New surfactant with SP-B and C analogs gives survival benefit after inactivation in preterm lambs

Relationship between chorioamnionitis or funisitis and lung injury among preterm infants: meta-analysis involved 16 observational studies with 68,397 participants

BACKGROUND

Chorioamnionitis (CA) can cause multiple organ injuries in premature neonates, particularly to the lungs. Different opinions exist regarding the impact of intrauterine inflammation on neonatal respiratory distress syndrome (NRDS) and bronchopulmonary dysplasia (BPD). We aim to systematically review the relationship between CA or Funisitis (FV) and lung injury among preterm infants.

METHODS

We electronically searched PubMed, EMbase, the Cochrane library, CNKI, and CMB for cohort studies from their inception to March 15, 2023. Two reviewers independently screened literature, gathered data, and did NOS scale of included studies. The meta-analysis was performed using RevMan 5.3.

RESULTS

Sixteen observational studies including 68,397 patients were collected. Meta-analysis showed CA or FV increased the lung injury risk (OR = 1.43, 95%CI: 1.06-1.92). Except for histological chorioamnionitis (HCA) (OR = 0.72, 95%CI: 0.57-0.90), neither clinical chorioamnionitis (CCA) (OR = 1.86, 95%CI: 0.93-3.72) nor FV (OR = 1.23, 95%CI: 0.48-3.15) nor HCA with FV (OR = 1.85, 95%CI: 0.15-22.63) had statistical significance in NRDS incidence. As a result of stratification by grade of HCA, HCA (II) has a significant association with decreased incidence of NRDS (OR = 0.48, 95%CI: 0.35-0.65). In terms of BPD, there is a positive correlation between BPD and CA/FV (CA: OR = 3.18, 95%CI: 1.68-6.03; FV: OR = 6.36, 95%CI: 2.45-16.52). Among CA, HCA was positively associated with BPD (OR = 2.70, 95%CI: 2.38-3.07), whereas CCA was not associated with BPD (OR = 2.77, 95%CI: 0.68-11.21). HCA and moderate to severe BPD (OR = 25.38, 95%CI: 7.13-90.32) showed a positive correlation, while mild BPD (OR = 2.29, 95%CI: 0.99-5.31) did not.

CONCLUSION

Currently, evidence suggests that CA or FV increases the lung injury incidence in premature infants. For different types of CA and FV, HCA can increase the incidence of BPD while decreasing the incidence of NRDS. And this "protective effect" only applies to infants under 32 weeks of age. Regarding lung injury severity, only moderate to severe cases of BPD were positively correlated with CA.

Historical perspective on surfactant therapy: Transforming hyaline membrane disease to respiratory distress syndrome

Lung surfactant is the first drug so far designed for the special needs of the newborn. In 1929, Von Neergard described lung hysteresis and proposed the role of surface forces. In 1955-1956, Pattle and Clements found direct evidence of lung surfactant. In 1959, Avery discovered that the airway's lining material was not surface-active in hyaline membrane disease (HMD). Patrick Bouvier Kennedy's death, among half-million other HMD-victims in 1963, stimulated surfactant research. The first large surfactant treatment trial failed in 1967, but by 1973, prediction of respiratory distress syndrome using surfactant biomarkers and promising data on experimental surfactant treatment were reported. After experimental studies on surfactant treatment provided insight in lung surfactant biology and pharmacodynamics, the first trials of surfactant treatment conducted in the 1980s showed a striking amelioration of severe HMD and its related deaths. In the 1990s, the first synthetic and natural surfactants were accepted for treatment of infants. Meta-analyses and further discoveries confirmed and extended these results. Surfactant development continues as a success-story of neonatal research.

Anti-inflammatory activity of non-selective PDE inhibitor aminophylline on the lung tissue and respiratory parameters in animal model of ARDS

Acute respiratory distress syndrome (ARDS) is a common complication of critical illness characterized by lung inflammation, epithelial and endothelial dysfunction, alveolar-capillary leakage, and worsening respiratory failure. The present study aimed to investigate the anti-inflammatory effects of non-selective phosphodiesterase (PDE) inhibitor aminophylline. New Zealand white rabbits were randomly divided into 3 groups: animals with respiratory failure defined as PaO₂/FiO₂ ratio (P/F) below < 26.7 kPa, and induced by saline lung lavage (ARDS), animals with ARDS treated with intravenous aminophylline (1 mg/kg; ARDS/AMINO), and healthy ventilated controls (Control). All animals were oxygen ventilated for an additional 4 h and respiratory parameters were recorded regularly. Post mortem, the lung tissue was evaluated for oedema formation, markers of inflammation (tumor necrosis factor, TNFα, interleukin (IL)-1β, -6, -8, -10, -13, -18), markers of epithelial damage (receptor for advanced glycation end products, RAGE) and endothelial injury (sphingosine 1-phosphate, S1P), oxidative damage (thiobarbituric acid reactive substances, TBARS, 3-nitrotyrosine, 3NT, total antioxidant capacity, TAC). Aminophylline therapy decreased the levels of pro-inflammatory cytokines, markers of epithelial and endothelial injury, oxidative modifications in lung tissue, reduced lung oedema, and improved lung function parameters compared to untreated ARDS animals. In conclusion, non-selective PDE inhibitor aminophylline showed a significant anti-inflammatory activity suggesting a potential of this drug to be a valuable component of ARDS therapy.

Efficacy of synthetic surfactant (CHF5633) bolus and/or lavage in meconium-induced lung injury in ventilated newborn rabbits

BACKGROUND

The pathogenesis of neonatal meconium aspiration syndrome (MAS) involves meconium-induced lung inflammation and surfactant inactivation. Bronchoalveolar lavage (BAL) with diluted surfactant facilitates the removal of meconium. CHF5633, one of the most promising synthetic surfactants, is effective in neonatal respiratory distress syndrome. Here we investigated its efficacy via BAL in an experimental MAS model.

METHODS

Experimental MAS was induced at birth in near-term newborn rabbits by intratracheal instillation of reconstituted human meconium. First, undiluted CHF5633 was compared with a porcine-derived surfactant (Poractant alfa) via intratracheal bolus (200 mg/kg). Second, the efficacy of BAL with diluted CHF5633 (5 mg/mL, 20 ml/kg) alone, or followed by undiluted boluses (100 or 300 mg/kg), was investigated.

RESULTS

Meconium instillation caused severe lung injury, reduced endogenous surfactant pool, and poor survival. CHF5633 had similar benefits in improving survival and alleviating lung injury as Poractant alfa. CHF5633 BAL plus higher boluses exerted better effects than BAL or bolus alone in lung injury alleviation by reversing phospholipid pools and mitigating proinflammatory cytokine mRNA expression, without fluid retention and function deterioration.

CONCLUSIONS

CHF5633 improved survival and alleviated meconium-induced lung injury, the same as Poractant alfa. CHF5633 BAL plus boluses was the optimal modality, which warrants further clinical investigation.

IMPACT

To explore the efficacy of a synthetic surfactant, CHF5633, in neonatal lung protection comparing with Poractant alfa in a near-term newborn rabbit model with meconium-induced lung injury. Similar effects on improving survival and alleviating lung injury were found between CHF5633 and Poractant alfa. Optimal therapeutic effects were identified from the diluted CHF5633 bronchoalveolar lavage followed by its undiluted bolus instillation compared to the lavage or bolus alone regimens. Animals with CHF5633 lavage plus bolus regimen exerted neither substantial lung fluid retention nor lung mechanics deterioration but a trend of higher pulmonary surfactant-associated phospholipid pools.

A recipe for a good clinical pulmonary surfactant

The lives of thousands premature babies have been saved along the last thirty years thanks to the establishment and consolidation of pulmonary surfactant replacement therapies (SRT). It took some time to close the gap between the identification of the biophysical and molecular causes of the high mortality associated with respiratory distress syndrome in very premature babies and the development of a proper therapy. Closing the gap required the elucidation of some key questions defining the structure–function relationships in surfactant as well as the particular role of the different molecular components assembled into the surfactant system. On the other hand, the application of SRT as part of treatments targeting other devastating respiratory pathologies, in babies and adults, is depending on further extensive research still required before enough amounts of good humanized clinical surfactants will be available. This review summarizes our current concepts on the compositional and structural determinants defining pulmonary surfactant activity, the principles behind the development of efficient natural animal-derived or recombinant or synthetic therapeutic surfactants, as well as a the most promising lines of research that are already opening new perspectives in the application of tailored surfactant therapies to treat important yet unresolved respiratory pathologies.

Pulmonary surfactant as a versatile biomaterial to fight COVID-19

The COVID-19 pandemic has wielded an enormous pressure on global health care systems, economics and politics. Ongoing vaccination campaigns effectively attenuate viral spreading, leading to a reduction of infected individuals, hospitalizations and mortality. Nevertheless, the development of safe and effective vaccines as well as their global deployment is time-consuming and challenging. In addition, such preventive measures have no effect on already infected individuals and can show reduced efficacy against SARS-CoV-2 variants that escape vaccine-induced host immune responses. Therefore, it is crucial to continue the development of specific COVID-19 targeting therapeutics, including small molecular drugs, antibodies and nucleic acids. However, despite clear advantages of local drug delivery to the lung, inhalation therapy of such antivirals remains difficult. This review aims to highlight the potential of pulmonary surfactant (PS) in the treatment of COVID-19. Since SARS-CoV-2 infection can progress to COVID-19-related acute respiratory distress syndrome (CARDS), which is associated with PS deficiency and inflammation, replacement therapy with exogenous surfactant can be considered to counter lung dysfunction. In addition, due to its surface-active properties and membrane-interacting potential, PS can be repurposed to enhance drug spreading along the respiratory epithelium and to promote intracellular drug delivery. By merging these beneficial features, PS can be regarded as a versatile biomaterial to combat respiratory infections, in particular COVID-19.

Nitric-Oxide-Releasing Dexamethasone Derivative NCX-1005 Improves Lung Function and Attenuates Inflammation in Experimental Lavage-Induced ARDS

Acute respiratory distress syndrome (ARDS) is a common complication of critical illness and remains a major source of morbidity and mortality in the intensive care unit (ICU). ARDS is characterised by diffuse lung inflammation, epithelial and endothelial deterioration, alveolar–capillary leak and oedema formation, and worsening respiratory failure. The present study aimed to investigate the anti-inflammatory activity of nitric-oxide-releasing dexamethasone derivative NCX-1005 as a potential novel drug for ARDS. Adult rabbits with lavage-induced ARDS were treated with dexamethasone i.v. (0.5 mg/kg; DEX) and nitro-dexamethasone i.v. (0.5 mg/kg, NCX-1005) or were untreated (ARDS). Controls represented healthy ventilated animals. The animals were subsequently oxygen-ventilated for an additional 4 h and respiratory parameters were recorded. Lung oedema, inflammatory cell profile in blood and bronchoalveolar lavage, levels of the cytokines (IL-1β, IL-6, IL-8, TNF-α), and oxidative damage (TBARS, 3NT) in the plasma and lung were evaluated. Nitric oxide-releasing dexamethasone derivative NCX-1005 improved lung function, reduced levels of cytokines, oxidative modifications, and lung oedema formation to similar degrees as dexamethasone. Only NCX-1005 prevented the migration of neutrophils into the lungs compared to dexamethasone. In conclusion, the nitric oxide-releasing dexamethasone derivative NCX-1005 has the potential to be effective drug with anti-inflammatory effect in experimental ARDS.

Pulmonary surfactant: a unique biomaterial with life-saving therapeutic applications

Pulmonary surfactant is a complex lipoprotein mixture secreted into the alveolar lumen by type 2 pneumocytes, which is composed by tens of different lipids (approximately 90% of its entire mass) and surfactant proteins (approximately 10% of the mass). It is crucially involved in maintaining lung homeostasis by reducing the values of alveolar liquid surface tension close to zero at end-expiration, thereby avoiding the alveolar collapse, and assembling a chemical and physical barrier against inhaled pathogens. A deficient amount of surfactant or its functional inactivation is directly linked to a wide range of lung pathologies, including the neonatal respiratory distress syndrome. This paper reviews the main biophysical concepts of surfactant activity and its inactivation mechanisms, and describes the past, present and future roles of surfactant replacement therapy, focusing on the exogenous surfactant preparations marketed worldwide and new formulations under development. The closing section describes the pulmonary surfactant in the context of drug delivery. Thanks to its peculiar composition, biocompatibility, and alveolar spreading capability, the surfactant may work not only as a shuttle to the branched anatomy of the lung for other drugs but also as a modulator for their release, opening to innovative therapeutic avenues for the treatment of several respiratory diseases.

Physiological fluid interfaces: Functional microenvironments, drug delivery targets, and first line of defense

Fluid interfaces, i.e. the boundary layer of two liquids or a liquid and a gas, play a vital role in physiological processes as diverse as visual perception, oral health and taste, lipid metabolism, and pulmonary breathing. These fluid interfaces exhibit a complex composition, structure, and rheology tailored to their individual physiological functions. Advances in interfacial thin film techniques have facilitated the analysis of such complex interfaces under physiologically relevant conditions. This allowed new insights on the origin of their physiological functionality, how deviations may cause disease, and has revealed new therapy strategies. Furthermore, the interactions of physiological fluid interfaces with exogenous substances is crucial for understanding certain disorders and exploiting drug delivery routes to or across fluid interfaces. Here, we provide an overview on fluid interfaces with physiological relevance, namely tear films, interfacial aspects of saliva, lipid droplet digestion and storage in the cell, and the functioning of lung surfactant. We elucidate their structure-function relationship, discuss diseases associated with interfacial composition, and describe therapies and drug delivery approaches targeted at fluid interfaces. STATEMENT OF SIGNIFICANCE: Fluid interfaces are inherent to all living organisms and play a vital role in various physiological processes. Examples are the eye tear film, saliva, lipid digestion & storage in cells, and pulmonary breathing. These fluid interfaces exhibit complex interfacial compositions and structures to meet their specific physiological function. We provide an overview on physiological fluid interfaces with a focus on interfacial phenomena. We elucidate their structure-function relationship, discuss diseases associated with interfacial composition, and describe novel therapies and drug delivery approaches targeted at fluid interfaces. This sets the scene for ocular, oral, or pulmonary surface engineering and drug delivery approaches.

[Association of different stages of histological chorioamnionitis with respiratory distress syndrome in preterm infants with a gestational age of < 32 weeks]

OBJECTIVE

To study the association of different stages of histological chorioamnionitis (HCA) with the incidence rate and severity of respiratory distress syndrome (RDS) in preterm infants.

METHODS

Related data were collected from the infants and their mothers who were treated in the Neonatal Intensive Care Unit of Qingdao Women and Children's Hospital, Qingdao University, from January 2018 to June 2020. According to the presence or absence of HCA and its stage, the infants were divided into four groups: control (n=109), early-stage HCA (n=126), middle-stage HCA (n=105), and late-stage HCA (n=36). The four groups were compared in terms of gestational age, birth weight, sex, maternal age, placental abruption, prenatal use of antibiotics, and incidence rate of RDS. The correlation between HCA stage and RDS severity was analyzed.

RESULTS

Compared with the control and late-stage HCA groups, the early-stage HCA group had a significantly lower incidence rate of placental abruption and a significantly higher rate of prenatal use of antibiotics (P < 0.05), and the early-stage HCA group had a significantly lower incidence rate of RDS than the control group (P < 0.05). The multivariate logistic regression analysis showed that early-, middle-, and late-stage HCA were protective factors against RDS (P < 0.05). The Spearman test showed that the severity of RDS in preterm infants was not correlated with the HCA stage (P > 0.05).

CONCLUSIONS

Early-, middle-, and late-stage HCA can reduce the incidence rate of RDS in preterm infants. HCA stage may not be correlated with RDS severity in preterm infants, which needs to be verified by further research.

Restoration of surfactant activity by polymyxin B in lipopolysaccharide-potentiated injury of immature rabbit lungs

During postnatal adaptation pulmonary surfactant may be inactivated by lipopolysaccharide (LPS). We evaluated the effect of surfactant therapy in combination with antibiotic polymyxin B (PxB) in double-hit model of neonatal lung injury. Surfactant (poractant alfa, Curosurf) was exposed to smooth (S) LPS without/with PxB and tested in captive bubble surfactometer. Preterm rabbits received intratracheally saline (control) or S-LPS and were ventilated with 100% oxygen. After 30 min, LPS-treated animals received no treatment, or surfactant (200 mg/kg) without/with 3% PxB; controls received the same dose of surfactant. Animals were ventilated for further 2 h. In vitro, addition of 5% S-LPS to surfactant increased minimum surface tension (γmin) and addition of 1-3% PxB to surfactant/S-LPS mixture restored γmin to low values. Animals only given S-LPS had lower lung compliance and lung gas volume (LGV) compared to surfactant groups. Treatment with surfactant/PxB, but not with surfactant only, restored LGV. Addition of PxB to the surfactant increased the alveolar expansion. S-LPS interferes with surface activity of the pulmonary surfactant and PxB improves the resistance of surfactant to LPS-induced inactivation. In our neonatal model of respiratory distress syndrome surfactant gives positive response even in simultaneous exposure to S-LPS, when enriched with PxB.

Impact of synthetic surfactant CHF5633 with SP-B and SP-C analogues on lung function and inflammation in rabbit model of acute respiratory distress syndrome

Acute respiratory distress syndrome (ARDS) is associated with diffuse inflammation, alveolar epithelial damage, and leakage of plasma proteins into the alveolar space, which together contribute to inactivation of pulmonary surfactant and respiratory failure. Exogenous surfactant delivery is therefore considered to hold potential for ARDS treatment, but clinical trials with natural derived surfactant or synthetic surfactant containing a surfactant protein C (SP-C) analogue have been negative. Synthetic surfactant CHF5633, containing analogues of SP-B and SP-C, may be effective against ARDS. The aim here was to compare treatment effects of CHF5633 and animal-derived surfactant poractant alfa in animal model of ARDS. ARDS was induced in adult New Zealand rabbits by mild lung lavages followed by injurious ventilation until respiratory failure (P/F ratio <26.7 kPa). The animals were then treated with intratracheal bolus of 200 mg/kg CHF5633 or poractant alfa (Curosurf® ), or air as control. The animals were subsequently ventilated for an additional 4 hr and respiratory parameters were recorded regularly. Postmortem, histological analysis, degree of lung edema, and levels of the cytokines TNFα, IL-6, and IL-8 in lung homogenates were evaluated. Both surfactant preparations improved lung function, reduced the levels of pro-inflammatory cytokines, and degree of lung edema to very similar degrees versus the controls. No significant differences in any of the analyzed parameters were observed between the CHF5633- and poractant alfa-treated groups. This study indicates that single dose of CHF5633 improves lung function and attenuates inflammation as effectively as poractant alfa in experimental ARDS caused by injurious ventilation.

Synthetic Surfactant CHF5633 Compared with Poractant Alfa in the Treatment of Neonatal Respiratory Distress Syndrome: A Multicenter, Double-Blind, Randomized, Controlled Clinical Trial

OBJECTIVE

To compare efficacy and safety of a new synthetic surfactant, CHF5633, enriched with surfactant proteins, SP-B and SP-C peptide analogues, with porcine surfactant, poractant alfa, for the treatment of respiratory distress syndrome in infants born preterm.

STUDY DESIGN

Neonates born preterm on respiratory support requiring fraction of inspired oxygen (FiO₂) ≥0.30 from 24^0/7 to 26^6/7 weeks and FiO₂ ≥0.35 from 27^0/7 to 29^6/7 weeks of gestation to maintain 88%-95% oxygen saturation were randomized to receive 200 mg/kg of CHF5633 or poractant alfa. If necessary, redosing was given at 100 mg/kg. Efficacy end points were oxygen requirement (FiO₂, respiratory severity score [FiO₂ × mean airway pressure]) in the first 24 hours, 7 and 28 days, discharge home, and/or 36 weeks of postmenstrual age; mortality and bronchopulmonary dysplasia at 28 days and 36 weeks of PMA. Adverse events and immunogenicity were monitored for safety.

RESULTS

Of the 123 randomized neonates, 113 were treated (56 and 57 in CHF5633 and poractant alfa groups, respectively). In both arms, FiO₂ and respiratory severity score decreased from baseline at all time points (P < .001) with no statistically significant differences between groups. Rescue surfactant use (19 [33.9%] vs 17 [29.8%]), bronchopulmonary dysplasia (31 [55.4%] and 32 [56.1%]), and mortality at day 28 (4 [7.1%] and 3 [5.3%]) were similar in the CHF5633 and poractant alfa groups, respectively. In 2 (3.4%) and 1 (1.7%) neonates, adverse drug reactions were reported in CHF5633 and poractant alfa groups, respectively. No immunogenicity was detected.

CONCLUSIONS

Treatment with CHF5633 showed similar efficacy and safety as poractant alfa in neonates born preterm with moderate-to-severe respiratory distress syndrome.

TRIAL REGISTRATION

ClinicalTrials.gov: NCT02452476.

In Vitro Functional and Structural Characterization of A Synthetic Clinical Pulmonary Surfactant with Enhanced Resistance to Inhibition

CHF5633 is a novel synthetic clinical pulmonary surfactant preparation composed by two phospholipid species, dipalmitoyl phosphatidylcholine (DPPC) and palmitoyloleoyl phosphatidylglycerol (POPG), and synthetic analogues of the hydrophobic surfactant proteins SP-B and SP-C. In this study, the interfacial properties of CHF5633 in the absence and in the presence of inhibitory serum proteins have been assessed in comparison with a native surfactant purified from porcine lungs and with poractant alpha, a widely used clinical surfactant preparation. The study of the spreading properties of CHF5633 in a Wilhelmy balance, its ability to adsorb and accumulate at air-liquid interfaces as revealed by a multiwell fluorescence assay, and its dynamic behavior under breathing-like compression-expansion cycling in a Captive Bubble Surfactometer (CBS), all revealed that CHF5633 exhibits a good behavior to reduce and sustain surface tensions to values below 5 mN/m. CHF5633 shows somehow slower initial interfacial adsorption than native surfactant or poractant alpha, but a better resistance to inhibition by serum proteins than the animal-derived clinical surfactant, comparable to that of the full native surfactant complex. Interfacial CHF5633 films formed in a Langmuir-Blodgett balance coupled with epifluorescence microscopy revealed similar propensity to segregate condensed lipid domains under compression than films made by native porcine surfactant or poractant alpha. This ability of CHF5633 to segregate condensed lipid phases can be related with a marked thermotropic transition from ordered to disordered membrane phases as exhibited by differential scanning calorimetry (DSC) of CHF5633 suspensions, occurring at similar temperatures but with higher associated enthalpy than that shown by poractant alpha. The good interfacial behavior of CHF5633 tested under physiologically meaningful conditions in vitro and its higher resistance to inactivation by serum proteins, together with its standardized and well-defined composition, makes it a particularly useful therapeutic preparation to be applied in situations associated with lung inflammation and edema, alone or in combined strategies to exploit surfactant-facilitated drug delivery.

Synthetic surfactant with a recombinant surfactant protein C analogue improves lung function and attenuates inflammation in a model of acute respiratory distress syndrome in adult rabbits

AIM

In acute respiratory distress syndrome (ARDS) damaged alveolar epithelium, leakage of plasma proteins into the alveolar space and inactivation of pulmonary surfactant lead to respiratory dysfunction. Lung function could potentially be restored with exogenous surfactant therapy, but clinical trials have so far been disappointing. These negative results may be explained by inactivation and/or too low doses of the administered surfactant. Surfactant based on a recombinant surfactant protein C analogue (rSP-C33Leu) is easy to produce and in this study we compared its effects on lung function and inflammation with a commercial surfactant preparation in an adult rabbit model of ARDS.

METHODS

ARDS was induced in adult New Zealand rabbits by mild lung-lavages followed by injurious ventilation (V_T 20 m/kg body weight) until P/F ratio < 26.7 kPa. The animals were treated with two intratracheal boluses of 2.5 mL/kg of 2% rSP-C33Leu in DPPC/egg PC/POPG, 50:40:10 or poractant alfa (Curosurf®), both surfactants containing 80 mg phospholipids/mL, or air as control. The animals were subsequently ventilated (V_T 8-9 m/kg body weight) for an additional 3 h and lung function parameters were recorded. Histological appearance of the lungs, degree of lung oedema and levels of the cytokines TNFα IL-6 and IL-8 in lung homogenates were evaluated.

RESULTS

Both surfactant preparations improved lung function vs. the control group and also reduced inflammation scores, production of pro-inflammatory cytokines, and formation of lung oedema to similar degrees. Poractant alfa improved compliance at 1 h, P/F ratio and PaO₂ at 1.5 h compared to rSP-C33Leu surfactant.

CONCLUSION

This study indicates that treatment of experimental ARDS with synthetic lung surfactant based on rSP-C33Leu improves lung function and attenuates inflammation.

Mass spectrometry imaging as a tool for evaluating the pulmonary distribution of exogenous surfactant in premature lambs

Background

The amount of surfactant deposited in the lungs and its overall pulmonary distribution determine the therapeutic outcome of surfactant replacement therapy. Most of the currently available methods to determine the intrapulmonary distribution of surfactant are time-consuming and require surfactant labelling. Our aim was to assess the potential of Mass Spectrometry Imaging (MSI) as a label-free technique to qualitatively and quantitatively evaluate the distribution of surfactant to the premature lamb.

Methods

Twelve preterm lambs (gestational age 126-127d, term ~150d) were allocated in two experimental groups. Seven lambs were treated with an intratracheal bolus of the synthetic surfactant CHF5633 (200 mg/kg) and 5 lambs were managed with mechanical ventilation for 120 min, as controls. The right lung lobes of all lambs were gradually frozen while inflated to 20 cmH₂O pressure for lung cryo-sections for MSI analysis. The intensity signals of SP-C analog and SP-B analog, the two synthetic peptides contained in the CHF5633 surfactant, were used to locate, map and quantify the intrapulmonary exogenous surfactant.

Results

Surfactant treatment was associated with a significant improvement of the mean arterial oxygenation and lung compliance (p < 0.05). Nevertheless, the physiological response to surfactant treatment was not uniform across all animals. SP-C analog and SP-B analog were successfully imaged and quantified by means of MSI in the peripheral lungs of all surfactant-treated animals. The intensity of the signal was remarkably low in untreated lambs, corresponding to background noise. The signal intensity of SP-B analog in each surfactant-treated animal, which represents the surfactant distributed to the peripheral right lung, correlated well with the physiologic response as assessed by the area under the curves of the individual arterial partial oxygen pressure and dynamic lung compliance curves of the lambs.

Conclusions

Applying MSI, we were able to detect, locate and quantify the amount of exogenous surfactant distributed to the lower right lung of surfactant-treated lambs. The distribution pattern of SP-B analog correlated well with the pulmonary physiological outcomes of the animals. MSI is a valuable label-free technique which is able to simultaneously evaluate qualitative and quantitative drug distribution in the lung.

Electronic supplementary material

The online version of this article (10.1186/s12931-019-1144-5) contains supplementary material, which is available to authorized users.

Helical side chain chemistry of a peptoid-based SP-C analogue: Balancing structural rigidity and biomimicry

Surfactant protein C (SP-C) is an important constituent of lung surfactant (LS) and, along with SP-B, is included in exogenous surfactant replacement therapies for treating respiratory distress syndrome (RDS). SP-C's biophysical activity depends upon the presence of a rigid C-terminal helix, of which the secondary structure is more crucial to functionality than precise side-chain chemistry. SP-C is highly sequence-conserved, suggesting that the β-branched, aliphatic side chains of the helix are also important. Nonnatural mimics of SP-C were created using a poly-N-substituted glycine, or "peptoid," backbone. The mimics included varying amounts of α-chiral, aliphatic side chains and α-chiral, aromatic side chains in the helical region, imparting either biomimicry or structural rigidity. Biophysical studies confirmed that the peptoids mimicked SP-C's secondary structure and replicated many of its surface-active characteristics. Surface activity was optimized by incorporating both structurally rigid and biomimetic side chain chemistries in the helical region indicating that both characteristics are important for activity. By balancing these features in one mimic, a novel analogue was created that emulates SP-C's in vitro surface activity while overcoming many of the challenges related to natural SP-C. Peptoid-based analogues hold great potential for use in a synthetic, biomimetic LS formulation for treating RDS.

Synthetic surfactants with SP-B and SP-C analogues to enable worldwide treatment of neonatal respiratory distress syndrome and other lung diseases

Treatment of neonatal respiratory distress syndrome (RDS) using animal-derived lung surfactant preparations has reduced the mortality of handling premature infants with RDS to a 50th of that in the 1960s. The supply of animal-derived lung surfactants is limited and only a part of the preterm babies is treated. Thus, there is a need to develop well-defined synthetic replicas based on key components of natural surfactant. A synthetic product that equals natural-derived surfactants would enable cost-efficient production and could also facilitate the development of the treatments of other lung diseases than neonatal RDS. Recently the first synthetic surfactant that contains analogues of the two hydrophobic surfactant proteins B (SP-B) and SP-C entered clinical trials for the treatment of neonatal RDS. The development of functional synthetic analogues of SP-B and SP-C, however, is considerably more challenging than anticipated 30 years ago when the first structural information of the native proteins became available. For SP-B, a complex three-dimensional dimeric structure stabilized by several disulphides has necessitated the design of miniaturized analogues. The main challenge for SP-C has been the pronounced amyloid aggregation propensity of its transmembrane region. The development of a functional non-aggregating SP-C analogue that can be produced synthetically was achieved by designing the amyloidogenic native sequence so that it spontaneously forms a stable transmembrane α-helix.

Disulphide Bridges in Surfactant Protein B Analogues Affect Their Activity in Synthetic Surfactant Preparations

BACKGROUND

Limited supply and complicated manufacturing procedure of animal-derived surfactants make the development of synthetic surfactants warranted. The synthesis of surfactant protein (SP)-B and SP-C is complicated and several analogues have been developed. Mini-BLeu is an analogue that corresponds to the first and last helix of SP-B joined by a loop and linked by 2 disulphide bridges. SP-C33Leu is an SP-C analogue that can be cost-efficiently produced, but no such analogue has yet been described for SP-B.

OBJECTIVE

To design short SP-B analogues which lack disulphide bridges, are easy to produce and are efficacious in a preterm rabbit fetus model of neonatal RDS.

METHODS

Synthetic surfactants were prepared by adding 2 or 8% (w/w) of synthetic variants of Mini-B27, similar to Mini-BLeu but with a short loop, or different peptides covering helix 1 of SP-B to 2% (w/w) of SP-C33Leu in 80 mg/mL of 1,2-dipalmitoyl-sn-glycero-3-phosphocholine/egg yolk phosphatidylcholine/1-palmitoyl-2-oleoyl-sn-glycero-3-phosphoglycerol, 50: 40: 10 (by weight). Premature newborn rabbit fetuses were treated with 200 mg/kg of the surfactant preparations and ventilated with defined pressures for 30 min without positive end-expiratory pressure. Tidal volumes were registered during the experiments and lung gas volumes were measured at the end of the ventilation period.

RESULTS

Synthetic surfactant containing the Mini-B27 analogue with 2 disulphides gives similar lung gas volumes as treatment with an animal-derived surfactant preparation, but all other SP-B analogues gave lower lung gas volumes. All synthetic surfactants studied gave no significant differences in compliances except the surfactant containing the Mini-B27 analogue without cysteines that performed somewhat better at 30 min.

CONCLUSION

The helix-loop-helix SP-B analogues tested in this study require the presence of 2 disulphide bridges for optimal activity in a rabbit RDS model.

Prenatal Intra-Amniotic Endotoxin Induces Fetal Gut and Lung Immune Responses and Postnatal Systemic Inflammation in Preterm Pigs

Prenatal inflammation is a major risk for preterm birth and neonatal morbidity, but its effects on postnatal immunity and organ functions remain unclear. Using preterm pigs as a model for preterm infants, we investigated whether prenatal intra-amniotic (IA) inflammation modulates postnatal systemic immune status and organ functions. Preterm pigs exposed to IA lipopolysaccharide (LPS) for 3 days were compared with controls at birth and postnatal day 5 after formula feeding. IA LPS induced mild chorioamnionitis but extensive intra-amniotic inflammation. There were minor systemic effects at birth (increased blood neutrophil counts), but a few days later, prenatal LPS induced delayed neonatal arousal, systemic inflammation (increased blood leukocytes, plasma cytokines, and splenic bacterial counts), altered serum biochemistry (lower albumin and cholesterol and higher iron and glucose values), and increased urinary protein and sodium excretion. In the gut and lungs, IA LPS-induced inflammatory responses were observed mainly at birth (increased LPS, CXCL8, and IL-1β levels and myeloperoxidase-positive cell density, multiple increases in innate immune gene expressions, and reduced villus heights), but not on postnatal day 5 (except elevated lung CXCL8 and diarrhea symptoms). Finally, IA LPS did not affect postnatal gut brush-border enzymes, hexose absorption, permeability, or sensitivity to necrotizing enterocolitis on day 5. Short-term IA LPS exposure predisposes preterm pigs to postnatal systemic inflammation after acute fetal gut and lung inflammatory responses.

Metabolism of a synthetic compared with a natural therapeutic pulmonary surfactant in adult mice

Secreted pulmonary surfactant phosphatidylcholine (PC) has a complex intra-alveolar metabolism that involves uptake and recycling by alveolar type II epithelial cells, catabolism by alveolar macrophages, and loss up the bronchial tree. We compared the in vivo metabolism of animal-derived poractant alfa (Curosurf) and a synthetic surfactant (CHF5633) in adult male C57BL/6 mice. The mice were dosed intranasally with either surfactant (80 mg/kg body weight) containing universally ¹³C-labeled dipalmitoyl PC (DPPC) as a tracer. The loss of [U¹³C]DPPC from bronchoalveolar lavage and lung parenchyma, together with the incorporation of ¹³C-hydrolysis fragments into new PC molecular species, was monitored by electrospray ionization tandem mass spectrometry. The catabolism of CHF5633 was considerably delayed compared with poractant alfa, the hydrolysis products of which were cleared more rapidly. There was no selective resynthesis of DPPC and, strikingly, acyl remodeling resulted in preferential synthesis of polyunsaturated PC species. In conclusion, both surfactants were metabolized by similar pathways, but the slower catabolism of CHF5633 resulted in longer residence time in the airways and enhanced recycling of its hydrolysis products into new PC species.

Quenching of tryptophan fluorescence in a highly scattering solution: Insights on protein localization in a lung surfactant formulation

CHF5633 (Chiesi Farmaceutici, Italy) is a synthetic surfactant developed for respiratory distress syndrome replacement therapy in pre-term newborn infants. CHF5633 contains two phospholipids (dipalmitoylphosphatidylcholine and 1-palmitoyl-2oleoyl-sn-glycero-3-phosphoglycerol sodium salt), and peptide analogues of surfactant protein C (SP-C analogue) and surfactant protein B (SP-B analogue). Both proteins are fundamental for an optimal surfactant activity in vivo and SP-B genetic deficiency causes lethal respiratory failure after birth. Fluorescence emission of the only tryptophan residue present in SP-B analogue (SP-C analogue has none) could in principle be exploited to probe SP-B analogue conformation, localization and interaction with other components of the pharmaceutical formulation. However, the high light scattering activity of the multi-lamellar vesicles suspension characterizing the pharmaceutical surfactant formulation represents a challenge for such studies. We show here that quenching of tryptophan fluorescence and Singular Value Decomposition analysis can be used to accurately calculate and subtract background scattering. The results indicate, with respect to Trp microenvironment, a conformationally homogeneous population of SP-B. Trp is highly accessible to the water phase, suggesting a surficial localization on the membrane of phospholipid vesicles, similarly to what observed for full length SP-B in natural lung surfactant, and supporting an analogous role in protein anchoring to the lipid phase.

Effective in vivo treatment of acute lung injury with helical, amphipathic peptoid mimics of pulmonary surfactant proteins

Acute lung injury (ALI) leads to progressive loss of breathing capacity and hypoxemia, as well as pulmonary surfactant dysfunction. ALI's pathogenesis and management are complex, and it is a significant cause of morbidity and mortality worldwide. Exogenous surfactant therapy, even for research purposes, is impractical for adults because of the high cost of current surfactant preparations. Prior in vitro work has shown that poly-N-substituted glycines (peptoids), in a biomimetic lipid mixture, emulate key biophysical activities of lung surfactant proteins B and C at the air-water interface. Here we report good in vivo efficacy of a peptoid-based surfactant, compared with extracted animal surfactant and a synthetic lipid formulation, in a rat model of lavage-induced ALI. Adult rats were subjected to whole-lung lavage followed by administration of surfactant formulations and monitoring of outcomes. Treatment with a surfactant protein C mimic formulation improved blood oxygenation, blood pH, shunt fraction, and peak inspiratory pressure to a greater degree than surfactant protein B mimic or combined formulations. All peptoid-enhanced treatment groups showed improved outcomes compared to synthetic lipids alone, and some formulations improved outcomes to a similar extent as animal-derived surfactant. Robust biophysical mimics of natural surfactant proteins may enable new medical research in ALI treatment.

Vitamin A Supplementation by Endotracheal Application of a Nano-encapsulated Preparation Is Feasible in Ventilated Preterm Lambs

BACKGROUND

Vitamin A (VA) is crucial for lung growth and development. In premature infants, inadequate VA levels are associated with an increased risk of bronchopulmonary dysplasia (BPD). Intramuscular VA supplementation has been shown to decrease the incidence of BPD, but is not widely used in the clinical setting due to concerns about feasibility and pain. We studied VA kinetics, distribution, and the induction of early genetic expression of retinoid homeostatic genes in the lung after endotracheal and intravenous application in a preterm lamb model.

METHODS

Lambs were delivered prematurely after 85% of gestation, intubated, and ventilated for 3 hours. The animals were randomized to receive no VA ("control"), a bolus of VA intravenously ("i.v."), or VA endotracheally directly after administration of surfactant ("e.t.").

RESULTS

Animals treated with VA endotracheally directly after administration of surfactant showed significant increases of VA in serum and lung compared to controls. Animals treated with a bolus of VA intravenously showed significant increases of VA in serum, lung, and liver; however, peak serum concentrations and mRNA levels of homeostatic genes raised concerns about toxicity in this group.

CONCLUSIONS

Endotracheal VA supplementation in preterm lambs is feasible and might offer advantages in comparison to i.v. Further studies are warranted to explore biological effects in the context of BPD.

Clinical, technological, and economic issues associated with developing new lung surfactant therapeutics

Discovery of lung surfactant deficiency as a main cause of neonatal respiratory distress syndrome (NRDS) has influenced a steep increase in lung surfactant research. Although this has yielded impactful scientific discoveries, much of the basic research on lung surfactants has failed to translate into clinical practices. This is attributed to insufficient information covering the entire lung surfactant ecosystem, from the basic science to economics surrounding the development and clinical practices. In this manuscript, developments related to improving therapeutic lung surfactant as well as the degree of unmet need are analyzed from both technical and economic perspectives. Two potential opportunities are emphasized: (1) aerosolized lung surfactants to treat NRDS infants, and (2) synthetic lung surfactants for acute respiratory distress syndrome (ARDS) patients. Each has a modestly projected US market size of $120 million and $4 billion, well enough to make up for the high development costs associated with investigational drug development. Both opportunities have been pursued in the past, but to date these attempts have met with no success mainly due to technical limitations. With the recent advancements in both fields, technology improvements have created opportunities to solve both decades-old problems.

A first-in-human clinical study of a new SP-B and SP-C enriched synthetic surfactant (CHF5633) in preterm babies with respiratory distress syndrome

OBJECTIVE

CHF5633 (Chiesi Farmaceutici S.p.A., Parma, Italy) is the first fully synthetic surfactant enriched by peptide analogues of two human surfactant proteins. We planned to assess safety and tolerability of CHF5633 and explore preliminary efficacy.

DESIGN

Multicentre cohort study.

PATIENTS

Forty infants from 27⁺⁰ to 33⁺⁶ weeks gestation with respiratory distress syndrome requiring fraction of inspired oxygen (FiO₂) ≥0.35 were treated with a single dose of CHF5633 within 48 hours after birth. The first 20 received 100 mg/kg and the second 20 received 200 mg/kg.

OUTCOME MEASURES

Adverse events (AEs) and adverse drug reactions (ADRs) were monitored with complications of prematurity considered AEs if occurring after dosing. Systemic absorption and immunogenicity were assessed. Efficacy was assessed by change in FiO₂ after dosing and need for poractant-alfa rescue.

RESULTS

Rapid and sustained improvements in FiO₂ were observed in 39 (98%) infants. One responded neither to CHF5633 nor two poractant-alfa doses. A total of 79 AEs were experienced by 19 infants in the 100 mg/kg cohort and 53 AEs by 20 infants in the 200 mg/kg cohort. Most AEs were expected complications of prematurity. Two unrelated serious AEs occurred in the second cohort. One infant died of necrotising enterocolitis and another developed viral bronchiolitis after discharge. The single ADR was an episode of transient endotracheal tube obstruction following a 200 mg/kg dose. Neither systemic absorption, nor antibody development to either peptide was detected.

CONCLUSIONS

Both CHF5633 doses were well tolerated and showed promising clinical efficacy profile. These encouraging data provide a basis for ongoing randomised controlled trials.

TRIAL REGISTRATION NUMBER

ClinicalTrials.gov NCT01651637.

Efficient Interfacially Driven Vehiculization of Corticosteroids by Pulmonary Surfactant

Pulmonary surfactant is a crucial system to stabilize the respiratory air-liquid interface. Furthermore, pulmonary surfactant has been proposed as an effective method for targeting drugs to the lungs. However, few studies have examined in detail the mechanisms of incorporation of drugs into surfactant, the impact of the presence of drugs on pulmonary surfactant performance at the interface under physiologically meaningful conditions, or the ability of pulmonary surfactant to use the air-liquid interface to vehiculise drugs to long distances. This study focuses on the ability of pulmonary surfactant to interfacially vehiculize corticosteroids such as beclomethasone dipropionate (BDP) or Budesonide (BUD) as model drugs. The main objectives have been to (a) characterize the incorporation of corticosteroids into natural and synthetic surfactants, (b) evaluate whether the presence of corticosteroids affects surfactant functionality, and (c) determine whether surfactant preparations enable the efficient spreading and distribution of BDP and BUD along the air-liquid interface. We have compared the performance of a purified surfactant from porcine lungs and two clinical surfactants: Poractant alfa, a natural surfactant of animal origin extensively used to treat premature babies, and CHF5633, a new synthetic surfactant preparation currently under clinical trials. Both, natural and clinical surfactants spontaneously incorporated corticosteroids up to at least 10% by mass with respect to phospholipid content. The presence of the drugs did not interfere with their ability to efficiently adsorb into air-liquid interfaces and form surface active films able to reach and sustain very low surface tensions (<2 mN/m) under compression-expansion cycling mimicking breathing dynamics. Furthermore, the combination of clinical surfactant with corticosteroids efficiently promoted the active diffusion of the drug to long distances along the air-liquid interface. This effect could not be mimicked by vehiculisation of corticosteroids in liposomes or in micellar emulsions similar to the formulations currently in use to deliver anti-inflammatory corticosteroids through inhalation.

A Combination of Short and Simple Surfactant Protein B and C Analogues as a New Synthetic Surfactant: In Vitro and Animal Experiments

PURPOSE

Pulmonary surfactants for preterm infants contain mostly animal-derived surfactant proteins (SPs), which are essential for lowering surface tension. We prepared artificial pulmonary surfactants using synthetic human SP analogs and performed in vitro and in vivo experiments.

MATERIALS AND METHODS

We synthesized peptide analogues that resemble human SP-B (RMLPQLVCRLVLRCSMD) and SP-C (CPVHLKRLLLLLLLLLLLLLLLL). Dipalmitoylphosphatidylcholine (DPPC), phosphatidylglycerol (PG), and palmitic acid (PA) were added and mixed in lyophilized to render powdered surfactant. Synsurf-1 was composed of DPPC:PG:PA:SP-B (75:25:10:3, w/w); Synsurf-2 was composed of DPPC:PG:PA:SP-C (75:25:10:3, w/w); and Synsurf-3 was composed of DPPC:PG:PA:SP-B:SP-C (75:25:10:3:3, w/w). We performed in vitro study to compare the physical characteristics using pulsating bubble surfactometer and modified Wilhelmy balance test. Surface spreading and adsorption test of the surfactant preparations were measured. In vivo test was performed using term and preterm rabbit pups. Pressure-volume curves were generated during the deflation phase. Histologic findings were examined.

RESULTS

Pulsating bubble surfactometer readings revealed following minimum and maximum surface tension (mN/m) at 5 minutes: Surfacten® (5.5±0.4, 32.8±1.6), Synsurf-1 (16.7±0.6, 28.7±1.5), Synsurf-2 (7.9±1.0, 33.1±1.6), and Synsurf-3 (7.1±0.8, 34.5±1.0). Surface spreading rates were as follows: Surfacten® (27 mN/m), Synsurf-1 (43 mN/m), Synsurf-2 (27 mN/m), and Synsurf-3 (27 mN/m). Surface adsorption rate results were as follows: Surfacten® (28 mN/m), Synsurf-1 (35 mN/m), Synsurf-2 (29 mN/m), and Synsurf-3 (27 mN/m). The deflation curves were best for Synsurf-3; those for Synsurf-2 were better than those for Surfacten®. Synsurf-1 was the worst surfactant preparation. Microscopic examination showed the largest aerated area of the alveoli in the Synsurf-3 group, followed by Synsurf-1 and Surfacten®; Synsurf-2 was the smallest.

CONCLUSION

Synsurf-3 containing both SP-B and SP-C synthetic analogs showed comparable and better efficacy than commercially used Surfacten® in lowering surface tension, pressure-volume curves, and tissue aerated area of the alveoli.

Cerebral and lung effects of a new generation synthetic surfactant with SP-B and SP-C analogs in preterm lambs

BACKGROUND

Though natural surfactants (SF) are clinically superior to protein-free synthetic preparations, CHF-5633, a synthetic SF containing SP-B and SP-C analog peptides is a potential alternative to natural SF for treating neonatal respiratory distress syndrome (RDS). Nevertheless, information is lacking regarding the safety of this new treatment for the neonatal brain. We sought to compare the cerebral and pulmonary effects of this new synthetic surfactant (CHF5633) with those of natural porcine surfactant (Cursosurf) in premature lambs with RDS.

METHODS

Twenty-one preterm lambs were randomly assigned to receive CHF5633, Curosurf, or no treatment (control). Pulmonary (gas exchange, lung mechanics) and cerebral (carotid artery blood flow, cerebral oxygen metabolism) effects were measured every 30 min for 6 h. Pulmonary and cerebral histological analysis were also performed.

RESULTS

After delivery, lambs developed severe RDS (F_IO2 :1, pH < 7.15, P_aCO2  > 70 mmHg, P_aO2  < 40 mmHg, C_dyn  < 0.1 mL/cmH₂ O/kg). By 30 min after treatment, animals in both SF-treated groups had consistently better gas exchange and lung mechanics than controls. After CHF5633 administration, P_aCO2 , carotid artery blood flow, and cerebral oxygen delivery tended to slowly decrease compared to other groups. By 2 h, SF-treated groups had similar values of all parameters studied, these remaining steady for the rest of the experiment. Lambs administered CHF5633 obtained better lung and brain injury scores than controls.

CONCLUSION

Intratracheal administration of a bolus of CHF5633 improves pulmonary status in preterm lambs with severe RDS, obtaining better lung and brain injury scores than controls and favorable cerebral hemodynamics, comparable to those with gold standard Curosurf treatment.

Optimization of Variable Ventilation for Physiology, Immune Response and Surfactant Enhancement in Preterm Lambs

Preterm infants often require mechanical ventilation due to lung immaturity including reduced or abnormal surfactant. Since cyclic stretch with cycle-by-cycle variability is known to augment surfactant release by epithelial cells, we hypothesized that such in vivo mechanotransduction improves surfactant maturation and hence lung physiology in preterm subjects. We thus tested whether breath-by-breath variability in tidal volume (V_T) in variable ventilation (VV) can be tuned for optimal performance in a preterm lamb model. Preterm lambs were ventilated for 3 h with conventional ventilation (CV) or two variants of VV that used a maximum V_T of 1.5 (VV1) or 2.25 (VV2) times the mean V_T. V_T was adjusted during ventilation to a permissive pCO₂ target range. Respiratory mechanics were monitored continuously using the forced oscillation technique, followed by postmortem bronchoalveolar lavage and tissue collection. Both VVs outperformed CV in blood gas parameters (pH, SaO₂, cerebral O₂ saturation). However, only VV2 lowered PaCO₂ and had a higher specific respiratory compliance than CV. VV2 also increased surfactant protein (SP)-B release compared to VV1 and stimulated its production compared to CV. The production and release of proSP-C however, was increased with CV compared to both VVs. There was more SP-A in both VVs than CV in the lung, but VV2 downregulated SP-A in the lavage, whereas SP-D significantly increased in CV in both the lavage and lung. Compared to CV, the cytokines IL-1β, and TNFα decreased with both VVs with less inflammation during VV2. Additionally, VV2 lungs showed the most homogeneous alveolar structure and least inflammatory cell infiltration assessed by histology. CV lungs exhibited over-distension mixed with collapsed and interstitial edematous regions with occasional hemorrhage. Following VV1, some lambs had normal alveolar structure while others were similar to CV. The IgG serum proteins in the lavage, a marker of leakage, were the highest in CV. An overall combined index of performance that included physiological, biochemical and histological markers was the best in VV2 followed by VV1. Thus, VV2 outperformed VV1 by enhancing SP-B metabolism resulting in open alveolar airspaces, less leakage and inflammation and hence better respiratory mechanics.

The Future of Bronchopulmonary Dysplasia: Emerging Pathophysiological Concepts and Potential New Avenues of Treatment

Yearly more than 15 million babies are born premature (<37 weeks gestational age), accounting for more than 1 in 10 births worldwide. Lung injury caused by maternal chorioamnionitis or preeclampsia, postnatal ventilation, hyperoxia, or inflammation can lead to the development of bronchopulmonary dysplasia (BPD), one of the most common adverse outcomes in these preterm neonates. BPD patients have an arrest in alveolar and microvascular development and more frequently develop asthma and early-onset emphysema as they age. Understanding how the alveoli develop, and repair, and regenerate after injury is critical for the development of therapies, as unfortunately there is still no cure for BPD. In this review, we aim to provide an overview of emerging new concepts in the understanding of perinatal lung development and injury from a molecular and cellular point of view and how this is paving the way for new therapeutic options to prevent or treat BPD, as well as a reflection on current treatment procedures.

Restoring pulmonary surfactant membranes and films at the respiratory surface

Pulmonary surfactant is a complex of lipids and proteins assembled and secreted by the alveolar epithelium into the thin layer of fluid coating the respiratory surface of lungs. There, surfactant forms interfacial films at the air-water interface, reducing dramatically surface tension and thus stabilizing the air-exposed interface to prevent alveolar collapse along respiratory mechanics. The absence or deficiency of surfactant produces severe lung pathologies. This review describes some of the most important surfactant-related pathologies, which are a cause of high morbidity and mortality in neonates and adults. The review also updates current therapeutic approaches pursuing restoration of surfactant operative films in diseased lungs, mainly through supplementation with exogenous clinical surfactant preparations. This article is part of a Special Issue entitled: Membrane Lipid Therapy: Drugs Targeting Biomembranes edited by Pablo V. Escribá.

In vitro and in vivo comparison between poractant alfa and the new generation synthetic surfactant CHF5633

BACKGROUND

CHF5633 is a new generation synthetic surfactant containing both SP-B and SP-C analogues developed for the treatment of respiratory distress syndrome. Here, the optimal dose and its performance in comparison to the animal-derived surfactant poractant alfa were investigated.

METHODS

In vitro surfactant activity was determined by means of the Wilhelmy balance and the capillary surfactometer. The dose-finding study was performed in preterm rabbits with severe surfactant deficiency. CHF5633 doses ranging from 50 to 300 mg/kg were used. Untreated animals and animals treated with 200 mg/kg of poractant alfa were included for comparison.

RESULTS

In vitro, minimum surface tension (γ_min) was decreased from values above 70 to 0 mN/m by both surfactants, and they formed rapidly a film at the air-liquid interface. In vivo studies showed a clear dose-dependent improvement of lung function for CHF5633. The pulmonary effect of CHF5633 200 mg/kg dose was comparable to the pulmonary response elicited by 200 mg/kg of poractant alfa in preterm rabbits.

CONCLUSION

CHF5633 is as efficient as poractant alfa in our in vitro and in vivo settings. A clear dose-dependent improvement of lung function could be observed for CHF5633, with the dose of 200 mg/kg being the most efficient one.

Evolution of surfactant therapy for respiratory distress syndrome: past, present, and future

Respiratory distress syndrome (RDS) due to surfactant deficiency is the most common cause of respiratory failure in preterm infants. Tremendous progress has been made since the original description that surfactant deficiency is the major cause of RDS. Surfactant therapy has been extensively studied in preterm infants and has been shown to significantly decrease air leaks and neonatal and infant mortality. Synthetic and animal-derived surfactants from bovine as well as porcine origin have been evaluated in randomized controlled trials. Animal-derived surfactants generally result in faster weaning of respiratory support, shorter duration of invasive ventilation, and decreased mortality when compared to first- or second-generation of synthetic surfactants, but some of the second-generation synthetic surfactants are at least not inferior to the animal-derived surfactants. Using a higher initial dose of porcine derived surfactant may provide better outcomes when compared with using lower doses of bovine surfactants, likely, due to compositional difference and/or the dose. Third-generation synthetic surfactant containing peptide analogs of surfactant protein B and C are currently being studied. Less invasive intra-tracheal surfactant administration techniques in spontaneously breathing neonate receiving noninvasive ventilator support are also being evaluated. In the present era, prophylactic surfactant is not recommended as it may increase the risk of lung injury or death. In the future, surfactants may be used as vector to deliver steroids, or used in combination with molecules, such as, recombinant Club Cell Protein-10 (rhCC-10) to improve pulmonary outcomes. Also, noninvasive surfactant administration techniques, such as aerosolization or atomization of surfactant may play a greater role in the future.

In Vivo Evaluation of the Acute Pulmonary Response to Poractant Alfa and Bovactant Treatments in Lung-Lavaged Adult Rabbits and in Preterm Lambs with Respiratory Distress Syndrome

BACKGROUND

Poractant alfa (Curosurf^®) and Bovactant (Alveofact^®) are two animal-derived pulmonary surfactants preparations approved for the treatment of neonatal respiratory distress syndrome (nRDS). They differ in their source, composition, pharmaceutical form, and clinical dose. How much these differences affect the acute pulmonary response to treatment is unknown.

OBJECTIVES

Comparing these two surfactant preparations in two different animal models of respiratory distress focusing on the short-term response to treatment.

METHODS

Poractant alfa and Bovactant were administered in a 50-200 mg/kg dose range to surfactant-depleted adult rabbits with acute respiratory distress syndrome induced by lavage and to preterm lambs (127-129 days gestational age) with nRDS induced by developmental immaturity. The acute impact of surfactant therapy on gas exchange and pulmonary mechanics was assessed for 1 h in surfactant-depleted rabbits and for 3 h in preterm lambs.

RESULTS

Overall, treatment with Bovactant 50 mg/kg or Poractant alfa 50 mg/kg did not achieve full recovery of the rabbits' respiratory conditions, as indicated by significantly lower arterial oxygenation and carbon dioxide values. By contrast, the two approved doses for clinical use of Poractant alfa (100 and 200 mg/kg) achieved a rapid and sustained recovery in both animal models. The comparison of the ventilation indices of the licensed doses of Bovactant (50 mg/kg) and Poractant alfa (100 mg/kg) showed a superior performance of the latter preparation in both animal models. At equal phospholipid doses, Poractant alfa was superior to Bovactant in terms of arterial oxygenation in both animal models. In preterm lambs, surfactant replacement therapy with Poractant alfa at either 100 or 200 mg/kg was associated with significantly higher lung gas volumes compared to Bovactant treatment with 100 mg/kg.

CONCLUSION

At the licensed doses, the acute pulmonary response to Poractant alfa was significantly better than the one observed after Bovactant treatment, either at 50 or at 100 mg/kg dose, in two animal models of pulmonary failure.

Anti-inflammatory effects of the new generation synthetic surfactant CHF5633 on Ureaplasma-induced cytokine responses in human monocytes

BACKGROUND

Synthetic surfactants represent a promising alternative to animal-derived preparations in the treatment of neonatal respiratory distress syndrome. The synthetic surfactant CHF5633 has proven biophysical effectiveness and, moreover, demonstrated anti-inflammatory effects in LPS-stimulated monocytes. With ureaplasmas being relevant pathogens in preterm lung inflammation, the present study addressed immunomodulatory features on Ureaplasma-induced monocyte cytokine responses.

METHODS

Ureaplasma parvum-stimulated monocytes were exposed to CHF5633. TNF-α, IL-1β, IL-8, IL-10, TLR2 and TLR4 expression were analyzed using qPCR and flow cytometry.

RESULTS

CHF5633 did not induce pro-inflammation, and did not aggravate Ureaplasma-induced pro-inflammatory cytokine responses. It suppressed U. parvum-induced intracellular TNF-α (p < 0.05) and IL-1β (p < 0.05) in neonatal monocytes and inhibited Ureaplasma-induced TNF-α mRNA (p < 0.05), TNF-α protein (p < 0.001), and IL-1β (p = 0.05) in adult monocytes. Ureaplasma-modulated IL-8, IL-10, TLR2 and TLR4 were unaffected.

CONCLUSION

CHF5633 does neither act pro-apoptotic nor pro-inflammatory in native and Ureaplasma-infected monocytes. Suppression of Ureaplasma-induced TNF-α and IL-1β underlines anti-inflammatory features of CHF5633.

Design of Surfactant Protein B Peptide Mimics Based on the Saposin Fold for Synthetic Lung Surfactants

Surfactant protein (SP)-B is a 79-residue polypeptide crucial for the biophysical and physiological function of endogenous lung surfactant. SP-B is a member of the saposin or saposin-like proteins (SAPLIP) family of proteins that share an overall three-dimensional folding pattern based on secondary structures and disulfide connectivity and exhibit a wide diversity of biological functions. Here, we review the synthesis, molecular biophysics and activity of synthetic analogs of saposin proteins designed to mimic those interactions of the parent proteins with lipids that enhance interfacial activity. Saposin proteins generally interact with target lipids as either monomers or multimers via well-defined amphipathic helices, flexible hinge domains, and insertion sequences. Based on the known 3D-structural motif for the saposin family, we show how bioengineering techniques may be used to develop minimal peptide constructs that maintain desirable structural properties and activities in biomedical applications. One important application is the molecular design, synthesis and activity of Saposin mimics based on the SP-B structure. Synthetic lung surfactants containing active SP-B analogs may be potentially useful in treating diseases of surfactant deficiency or dysfunction including the neonatal respiratory distress syndrome and acute lung injury/acute respiratory distress syndrome.

Micropipette Technique Study of Natural and Synthetic Lung Surfactants at the Air-Water Interface: Presence of a SP-B Analog Peptide Promotes Membrane Aggregation, Formation of Tightly Stacked Lamellae, and Growth of Myelin Figures

The present study is a microscopic interfacial characterization of a series of lung surfactant materials performed with the micropipette technique. The advantages of this technique include the measurement of equilibrium and dynamic surface tensions while acquiring structural and dynamic information at microscopic air-water interfaces in real time and upon compression. Here, we characterized a series of animal-derived and synthetic lung surfactant formulations, including native surfactant obtained from porcine lungs (NS); the commercial Curosurf, Infasurf, and Survanta; and a synthetic Super Mini-B (SMB)-containing formulation. It was observed that the presence of the natural hydrophobic proteins and, more strikingly, the peptide SMB, promoted vesicle condensation as thick membrane stacks beneath the interface. Only in the presence of SMB, these stacks underwent spontaneous structural transformations, consisting of the nucleation and growth of microtubes and in some cases their subsequent coiling into helices. The dimensions of these tubes (2-15 μm diameter) and their linear (2-3 μm/s) and volumetric growth rates (20-30 μm³/s) were quantified, and no specific effects were found on them for increasing SMB concentrations from 0.1 to 4%. Nevertheless, a direct correlation between the number of tubes and SMB contents was found, suggesting that SMB molecules are the promoters of tube nucleation in these membranes. A detailed analysis of the tube formation process was performed following previous models for the growth of myelin figures, proposing a combined mechanism between dehydration-rehydration of the lipid bilayers and induction of mechanical defects by SMB that would act as nucleation sites for the tubes. The formation of tubes was also observed in Infasurf, and in NS only after subsequent expansion and compression but neither in the other clinical surfactants nor in protein-free preparations. Finally, the connection between this data and the observations from the lung surfactant literature concerning the widely reported "near-zero surface tension" for lung surfactant films and intact alveolar surfaces is also discussed.

The new generation synthetic reconstituted surfactant CHF5633 suppresses LPS-induced cytokine responses in human neonatal monocytes

BACKGROUND

New generation synthetic surfactants represent a promising alternative in the treatment of respiratory distress syndrome in preterm infants. CHF5633, a new generation reconstituted agent, has demonstrated biophysical effectiveness in vitro and in vivo. In accordance to several well-known surfactant preparations, we recently demonstrated anti-inflammatory effects on LPS-induced cytokine responses in human adult monocytes. The present study addressed pro- and anti-inflammatory effects of CHF5633 in human cord blood monocytes.

METHODS

Purified neonatal CD14(+) cells, either native or simultaneously stimulated with E. coli LPS, were exposed to CHF5633. TNF-α, IL-1β, IL-8 and IL-10 as well as TLR2 and TLR4 expression were analyzed by means of real-time quantitative PCR and flow cytometry.

RESULTS

CHF5633 did not induce pro-inflammation in native human neonatal monocytes and did not aggravate LPS-induced cytokine responses. Exposure to CHF5633 led to a significant decrease in LPS-induced intracellular TNF-α protein expression, and significantly suppressed LPS-induced mRNA and intracellular protein expression of IL-1β. CHF5633 incubation did not affect cell viability, indicating that the suppressive activity was not due to toxic effects on neonatal monocytes. LPS-induced IL-8, IL-10, TLR2 and TLR4 expression were unaffected.

CONCLUSION

Our data confirm that CHF5633 does not exert unintended pro-apoptotic and pro-inflammatory effects in human neonatal monocytes. CHF5633 rather suppressed LPS-induced TNF-α and IL-1β cytokine responses. Our data add to previous work and may indicate anti-inflammatory features of CHF5633 on LPS-induced monocyte cytokine responses.

Impact of the New Generation Reconstituted Surfactant CHF5633 on Human CD4+ Lymphocytes

Background

Natural surfactant preparations, commonly isolated from porcine or bovine lungs, are used to treat respiratory distress syndrome in preterm infants. Besides biophysical effectiveness, several studies have documented additional immunomodulatory properties. Within the near future, synthetic surfactant preparations may be a promising alternative. CHF5633 is a new generation reconstituted synthetic surfactant preparation with defined composition, containing dipalmitoyl-phosphatidylcholine, palmitoyl-oleoyl-phosphatidylglycerol and synthetic analogs of surfactant protein (SP-) B and SP-C. While its biophysical effectiveness has been demonstrated in vitro and in vivo, possible immunomodulatory abilities are currently unknown.

Aim

The aim of the current study was to define a potential impact of CHF5633 and its single components on pro- and anti-inflammatory cytokine responses in human CD4⁺ lymphocytes.

Methods

Purified human CD4⁺ T cells were activated using anti CD3/CD28 antibodies and exposed to CHF5633, its components, or to the well-known animal-derived surfactant Poractant alfa (Curosurf^®). Proliferative response and cell viability were assessed using flow cytometry and a methylthiazolyldiphenyltetrazolium bromide colorimetric assay. The mRNA expression of IFNγ, IL-2, IL-17A, IL-22, IL-4, and IL-10 was measured by quantitative PCR, while intracellular protein expression was assessed by means of flow cytometry.

Results

Neither CHF5633 nor any of its phospholipid components with or without SP-B or SP-C analogs had any influence on proliferative ability and viability of CD4⁺ lymphocytes under the given conditions. IFNγ, IL-2, IL-17A, IL-22, IL-4, and IL-10 mRNA as well as IFNγ, IL-2, IL-4 and IL-10 protein levels were unaffected in both non-activated and activated CD4⁺ lymphocytes after exposure to CHF5633 or its constituents compared to non-exposed controls. However, in comparison to Curosurf^®, expression levels of anti-inflammatory IL-4 and IL-10 mRNA were significantly increased in CHF5633 exposed CD4⁺ lymphocytes.

Conclusion

For the first time, the immunomodulatory capacity of CHF5633 on CD4⁺ lymphocytes was evaluated. CHF5633 did not show any cytotoxicity on CD4⁺ cells. Moreover, our in vitro data indicate that CHF5633 does not exert unintended pro-inflammatory effects on non-activated and activated CD4⁺ T cells. As far as anti-inflammatory cytokines are concerned, it might lack an overall reductive ability in comparison to animal-derived surfactants, potentially leaving pro- and anti-inflammatory cytokine response in balance.

Can the preterm lung recover from perinatal stress?

After birth, adequate lung function is necessary for the successful adaptation of a preterm baby. Both prenatal and postnatal insults and therapeutic interventions have an immediate effect on lung function and gas exchange but also interfere with fetal and neonatal lung development. Prenatal insults like chorioamnionitis and prenatal interventions like maternal glucocorticosteroids interact but might also determine the preterm baby's lung response to postnatal interventions ("second hit") like supplementation of oxygen and drug therapy. We review current experimental and clinical findings on the influence of different perinatal factors on preterm lung development and discuss how well-established interventions in neonatal care might be adapted to attenuate postnatal lung injury.

Meconium-induced inflammation and surfactant inactivation: specifics of molecular mechanisms

This review summarizes neonatal meconium aspiration syndrome in light of meconium-induced inflammation and inflammatory surfactant inactivation, related to both endogenous and therapeutic exogenous surfactant. The wide effect of meconium on surfactant properties is divided into three points. Direct effect of meconium on surfactant properties refers mainly to fragmentation of dipalmitoylphosphatidylcholine and other surfactant phospholipids together with cleavage of surfactant proteins. Initiation of inflammatory response due to activation of receptors by yet unspecified compounds involves complement and Toll-like receptor activation. A possible role of lung collectins, surfactant proteins A and D, which can exert both pro- and anti-inflammatory reactions, is discussed. Initiation of inflammatory response by specified compounds in meconium reflects inflammatory functioning of cytokines, bile acids, and phospholipases contained in meconium. Unifying sketch of many interconnections in all these actions aims at providing integrated picture of inflammatory surfactant inactivation.

Effects of the New Generation Synthetic Reconstituted Surfactant CHF5633 on Pro- and Anti-Inflammatory Cytokine Expression in Native and LPS-Stimulated Adult CD14+ Monocytes

Background

Surfactant replacement therapy is the standard of care for the prevention and treatment of neonatal respiratory distress syndrome. New generation synthetic surfactants represent a promising alternative to animal-derived surfactants. CHF5633, a new generation reconstituted synthetic surfactant containing SP-B and SP-C analogs and two synthetic phospholipids has demonstrated biophysical effectiveness in vitro and in vivo. While several surfactant preparations have previously been ascribed immunomodulatory capacities, in vitro data on immunomodulation by CHF5633 are limited, so far. Our study aimed to investigate pro- and anti-inflammatory effects of CHF5633 on native and LPS-stimulated human adult monocytes.

Methods

Highly purified adult CD14⁺ cells, either native or simultaneously stimulated with LPS, were exposed to CHF5633, its components, or poractant alfa (Curosurf^®). Subsequent expression of TNF-α, IL-1β, IL-8 and IL-10 mRNA was quantified by real-time quantitative PCR, corresponding intracellular cytokine synthesis was analyzed by flow cytometry. Potential effects on TLR2 and TLR4 mRNA and protein expression were monitored by qPCR and flow cytometry.

Results

Neither CHF5633 nor any of its components induced inflammation or apoptosis in native adult CD14⁺ monocytes. Moreover, LPS-induced pro-inflammatory responses were not aggravated by simultaneous exposure of monocytes to CHF5633 or its components. In LPS-stimulated monocytes, exposure to CHF5633 led to a significant decrease in TNF-α mRNA (0.57 ± 0.23-fold, p = 0.043 at 4h; 0.56 ± 0.27-fold, p = 0.042 at 14h). Reduction of LPS-induced IL-1β mRNA expression was not significant (0.73 ± 0.16, p = 0.17 at 4h). LPS-induced IL-8 and IL-10 mRNA and protein expression were unaffected by CHF5633. For all cytokines, the observed CHF5633 effects paralleled a Curosurf®-induced modulation of cytokine response. TLR2 and TLR4 mRNA and protein expression were not affected by CHF5633 and Curosurf®, neither in native nor in LPS-stimulated adult monocytes.

Conclusion

The new generation reconstituted synthetic surfactant CHF5633 was tested for potential immunomodulation on native and LPS-activated adult human monocytes. Our data confirm that CHF5633 does not exert unintended pro-inflammatory effects in both settings. On the contrary, CHF5633 significantly suppressed TNF-α mRNA expression in LPS-stimulated adult monocytes, indicating potential anti-inflammatory effects.

Phospholipid Composition in Synthetic Surfactants Is Important for Tidal Volumes and Alveolar Stability in Surfactant-Treated Preterm Newborn Rabbits

BACKGROUND

The development of synthetic surfactants for the treatment of lung pulmonary diseases has been going on for many years.

OBJECTIVES

To investigate the effects of phospholipid mixtures combined with SP-B and SP-C analogues on lung functions in an animal model of respiratory distress syndrome.

METHODS

Natural and synthetic phospholipid mixtures with/without SP-B and/or SP-C analogues were instilled in ventilated premature newborn rabbits. Lung functions were evaluated.

RESULTS

Treatment with Curosurf or phospholipids from Curosurf combined with SP-B and SP-C analogues gave similar results. Treatment with phospholipids from adult rabbit lungs or liver combined with dipalmitoylphosphatidylcholine (DPPC) and palmitoyloleoylphosphatidylglycerol (POPG) gave tidal volumes (VT) well above physiological levels, but alveolar stability at end-expiration was only achieved when these phospholipids were combined with analogues of SP-B and SP-C. Treatment with egg yolk-PC mixed with DPPC with and without POPG gave small VT, but after addition of both analogues VT was only somewhat lower and lung gas volumes (LGV) similar to those obtained with Curosurf. Substitution of egg yolk-PC (≥99% PC) with 1-palmitoyl-2-oleoyl-sn-glycero-3-phosphocholine and 1-palmitoyl-2-linoleoyl-sn-glycero-3-phosphocholine, and combining them with DPPC, POPG and 2% each of the SP-B and SP-C analogue gave a completely synthetic surfactant with similar effects on VT and LGV as Curosurf.

CONCLUSIONS

Phospholipid composition is important for VT while the SP-B and SP-C analogues increase alveolar stability at end-expiration. Synthetic surfactant consisting of unsaturated and saturated phosphatidylcholines, POPG and the analogues of SP-B and SP-C has similar activity as Curosurf regarding VT and LGV in an animal model using preterm newborn rabbits ventilated without positive end-expiratory pressure.

Development of a Synthetic Surfactant Using a Surfactant Protein-C Peptide Analog: In Vitro Studies of Surface Physical Properties

PURPOSE

Pulmonary surfactant (PS) replacement has been the gold standard therapy for neonatal respiratory distress syndrome; however, almost all commercial PSs contain animal proteins. We prepared a synthetic PS by using a human surfactant protein (SP) analog and evaluated its in vitro properties.

MATERIALS AND METHODS

A peptide sequence (CPVHLKRLLLLLLLLLLLLLLLL) of human SP-C was chosen to develop the peptide analog (SPa-C). The new synthetic SP-C PS (sSP-C PS) was synthesized from SPa-C, dipalmitoyl phosphatidylcholine, phosphatidyl glycerol, and palmitic acid. Physical properties of the sSP-C PS were evaluated by measuring the maximum and minimum surface tensions (STs), surfactant spreading, and adsorption rate. In addition, we recorded an ST-area diagram. The data obtained on sSP-C PS were subsequently compared with those of purified natural bovine surfactant (PNBS), and the commercial product, Surfacten®.

RESULTS

The sSP-C PS and Surfacten® were found to have maximum ST values of 32-33 mN/m, whereas that of PNBS was much lower at 19 mN/m. The minimum ST values of all three products were less than 10 mN/m. The values that were measured for the equilibrium ST of rapidly spreading sSP-C PS, Surfacten®, and PNBS were 27, 27, and 24 mN/m, respectively. The surface adsorptions were found to be the same for all three PSs (20 mN/m). ST-area diagrams of sSP-C PS and Surfacten® revealed similar properties.

CONCLUSION

In an in vitro experiment, the physical properties exhibited by sSP-C PS were similar to those of Surfacten®. Further study is required to evaluate the in vivo efficacy.