Survival Time of Campylobacter jejuni in Broiler Crops

Lactobacillus spp. inhibit the growth of Campylobacter spp. in vitro. However, in chicken crops, in which Lactobacillus spp. predominate, such inhibition of Campylobacter has not been confirmed. In our previous study, feeding paddy rice to broiler chicks increased the residence time of the food, which might enhance the bactericidal activity of the crop. Here, the bactericidal activity against the remaining Campylobacter spp. in broiler crops was evaluated. A suspension prepared by mixing Campylobacter jejuni and titanium dioxide (TiO2) was inoculated into the pharynx of 26-day-old broiler chicks fed a paddy rice-based diet. The crop contents were sampled at 20-min intervals. The TiO2 residual ratio in the crop gradually decreased with time after inoculation, with 57% of the inoculated TiO2 remaining in the crop 60 min after inoculation. The survival fraction of C. jejuni in the crops was 11% at 40 min, only 1% at 60 min, and was undetectable at 80 min. Most of the inoculated C. jejuni died in the crop before entering the next segment. These data indicated that bacterial death occurred between 30 min and 40 min after inoculation. The average survival time of C. jejuni in the crop was calculated to be 37.1 min. Thus, C. jejuni remaining in a chicken crop for more than 40 min died.

Dry residue of cassava on slow-growing broiler diets, with or without the addition of carbohydrases

Dry residue of cassava was studied on the digestibility, performance, intestinal measurements, with or without inclusion of carbohydrases, of slow-growing broilers. 160 Label Rouge broiler chickens, 21-d-old, were distributed in a randomized, 2x5 factorial arrangement (male and female x 0, 10, 20, 30 and 40% residue) (metabolism trial). 1,100 male chicks were distributed in a 2x5 factorial arrangement (with/without carbohydrases x 0; 2.5; 5.0; 7.5; and 10.0% residue), with five replicates (performance trial). Increasing residue levels led to increases in energetic values. Feed intake from 1-21-d-old and 1-63-d-old decreased linearly. At 42 d-old, feed intake and weight gain levels exhibited a quadratic response, which predicted a highest value at 3.32% and 4.77%, respectively, for diets without carbohydrases. For 21- and 42-d-old chickens, the inclusion of carbohydrases reduced the weight and length of the small intestine. The energetic values of the diets were positively influenced by the residue and had similar digestibility values for both sexes. Inclusion of up to 10% of residue in slow-growing broiler diets does not impaired performance and intestinal morphology. The addition of carbohydrases reduced the viscosity of the digesta but it was not enough to improve the performance of the birds.

Targeted dosing for susceptible heteroresistant subpopulations may improve rational dosage regimen prediction for colistin in broiler chickens

The dosage of colistin for the treatment of enteric E. coli in animals necessitates considering the heteroresistant (HR) nature of the targeted inoculum, described by the presence of a major susceptible population (S1, representing 99.95% of total population) mixed with an initial minor subpopulation of less susceptible bacteria (S2). Herein, we report the 1-compartment population pharmacokinetics (PK) of colistin in chicken intestine (jejunum and ileum) and combined it with a previously established pharmacodynamic (PD) model of HR in E. coli. We then computed probabilities of target attainment (PTA) with a pharmacodynamic target (AUC24h/MIC) that achieves 50% of the maximal kill of bacterial populations (considering inoculums of pure S1, S2 or HR mixture of S1 + S2). For an MIC of 1 mg/L, PTA > 95% was achieved with the registered dose (75,000 IU/kg BW/day in drinking water) for the HR mixture of S1 + S2 E. coli, whether they harboured mcr or not. For an MIC of 2 mg/L (ECOFF), we predicted PTA > 90% against the dominant susceptible sub-population (S1) with this clinical dose given (i) over 24 h for mcr-negative isolates or (ii) over 6 h for mcr-positive isolates (pulse dosing). Colistin clinical breakpoint S ≤ 2 mg/L (EUCAST rules) should be confirmed clinically.

The effect of amylase supplementation on individual variation, growth performance, and starch digestibility in broiler chickens

The objective of this study was to evaluate the variance of starch digestibility in broilers individually fed diets without or with supplemental exogenous amylase. A total of 120 d-of-hatch male chicks were individually reared from 5 to 42 d in metallic cages and fed maize-based basal diets or diets containing 80 kilo-novo-α-amylase units/kg (60 birds or replicates per treatment). Beginning on d 7, feed intake, body weight gain, and feed conversion ratio were recorded; partial excreta collection was conducted every Monday, Wednesday, and Friday until 42 d, when all birds were sacrificed for individual collection of duodenal and ileal digesta. Lower feed intake (4,675 vs. 4,815 g) and feed conversion ratio (1.470 vs. 1.508) were observed in amylase-fed broilers during the overall period (7-43 d; P < 0.01), whereas body weight gain was not affected. Amylase supplementation improved total tract starch (TTS) digestibility (P < 0.05) on each day of excreta collection (except for d 28, where no difference was found), averaging 0.982 vs. 0.973 compared to basal-fed broilers from d 7 to 42. Both apparent ileal starch (AIS) digestibility and apparent metabolizable energy (AME_N) were increased (P <0.05) from 0.968 to 0.976 and from 3,119 to 3,198 kcal/kg, respectively, with enzyme supplementation. Activity of amylase in the duodenum was higher (18.6 vs. 50.1 IU/g of digesta) in supplemented birds. Amylase supplementation led to a reduced coefficient of variation for both TTS (averaged 2.41 vs. 0.92% from 7 to 42 d) and AIS digestibilities (1.96 vs. 1.03%), as well as AME_N (0.49 vs. 0.35%), when compared to the nonsupplemented group, indicating lower individual heterogenity. An age effect was detected for TTS digestibility, as both groups saw an increase during the first weeks (slightly more pronounced in the supplemented group); older birds (d 30 onwards) presented a lower TTS digestibility compared to ages between 7 and 25 d. In conclusion, amylase supplementation in maize diets for broilers can attenuate individual bird variation for starch and energy utilization by increasing amylase activity and enhancing starch digestibility.

Fat digestion and metabolism: effect of different fat sources and fat mobilisers in broilers diet on growth performance and physiological parameters – a review

Commercial broilers have a short production cycle and a high requirement for energy (3000 kcal/kg in starter phase and 3200 kcal/kg in finisher phase). Therefore, the need to add energy rich lipids to their diet is inevitable. Digestibility of fat depends on its multiple properties: chain length, the composition of fatty acids, ratio of saturated/unsaturated fatty acids and free fatty acids. The high cost of vegetable oils and less availability due to their consumption in human diet are the main reasons for searching cheaper alternative fat sources. Animal oils like poultry and fish oil are the by-product of rendering plants and after refining, they are used in poultry diets as an energy source. Due to presence of impurities and free fatty acids, the digestibility of animal fat is less. There is a limited amount of bile acids and lipase available during early age and when birds are reared on high energy diet (finisher phase). Supplementation of emusifier or lipase in broilers diet increase fat utilisation. Emulsifiers increase fat digestibility by increasing active surface area of lipid droplets. Lysolecithin and Lysophospholipids are produced from hydrolyses of lecithin and phospholipids by phopholipase A2. The bile acids mainly compose of cholic acid, hyodeoxycholic acid and chenodeoxycholic acid and have strong emulsification properties. Triacylglyceryl acylase (lipase) is an enzyme involved in catalysis and the hydrolysis of lipids. It can be concluded that use of emulsifier and lipase in broilers diet improves growth performance, nutrient digestibility and intestinal histology in broilers.

Xylanase supplementation of pelleted wheat-based diets increases growth efficiency and apparent metabolizable energy and decreases viscosity of intestinal contents in broilers

This study was designed to test graded supplementation of a thermostable xylanase in pelleted, wheat-based diets fed to broiler chickens over a 28-d period. A total of 600 Ross 708 male broilers were allotted to 1 of 5 dietary treatments: positive control (PC), negative control (NC; 125 kcal of AME/kg diet reduction relative to PC), and NC supplemented with 10, 15, or 30 g/ton of xylanase. Wheat-soybean meal-based diets were pelleted and fed in 2 feeding phases (14-d each). Study outcomes included growth performance, AME, and ileal digesta viscosity with 20 battery cages of 6 birds per treatment. Data were analyzed by 1-way ANOVA along with estimation of Pearson correlation coefficients. Whereas no difference between NC and PC was observed for BW gain, NC birds exhibited increased (P < 0.05) feed intake during each feeding phase and overall, which caused improvements (P < 0.05) in feed conversion ratio (FCR) for PC vs. NC birds. The analyzed AME of PC birds was 112 kcal/kg of diet greater (P < 0.05) than for NC birds, though no differences in digesta viscosity were observed. Xylanase supplementation of the NC diet at 15 or 30 g/ton elicited overall improvements (P < 0.05) in BW gain beyond the PC, while the 30 g/ton level equalized feed intake with the PC. Regardless of level, xylanase supplementation improved (P < 0.05) the FCR relative to the NC, thereby equalizing the response with the PC. Similarly, supplementation with any xylanase level increased (P < 0.05) AME over the NC, making all treatments synonymous with the PC. Digesta viscosity of all xylanase-supplemented treatments was decreased relative to both the NC and PC treatments. Overall, this study provided clear evidence that addition of a thermostable xylanase to pelleted wheat-based diets elicited improvements in growth performance of broilers concomitant with a reduction in digesta viscosity and elevation of analyzed dietary AME content.

The influence of nutrition on intestinal disease with emphasis on coccidiosis

Ever since the poultry industry began to intensify early last century, coccidiosis has been a significant problem with which it has had to contend. Losses due to mortality and morbidity can be significant and before the advent of control agents there were several practices, some of which were nutritional, which were implemented to limit these losses. The development of coccidiostats reduced these problems considerably and as a result some of the more extreme intervention measures were no longer necessary. Modern day interpretation of what may have been happening with some of these early interventions provide interesting insights into what may be possible today should cocciodiostats be removed. More recent research has also indicated that the diet has a significant influence on the ability of poultry to resist and resolve an infection through direct and indirect effects on the pathogen, the immune system and on the litter. This paper reviews the role of dietary ingredients and nutrients on the pathogen to establish and the host to resist such an infection. There is clearly no panacea, but the combination of a few practices may reduce the overall challenge experienced by the poultry producer.

Cloning, expression, and characterization of a recombinant xylanase from Bacillus sonorensis T6

Xylanase is one of industrial enzymes with diverse applications including the paper-bleaching industry and feed additives. Here, a strain having xylanolytic activity and identified as Bacillus sonorensis T6 was isolated from soil. A secretory enzyme was identified by mass-spectrometry as a xylanase of glycosyl hydrolase family 11, with a molecular weight of 23.3 kDa. The xylanase gene of Bacillus sonorensis T6 was cloned and expressed in Escherichia coli (yielding an enzyme designated as rXynT6-E) and in Pichia pastoris (yielding rXynT6-P). The recombinant xylanases were found to have optimal activity at 47–55°C and pH 6.0–7.0. The recombinant xylanase expressed in P. pastoris has 40% higher thermal stability than that expressed in E. coli. The recombinant xylanases retained 100% of activity after 10 h incubation in the pH range 3–11 and 68% of activity after 1 h at pH 2.0. The xylanase activities of rXynT6-E and rXynT6-P under optimal conditions were 1030.2 and 873.8 U/mg, respectively. The good stability in a wide range of pH and moderate temperatures may make the xylanase from Bacillus sonorensis T6 useful for various biotechnological applications, e.g., as an enzyme additive in the feed industry.

Air-classified faba bean protein fraction as a substitute to soybean meal in pelleted and extruded broiler diets

1. The hypothesis that air-classified faba bean protein fraction (FBP) can replace soybean meal (SBM) in pelleted or extruded broiler diets without adverse effect on performance or nutrient digestibility was tested.2. At 17 d of age, male broilers were randomly distriibuted among four dietary treatments consisting of either SBM or FBP (main dietary protein source) and pelleting or extrusion as processing methods. Treatments had 10 replicate pens containing five birds each.3. Compared to SBM, birds fed FBP had significantly lower feed intake, less weight gain and had poorer feed conversion.4. Pellet durability was high (above 92%) for all diets. In pelleted diets, FBP was harder than SBM whereas extruded diets had similar hardness. Pelleting increased water stability compared to extrusion. FBP diets were more water stable than the SBM diets.5. Gizzard content weight was 2.2-fold higher (P = 0.002) for birds given FBP compared to those fed SBM. The weight of the jejunum and ileum with contents was 1.4-fold lower for the FBP diets, and this effect was larger (P < 0.05) for the extruded FBP diet.6. Birds fed FBP diets had significantly higher nitrogen digestibility in the lower jejunum and ileum compared to those given SBM diets, while the starch digestibility coefficient was above 0.980 in all treatments.7. The high nutrient digestibility of FBP diets indicates that the poor performance of the FBP group was due to lower feed intake which was not explained by the differences in pellet durability or hardness. The reduced palatability of the FBP and the longer retention of the FBP diets in the upper gut are more likely to have depressed feed intake.

Assessment of crop usage in ad libitum fed birds and short-term phytase efficiency as affected by acid addition

1. A field assessment was performed to map the extent of crop usage and thus retention time in broiler chickens. In addition, a broiler experiment was carried out to study the short-term effect of acid addition on phytase efficacy in the crop.2. In the field assessment, the crop content of 40 ad libitum fed broiler chickens from four different farms were sampled at 10, 20 and 30 d of age. The dry matter (DM) content varied from zero to 32 g.3. From 11 d of age, 120 individually caged chickens were intermittently fed a high phytate-P diet with either no addition or 500 FYT C. braakii-derived phytase added or both phytase and 1.4 % formic acid added. Excreta were collected for assessment of phosphorus (P) retention. At 20 and 21 d of age, starved birds were fed for 1 h, and thereafter crop and gizzard contents were collected every 20 min until 140 min after start of the feeding. At 60 and 140 min, the contents from the jejunum and ileum were collected.4. All diets reduced the concentration of phytate in the crop, however the combination of acid and phytase resulted in a higher degradation (P<0.05) than the other diets from 20 min after the start of feeding. Simultaneously, the concentration of the smaller inositol phosphate isomers, such as inositol-5-phosphate, increased (P<0.05). Phytase increased (P<0.05) P retention, and the combination of acid and phytase increased jejunal P digestibility (P<0.05) compared to the other diets.5. The results indicated that lower pH in the crop due to acid addition improved phytase efficacy and increased P digestibility in the anterior digestive tract, even with short retention times.

Impact of fiber on growth, plasma, gastrointestinal and excreta attributes in broiler chickens and turkey poults fed corn- or wheat-based diets with or without multienzyme supplement

Effects of fiber on growth performance, gizzard attributes, ileal digesta viscosity, plasma uric acid (PUA) and excreta characteristics were investigated in broiler chickens (experiment 1) and turkey poults (experiment 2) fed corn or wheat-based diets with or without multienzyme supplement (MES). Fibrous diets were created by adding 10% corn distillers dried grains with solubles or wheat middlings in corn or wheat-based diets, respectively. The MES had main activities of xylanase and β-glucanase. A total of 960-d old Ross x Ross 708 male chicks and 720-d old male Hybrid toms were allocated to eight grain, fiber and MES combinations to give 6 replicates per combination. In each experiment, birds had free access to feed and water for 28 days. Excreta samples were collected for 3-d prior to the end and on d 28, body weight and feed intake were recorded, birds bled and subsequently necropsied for gastrointestinal samples. There was an interaction (P ≤ 0.036) between grain, fiber and MES in broilers final body weight (FBW) and BW gain (BWG). In this context, high fiber corn diets reduced FBW and BWG and supplementation of MES improved these parameters. Broilers fed corn had a higher (P < 0.05) FBW (1,462 vs. 1,424 g) and BWG (1,416 vs. 1,378 g) than birds fed wheat diets. Broilers fed corn-based diets without fiber diets had a higher ileal viscosity and excreta moisture compared to birds fed wheat-based and high fiber diets. Broilers fed low fiber wheat diets without MES had higher (P < 0.05) PUA concentration compared to birds fed low fiber corn diets without MES. Poults fed wheat diets had a higher (P < 0.05) FBW (1,441 vs. 1,408 g) and BWG (1,376 vs. 1,343 g) than poults fed corn diet. The MES supplementation in corn-based diets rich in fiber increased (P = 0.03) gizzard weight in poults. In conclusion, there were varied growth and physiological responses in broilers and turkey suggesting the need for refining enzyme application for different poultry species.

Effect of crop retention time and acidification of the feed on phytase efficacy in broiler chickens

1. An in vitro test to study the effect of pH reduction on phytic acid degradation over time for four commercial phytases was conducted. Changing the pH level affected phytate degradation over time differently for the various phytases (P < 0.05).2. The phytase with the largest response of pH reduction in the in vitro test and a feed pH level of 4.5 was chosen for the broiler experiment. The effect of intermittent feeding, addition of 500 FYT C. braakii-derived phytase and 1% formic acid were tested in a 2 x 2 x 2 factorial arrangement. Ten pens containing 10 birds each were fed each of the treatment combinations from 15 to 36 d of age. Ad libitum fed birds had two 4-h dark periods with 2-h light in-between, while intermittently fed birds in addition had restricted access to the feed through except for four 1-h and one 2-h feeding bouts.3. In addition to assessing performance, excreta were collected on a pen basis. The tibia and contents from jejunum and ileum were collected from one bird per pen. In addition, crop contents were collected from the intermittently fed birds 80, 160 and 240 min after the start of feeding.4. Phytase improved performance, ileal and jejunal P digestibility, P retention and tibia ash and P concentration (P < 0.001). Intermittent feeding increased jejunal P digestibility and P retention (P < 0.001), but ileal P digestibility increased only in the intermittently fed birds compared to the ad libitum fed birds without phytase addition (P = 0.025). Acidification increased jejunal P digestibility only in the ad libitum fed birds (P = 0.019). There was a considerable inositol hexakisphosphate degradation into lower isomers in the crop after 80 min for diets with phytase (InsP_{3 and 4}:P < 0.001), and acidification further increased this degradation (InsP₄:P = 0.007). After 160 min retention time, the effect of phytase and acidification was even higher with more significant (P < 0.05) interactions.5. The current data showed that prolonged retention time in the crop combined with feed acidification increased phytase efficacy by improving the phytate degradation.

Nutrition, feeding and laying hen welfare

The relationship between nutrition and welfare is usually considered to be a direct result of supplying the hen with adequate quantities of feed and water. This simple notion of freedom from hunger and thirst belies the fact that nutrients play a pivotal role in the body’s response to challenges whether they relate to ambient temperature, gastrointestinal health, pathogen exposure, metabolic disorders, or social and mental stress. In all instances, maintaining homeostasis and allowing for physiologic response is dependent on an adequate and balanced nutrient supply. It is accepted that most laying hens are fed a complete diet, formulated commercially to provide the required nutrients for optimal health, egg production and welfare. In other words, the laying hen, irrespective of her housing, does not experience hunger or thirst. However, despite adequate nutrient and water supply, certain senarios can significantly affect and alter the nutrient requirements of the hen. Furthermore, the chemical composition and also the physical form of feed can significantly contribute to prevent or treat welfare and health conditions and is, therefore, a highly relevant tool to ensure and maintain an adequate welfare status. Therefore, this review takes a broader perspective of nutritional welfare and considers the nutrition of hens managed in different production systems in relation to nutritional physiology, gut microbiota, stress, metabolic disorders and feeding management.

Impact of Rye Inclusion in Diets for Broilers on Performance, Litter Quality, Foot Pad Health, Digesta Viscosity, Organ Traits and Intestinal Morphology

Rye could offer diverse benefits in terms of sustainability if it could replace parts of the main cereals, corn and wheat, in broiler diets. A total of 256 broilers, Ross 308, were randomly allocated into 32 pens. From day 14 till day 42, the birds were divided into four feeding groups (eight replicates each). The control group received a conventional finisher diet “control”, whereas in the other groups, a pelleted supplementary feed was offered (SFI to corn and SFII to rye), to which crushed corn (SFI-Corn) or squashed rye (SFII-Rye) was added. The fourth group received a mixture of 50% SFI-Corn and 50% SFII-Rye. The cereal level was increased weekly (5%, 10%, 20%, 30%) at the expense of the supplementary feeds. No significant effects were observed for body weight at d 42 and excreta viscosity between all groups. Overall, foot pad health was excellent. Compared to the control group, birds fed SFI-Corn displayed a significant increase in gizzard relative weight, whereas, in contrast to all other groups, ileal villus height was significantly lower. In conclusion, feeding SFI-Corn or SFII-Rye diets had no negative influences on performance, litter quality and digesta viscosity, whereas SFI-Corn partially affected ileal morphology.

Varying starch to fat ratios in pelleted diets: I. Effects on nutrient digestibility and production performance in Eimeria-challenged broiler chickens

1. The hypothesis was that a diet with a high starch to fat ratio (HS) impairs nutrient digestibility and growth performance, as compared to a diet with a low starch to fat ratio (LS) in Eimeria-challenged broilers. From days 10 to 29, 12 replicate pens of birds were given isocaloric and isonitrogenous steam-pelleted diets with either HS or LS, by replacing the wheat starch in one diet by a mixture of rapeseed oil and inert sand in the other. On d 17, a 10-fold dose of live vaccine strains of Eimeria spp. was administered via drinking water. Ileal samples were collected on days 16 and 29. 2. Starch content in the ileum tended to be higher on d 16 and was significantly higher on d 29 in the HS group. 3. The HS diet did not induce exceedingly high levels of starch in the ileum, suggesting there was no starch overload in the gut. Ileal starch digestibility was improved with increasing dietary starch level from 23% to 45%. This demonstrated the capacity of the broiler chicken to digest high levels of starch regardless of Eimeria spp. infection. Ileal energy digestibility was not affected by the treatments. 4. Weight gain did not differ between treatments; however, birds fed the LS diet were less efficient in feed conversion as compared to those fed the HS diet. 5. The use of isolated starch and the unintended higher extent of starch gelatinisation in the HS diet may have contributed to the higher starch digestibility in birds given the HS diet. Thus, the hypothesis that high ratios of starch to fat in pelleted diets may impair starch digestibility and production performance in Eimeria-challenged broiler chickens was not verified. Further work is required to clarify this research question, taking into consideration the physical form of starch source and the potentially confounding role of feed processing on starch availability.

Managing Free-Range Laying Hens-Part A: Frequent and Non-Frequent Range Users Differ in Laying Performance but Not Egg Quality

Simple Summary

Free-range laying hens are allowed to roam around and exhibit their desired behaviours including usage of the outdoor range. Consequently, flock sub-populations of high-range users (“rangers”) and low-range users (“stayers”) appear. The subpopulation effect on egg production and egg quality has not been studied to date. Rangers were more consistent in their range use, while stayers increased their range use over time. Rangers came into lay earlier compared to the stayers but their egg production dropped during mid-lay until the end of lay when they were outperformed by the stayers. The flock sub-populations did not differ in their egg quality during the production period. These findings are of relevance to egg producers, as it allows them to manage their flock knowing that they can encourage them to range/stay in the shed without compromising egg quality, including off-grade eggs. In the future, it would be interesting to investigate if increased egg performance was triggered by the more frequent range usage.

Abstract

Little is known about the impact of ranging on laying performance and egg quality of free-range hens. The aim of this study was to characterise egg production of commercial free-range laying hen sub-populations of low-, moderate- and high-range use at an early age. A total of five flocks with 40,000 hens/flock were investigated where 1875 hens/flock were randomly selected at 16 weeks of age, monitored for their range use and subsequently grouped into “stayers” (the 20% of hens that spent the least time on the range), “roamers” (the 20% of the hens that used the range more than stayers but less than rangers) and “rangers” (the 60% of the hens that spent the most time on the range). Eggs from the individual groups were collected in 10-weekly intervals until hens were 72 weeks of age, commercially graded and tested for several quality parameters. Significant differences were noted for hen-day production. For example, at 22 weeks of age, rangers enjoyed a laying rate of 88.0% ± 1.1%, while stayers performed at 78.2% ± 1.9% but at 72 weeks of age egg production of rangers was 85.1% ± 0.9% and of stayers was 95.5% ± 0.9% (p < 0.05). Range use was of minor importance to the egg quality.

Whole pearl millet feeding does not impair performance and nutrient digestibility in 28-day-old broiler chickens

The effects of varying inclusion levels of whole grain millet in millet-soya bean-based diets on growth performance, gizzard development, digesta characteristics and nutrient digestion in broiler chicken were investigated. Starter (0-14 days) and grower (15-28 days) broiler chicken diets containing pearl millet at 500 and 540 g/kg diet, respectively, were formulated. The diets comprised of 0%, 20%, 40%, 60%, 80% and 100% of millet incorporated as whole grain. One-day-old unsexed Arbor Acres Plus chicks (n = 540) were allotted to the experimental diets in a completely randomized design with the diets and water provided ad libitum for 28 days. Each treatment was replicated seven times, and each replicate had 12 chicks. Results showed that daily live weight gain and feed conversion ratio of chickens on the whole millet grain diets compared favourably with chicken on the control in both starter and grower phases, while feed intake reduced quadratically (p < .05) with increased whole grain millet levels in the starter phase. Morphological and structural characteristics of the gizzard and small intestine and intestinal digesta pH and viscosity were also unaffected (p > .05) by whole grain millet inclusion levels. However, the weight of intact millet grain in gizzard increased linearly (p < .001) with whole grain millet inclusion in the diets. Dietary whole grain millet inclusion also consistently lowered (p < .05) jejunal and ileal maltase and sucrase activities, but did not influence (p > .05) pancreatic amylase activity. Ileal crude protein and starch digestibility increased, while ileal energy digestibility decreased significantly (p < .05) with whole grain millet inclusion. Whole grain millet inclusion in broiler starter and grower diets up to 500-540 g/kg did not negatively impact on broiler chicken performance.

The length of the feed restriction period affects eating behavior, growth performance, and the development of the proximal part of the gastrointestinal tract of young broilers

We studied the effects of restricting the access to feed on the anticipatory eating behavior, growth performance, and the development of the proximal part of the gastrointestinal tract (GIT) in broilers. The experiment consisted in physical restriction of the access of broilers to feed for 0, 4, 6, or 8 h per day from 7 to 19 D of age. At 10, 13, 16, and 19 D of age, immediately before the start of the feed restriction (FR) period, 2 birds per cage were euthanized to evaluate crop and gizzard development. The experimental design was completely randomized, and the linear (L) and quadratic (Q) effects of fasting length on growth performance and GIT traits were determined. In addition, the effect of broiler age on GIT development was studied. From 7 to 19 D of age, ADFI (L, Q; P ≤ 0.05) and BW gain (L; P ≤ 0.01) decreased as the length of the FR period increased, with most of the differences observed with 6 or more hours of fasting. However, feed conversion ratio was not affected by FR length. The relative weight of the crop (% BW) and its fresh content increased (L; P ≤ 0.001) and the moisture of the digesta (%) decreased (L; P ≤ 0.001) as the FR period increased. The DM content (g) of the crop increased with FR, with most of the differences observed with 6 or more hours of fasting (L, Q; P ≤ 0.001). At 19 D of age, the Lactobacillus spp. count in the crop increased (L; P ≤ 0.05) with increase in the FR period. Fasting did not affect any gizzard trait at any age. In summary, physical restriction of the access to feed for 6 h or more reduced BW gain but did not affect feed conversion ratio in broilers from 7 to 19 D of age. Feed restriction for 4 to 8 h stimulated the anticipatory feeding behavior and crop development in broilers.

Determination of gastrointestinal passage rate using three different markers in laying hens

The titanium dioxide (TiO₂ ) marker technique is currently widely practiced as a method to evaluate gastrointestinal (GI) passage rate in poultry. However, this method requires sacrificing the animal to obtain digesta samples, is labour-intensive and eliminates the possibility of follow-up studies with the same individual. The aim of this study was to evaluate whether the radiographic methods barium-impregnated polyethylene spheres (BIPS) and barium sulphate (BaSO₄ ) suspension are in agreement with the TiO₂ technique and can be used as an alternative method for GI passage rate determination in laying hens. Whole-body radiographs were taken at different time points. Hens of group 3 (n = 55) were orally inoculated with 5 g of feed mixed with 0.15 g TiO₂ , 5 hens per time point sacrificed, and whole gastrointestinal organs (crop, proventriculus, gizzard, small intestine and large intestine) were collected and analysed for TiO₂ content. The average marker passage rate of hens administered BaSO₄ was significantly faster than those administered BIPS (gizzard: 15.2 hr vs. 43.2 hr; small intestine: 15.2 hr vs. 38.4 hr, respectively). A greater percentage of BIPS remained in the crop at 0, 0.5, 2, 3 and 8 hr post-inoculation (p.i.) and in the gizzard at 2, 24, 36 and 48 hr p.i. (all p < 0.05) compared to TiO₂ . In conclusion, the evaluation of the GI transit time is feasible using BIPS, TiO₂ and BaSO₄ . The evaluation of the GI transit time using BIPS and BaSO₄ needs further investigation.

Effects of Feed Particle Size and Hydro-Thermal Processing Methods on Starch Modification, Nutrient Digestibility and the Performance and the Gastrointestinal Tract of Broilers

Simple Summary

Technological benefits of feed processing methods are well defined but not their benefits and disadvantages for broiler feeding. The current study tested the impact of feed particle size and various hydro-thermal processing methods (HTPM) on feed value, broiler performance and alterations of the digestive tract. It was shown that HTPM influences physico-chemical characteristics of the feed including starch modifications. The compaction process during pelleting contributes to the reduction of feed wastage and selection. However, the high daily feed intake caused by pellet feeding is also a main risk factor for proventricular dilatation.

Abstract

Influences of feed particle size (coarse, fine) and hydro-thermal processing methods (HTPM) (without–non-compacted feed, pelleting, expanding and pelleting) on feeding value and the performance and digestive tract of 624 broilers were studied. HTPM increased the starch disintegration of feed. Starch disintegration and electron microscopy indicated the highest degree of starch modification in expanded and pelleted feed. HTPM affected ether extract digestibility (p < 0.05). A grinding-by-HTPM interaction was found in case of crude protein digestibility (p = 0.008). Non-compacted feed reduced daily feed intake (DFI) and body weight gain and increased the feed to gain ratio compared to compacted feeds (p < 0.001). Compacted feeds increased proventricular size and the risk of Isthmus gastrici dilatation compared to coarsely ground non-compacted feed, except for finely ground expanded and pelleted feed. Finely ground feed reduced proventricular weights compared to coarsely ground feed and pelleted feed compared to other feeds. Non-compacted feed increased gizzard weights compared to compacted feeds. Relationships between proventricular size and Isthmus gastrici dilatation and the DFI were detected. Summarizing, the beneficial effects of pelleted feed were mainly based on the reduction of feed wastage and selection. However, the high DFI caused by pellet feeding is also a main risk factor for proventricular dilatation.

Role of Feed Processing on Gut Health and Function in Pigs and Poultry: Conundrum of Optimal Particle Size and Hydrothermal Regimens

The aim is to give an overview of available literature data on the role of feed processing on gut health and function with specific focus on particle size and hydrothermal processing. In addition, influence of feed processing on efficacy of exogenous feed enzymes will be discussed. The current feed processing technologies are such that ingredient choices and diet form are refined to improve feed intake and nutrient utilization efficiency. Finer feed particle size enables optimal nutrient utilization and enhances animal performance due to increased surface area allowing better contact with digestive enzymes. Moreover, adequate diminution of feed ingredients is beneficial to feed manufacturing processes such as mixing and hydrothermal treatments including pelleting, extrusion, and expansion. However, emerging trends in consumer and regulatory demands for restriction or cessation of animal production practices such as use of antimicrobial growth promoters are challenging current approaches to feed processing. There is limit as to the fineness of the particle size, as very fine particles negatively affect gut health due to higher incidences of stomach ulceration in pigs and gizzard dysfunction in poultry. Coarse particle size increases stomach and hindgut acidification which may be beneficial in controlling proliferation of enteric pathogens such as salmonella and E. coli. Optimal particle size could be designed in the grinding process using roller or hammer mill. However, since most commercial pigs and poultry diets are subjected to hydrothermal processes, additional reduction of feed particle size is inevitable. The need to achieve high physical quality and to reduce potential levels of feed-borne pathogens such as Salmonella has led to the application of relatively high conditioning temperatures during conventional hydrothermal processes, a practice that does not favor high nutrient utilization and stability of heat sensitive feed additives such as feed enzymes. Therefore, with evolving pig and poultry production practices, the regimens for feed processing will no longer be appreciated only in terms of optimizing nutrients utilization, but also in terms of impact on feed hygienic status, efficacy of feed additives, animal health, and food safety.

Feeding whole grain and phytase to meat chickens: recent Australian experience

Both whole-grain feeding and exogenous phytases have been widely accepted by the chicken-meat industry, so any interactions that arise from this combined supplementation are potentially important. Nevertheless, there is a paucity of research evaluating the effect of phytase under whole-grain feeding regimens. Whole-grain feeding increases relative gizzard weights and gizzard functionality. However, the gizzard is the primary site of phytate degradation by phytase, so this combined supplementation should enhance phytase efficacy. Moreover, there has been recent progress towards understanding the influence of whole-grain feeding and exogenous phytase on broiler performance, which is discussed. Further research is warranted to establish a whole-grain feeding regimen that generates robust gizzard responses so as to enhance feed efficiency, energy utilisation and phytase efficacy.

Wheat particle size, insoluble fibre sources and whole wheat feeding influence gizzard musculature and nutrient utilisation to different extents in broiler chickens

A 21-day experiment was conducted to investigate the effects of wheat particle size, insoluble fibre source and whole wheat (WW) inclusion on the gizzard musculature, intestinal architecture and nutrient utilisation of broiler chickens. The following seven treatments, all in mash form, were tested: control diet using finely ground wheat (Fine); control diet using medium-ground wheat (Medium); control diet using coarsely ground wheat (Coarse); fine diet diluted with 10 g/kg lignocellulose (LC); fine diet diluted with 30 g/kg oat hulls (OH); fine diet diluted with 30 g/kg wood shavings (WS); and ground wheat in the fine diet replaced with 50 and 100 g/kg WW during the second (day 8-14) and third (day 15-21) weeks of the study respectively. Except for the LC diet, all treatments increased (p < 0.05) the thickness of the caudodorsal thick muscle of gizzard compared to the fine diet. The highest (p < 0.05) caudoventral thin and cranioventral thick muscle diameters in the gizzard walls were achieved with the OH and WS diets. Feeding OH, WS and WW diets improved (p < 0.05) starch digestibility compared with the fine diet, while medium, coarse and LC diets had no effect (p > 0.05). All diets containing fibre sources (LC, OH and WS) reduced (p < 0.05) the energy digestibility compared to the fine diet. Birds fed OH and WS diets gained the lowest (p < 0.05) weights. Feeding LC, OH, WS and WW diets increased (p < 0.05) the feed per gain compared with the fine diet. The current results suggest that there is a potential for coarse particles, insoluble fibre sources and WW feeding to improve the gizzard musculature and digestibility of some nutrients, with the effect being more pronounced with the inclusion of structural fibre sources.

Influence of feed provisioning prior to digesta sampling on precaecal amino acid digestibility in broiler chickens

A regression approach was applied to determine the influence of feed provisioning prior to digesta sampling on precaecal (pc) amino acid (AA) digestibility in broiler chickens. Soybean meal was used as an example test ingredient. Five feed-provisioning protocols were investigated, four with restricted provision and one with ad libitum provision. When provision was restricted, feed was provided for 30 min after a withdrawal period of 12 h. Digesta were sampled 1, 2, 4 and 6 h after feeding commenced. A diet containing 300 g maize starch/kg was prepared. Half or all the maize starch was replaced with soybean meal in two other diets. Average pc digestibility of all determined AA in the soybean meal was 86% for the 4 and 6-h protocols and 66% and 60% for the 2 and 1-h protocols, respectively. Average pc AA digestibility of soybean meal was 76% for ad libitum feed provision. Feed provisioning also influenced the determined variance. Variance in digestibility ranked in magnitude 1 h > ad libitum > 2 h > 6 h > 4 h for all AA. Owing to the considerable influence of feed-provisioning protocols found in this study, comparisons of pc AA digestibility between studies applying different protocols prior to digesta sampling must be treated with caution. Digestibility experiments aimed at providing estimates for practical feed formulation should use feed-provisioning procedures similar to those used in practice.

Impacts of dietary calcium, phytate, and nonphytate phosphorus concentrations in the presence or absence of phytase on inositol hexakisphosphate (IP6) degradation in different segments of broilers digestive tract

A total of 1,440 straight-run Heritage 56M × fast-feathering Cobb 500F broiler birds were fed from 11 to 13 d of age to determine the impacts of calcium (Ca), phytate phosphorus (PP), nonphytate P (NPP) and phytase concentrations on the myo-inositol hexakisphosphate (IP6) flow through the different parts of gastrointestinal tract (GIT). The experiment was a 2×2×2×3 randomized block design with 2 Ca (0.7 and 1.0%), 2 PP (0.23 and 0.34%), 2 nPP (0.28 and 0.45%) and 3 phytase (0-, 500-, and 1,000-phytase unit (FTU)/kg) concentrations. The experiment was replicated twice (block) with 3 replicates per treatment (TRT) of 10 birds per block. Concentration of IP6 in crop, proventriculus (PROV) plus (+) gizzard (GIZ) and distal ileum digesta as well as the ileal IP6 disappearance was determined at 13 d of age. In crop, higher IP6 concentration was seen with increased Ca (P < 0.05). Despite the interaction between PP and phytase, higher dietary PP led to greater IP6 concentration (P < 0.05). Similar main effects of PP and phytase were also seen in Prov+Giz and ileum (P < 0.05) without interactions. Interaction between Ca and nPP on IP6 concentration was seen in Prov+Giz (P < 0.05). Decreased ileal IP6 disappearance was found at higher Ca (62.3% at 0.7% Ca vs. 57.5% at 1.0% Ca; P < 0.05). In general, adding phytase improved IP6 degradation but the degree of impact was dependent on nPP and PP (P < 0.05). In conclusion, phytase inclusion significantly reduced IP6 concentration and IP6 disappearance in distal ileum regardless of GIT segments or diet composition, but impacts of dietary Ca, nPP, and PP differed depending on GIT segment examined.

Starch utilisation in chicken-meat production: the foremost influential factors

Starch is the chief dietary energy source for chicken-meat production, the majority of which is derived from the grain basis of diets for broiler chickens. The utilisation of starch from maize is of a high order in terms of ileal starch digestibility coefficients but this is not necessarily the case with wheat or sorghum. This may stem from the fact that maize essentially lacks the soluble non-starch polysaccharides in wheat and ‘non-tannin’ phenolic compounds found in sorghum. Numerous factors may influence starch digestibility with emphasis placed on starch–protein interactions as starch granules are located in the prolamin protein matrixes of grain endosperm. This close proximity facilitates any physical and chemical interactions and in this connection particular attention has been paid to kafirin, the dominant protein fraction in sorghum. Nevertheless, despite their apparent importance, the precise nature of starch–protein interactions has not been well defined. Exogenous phytases are routinely included in broiler diets primarily to liberate phytate-bound phosphorus; however, phytate may impede starch digestion and may retard glucose absorption. Additional feed additives, including non-starch polysaccharide-degrading enzymes, other exogenous enzymes and reducing agents may have the capacity to influence starch utilisation. Nevertheless, ileal and total tract starch digestibility coefficients are static parameters and overlook the digestive dynamics of starch, which is inappropriate given the possibility that slowly digestible starch enhances energy utilisation and feed conversion efficiency. However, if the slowly digestible starch concept is valid, the underlying mechanisms have not been fully elucidated. Consideration is given to the suggestion that slowly digestible starch ameliorates the catabolism of amino acids to provide energy to the gut mucosa by increasing the provision of glucose to posterior small intestinal segments. There is the prospect that whole grain feeding provides slowly digestible starch in addition to generating heavier relative gizzard weights. The digestive dynamics of starch and protein are inter-related and the digestion of starch and absorption of glucose should not be considered in isolation from protein digestion and amino acid absorption in the quest to improve the performance of broiler chickens. The foremost factor influencing starch utilisation in chicken-meat production may be the interaction between starch and protein digestive dynamics.

Inclusion of insoluble fiber sources in mash or pellet diets for young broilers. 1. Effects on growth performance and water intake

The effects of feed form and the inclusion of insoluble fiber in the diet on growth performance and water intake were studied in female broilers from 0 to 21 d of age. The experimental design was completely randomized with 14 treatments arranged as a 2 × 7 factorial with 2 feed forms (mash vs. pelleted) and 7 diets that consisted of a control diet low in fiber (1.6% crude fiber) based on broken rice, fermented soybean meal, and fish meal and 6 extra diets that resulted from the inclusion of 3 insoluble fiber sources (oat hulls; OH, rice hulls; RH, and sunflower hulls; SFH) at 2 levels (2.5 vs. 5%). Each treatment was replicated 6 times. Broilers fed pellets had 32% greater ADG and 3% better feed to gain ratio (F:G) than those fed mash (P ≤ 0.001). The inclusion of the fiber sources improved ADG (P ≤ 0.05) and F:G (P ≤ 0.05). Pelleting increased (P ≤ 0.001) water intake from 6 to 8 d, water-to-feed intake ratio from 18 to 20 d, and moisture content of the excreta at 20 d of age. The inclusion of the insoluble fiber sources increased water intake (P ≤ 0.05) from d 18 to 20 but not from d 6 to 8. Increasing the level of fiber inclusion from 2.5 to 5.0% tended to increase (P = 0.086) moisture content in the excreta at d 20. Pelleting and the inclusion of insoluble fiber sources improved ADG and F:G in broilers fed low-fiber diets, and the improvements observed were more pronounced with pellets than with mash. Growth performance of young broilers improves with the addition of moderate amounts of structural insoluble fiber in the diet, regardless of feed form. The inclusion of OH or SFH into low fiber diets was more beneficial for improving broiler performance than the inclusion of RH.

Effects of the Physical Form of Diet on the Outcome of an Artificial Salmonella Infection in Broilers

To prove the hypothesis that the physical form of diet affects the outcome of an artificial infection with Salmonella Enteritidis in broilers, 7-day-old birds were allotted to one of four groups and fed botanically, and nearly also chemically identical diets, differing in grinding and further compaction. In total, two birds from each group (age 14 days) were administered on average 1.06 x 10(8) colony-forming units (CFU) of Salmonella Enteritidis directly into the crop by gavage and immediately put back as "seeder birds" into their respective groups. The salmonella status of each bird was analyzed by cloacal swabs, and at postmortem examination, cecal content and liver tissue samples were taken. Shedding (measured by cloacal swabs) was reduced significantly (P < 0.05) in groups offered the coarsely ground and pelleted diet and the diet including whole wheat compared with the groups fed the finely ground and pelleted and the coarsely ground and extruded diet. Nevertheless, only broilers fed the diet containing whole wheat showed a significantly (P < 0.05) lower frequency of Salmonella Enteritidis isolation in the cecal content and liver tissue. This diet was characterized by the highest percentage of particles > 2 mm. In this study the physical form of diet affected the outcome of an artificial infection with Salmonella Enteritidis significantly.