Hydrophobic resin treatment of hydrothermal autohydrolysate for prebiotic applications

An Adsorption Based Downstream Processing Approach for Penicillin V from a Penicillium chrysogenum BIONCL I22 Culture Filtrate

Penicillin V (phenoxy methyl penicillin) is highly sought after among natural penicillins because of its exceptional acid stability and effectiveness against common skin and respiratory infections. Given its wide-ranging therapeutic uses, there is a need to establish a greener method for its maximum recovery to reduce the carbon footprint. Here, we have identified and validated optimized operational conditions for resin-based penicillin V recovery. It was observed that Amberlite XAD4 had the highest penicillin V hydrophobic adsorption capacity among the other screened resins. Kinetic and isothermal studies using linear and nonlinear regression analysis showed that the adsorption process well fitted with pseudo-second-order kinetics (R 2 = 0.9816) and the Freundlich adsorption isotherm model (R 2 = 0.9871). Adsorption equilibrium was attained within 4 h, while maximum adsorption was observed at 3 mg/mL penicillin V concentration. Furthermore, the optimized extraction protocol was compared with the conventional butyl acetate-based downstream processing. Under optimum conditions resin-based penicillin V recovery was 2-fold higher as compared to the solvent extraction method and the resin could be reused for over six cycles without compromising the yield. These findings signify substantial progress toward the development of an environmentally sustainable approach for penicillin V recovery and a potentially viable method for extractive fermentation.

Combined iron (III) chloride/sodium citrate with enzymatic hydrolysis for xylo-oligosaccharides and monosaccharides production from poplar

Currently, the production of xylo-oligosaccharides (XOS) from lignocelluloses by chelating system hydrolysis has not been investigated. Herein, iron (III) chloride/sodium citrate (IC/SC) chelating system hydrolysis and xylanase hydrolysis were used to produce XOS from poplar. Then, the delignification of IC/SC-hydrolyzed poplar was performed by p-toluenesulfonic acid (p-TsOH) pretreatment to increase the accessibility of cellulase. The results demonstrated that 42.3% of XOS with an extremely low by-product (xylose/XOS = 0.11) was produced from poplar by 50 mM IC/SC hydrolysis (molar ratio of 1:1, 170 °C, 60 min) and xylanase hydrolysis. The second step IC/SC hydrolysis and xylanase hydrolysis of poplar increased the yield of XOS to 51.3%. Finally, the glucose yield of p-TsOH-pretreated poplar (60% p-TsOH, 70 °C, 30 min) was greatly increased from 37.5% to 83.8% by cellulase hydrolysis with Tween 80 addition. The novel strategy proposed in this work was feasible for XOS and monosaccharides production from poplar.

Techno-economic analysis of producing xylo-oligosaccharides and cellulose microfibers from lignocellulosic biomass

This study assesses the economic performance of a biorefinery producing xylo-oligosaccharides (XOS) from miscanthus by autohydrolysis and purification based on a rigorous model developed in ASPEN Plus. Varied biorefinery capacities (50-250 oven dry metric ton (ODMT)/day) and three XOS content levels (80%, 90%, 95%) are analyzed. The XOS minimum selling price (XOS MSP) is varied between $3,430-$7,500, $4,030-$8,970, and $4,840-$10,640 per metric ton (MT) for 80%, 90%, and 95% content, respectively. The results show that increasing biorefinery capacity can significantly reduce the XOS MSP and higher purity leads to higher XOS MSP due to less yield, and higher capital and operating costs. This study also explores another system configuration to produce high-value byproducts, cellulose microfiber, by utilizing the cellulose to produce microfiber instead of combusting for energy recovery. The XOS MSP of cellulose microfiber case is $2,460-$7,040/MT and thus exhibits potential economic benefits over the other cases.

Tracing Sweetgum Lignin's Molecular Properties through Biorefinery Processing

Changes to the molecular properties of lignin over the course of biorefinery processing were investigated by using sweetgum as a feedstock. Hydrothermal pretreatment has been used because it is an economically attractive, green process. Three representative biorefinery lignin preparations were obtained, with about 70 % yield based on raw lignin. The three fractions included soluble lignin adsorbed on resin (XADL), solvent-extracted lignin (HTCELp), and an additional ball-milled residual lignin (HTRELp). By comparing the raw and biorefinery lignin preparations, it can be concluded that lignin undergoes both degradation and condensation throughout the various stages of the hydrothermal-based biorefinery process. The two fractions made soluble by biorefinery processing, XADL and HTCELp, were found to be low-molecular-weight degradation products enriched with free phenolic hydroxyl groups. In addition, about 15 % of noncondensed phenolic units were involved in condensation reactions. Quantitative NMR spectroscopy analysis revealed that at least about 28 % of β-O-4' substructures were cleaved. Hibbert's ketones were identified in XADL and HTRELp, which provided evidence of lignin undergoing acidolysis. The contents of β-5' and β-β' did not change significantly upon biorefinery processing. Finally, episyringaresinol was detected in XADL and HTCELp. It is hoped that these findings will help to further demonstrate the specific effects of biorefinery processing on lignin in hardwood and facilitate its utilization to improve biorefinery economics.

Structural features, interaction with the gut microbiota and anti-tumor activity of oligosaccharides

Some oligosaccharides are regarded as biological constituents with benefits to human health in an indirect way. They enter the intestinal tract to be fermented by the gut microbiota, causing changes in the abundance and composition of the gut microbiota and producing fermentation products such as short-chain fatty acids (SCFAs). In this review, the structural features and biological activities of eight common natural oligosaccharides were summarized, including human milk oligosaccharides (HMOS), xylo-oligosaccharides (XOS), arabinoxylo-oligosaccharides (AXOS), isomaltooligosaccharides (IMOS), chitin oligosaccharides (NACOS), mannan-oligosaccharides (MOS), galacto-oligosaccharides (GOS) and fructo-oligosaccharides (FOS). Furthermore, XOS were selected to explain the anti-tumor mechanism mediated by gut microbiota. The review aims to reveal primary structural features of natural functional oligosaccharides related to the biological activities and also provide an explanation of the anti-tumor activity of functional oligosaccharides mediated by the gut microbiota.