Can Dynamics Be Responsible for the Complex Multipeak Infrared Spectra of NO Adsorbed to Copper(II) Sites in Zeolites?

Redox and Kinetic Properties of Composition-Dependent Active Sites in Copper-Exchanged Chabazite for Direct Methane-to-Methanol Oxidation

The CH4 oxidation performance of Cu-chabazite zeolites characterized by distinct Si/Al ratios and Cu loadings has been studied and the observed variations in reactivity have been correlated to the differences in the nature of the formed active centers. Plug flow reactor tests, in situ Fourier-transform infrared, and X-ray absorption spectroscopy demonstrate that a decrease in Cu loading shifts the reactivity/redox profile to higher temperatures and increases the CH3OH selectivity and Cu-efficiency. In situ electron paramagnetic resonance, Raman, ultraviolet-visible, Fourier-transform infrared, and photoluminescence spectroscopies reveal that this behavior is associated with the presence of monomeric Cu active sites, including bare Cu2+ and [CuOH]+ present at low Si/Al ratio and Cu loading. Formation of two distinct [Cu2(μ-O)]2+ moieties at higher Si/Al ratio or Cu loading forces these trends into the opposite direction. Operando electron paramagnetic resonance and ultraviolet-visible spectroscopy show that the apparent activation energy of monomeric Cu active species decreases with increasing Si/Al ratio, whereas the one of dimeric centers is unaffected.

Prediction of Cu Zeolite NH3-SCR Activity from Variable Temperature 1H NMR Spectroscopy

Selective catalytic reduction (SCR) of NOx by ammonia is one of the dominant pollution abatement technologies for near-zero NOx emission diesel engines. A crucial step in the reduction of NOx to N2 with Cu zeolite NH3-SCR catalysts is the generation of a multi-electron donating active site, implying the permanent or transient dimerization of Cu ions. Cu atom mobility has been implicated by computational chemistry as a key factor in this process. This report demonstrates how variable temperature 1H NMR reveals the Cu induced generation of sharp 1H resonances associated with a low concentration of sites on the zeolite. The onset temperature of the appearance of these signals was found to strongly correlate with the NH3-SCR activity and was observed for a range of catalysts covering multiple frameworks (CHA, AEI, AFX, ERI, ERI-CHA, ERI-OFF, *BEA), with different Si/Al ratios and different Cu contents. The results point towards universal applicability of variable temperature NMR to predict the activity of a Cu-zeolite SCR catalyst. The unique relationship of a spectroscopic feature with catalytic behavior for zeolites with different structures and chemical compositions is exceptional in heterogeneous catalysis.

Bimetallic Fe–Cu/beta zeolite catalysts for direct hydroxylation of benzene to phenol: effect of the sequence of ion exchange for Fe and Cu cations

Recently, bimetallic cation-exchanged zeolite catalysts have received much attention.

Computational description of key spectroscopic features of zeolite SSZ-13

The catalytic properties of zeolites are intimately linked to the distribution and relative positions of Al atoms and defects in the pore network. However, characterizing this distribution is challenging, in particular when different local Al arrangements are considered. In this contribution we use a combination of first principles calculations and experimental measurements to develop a model for the Al-distribution in protonated SSZ-13. We furthermore apply this model to understand trends in OH-IR, ²⁷Al-NMR and ²⁹Si-NMR spectra. We use a Boltzmann distribution to predict the proton position for a given local Al configuration and show that for each configuration several H positions are occupied. Therefore a multi-peak spectrum in OH-IR vibrational spectroscopy is observed for all Al configurations, which is in line with experimentally measured spectra for zeolites at different Si/Al ratios. From NMR spectroscopy we find that the proton position leads to significant shifts in ²⁷Al-NMR and ²⁹Si-NMR spectra due to the modification of the local strain, which is lost when a uniform background charge is introduced. These findings are supported by experimental measurements. Finally we discuss the shortcomings of the presented model in terms of unit cell size and the impact of adjacent unit cells.

Rare-earth ion exchanged Cu-SSZ-13 zeolite from organotemplate-free synthesis with enhanced hydrothermal stability in NH3-SCR of NOx

Rare-earth Y exchanged Al-rich Cu-CHA shows significantly improved hydrothermal stability in NH₃-SCR reaction.

Redox-Driven Migration of Copper Ions in the Cu-CHA Zeolite as Shown by the In Situ PXRD/XANES Technique

Using quasi-simultaneous in situ PXRD and XANES, the direct correlation between the oxidation state of Cu ions in the commercially relevant deNO_x NH₃ -SCR zeolite catalyst Cu-CHA and the Cu ion migration in the zeolitic pores was revealed during catalytic activation experiments. A comparison with recent reports further reveals the high sensitivity of the redox-active centers concerning heating rates, temperature, and gas environment during catalytic activation. Previously, Cu⁺ was confirmed present only in the 6R. Results verify a novel 8R monovalent Cu site, an eventually large Cu⁺ presence upon heating to high temperatures in oxidative conditions, and demonstrate the unique potential in combining in situ PXRD and XANES techniques, with which both oxidation state and structural location of the redox-active centers in the zeolite framework could be tracked.

The dependence on ammonia pretreatment of N-O activation by Co(II) sites in zeolites: a DFT and ab initio molecular dynamics study

This work is focused on the donor properties of cobalt-exchanged cationic sites in zeolites. It is based on cluster and periodic density functional theory modeling for relevant {[Co(II)(NH3)n]-NO} adducts, where Co(II) means a cobalt cation embedded either in a periodic model of chabasite (CHA) zeolite or in model clusters. NO stretching frequencies were derived from MD trajectories and compared to harmonic values from cluster calculations. By relating calculated NO frequencies to experimental FTIR spectra, it was shown that the forms of {Co(II)-NO} adducts comprising three or four ammonia co-ligands dominate the spectrum taken in ammonia-saturation conditions while forms with two NH3 ligands prevail under intermediate ammonia saturation. Finally, this work confirms the critical dependence of Co(II) activation ability towards NO upon the center donor properties, reinforced by ligation of strong donor ammonia ligands. However, strongly bound ligands appear also to compete with interaction of the center with the electron-rich framework, and a balance must be observed to maintain optimal activation ability. Graphical abstract A snapshot from MD trajectory showing a fragment of periodic framework with twoCo(II)-NO centers, bound to one framework oxygen and strongly coordinating three ammonia ligands with four others forming the second coordination sphere.

Assessing the relative stability of copper oxide clusters as active sites of a CuMOR zeolite for methane to methanol conversion: size matters?

Copper-containing zeolites exhibit high activity in the direct partial oxidation of methane into methanol at relatively low temperatures. Di- and tricopper species have been proposed as active catalytic sites, with recent experimental evidence also suggesting the possibility of the formation of larger copper oxide species. Using density functional theory based global geometry optimization, we were able to identify a general trend of the copper oxide cluster stability increasing with size. For instance, the identified ground-state structures of tetra- and pentamer copper clusters of Cu_nO_n²⁺ and Cu_nO_n-1²⁺ stoichiometries embedded in an 8-ring channel of mordenite exhibit higher relative stability compared to smaller clusters. Moreover, the aluminium content and localization in the zeolite pore influence the cluster's stability and its geometrical motif, which offers a perspective of tuning the properties of copper-exchanged zeolites by creating copper oxide clusters of a given structure and size. With the activity of the cluster towards methane being connected to its stability, such tuning will potentially allow the design of catalysts with engineered properties.

A comparative first principles study on trivalent ion incorporated SSZ-13 zeolites

The dispersion-corrected density functional theory has been used to study the trivalent ions B, Al, Ga, and Fe incorporated SSZ-13-type zeolites.