Petrimonas, Phenylobacterium, Pseudoxanthomonas, and Thiobacillus. In contrast, in T10 were Pseudomonas, Delftia, Leucobacter, and Thermomonas. While T30 and T15 promoted microbial cooperation for anaerobic degradation and facultative respiration, T10 resulted in a competitive environment due to dominance and oxygen scarcity. Despite aniline degradation in 9.4 h under T10, this condition was toxic to Allium cepa seeds and exhibited cytogenotoxic effects. Therefore, T15 emerged as the optimal condition, effectively promoting anaerobic degradation without accumulating toxic byproducts. Intermittent micro-aeration emerges as a promising strategy for enhancing the anaerobic degradation of AA-contaminated effluents.

Sewage sludge management and enhanced energy recovery using anaerobic digestion: an insight

Sewage sludge (SS) is a potential source of bioenergy, yet its management is a global concern. Anaerobic digestion (AD) is applied to effectively valorize SS by reclaiming energy in the form of methane. However, the complex floc structure of SS hinders hydrolysis during AD process, thus resulting in lower process efficiency. To overcome the rate-limiting hydrolysis, various pre-treatment methods have been developed to enhance AD efficiency. This review aims to provide insights into recent advancements in pre-treatment technologies, including mechanical, chemical, thermal, and biological methods. Each technology was critically evaluated and compared, and its relative worth was summarized based on full-scale applicability, along with economic benefits, AD performance improvements, and impact on digested sludge. The paper illuminates the readers about existing research gaps, and the future research needed for successful implementation of these approaches at full scale.

Metaproteomics-informed stoichiometric modeling reveals the responses of wetland microbial communities to oxygen and sulfate exposure

Climate changes significantly impact greenhouse gas emissions from wetland soil. Specifically, wetland soil may be exposed to oxygen (O2) during droughts, or to sulfate (SO42-) as a result of sea level rise. How these stressors - separately and together - impact microbial food webs driving carbon cycling in the wetlands is still not understood. To investigate this, we integrated geochemical analysis, proteogenomics, and stoichiometric modeling to characterize the impact of elevated SO42- and O2 levels on microbial methane (CH4) and carbon dioxide (CO2) emissions. The results uncovered the adaptive responses of this community to changes in SO42- and O2 availability and identified altered microbial guilds and metabolic processes driving CH4 and CO2 emissions. Elevated SO42- reduced CH4 emissions, with hydrogenotrophic methanogenesis more suppressed than acetoclastic. Elevated O2 shifted the greenhouse gas emissions from CH4 to CO2. The metabolic effects of combined SO42- and O2 exposures on CH4 and CO2 emissions were similar to those of O2 exposure alone. The reduction in CH4 emission by increased SO42- and O2 was much greater than the concomitant increase in CO2 emission. Thus, greater SO42- and O2 exposure in wetlands is expected to reduce the aggregate warming effect of CH4 and CO2. Metaproteomics and stoichiometric modeling revealed a unique subnetwork involving carbon metabolism that converts lactate and SO42- to produce acetate, H2S, and CO2 when SO42- is elevated under oxic conditions. This study provides greater quantitative resolution of key metabolic processes necessary for the prediction of CH4 and CO2 emissions from wetlands under future climate scenarios.

Performance and mechanism of various microaerobic pretreatments on anaerobic digestion of tobacco straw

Tobacco straw is an abundant biomass in China's agricultural ecosystems, and has high potential for methane production. However, the anaerobic digestion (AD) efficiency is limited by the recalcitrant lignocellulose structure of the tobacco straw. In this study, three microaerobic pretreatments were performed for the AD of tobacco straw to increase methane production. Among them, microbial pretreatment with biogas slurry at an oxygen concentration of 4 mL/g VS resulted in the highest methane production of 349.1 mL/g VS, increasing by 19.8 % than that of untreated. During this pretreatment, the relative abundances of Enterococcus and Clostridium sensu stricto 12, which are closely related to acetic acid production and cellulose degradation, were high, and these bacteria might have an important contribution to substrate hydrolysis and the methanogenesis efficiency of the AD process. This study advances the understanding of microaerobic pretreatment processes and provides technological guidance for the efficient utilization of tobacco straw.

Microbiome Diversity of Anaerobic Digesters Is Enhanced by Microaeration and Low Frequency Sound

Biogas is produced by a consortium of bacteria and archaea. We studied how the microbiome of poultry litter digestate was affected by time and treatments that enhanced biogas production. The microbiome was analyzed at six, 23, and 42 weeks of incubation. Starting at week seven, the digesters underwent four treatments: control, microaeration with 6 mL air L-1 digestate per day, treatment with a 1000 Hz sine wave, or treatment with the sound wave and microaeration. Both microaeration and sound enhanced biogas production relative to the control, while their combination was not as effective as microaeration alone. At week six, over 80% of the microbiome of the four digesters was composed of the three phyla Actinobacteria, Proteobacteria, and Firmicutes, with less than 10% Euryarchaeota and Bacteroidetes. At week 23, the digester microbiomes were more diverse with the phyla Spirochaetes, Synergistetes, and Verrucomicrobia increasing in proportion and the abundance of Actinobacteria decreasing. At week 42, Firmicutes, Bacteroidetes, Euryarchaeota, and Actinobacteria were the most dominant phyla, comprising 27.8%, 21.4%, 17.6%, and 12.3% of the microbiome. Other than the relative proportions of Firmicutes being increased and proportions of Bacteroidetes being decreased by the treatments, no systematic shifts in the microbiomes were observed due to treatment. Rather, microbial diversity was enhanced relative to the control. Given that both air and sound treatment increased biogas production, it is likely that they improved poultry litter breakdown to promote microbial growth.

Evaluation of Nanaerobic Digestion as a Mechanism to Explain Surplus Methane Production in Animal Rumina and Engineered Digesters

Nanaerobes are a newly described class of microorganisms that use a unique cytochrome bd oxidase to achieve nanaerobic respiration at <2 μM dissolved oxygen (∼1% of atmospheric oxygen) but are not viable above this value due to the lack of other terminal oxidases. Although sharing an overlapping ecological niche with methanogenic archaea, the role of nanaerobes in methanogenic systems has not been studied so far. To explore their occurrence and significance, we re-analyzed published meta-omic datasets from animal rumina and waste-to-energy digesters, including conventional anaerobic digesters and anaerobic digesters with ultra-low oxygenation. Results show that animal rumina share broad similarities in the microbial community and system performance with oxygenated digesters, rather than with conventional anaerobic digesters, implying that trace levels of oxygen drive the efficient digestion in ruminants. The rumen system serves as an ideal model for the newly named nanaerobic digestion, as it relies on the synergistic co-occurrence of nanaerobes and methanogens for methane yield enhancement. The most abundant ruminal bacterial family Prevotellaceae contains many nanaerobes, which perform not only anaerobic fermentation but also nanaerobic respiration using cytochrome bd oxidase. These nanaerobes generally accompany hydrogenotrophic methanogens to constitute a thermodynamically and physiologically consistent framework for efficient methane generation. Our findings provide new insights into ruminal methane emissions and strategies to enhance methane generation from biomass.

Microbial community composition of food waste before anaerobic digestion

Anaerobic digestion is widely used to process and recover value from food waste. Commercial food waste anaerobic digestion facilities seek improvements in process efficiency to enable higher throughput. There is limited information on the composition of microbial communities in food waste prior to digestion, limiting rational exploitation of the catalytic potential of microorganisms in pretreatment processes. To address this knowledge gap, bacterial and fungal communities in food waste samples from a commercial anaerobic digestion facility were characterised over 3 months. The abundance of 16S rRNA bacterial genes was approximately five orders of magnitude higher than the abundance of the fungal intergenic spacer (ITS) sequence, suggesting the numerical dominance of bacteria over fungi in food waste before anaerobic digestion. Evidence for the mass proliferation of bacteria in food waste during storage prior to anaerobic digestion is presented. The composition of the bacterial community shows variation over time, but lineages within the Lactobacillaceae family are consistently dominant. Nitrogen content and pH are correlated to community variation. These findings form a foundation for understanding the microbial ecology of food waste and provide opportunities to further improve the throughput of anaerobic digestion.

Bacterial antioxidant mechanism in calcium peroxide aided sludge anaerobic fermentation

Although calcium peroxide (CaO₂) can enhance the short-chain fatty acids (SCFAs) production in sludge anaerobic fermentation, the microbiological mechanisms underlying this process remain unclear. In this study, it is aimed to elucidate the bacterial protective mechanisms in response to the oxidative stress induced by CaO₂. Results show that extracellular polymeric substance (EPS) and anti-oxidant enzymes play vital roles in protecting bacterial cells from CaO₂. The addition of CaO₂ resulted in increased relative abundances of genes exoP and SRP54, which are associated with EPS secretion and transportation. Superoxide dismutase (SOD) played a crucial in alleviating oxidative stress. The dosage of CaO₂ significantly influences the succession of the bacterial community in the anaerobic fermentation system. With 0.3 g CaO₂/g VSS, the net income was approximately 4 USD/ton of sludge treated. The CaO₂-assisted anaerobic fermentation process has the potential to recover more resources from sludge and thus, benefit the environment.

Microaerobic condition as pretreatment for improving anaerobic digestion: A review

Pretreatment of waste before anaerobic digestion (AD) has been extensively studied during the last decades. One of the biological pretreatments studied is the microaeration. This review examines this process, including parameters and applications to different substrates at the lab, pilot and industrial scales, to guide further improvement in large-scale applications. The underlying mechanisms of accelerating hydrolysis and its effects on microbial diversity and enzymatic production were reviewed. In addition, modelling of the process and energetic and financial analysis is presented, showing that microaerobic pretreatment is commercially attractive under certain conditions. Finally, challenges and future perspectives were also highlighted to promote the development of microaeration as a pretreatment before AD.

Sustainable management of food waste; pre-treatment strategies, techno-economic assessment, bibliometric analysis, and potential utilizations: A systematic review

Food waste (FW) contains many nutritional components such as proteins, lipids, fats, polysaccharides, carbohydrates, and metal ions, which can be reused in some processes to produce value-added products. Furthermore, FW can be converted into biogas, biohydrogen, and biodiesel, and this type of green energy can be used as an alternative to nonrenewable fuel and reduce reliance on fossil fuel sources. It has been demonstrated in many reports that at the laboratory scale production of biochemicals using FW is as good as pure carbon sources. The goal of this paper is to review approaches used globally to promote turning FW into useable products and green energy. In this context, the present review article highlights deeply in a transdisciplinary manner the sources, types, impacts, characteristics, pre-treatment strategies, and potential management of FW into value-added products. We find that FW could be upcycled into different valuable products such as eco-friendly green fuels, organic acids, bioplastics, enzymes, fertilizers, char, and single-cell protein, after the suitable pre-treatment method. The results confirmed the technical feasibility of all the reviewed transformation processes of FW. Furthermore, life cycle and techno-economic assessment studies regarding the socio-economic, environmental, and engineering aspects of FW management are discussed. The reviewed articles showed that energy recovery from FW in various forms is economically feasible.

A novel simultaneous partial nitrification, anammox, denitrification and fermentation process: Enhancing nitrogen removal and sludge reduction in a single reactor

This study verified the feasibility of simultaneous partial nitrification, anammox, denitrification and fermentation process under intermittent aeration in a single reactor, and explored the impact of dissolved oxygen (DO) on the synergy between fermentation and nitrogen removal. An advanced nitrogen removal efficiency of 92.8 % and a low observed sludge yield of 0.0268-0.1474 kgMLSS/kgCOD were achieved. In-situ test showed that nitrate and ammonium decreased synchronously in the absence of organic matter, indicating the possibility of simultaneous partial denitrification, anammox and fermentation. Additionally, the abundance of functional genes for acetate production was 66,894 hits, while the key genes relevant to methanogenesis were only 348 hits, which suggested that fermentation might stop at the acid-producing stage and promote partial denitrification-anammox reaction, achieving simultaneous sludge reduction and advanced nitrogen removal performance. When DO increased from 0.1-0.3 to 0.4-0.6 mg/L, the nitrogen removal efficiency was increased (63.9 %→92.8 %) while sludge reduction was negatively affected.

Anaerobic digestion of fruit and vegetable waste: a critical review of associated challenges

The depletion of fossil fuels coupled with stringent environmental laws has encouraged us to develop sustainable renewable energy. Due to its numerous benefits, anaerobic digestion (AD) has emerged as an environment-friendly technology. Biogas generated during AD is primarily a mixture of CH₄ (65-70%) and CO₂ (20-25%) and a potent energy source that can combat the energy crisis in today's world. Here, an attempt has been made to provide a broad understanding of AD and delineate the effect of various operational parameters influencing AD. The characteristics of fruit and vegetable waste (FVW) and its feasibility as a potent substrate for AD have been studied. This review also covers traditional challenges in managing FVW via AD, the implementation of various bioreactor systems to manage large amounts of organic waste and their operational boundaries, microbial consortia involved in each phase of digestion, and various strategies to increase biogas production.

Employing micro-aeration in anaerobic digestion of poultry litter and wheat straw: Batch kinetics and continuous performance

In this study, different micro-aeration (MA) strategies for anaerobic digestion (AD) of poultry litter (PL) and wheat straw (WS) were examined. MA at different stages (pretreatment, middle, pretreatment plus middle, and daily) in batch AD of WS showed that daily MA had the highest increase (16.5 %) of the cumulative methane yield (CMY) compared to the control. Batch co-digestion (Co-AD) of WS and PL with daily MA obtained a furtherly improved (15.1 %) CMY of 225.44 N mL CH₄/g vS _added. The modified Gompertz model and Cone model were good in fitting the methane yield kinetics of MA engaged AD process (R² greater than 0.99). Daily MA shortened the lag phase of Co-AD by 3.4 %. The sequencing batch reactor for the Co-AD of WS and PL showed an increased (21.5 %) daily methane yield when 0.5-h/d MA was employed. The results provided support for the application of micro-aeration in the AD of agricultural wastes.

Revealing mechanism of micro-aeration for enhancing volatile fatty acids production from swine manure

Micro-aeration is considered a new strategy for improving volatile fatty acids (VFAs) production of agricultural waste. This study investigated the effect and mechanism of micro-aeration of air and oxygen (O₂) on VFAs production from swine manure. The results showed that Air-micro-aeration had the most significant improvement effect, with the highest VFAs of 8.21 g/L, which was increased by 22.4%. Moreover, the mixing effects of different micro-aeration were limited, and the microbial communities significantly varied. Firmicutes and Bacteroidota were the dominant hydrolytic and acidogenic bacteria, and Air-micro-aeration preferentially promoted electron transfer activity and energy generation. Methanosarcina, Methanocorpusculum, and Methanobrevibacter can adapt to environmental changes according to their different oxygen tolerance, and the consumption and conversion of VFAs by methanogens were slow under Air-micro-aeration condition. This study revealed mechanism of micro-aeration for improving VFAs production from swine manure, providing a theoretical basis for micro-aeration regulation optimization.

Anaerobic Digestion of Food Waste and Its Microbial Consortia: A Historical Review and Future Perspectives

Renewable energy source, such as food waste (FW), has drawn great attention globally due to the energy crisis and the environmental problem. Anaerobic digestion (AD) mediated by novel microbial consortia is widely used to convert FW to clean energy. Despite of the considerable progress on food waste and FWAD optimization condition in recent years, a comprehensive and predictive understanding of FWAD microbial consortia is absent and therefore represents a major research challenge in FWAD. The review begins with a global view on the FWAD status and is followed by an overview of the role of AD key conditions’ association with microbial community variation during the three main energy substances (hydrogen, organic acids, and methane) production by FWAD. The following topic is the historical understanding of the FWAD microorganism through the development of molecular biotechnology, from classic strain isolation to low-throughput sequencing technologies, to high-throughput sequencing technologies, and to the combination of high-throughput sequencing and isotope tracing. Finally, the integration of multi-omics for better understanding of the microbial community activity and the synthetic biology for the manipulation of the functioning microbial consortia during the FWAD process are proposed. Understanding microbial consortia in FWAD helps us to better manage the global renewable energy source.

Resource Cycling: Application of Anaerobic Utilization Methods

Human activity and modern production contribute to the formation of a certain amount of waste that can be recycled to obtain useful products and energy sources. Today, the higher the level of industrial development, the greater the amount of waste generated, and as a result, the more important the need for disposal. A similar pattern is typical for any human production activity; as a result of large-scale production, at least 70–80% of waste is generated in relation to the amount of raw materials used. The large-scale use of polymeric materials and the plastic waste generated after their use lead to environmental pollution. While a small part of the waste is utilized naturally due to the vital activity of soil microorganisms, and a part is purposefully processed by humans into products for various purposes, a fairly large amount of waste occupies large areas in the form of a variety of garbage. After the removal of garbage by incineration, the liberated territories cannot be transferred to agricultural land due to the high content of harmful contaminants. The harm to the environment is quite obvious. In practice, certain types of waste consist of more than 70% content of valuable substances that can find further practical application in a wide variety of industries.

Intermittent Microaeration Technology to Enhance the Carbon Source Release of Particulate Organic Matter in Domestic Sewage

Domestic sewage treatment plants often have insufficient carbon sources in the influent water. To solve this problem, the commonly used technical means include an additional carbon source, primary sludge fermentation, and excess sludge fermentation, but these methods are uneconomical, unsustainable, and not applicable to small-scale wastewater treatment plants. Intermittent microaeration technology has the advantages of low energy-consumption, ease of application, and low cost, and can effectively promote anaerobic digestion of municipal sludge; however little research has been reported on its use to enhance the carbon sources release of particulate organic matter (POM) from domestic wastewater. Therefore, the effect of intermittent microaeration on the carbon source release of POM was evaluated in this study, with POM as the control test. The results showed that the release concentration of soluble chemical oxygen demand (SCOD) was the highest on day 4 under microaerobic conditions, and the concentrations of SCOD, NH4+-N, and PO43−-P in the liquid phase were 1153, 137.1, and 13 mg/L, respectively. Compared with the control group, the SCOD concentration increased by 34.2%, and the NH4+-N and PO43−-P concentrations decreased by 18.65% and 17.09%, respectively. Intermittent microaeration can effectively promote the growth of Paludibacter, Actinomyces, and Trichococcus hydrolytic fermentation functional bacteria. Their relative abundances increased by 282.83%, 21.77%, and 23.47%, respectively, compared with the control group. It can simultaneously inhibit the growth of acetate-type methanogenic archaea, Methanosaeta and Methanosarcina, with a decrease in relative abundances of 16.81% and 6.63%, respectively. The aforementioned data show that intermittent microaeration can not only promote the hydrolysis of POM, but can also reduce the loss of acetic acid carbon source, which is a cost-effective technical way to enhance the release of a carbon source of particulate organic matter in domestic sewage.

The Measurement, Application and Effect of Oxygen in Microbial Fermentations: Focusing on Methane and Carboxylate Production

Oxygen is considered detrimental to anaerobic fermentation processes by many practitioners. However, deliberate oxygen sparging has been used successfully for decades to remove H2S in anaerobic digestion (AD) systems. Moreover, microaeration techniques during AD have shown that small doses of oxygen may enhance process performance and promote the in situ degradation of recalcitrant compounds. However, existing oxygen dosing techniques are imprecise, which has led to inconsistent results between studies. At the same time, real-time oxygen fluxes cannot be reliably quantified due to the complexity of most bioreactor systems. Thus, there is a pressing need for robust monitoring and process control in applications where oxygen serves as an operating parameter or an experimental variable. This review summarizes and evaluates the available methodologies for oxygen measurement and dosing as they pertain to anaerobic microbiomes. The historical use of (micro-)aeration in anaerobic digestion and its potential role in other anaerobic fermentation processes are critiqued in detail. This critique also provides insights into the effects of oxygen on these microbiomes. Our assessment suggests that oxygen dosing, when implemented in a controlled and quantifiable manner, could serve as an effective tool for bioprocess engineers to further manipulate anaerobic microbiomes for either bioenergy or biochemical production.

Methods of pretreatment and their impacts on anaerobic codigestion of multifeedstocks: A review

Anaerobic codigestion (AnCoD) has attracted attention owing to its advantages over conventional anaerobic digestion, and attempts are still going on to develop methods for improving the efficiency of this technology. Mostly, addition of cosubstrates without applying a proper pretreatment cannot adequately enhance the performance of the digestion. However, there is a lack of a comprehensive study on different pretreatment methods specific to the wide range of cosubstrates. This review aimed to (i) categorize pretreatment techniques that have been developed for improving AnCoD, (ii) present the results of the studies on the effect of pretreatment on improving AnCoD, and (iii) provide a comparison between pretreatment methods and their application for different types of cosubstrates. The findings primarily validated the influence of pretreatment to enhance the process by increasing biodegradability, improved hydrolysis, reduced hydraulic retention time (HRT), and improved methane production. The five main categories of pretreatment employed in codigestion included the following: mechanical, thermal, chemical, biological, and hybrid pretreatment. Among them, mechanical and biological pretreatment have the most and least application in codigestion, respectively. Greater efforts are required on the application of biological pretreatment and cost-benefit analysis of different pretreatment options on the variety of the cosubstrates. PRACTITIONER POINTS: Pretreatment can significantly enhance biomethane production in anaerobic digestion Anaerobic codigestion along with pretreatment can further enhance the conventional anaerobic digestion of single feedstock Mechanical and biological methods have been the most and least practiced pretreatment options Selection of applicable pretreatment option to enhance methane production is subject to the type of cosubstrates in the system There is a research gap in evaluating the application of biological pretreatment for various types of cosubstrates.

Effect of microaerophilic treatment on swine wastewater (SWW) treatment: Engineering and microbiological aspects

The microaerobic process on swine wastewater (SWW) treatment was investigated, evaluating its effect on organic matter hydrolysis and removal, biogas production, operational stability, and microbial community structure. UASB reactors operating under higher organic loading rates (OLRs) and lower hydraulic retention times (HRTs) than those found in the SWW treatment literature were also assessed. The microaerophilic reactor R2 presented a higher total and particulate organic matter removals and operational stability than the anaerobic reactor R1, reaching COD_P removals of 79.4 ± 4.6%. In the specific methanogenic activity (SMA) tests, the microaerobic sludge (R2) showed hydrolytic and acetogenic/methanogenic activity superior to inoculum and anaerobic sludge (R1). The microbiological evaluation of R2 revealed the high presence of hydrolytic microorganisms, therefore justifying the higher hydrolytic activity found in the SMA tests and higher particulate organic matter removal found in the microaerobic reactor.

Shifts in enzymatic activities and microbial community structures in the bioenhanced treatment of ship domestic sewage under microaerobic conditions

A bioenhancement strategy for improving the anaerobic degradation efficiency of ship domestic sewage under microaerobic conditions was proposed in this study. Strains Stenotrophomonas sp. MSPP05 and Prevotella sp. MSPP07 with high organic-degrading efficiency and extracellular hydrolase yield were used for the bioenhancement of activated sludge. In batch experiments, the removal rates of chemical oxygen demand and total nitrogen reached 94.5% and 66.9% after 72 h of degradation. The activities of dehydrogenase, extracellular amylase, and protease in the treatment group were 1.2, 1.4, and 2.0 times higher than those in the control group. Microbial community analysis showed that exogenous enhanced strains competed with original microorganisms and became dominant. One-stage continuous stirred tank reactor with bioenhanced activated sludge ran steadily for 90 days with average effluent COD and TN concentrations of 87.5 and 14.6 mg/L. The feasibility of improving organic-degrading efficiency through bioenhancement by using exogenous hydrolase-producing strains was confirmed under microaerobic conditions. This work provided a theoretical basis for improving treatment effects and developing a new technique for ship domestic sewage treatment.

Effects of different microbial pretreatments on the anaerobic digestion of giant grass under anaerobic and microaerobic conditions

Microbial pretreatment to lignocellulosic biomass for anaerobic digestion (AD) has achieved increased attention; however, the low efficiency and unclear mechanism of oxygen parameter affecting this process performance limit its practical application. In this study, five readily available microbial consortia were developed to analyze the influences of various oxygen concentrations during pretreatment process upon methane conversion efficiency and microbiota within AD of giant grass. Results found that anaerobic pretreatment by liquid or straw composting inoculant, along with microaerobic pretreatment by cow manure at 10 mL/g VS oxygen concentration, obtained 23.1%, 24.4%, and 16.0% higher methane yields (275.3, 279.8, and 265.3 mL/g VS) than corresponding untreated group, respectively. Microbial community analyses showed that microbial responses to oxygen varied significantly with microbial consortium, which consequently caused different AD performances. The findings will enrich theoretical knowledge of microbial pretreatment and provide a technological guidance for efficient utilization of giant grass and other lignocellulosic biomasses.

Intermittent air mixing system for anaerobic digestion of animal wastewater: Operating conditions and full-scale validation

An air mixing system for anaerobic digestion has been proved to be beneficial for methane production. The aim of the present study was to further investigate the appropriate conditions for air mixing. The effective methane production time (EMPT) was defined to determine the air mixing time in the article. The results indicated that the appropriate aeration intensity was 66.7 mL air per volume of reactor per min and mixing time was 1.5 min. When air mixing time exceeded 3 min on each occasion, total CH₄ production was less than that achieved under the no mixing condition due to a decrease in the EMPT. In addition, the possibility of air mixing was evaluated in an anaerobic full-scale plant comprising a continuous stirred tank reactor. One year of operating data validated the feasibility of air mixing during the anaerobic digestion of swine wastewater.

Volatile Fatty Acid Production from Organic Waste with the Emphasis on Membrane-Based Recovery

In recent years, interest in the biorefinery concept has emerged in the utilization of volatile fatty acids (VFAs) produced by acidogenic fermentation as precursors for various biotechnological processes. This has attracted substantial attention to VFA production from low-cost substrates such as organic waste and membrane based VFA recovery techniques to achieve cost-effective and environmentally friendly processes. However, there are few reviews which emphasize the acidogenic fermentation of organic waste into VFAs, and VFA recovery. Therefore, this article comprehensively summarizes VFA production, the factors affecting VFA production, and VFA recovery strategies using membrane-based techniques. Additionally, the outlook for future research on VFA production is discussed.

Genomic driven factors enhance biocatalyst-related cellulolysis potential in anaerobic digestion

Anaerobic digestion (AD) is a promising technology to recover bioenergy from biodegradable biomass, including cellulosic wastes. Through a few fractionation/separation techniques, cellulose has demonstrated its potential in AD, but the performance of the process is rather substrate-specific, as cellulolysis bacteria are sensitive to the enzyme-substrate interactions. Cellulosome is a self-assembled enzyme complex with many functionalized modules in the bacteria which has been gradually studied, however the genomic fingerprints of the culture-specific cellulosome in AD are relatively unclear especially under processing conditions. To clarify the key factors affecting the cellulosome induced cellulolysis, this review summarized the most recent publications of AD regarding the fates of cellulose, sources and functional genes of cellulosome, and omics methods for functional analyses. Different processes for organic treatment including applying food grinds in sewer, biomass valorization, cellulose fractionation, microaeration, and enzymatic hydrolysis enhanced fermentation, were highlighted to support the sustainable development of AD technology.

Anaerobic and Microaerobic Pretreatment for Improving Methane Production From Paper Waste in Anaerobic Digestion

Having been generated with a tremendous amount annually, paper waste (PW) represents a large proportion in municipal solid waste (MSW) and also a potential source of renewable energy production through the application of anaerobic digestion (AD). However, the recalcitrant lignocellulosic structure poses obstacles to efficient utilization in this way. Recently, anaerobic and microaerobic pretreatment have attracted attention as approaches to overcome the obstacles of biogas production. This study was set out to present a systematic comparison and assessment of anaerobic and microaerobic pretreatment of PW with different oxygen loadings by five microbial agents: composting inoculum (CI), straw-decomposing inoculum (SI), cow manure (CM), sheep manure (SM), and digestate effluent (DE). The hints of microbial community evolution during the pretreatment and AD were tracked by 16S rRNA high-throughput sequencing. The results demonstrated that PW pretreated by DE with an oxygen loading of 15 ml/gVS showed the highest cumulative methane yield (CMY) of 343.2 ml/gVS, with a BD of 79.3%. In addition to DE, SI and SM were also regarded as outstanding microbial agents for pretreatment because of the acceleration of methane production at the early stage of AD. The microbial community analysis showed that Clostridium sensu stricto 1 and Clostridium sensu stricto 10 possessed high relative abundance after anaerobic pretreatment by SI, while Bacteroides and Macellibacteroides were enriched after microaerobic pretreatment by SM, which were all contributable to the cellulose degradation. Besides, aerobic Bacillus in SI and Acinetobacter in SM and DE probably promoted lignin degradation only under microaerobic conditions. During AD, VadinBC27, Ruminococcaceae Incertae Sedis, Clostridium sensu stricto 1, Fastidiosipila, and Caldicoprobacter were the crucial bacteria that facilitated the biodegradation of PW. By comparing the groups with same microbial agent, it could be found that changing the oxygen loading might result in the alternation between hydrogenotrophic and acetoclastic methanogens, which possibly affected the methanogenesis stage. This study not only devised a promising tactic for making full use of PW but also provided a greater understanding of the evolution of microbial community in the pretreatment and AD processes, targeting the efficient utilization of lignocellulosic biomass in full-scale applications.

Effects of biological pretreatments of microalgae on hydrolysis, biomethane potential and microbial community

Parameters of temperature-phased anaerobic digestion (TPAD) were varied to study their effects on hydrolysis, biomethane potential (BMP), and microbial diversity of microalgae biodegradation. Anaerobic pretreatments at 85 °C demonstrated the release of soluble carbohydrate and protein molecules under low microbial metabolic activity. However, at 55 °C, anaerobic pretreatments showed superior performance in methane yield, nutrient release, and volatile fatty acids (VFAs) production due to dominant Clostridium. Furthermore, the highest destruction of volatile solids (VS) was observed during aerobic pretreatments at 55 °C under the influence of various quantities of these genera - Luteimonas, Symbiobacterium, Soehngenia, Thermobacillus, and Ureibacillus. Statistical analysis revealed that hydrolysis and BMP were not correlated. However, soluble nitrogen and phosphorous showed strong correlation with methane (r = 0.623 and 0.948, respectively) under thermo-anaerobic pretreatment, while VS removal and concentrations of acetic and butyric acids and lipids were positively correlated with each other under thermo-aerobic pretreatment.

Improvement of Biogas Quality and Quantity for Small-Scale Biogas-Electricity Generation Application in off-Grid Settings: A Field-Based Study

Small-scale electrical power generation (<100 kW) from biogas plants to provide off-grid electricity is of growing interest. Currently, gas engines are used to meet this demand. Alternatively, more efficient small-scale solid oxide fuel cells (SOFCs) can be used to enhance electricity generation from small-scale biogas plants. Most electricity generators require a constant gas supply and high gas quality in terms of absence of impurities like H2S. Therefore, to efficiently use the biogas from existing decentralized anaerobic digesters for electricity production, higher quality and stable biogas flow must be guaranteed. The installation of a biogas upgrading and buffer system could be considered; however, the cost implication could be high at a small scale as compared to locally available alternatives such as co-digestion and improved digester operation. Therefore, this study initially describes relevant literature related to feedstock pre-treatment, co-digestion and user operational practices of small-scale digesters, which theoretically could lead to major improvements of anaerobic digestion process efficiency. The theoretical preamble is then coupled to the results of a field study, which demonstrated that many locally available resources and user practices constitute frugal innovations with potential to improve biogas quality and digester performance in off-grid settings.

Effect of microaerobic microbial pretreatment on anaerobic digestion of a lignocellulosic substrate under controlled pH conditions

The effects of various microaeration strategies and process parameters on anaerobic digestion (AD) of lignocellulosic substrates have received increased attention; however, different results have been reported. To determine optimal conditions and clarify the mechanisms influencing this process, the effect of pretreatment of microaerobic microbial on corn stover decomposition and AD was investigated with real-time pH control. Fresh cow manure was chosen as the inoculum, as it has the strongest cellulose hydrolysis capacity under microaeration conditions. Microaeration microbial pretreatment effectively promoted the hydrolysis and acidogenesis of corn stover, and pH considerably affected total solid reduction, volatile fatty acid (VFA), and accumulation of soluble chemical oxygen demand (sCOD) patterns by shifting microbial communities. Different pH levels and pretreatment times led to positive and negative effects on methane yield. A 12-h pretreatment of substrate at pH 8 prior to AD increased the methane yield by 16.6% in comparison with the un-pretreated sample.

The influence of combined low-strength ultrasonics and micro-aerobic pretreatment process on methane generation and sludge digestion: Lipase enzyme, microbial activation, and energy yield

Low-frequency ultrasonics is a potential technology to reduce the hydrolysis phase period in anaerobic digestion process. In this study, theinfluence of combined low frequency ultrasonics and micro-aerobic (MA) pretreatment on sewage sludge solubilization, enzyme activity and anaerobic digestion were assessed. Initially, the effect of ultrasonic density (0.012, 0.014, 0.016, 0.018, 0.1, 0.12 and 0.14 W/mL) and irradiation time (1, 3, 5, 8, 9, 10 and 12 min) of 20 kHz frequency waves were investigated. Accordingly, the effect of micro-aerobic pretreatment (Air flow rate (AFR) = 0.1, 0.2, 0.3 and 0.5 VVM) within 20, 30, 40.48 and 60 h were examined. In addition, the effect of combined pretreatment on COD solubilization, lipase enzyme activation, ATP, percentage of live bacteria and methane gas production during the anaerobic process were examined. The results showed that the highest lipase activity (14.9 Umol/mL) was obtained under the effect of ultrasonic density of 0.1 W/ml within 9 min. The highest solubilization (65%) was observed under optimal micro-aerobic conditions: AFR = 0.2 (VVM) and micro-aerobic time: 40 h. Combined ultrasonic and micro-aerobic (US + MA) pretreatment increases the solubilization (70%), microbial activity (2080%) and lipase enzymatic activity (129%) compared to individual pretreatment. The Biogas production during anaerobic digestion pretreated with combined methods increased by 193% compared to the control, while the elevated values of biogas production in reactors pretreated by ultrasonic and micro-aerobic pretreatment alone were observed to be 101% and 165%, respectively. The net energy in reactor with the combined pre-treatment methods was calculated to be 1.26 kWh, while this value for control, pretreated ultrasonic and micro-aerobic reactors were obtained to be 0.56, 0.67 and 1.2 kWh, respectively.

Impact of storage duration and micro-aerobic conditions on lactic acid production from food waste

Food waste (FW) is an abundant resource with great potential for lactic acid (LA) production. In the present study, the effect of storage time on FW characteristics and its potential for LA production was investigated. The largest part of sugars was consumed during 7 to 15 days of FW storage and the sugar consumption reached 68.0% after 15 days. To enhance the LA production, micro-aerobic conditions (13 mL air/g VS) and addition of β-glucosidase were applied to improve polysaccharides hydrolysis, resulting to increase of monosaccharides content to 76.6%. Regarding fermentative LA production, the highest LA titer and yield of hydrolyzed FW was 32.1 ± 0.5 g/L and 0.76 ± 0.01 g/g_-sugar, respectively. Furthermore, L-LA isomer was higher than 70% when FW was stored for up to 7 days. However, attention should be paid on controlling the FW storage to approximately one week.

Synergistic association between cytochrome bd-encoded Proteiniphilum and reactive oxygen species (ROS)-scavenging methanogens in microaerobic-anaerobic digestion of lignocellulosic biomass

Intermittent (every other day) microaerobic [picomolar oxygen by oxidation-reduction potential (ORP) set at +25 mV above anaerobic baseline] digestion of lignocellulosic biomass showed higher digestibility and better stability at a high organic loading rate (OLR) of 5 g volatile solids (VS)/L/d than that under strict anaerobic conditions. However, the microbial mechanisms supporting the delicate balance under microaeration remain underexplored. On the basis of our previous findings that microbial communities in replicate experiments were dominated by strains of the genus Proteiniphilum but contained diverse taxa of methanogenic archaea, here we recovered related genomes and reconstructed the putative metabolic pathways using a genome-centric metagenomic approach. The highly enriched Proteiniphilum strains were identified as efficient cellulolytic facultative bacterium, which directly degraded lignocellulose to carbon dioxide, formate, and acetate via aerobic respiration and anaerobic fermentation, alternatively. Moreover, high oxygen affinity cytochromes, bd-type terminal oxidases, in Proteiniphilum strains were found to be closely associated with such picomolar oxygen conditions, which has long been overlooked in anaerobic digestion. Furthermore, hydrogenotrophic methanogenesis was the prevalent pathway for methane production while Methanosarcina, Methanobrevibacter, and Methanocorpusculum were the dominant methanogens in the replicate experiments. Importantly, the two functional groups, namely cellulolytic facultative Proteiniphilum strains and methanogens, encoded various antioxidant enzymes. Energy-dependent reactive oxygen species (ROS) scavengers (superoxide reductase (SOR) and rubrerythrin (rbr) were ubiquitously present in different methanogenic taxa in response to replicate-specific ORP levels (-470, -450 and -475 mV). Collectively, cytochrome bd oxidase and ROS defenders may play roles in improving the digestibility and stability observed in intermittent microaerobic digestion.

Novel CaO2 beads used in the anaerobic fermentation of iron-rich sludge for simultaneous short-chain fatty acids and phosphorus recovery under ambient conditions

A novel composite CaO₂ bead was prepared to improve total short-chain fatty acids (TSCFAs) production and phosphorus (P) recovery from iron-rich waste activated sludge (WAS) during ambient anaerobic fermentation. Results showed that CaO₂ mass percentage of 5% and CaCl₂:nylon66 = 1:1 (mass ratio) were the optimal prescription for the preparation of CaO₂ beads with porous structure, loose morphology, and sustained-release of CaO₂. The highest TSCFAs production (356 mg/g VSS) was observed and about 9% of P in sludge could be recovered on beads. The decrease of Fe-phosphate and Fe-oxides in the sludge were due to different mechanisms. Microbial community analyses showed that CaO₂ beads effectively enriched dissimilatory iron-reducing bacteria (DIRB) and promoted iron-reduction related genes. After fermentation, the P-rich beads are easy to separate from sludge for further P recovery, and the supernatant carrying abundant acetate and Fe²⁺ can be returned to the wastewater treatment line to improve nutrient removal.

Comparison of Operating Methods in Cartridge Anaerobic Digestion of Corn Stover

Anaerobic digestion of lignocellulosic biomass faces changes such as biomass floating and effluent discharge. To overcome these challenges, a unique removable cartridge anaerobic digester was built and tested using corn stover as the feedstock. Three operating methods differing in the number of cartridges and days of rotation were tested. The first method used three cartridges, with each cartridge being rotated every 7 days. The second and third methods employed four cartridges, with cartridges being rotated every 7 and 9-10 days, respectively. The retention time for methods 1, 2, and 3 was 21, 28, and 38 days, respectively. After observation spanning 1 year, it was found that the cartridge digester was capable of generating a stable amount of biogas for energy without biomass floating or effluent discharging issues. The average daily methane yield from each method was 7.57, 7.11, and 6.82 L/day/kg-VS, and the cumulative methane yield was 158.95, 199.04, and 259.00 L/kg-VS, respectively. Ammonium nitrogen and pH values were in normal ranges throughout the experiment. This study provided new knowledge in operating and optimizing this cartridge digester, which may be broadly used for the anaerobic digestion of lignocellulosic biomass in the near future.

SUPPLEMENTARY INFORMATION

The online version contains supplementary material available at 10.1007/s12155-021-10252-w.

Effect of different aerobic hydrolysis time on the anaerobic digestion characteristics and energy consumption analysis

Aerobic hydrolysis of stover before anaerobic digestion is beneficial to improve the biodegradability of corn stover. Aerobic hydrolysis of corn stover at 43 °C was conducted to investigate the effects of hydrolysis time (0 h, 8 h, 16 h, and 24 h) on the degradation of lignocellulose from corn stover and material conversion. Further anaerobic digestion and energy consumption analysis with the digestion temperature of 36 °C were carried out. The accumulation rate of volatile fatty acids began to slow down after 16 h of hydrolysis, and the concentration of acetic acid reached 221.85 mmol/L at 24 h of hydrolysis. The degradation rate of lignocellulose was obviously increased after hydrolysis. When the hydrolysis time was 16 h, it reached the maximum cumulative methane production with 268.75 ml/g VS. In terms of biogas production and energy conversion efficiency, it is more appropriate to choose 16 h as hydrolysis time in biogas engineering.

Improving the treatment of waste activated sludge using calcium peroxide

The treatment and disposal of waste activated sludge (WAS) has become one of the major challenges for the wastewater treatment plants (WWTPs) due to large output, high treatment costs and enriched substantial emerging contaminants (ECs). Therefore, reducing sludge volume, recovering energy and resource from WAS, and removing ECs and decreasing environmental risk have gained increasing attentions. Calcium peroxide (CaO₂), a versatile and safe peroxide, has been widely applied in terms of WAS treatment including sludge dewatering, anaerobic sludge digestion and anaerobic sludge fermentation due to its specific properties such as generating free radicals and alkali, etc., providing supports for sludge reduction, recycling, and risk mitigation. This review outlines comprehensively the recent progresses and breakthroughs of CaO₂ in the fields of sludge treatment. In particular, the relevant mechanisms of CaO₂ enhancing WAS dewaterability, methane production from anaerobic digestion, short-chain fatty acids (SCFA) and hydrogen production from anaerobic fermentation, and the removal of ECs in WAS and role of experiment parameters are systematically elucidated and discussed, respectively. Finally, the knowledge gaps and opportunities in CaO₂-based sludge treatment technologies that need to be focused in the future are prospected. The review presented can supply a theoretical basis and technical reference for the application of CaO₂ for improving the treatment of WAS.

Biological pretreatment of corn straw for enhancing degradation efficiency and biogas production

In order to explore the effect of pretreatment on corn straw degradation and biogas production, corn straw was pretreated with mixed microbes and composting at 30°C for 14 days. The characteristics of material were measured and analyzed in the pretreatment process. Then, the pretreated and untreated corn straw was digested by anaerobic fermentation. Gas production and methane content of corn straw were analyzed. The results showed that the biological pretreatment process with mixed microbes could accelerate the degradation rate of straw and increase the degradation efficiency of lignin. The pH value of material was more stable, and the content of organic matter in the material was higher in the pretreatment process of corn straw with mixed microbes. The Scanning Electron Microscope (SEM) images showed that the structure of the lignocellulose was changed by mixed microbes, increasing the exposed area of cellulose and hemicellulose, which was beneficial to improve the utilization efficiency of straw. The degradation rates of hemicellulose, cellulose and lignin were 44.4%, 34.9% and 39.2%, respectively, after the pretreatment process with mixed microbes. Pretreatment was more helpful to increase the methane content in the anaerobic fermentation process of corn straw pretreated with mixed microbes, and could also shorten the fermentation period.

Evaluation of Microaeration and Sound to Increase Biogas Production from Poultry Litter

Microaeration, wherein small amounts of air are introduced into otherwise anaerobic digesters, has been shown to enhance biogas production. This occurs by fostering the growth of facultatively aerobic bacteria and production of enzymes that enhance the degradation of complex polymers such as cellulose. The treatment of anaerobic digestate with sound at sonic frequencies (<20 kHz) has also been shown to improve biogas production. Microaeration at a rate of 800 mL day−1, treatment with a 1000-Hz sine wave, and combined microaeration/sound were compared to a control digester for the production of biogas and their effect on wastewater quality. Poultry litter from a facility using wood chips as bedding was used as feed. The initial feeding rate was 400 g week−1, and this was slowly increased to a final rate of 2400 g week−1. Compared to the control, sound treatment, aeration, and combined sound/aeration produced 17%, 32%, and 28% more biogas. The aeration alone treatment may have been more effective than combined aeration/sound due to the sound interfering with retention of aeration or the formation of free radicals during cavitation. Digesters treated with sound had the highest concentrations of suspended solids, likely due to cavitation occurring within the sludge and the resulting suspension of fine particles by bubbles.

Modified steel slag for effect prolongation of calcium peroxide: A novel approach to enhancing SCFAs production from sludge anaerobic fermentation

In order to prolong the effect of CaO₂ on improvement of short-chain fatty acids (SCFAs) production in sludge anaerobic fermentation, CaO₂ particles were successfully loaded onto the porous surface of steel slag pre-modified with salicylic acid-methanol (SAM-SS). The prepared CaO₂/SAM-SS was then characterized and investigated for its effects on anaerobic fermentation. Experimental results revealed that, due to the slow release and reaction of CaO₂/SAM-SS, SCFAs concentrations in CaO₂/SAM-SS tests were significantly higher than in the control and SAM-SS tests, and high SCFAs concentration was sustained for a longer period than in the CaO₂ tests. Since most bacterial indexes were reduced by CaO₂/SAM-SS, more supply of "raw materials" from a better disintegration and hydrolysis, which was associated with the alkalinity and •OH radicals released from the reaction of CaO₂ with H₂O, contribute to the higher SCFAs yields. This study provides a new approach towards a higher and longer SCFAs harvesting.

Simultaneous H2S mitigation and methanization enhancement of chicken manure through the introduction of the micro-aeration approach

The impact on H₂S alleviation and methane yield enhancement after submitting the anaerobic digestion of chicken manure to a finite amount of air was investigated. The largest reduction in the H₂S biogas content (58% lower) occurred when air intensity of 30 ml/g VS_in was injected into the reactors. Consequently, a maximum methane yield (335 mL-g VS_in^-1), which was 77% higher than the control, was concurrently achieved. Slight sulfate accumulation (<330 mg L^-1) was observed inside the micro-aerated digesters with higher air intensities, suggesting a suppression of sulfide inhibition. Bacterial diversity/richness was enhanced in these digesters while the relative abundance of Methanocelleus increased by 36%. The most important contributing factor to enhancement was the synergistic effect resulting from increments in the hydrolysis rate and the suppression of sulfide inhibition. The results highlighted the potential of in situ H₂S mitigation with the added benefit of methane yield enhancement.

Different micro-aeration rates facilitate production of different end-products from source-diverted blackwater

The effects of micro-aeration on the performance of anaerobic sequencing batch reactors (ASBR) for blackwater treatment were investigated in this study. Different micro-aeration rates, 0, 5, 10, 50, and 150 mg O₂/L-reactor/cycle, and their effect on the hydrolysis, acidogenesis, and methanogenesis of blackwater were evaluated and compared at ambient temperature. Source-diverted blackwater (toilet water) contains high organic contents which can be recovered as biogas. Previous studies have found that anaerobic digestion of blackwater without micro-aeration can only recover upwards of less than 40% of chemical oxygen demand (COD) to methane at room temperature due to the low hydrolysis rate of biomass content in blackwater. This study achieved increases in blackwater hydrolysis (from 34.7% to 48.7%) and methane production (from 39.6% to 50.7%) with controlled micro-aeration (5 mg O₂/L-reactor/cycle). The microbial analysis results showed that hydrolytic/fermentative bacteria and acetoclastic methanogens (e.g. Methanosaeta) were in higher abundances in low-dose micro-aeration reactors (5 and 10 mg O₂/L-reactor/cycle), which facilitated syntrophic interactions between microorganisms. The relative abundance of oxygen-tolerant methanogen such as Methanosarcina greatly increased (from 1.5% to 11.4%) after oxygen injection. High oxygen dosages (50 and 150 mg O₂/L-reactor/cycle) led to reduced methane production and higher accumulation of volatile fatty acids, largely due to the oxygen inhibition on methanogens and degradation of organic matters by aerobic growth and respiration, as indicated by the predicted metagenome functions. By combining reactor performance results and microbial community analyses, this study demonstrated that low-dose micro-aeration improves blackwater biomethane recovery by enhancing hydrolysis efficiency and promoting the development of a functional microbial population, while medium to high-dose micro-aeration reduced the activities of certain anaerobes. It was also observed that medium-dose micro-aeration maximizes VFA accumulation, which may be used in two-stage anaerobic digesters.

Review on microaeration-based anaerobic digestion: State of the art, challenges, and prospectives

Microaeration (dosing small quantities of air or oxygen) is an effective approach to facilitate anaerobic digestion (AD) process and has gained increased attention in recent years. The underlying mechanisms of the facilitation effect of microaeration on AD process were reviewed in terms of accelerating hydrolysis, scavenging hydrogen sulfide, and affecting microbial diversity. Process parameters and control strategies were summarized to reveal considerable factors in implementing microaeration-based AD process. In addition, current applications, including lab-, pilot- and full-scale level cases, were summarized to provide guidance for further improvement in large-scale applications. The challenges and future perspectives were also highlighted to promote the development of AD process associated with microaeration.

Boosting landfill gas production from lignin-containing wastes via termite hindgut microorganism

Lignocellulose comprises a significant portion of municipal solid waste (MSW) - 40-70% in developed countries, including paper, wood, and yard waste. Cellulose and hemicellulose are often shielded by lignin, posing a barrier to waste decomposition and landfill gas generation. Unfortunately, lignin is resistant to microbial degradation under low-oxygen conditions that normally occur in MSW landfills. The bacterium strain TAV5, microaerophilic and member of phylum Verrucomicrobia, isolated from the hindgut of the Reticulitermes flavipes termite, the most widely distributed subterranean termite in North America. Its genome contains genes associated with methylotrophic competency which code for enzymes that structurally modify lignin. The overall goal of this research was to use TAV5 to modify lignin and boost methane production from MSW. Batch-scale reactors (125 mL) were filled with paper, yard, or wood waste, and four ratios of mixed of waste. Reactors were seeded with different ratios of TAV5 to anaerobic digester (AD) microorganisms (representing landfill anaerobic microorganisms). Based on batch tests, optimal ratios of TAV5 to AD microorganisms were used to seed wastes (mixed, yard, and wood) in 6-gallon reactors. Addition of TAV5 increased methane production from mixed waste, yard waste, and wood, by 49%, 34%, and 297%, respectively. TAV5 decreased acid soluble lignin by 7-39%, depending on waste type. TAV5 grown under aerobic conditions and room temperature (not requiring a heated anaerobic chamber) was found to remain viable and increase methane production under low-level oxygen conditions (1-2%). This finding will potentially lessen costs for growing large volumes of it for seeding landfills.

Two Phase Anaerobic Digestion System of Municipal Solid Waste by Utilizing Microaeration and Granular Activated Carbon

In an anaerobic digestion (AD) process, the hydrolysis phase is often limited when substrates with high concentrations of solids are used. We hypothesized that applying micro-aeration in the hydrolysis phase and the application of granular activated carbon (GAC) in the methanogenesis phase could make the AD process more efficient. A packed bed reactor (PBR) coupled with an up-flow anaerobic sludge blanket (UASB) was conducted, and its effects on methane generation were evaluated. The micro-aeration rate applied in PBR was 254 L-air/kg-Total solids (TS)-d was compared with a control reactor. Micro-aeration showed that it reduced the hydrolysis time and increased the organic matter solubilization as chemical oxygen demand (COD) increasing 200%, with a volatile fatty acids (VFAs) increment higher than 300%, compared to the control reactor (without aeration). Our findings revealed that the implementations of microaeration and GAC in the two-phase AD system could enhance methane production by reducing hydrolysis time, increasing solid waste solubilization.

Continuous hydrogen production from food waste by anaerobic digestion (AD) coupled single-chamber microbial electrolysis cell (MEC) under negative pressure

Increased generation of food waste (FW) poses significant risks to the social environment, and therefore it is critical that efficient technology be developed for effective waste valorization. This study used an integrated reactor to combine single-chamber microbial electrolysis cell (MEC) treatment and anaerobic digestion (AD) to achieve efficient hydrogen recovery using FW as substrate. Hydrogen production during continuous AD-MEC operation (511.02 ml H₂ g^-1 VS) was higher than that achieved by AD (49.39 ml H₂ g^-1 VS). The hydrogen recovery and electrical energy recovery in AD-MEC were as high as 96% and 238.7 ± 5.8%, respectively. To explore the mechanism of hydrogen production increase, the main components of FW [lipids, volatile fatty acids (VFAs), carbohydrates, and protein] were analyzed to investigate the utilization of organic matter. Compared with AD treatment, the removal rates of carbohydrates and proteins in the soluble phase in AD-MEC were increased by 4 times and 2.3 times, respectively. The removal of VFAs by AD-MEC was increased by 4.7 times, which indicated that the AD reactor coupled with MEC technology improved the utilization of the main organic components and thus increased hydrogen production. This study demonstrates the possibilities of reducing FW quantities along with the production of bio-hydrogen.

Evaluation of hydrothermal pretreatment for biological treatment of lignocellulosic feedstock (pepper plant and eggplant)

Plant residues are an important source of organic matter that can be degraded by aerobic or anaerobic biological processes. However, due to the presence of lignocellulosic material, these residues are not easily biodegradable. Greenhouse crops, such as pepper and eggplant, generate large amounts of this type of waste after harvesting. In this study, a hydrothermal pretreatment was applied at 120 °C and different times to evaluate the enhancement of C and N solubilization in these residues. The highest solubilization of C was obtained at 40 min, as no significant increases were observed at higher times (100% and 68% for pepper plant [PP] and eggplant [EP], respectively). The solubilization of N shows a linear behavior (PP r² = 0.9670 and EP r² = 0.9395). Aerobic and anaerobic biodegradability were also evaluated, with better results found for the anaerobic digestion of the pretreated substrates. The nutrients balance with anaerobic co-digestion of both pretreated substrates (50:50% wt) improved methane production by 1.4 and 1.8 with respect to the substrates individually.