Mycotoxins in corn and wheat silage in Israel

Evolution of fungal populations in corn silage conserved under polyethylene or biodegradable films

AIMS

To identify cultivable filamentous fungi before ensiling, after silage conservation, in farm-silos covered with two different plastic films (polyethylene (PE) vs biodegradable (MB)), as well as after aerobic exposure of whole-crop corn silage.

METHODS AND RESULTS

Molecular techniques coupled with traditional microbial counting were utilized to identify the predominant fungal species. The cultivable fungal population changed remarkably from harvesting to silo opening. Anaerobiosis and low pH reduced mould count and the presence of Fusarium species both under PE and MB film. However, in the peripheral areas of the silo, where air penetration could not be completely prevented, the fungal population did not decrease. The predominant fungal species after aerobic exposure of silage was Aspergillus fumigatus, without differences between the two plastic films.

CONCLUSIONS

Maintenance of anaerobiosis and a low pH also in the upper layer of the silo reduce the risk of mould growth during corn silage feed-out.

SIGNIFICANCE AND IMPACT OF THE STUDY

Even if the new MB plastic film did not completely maintain the anaerobiosis in the upper layer of silage, the overall silage quality was not compromised and was similar to that observed under PE, indicating that the development and use of MB film to cover silage is promising, but needs some improvement.

Fusaric acid induces a notochord malformation in zebrafish via copper chelation

Over a thousand extracts were tested for phenotypic effects in developing zebrafish embryos to identify bioactive molecules produced by endophytic fungi. One extract isolated from Fusarium sp., a widely distributed fungal genus found in soil and often associated with plants, induced an undulated notochord in developing zebrafish embryos. The active compound was isolated and identified as fusaric acid. Previous literature has shown this phenotype to be associated with copper chelation from the active site of lysyl oxidase, but the ability of fusaric acid to bind copper ions has not been well described. Isothermal titration calorimetry revealed that fusaric acid is a modest copper chelator with a binding constant of 4.4 × 10(5) M(-1). These results shed light on the toxicity of fusaric acid and the potential teratogenic effects of consuming plants infected with Fusarium sp.

Role of the European corn borer (Ostrinia nubilalis) on contamination of maize with 13 Fusarium mycotoxins

The European corn borer (ECB) plays an important role in promoting Fusarium verticillioides infections and in the consequent fumonisin contamination in maize grain in temperate areas. The objective of this study was to evaluate whether the ECB feeding activity could also affect the occurrence of emerging mycotoxins in maize kernels. During the 2008-10 period, natural infestation of the insect was compared, in field research, with the protection of infestation, which was obtained by using an entomological net. The ears collected in the protected plots were free from ECB attack, while those subject to natural insect attacks showed a damage severity that varied from 10% to 25%. The maize samples were analysed by means of an LC-MS/MS-based multi-mycotoxin method, which led to the detection of various metabolites: fumonisins (FUMs), fusaproliferin (FUS), moniliformin (MON), bikaverin (BIK), beauvericin (BEA), fusaric acid (FA), equisetin (EQU), deoxynivalenol (DON), deoxynivalenol-3-glucoside (DON-3-G), zearalenone (ZEA), culmorin (CULM), aurofusarin (AUR) and butenolide (BUT). The occurrence of mycotoxins produced by Fusarium spp. of Liseola section was affected significantly by the ECB feeding activity. The presence of ECB injuries increased the FUMs from 995 to 4694 µg kg(-1), FUS from 17 to 1089 µg kg(-1), MON from 22 to 673 µg kg(-1), BIK from 58 to 377 µg kg(-1), BEA from 6 to 177 µg kg(-1), and FA from 21 to 379 µg kg(-1). EQU, produced by F. equiseti section Gibbosum, was also increased by the ECB activity, by 1-30 µg kg(-1) on average. Instead, the content of mycotoxins produced by Fusarium spp. of Discolor and Roseum sections was not significantly affected by ECB activity. As for FUMs, the application of a strategy that can reduce ECB damage could also be the most effective solution to minimise the other mycotoxins produced by Fusarium spp. of Liseola section.

Non-linear relationships between aflatoxin B₁ levels and the biological response of monkey kidney vero cells

Aflatoxin-producing fungi contaminate food and feed during pre-harvest, storage and processing periods. Once consumed, aflatoxins (AFs) accumulate in tissues, causing illnesses in animals and humans. Most human exposure to AF seems to be a result of consumption of contaminated plant and animal products. The policy of blending and dilution of grain containing higher levels of aflatoxins with uncontaminated grains for use in animal feed implicitly assumes that the deleterious effects of low levels of the toxins are linearly correlated to concentration. This assumption may not be justified, since it involves extrapolation of these nontoxic levels in feed, which are not of further concern. To develop a better understanding of the significance of low dose effects, in the present study, we developed quantitative methods for the detection of biologically active aflatoxin B₁ (AFB1) in Vero cells by two independent assays: the green fluorescent protein (GFP) assay, as a measure of protein synthesis by the cells, and the microculture tetrazolium (MTT) assay, as a measure of cell viability. The results demonstrate a non-linear dose-response relationship at the cellular level. AFB1 at low concentrations has an opposite biological effect to higher doses that inhibit protein synthesis. Additional studies showed that heat does not affect the stability of AFB1 in milk and that the Vero cell model can be used to determine the presence of bioactive AFB1 in spiked beef, lamb and turkey meat. The implication of the results for the cumulative effects of low amounts of AFB1 in numerous foods is discussed.