The Effect of pH and Chloride Concentration on the Stability and Antimicrobial Activity of Chlorine-Based Sanitizers

Electrolyzed Salt Solutions Used against Major Postharvest Diseases of Fresh Fruit and Vegetables

Alternative means of control are becoming increasingly relevant to the improvement of safety and the reduction of postharvest losses and waste of fruit and vegetables, especially in view of the application of the EU Greed Deal. A previous study from our research group that focused on the electrolysis process of water and was conducted using NaCl and NaHCO3 as electrolytes proved to efficiently reduce pathogen inoculum in packinghouse washing water. In the present study, we examined the effect of the electrolyzed salt solutions (eNaCl and eNaHCO3) produced in the same experimental conditions previously reported to be used as postharvest treatments during handling and commercialization, and/or at the consumer's site. We tested the electrolyzed solutions, obtained in the presence or absence of the salts, against five relevant fungal pathogens in terms of conidia viability, and on various hosts in terms of rot incidence/severity. Chemical parameters of electrolyzed and non-electrolyzed solutions were also assessed. Although a different susceptibility to treatments was observed among pathogens, electrolyzed sodium chloride (eNaCl) was the most efficient treatment for preventing spore germination, as well as for minimizing fruit rot. However, a consistent control of fungal viability and consequent rot was also achieved using electrolyzed tap water (eW). The eNaHCO3, although less efficient on fungal viability, provided a significant effect against fruit rot. The investigated electrolyzed solutions seem promising for reducing the waste of fresh fruit and vegetables.

Effect of Storage Conditions on Shelf Stability of Undiluted Neutral Electrolyzed Water

ABSTRACT

Neutral electrolyzed water (NEW) is an oxidizing sanitizer that can be made locally on-site; it is often stored in a ready-to-use format to accumulate the large volumes required for periodic or seasonal use. The shelf stability of NEW sanitizer was, therefore, assessed under various storage conditions to guide the development of protocols for its industrial application. To that end, fresh NEW with an available chlorine concentration (ACC) of 480 mg/L, pH 6.96, and oxidation reduction potential (ORP) of 916 mV was stored under different conditions. These were open or sealed polypropylene bottles, three different surface area-to-volume (SA:V) ratios (0.9, 1.7, and 8.7), and two temperatures (4 and 25°C). NEW stored at 4°C was significantly more stable than NEW stored at 25°C; ACC and pH decreased by 137 mg/L and 0.7, respectively, whereas ORP increased by 23 mV, after 101 days of storage. At 25°C, ACC decreased to <0.01 mg/L after 52 days in bottles with a SA:V ratio of 8.7, with a similar decrease after 101 days in bottles with a SA:V ratio of 1.7. However, pH decreased by up to 3.7 pH units, and ORP increased by up to 208 mV. The antimicrobial efficacy of "aged" electrolyzed oxidizing (EO) water with different ACC and ORP, but the same pH (i.e., 3.4 ± 0.2), was evaluated against Escherichia coli and Listeria innocua to determine any differences in residual antimicrobial activity. EO water with an ACC of ≥7 mg/L and an ORP of 1,094 mV caused a reduction of at least 4.7 log, whereas EO water with nondetectable ACC and considerably high ORP (716 mV) had little antimicrobial effect (<1-log reduction). Results from this study indicate that the efficacy of NEW as a sanitizer for large-scale applications such as horticulture can be maintained for at least 3 months when it is stored in closed containers with low SA:V ratio at low temperatures.

HIGHLIGHTS

Efficacy of Neutral pH Electrolyzed Water in Reducing Escherichia coli O157:H7 and Salmonella Typhimurium DT 104 on Fresh Produce Items using an Automated Washer at Simulated Food Service Conditions

The objective of this study was to determine the efficacy of neutral pH electrolyzed (NEO) water (155 mg/L free chlorine, pH 7.5) in reducing Escherichia coli O157:H7 and Salmonella Typhimurium DT 104 on romaine lettuce, iceberg lettuce, and tomatoes washed in an automated produce washer for different times and washing speeds. Tomatoes and lettuce leaves were spot inoculated with 100 μL of a 5 strain cocktail mixture of either pathogen and washed with 10 or 8 L of NEO water, respectively. Washing lettuce for 30 min at 65 rpm led to the greatest reductions, with 4.2 and 5.9 log CFU/g reductions achieved for E. coli O157:H7 and S. Typhimurium respectively on romaine, whereas iceberg lettuce reductions were 3.2 and 4.6 log CFU/g for E. coli O157:H7 and S. Typhimurium respectively. Washing tomatoes for 10 min at 65 rpm achieved reductions greater than 8 and 6 log CFU/tomato on S. Typhimurium and E. coli O157:H7 respectively. All pathogens were completely inactivated in NEO water wash solutions. No detrimental effects on the visual quality of the produce studied were observed under all treatment conditions. Results show the adoption of this washing procedure in food service operations could be useful in ensuring produce safety.