Entrance and Growth of Lactic Acid Bacteria in Gas-Exchanged, Brined Cucumbers

Survival of Escherichia coli O157:H7 in cucumber fermentation brines

Bacterial pathogens have been reported on fresh cucumbers and other vegetables used for commercial fermentation. The Food and Drug Administration currently has a 5-log reduction standard for E. coli O157:H7 and other vegetative pathogens in acidified pickle products. For fermented vegetables, which are acid foods, there is little data documenting the conditions needed to kill acid resistant pathogens. To address this knowledge gap, we obtained 10 different cucumber fermentation brines at different stages of fermentation from 5 domestic commercial plants. Cucumber brines were used to represent vegetable fermentations because cabbage and other vegetables may have inhibitory compounds that may affect survival. The 5-log reduction times for E. coli O157:H7 strains in the commercial brines were found to be positively correlated with brine pH, and ranged from 3 to 24 d for pH values of 3.2 to 4.6, respectively. In a laboratory cucumber juice medium that had been previously fermented with Lactobacillus plantarum or Leuconostoc mesenteroides (pH 3.9), a 5-log reduction was achieved within 1 to 16 d depending on pH, acid concentration, and temperature. During competitive growth at 30 °C in the presence of L. plantarum or L. mesenteroides in cucumber juice, E. coli O157:H7 cell numbers were reduced to below the level of detection within 2 to 3 d. These data may be used to aid manufacturers of fermented vegetable products determine safe production practices based on fermentation pH and temperature.

PRACTICAL APPLICATION

  Disease causing strains of the bacterium E. coli may be present on fresh vegetables. Our investigation determined the time needed to kill E. coli in cucumber fermentation brines and how E. coli strains are killed in competition with naturally present lactic acid bacteria. Our results showed how brine pH and other brine conditions affected the killing of E. coli strains. These data can be used by producers of fermented vegetable products to help assure consumer safety.

Reduction of Salmonella enterica on alfalfa seeds with acidic electrolyzed oxidizing water and enhanced uptake of acidic electrolyzed oxidizing water into seeds by gas exchange

Alfalfa sprouts have been implicated in several salmonellosis outbreaks in recent years. The disinfectant effects of acidic electrolyzed oxidizing (EO) water against Salmonella enterica both in an aqueous system and on artificially contaminated alfalfa seeds were determined. The optimum ratio of seeds to EO water was determined in order to maximize the antimicrobial effect of EO water. Seeds were combined with EO water at ratios (wt/vol) of 1:4, 1:10, 1:20, 1:40, and 1:100, and the characteristics of EO water (pH, oxidation reduction potential [ORP], and free chlorine concentration) were determined. When the ratio of seeds to EO water was increased from 1:4 to 1:100, the pH decreased from 3.82 to 2.63, while the ORP increased from +455 to +1,073 mV. EO water (with a pH of 2.54 to 2.38 and an ORP of +1,083 to +1,092 mV) exhibited strong potential for the inactivation of S. enterica in an aqueous system (producing a reduction of at least 6.6 log CFU/ml). Treatment of artificially contaminated alfalfa seeds with EO water at a seed-to-EO water ratio of 1:100 for 15 and 60 min significantly reduced Salmonella populations by 2.04 and 1.96 log CFU/g, respectively (P < 0.05), while a Butterfield's buffer wash decreased Salmonella populations by 0.18 and 0.23 log CFU/g, respectively. After treatment, EO water was Salmonella negative by enrichment with or without neutralization. Germination of seeds was not significantly affected (P > 0.05) by treatment for up to 60 min in electrolyzed water. The uptake of liquid into the seeds was influenced by the internal gas composition (air, N2, or O2) of seeds before the liquid was added.