1
|
Huang YC, Huang YH, Chen LY, Dai CA, Dai SA, Chen YH, Wu CH, Jeng RJ. Robust thermoplastic polyurethane elastomers prepared from recycling polycarbonate. POLYMER 2021. [DOI: 10.1016/j.polymer.2020.123296] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/22/2022]
|
2
|
Imre B, Gojzewski H, Check C, Chartoff R, Vancso GJ. Properties and Phase Structure of Polycaprolactone-Based Segmented Polyurethanes with Varying Hard and Soft Segments: Effects of Processing Conditions. MACROMOL CHEM PHYS 2017. [DOI: 10.1002/macp.201700214] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/03/2023]
Affiliation(s)
- Balazs Imre
- School of Chemical Biological and Environmental Engineering; Oregon State University; Corvallis OR 97331 USA
| | - Hubert Gojzewski
- Materials Science and Technology of Polymers; Faculty of Science and Technology; University of Twente; Drienerlolaan 5 7522 NB Enschede The Netherlands
| | - Casey Check
- Center for Advanced Materials Characterization in Oregon (CAMCOR); University of Oregon; Eugene OR 97403 USA
| | - Richard Chartoff
- School of Chemical Biological and Environmental Engineering; Oregon State University; Corvallis OR 97331 USA
| | - G. Julius Vancso
- Materials Science and Technology of Polymers; Faculty of Science and Technology; University of Twente; Drienerlolaan 5 7522 NB Enschede The Netherlands
| |
Collapse
|
3
|
Sánchez DA, Tonetto GM, Ferreira ML. Burkholderia cepacia
lipase: A versatile catalyst in synthesis reactions. Biotechnol Bioeng 2017; 115:6-24. [DOI: 10.1002/bit.26458] [Citation(s) in RCA: 63] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/17/2017] [Revised: 07/14/2017] [Accepted: 09/21/2017] [Indexed: 12/19/2022]
Affiliation(s)
- Daniel A. Sánchez
- Planta Piloto de Ingeniería Química (PLAPIQUI), Universidad Nacional del Sur; CONICET; Bahía Blanca Argentina
| | - Gabriela M. Tonetto
- Planta Piloto de Ingeniería Química (PLAPIQUI), Universidad Nacional del Sur; CONICET; Bahía Blanca Argentina
| | - María L. Ferreira
- Planta Piloto de Ingeniería Química (PLAPIQUI), Universidad Nacional del Sur; CONICET; Bahía Blanca Argentina
| |
Collapse
|
4
|
Gojzewski H, Imre B, Check C, Chartoff R, Vancso J. Mechanical mapping and morphology across the length scales unveil structure-property relationships in polycaprolactone based polyurethanes. ACTA ACUST UNITED AC 2016. [DOI: 10.1002/polb.24140] [Citation(s) in RCA: 20] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/03/2023]
Affiliation(s)
- Hubert Gojzewski
- Materials Science and Technology of Polymers, Faculty of Science and Technology; University of Twente; Enschede 7522 NB The Netherlands
| | - Balazs Imre
- School of Chemical, Biological and Environmental Engineering; Oregon State University; Corvallis Oregon 97331
| | - Casey Check
- Center for Advanced Materials Characterization in Oregon (CAMCOR); University of Oregon; Eugene Oregon 97405
| | - Richard Chartoff
- School of Chemical, Biological and Environmental Engineering; Oregon State University; Corvallis Oregon 97331
| | - Julius Vancso
- Materials Science and Technology of Polymers, Faculty of Science and Technology; University of Twente; Enschede 7522 NB The Netherlands
| |
Collapse
|
5
|
Chew PL, Annuar MSM, Show PL, Ling TC. Extractive bioconversion of poly-ϵ-caprolactone by Burkholderia cepacia lipase in an aqueous two-phase system. Biochem Eng J 2015. [DOI: 10.1016/j.bej.2015.04.015] [Citation(s) in RCA: 20] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/15/2022]
|
6
|
Choi KK, Park SH, Oh KW, Kim SH. Effect of castor oil/polycaprolactone hybrid polyols on the properties of biopolyurethane. Macromol Res 2015. [DOI: 10.1007/s13233-015-3052-y] [Citation(s) in RCA: 24] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
7
|
Bhattacharyya A, Mukhopadhyay P, Kundu PP. Synthesis of a novel pH-sensitive polyurethane-alginate blend with poly(ethylene terephthalate) waste for the oral delivery of protein. J Appl Polym Sci 2014. [DOI: 10.1002/app.40650] [Citation(s) in RCA: 18] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
Affiliation(s)
- Aditi Bhattacharyya
- Department of Polymer Science and Technology; University of Calcutta; 92 A.P.C. Road Kolkata 700009 India
| | - Piyasi Mukhopadhyay
- Department of Polymer Science and Technology; University of Calcutta; 92 A.P.C. Road Kolkata 700009 India
| | - P. P. Kundu
- Department of Polymer Science and Technology; University of Calcutta; 92 A.P.C. Road Kolkata 700009 India
| |
Collapse
|
8
|
Gumel AM, Annuar MSM, Chisti Y. Ultrasound-Assisted Enzymatic Synthesis of Poly-ε-Caprolactone: Kinetic Behavior and ReactorDesign. INTERNATIONAL JOURNAL OF CHEMICAL REACTOR ENGINEERING 2014. [DOI: 10.1515/ijcre-2013-0115] [Citation(s) in RCA: 8] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/15/2022]
Abstract
Abstract
Lipase-mediated, ultrasound-assisted synthesis of poly-ε-caprolactone was investigated. It was found that ultrasound irradiation helped to improve the rate constant of poly-ε-caprolactone chain propagation (kp) at high initial monomer (ε-caprolactone) concentration. The enhancement of kp ranged from 34% to 46% at 22.5–18.0 M initial monomer concentration, respectively. In a system proned to time-dependent mass-transfer limitation due to polymer chain extension, the acoustic effects could have also allowed the reaction to continue longer compared to non-sonicated process until it became impossible at highly elevated reaction mixture viscosity(>2,000 times increase from initial viscosity). Consequently, it also helped to improve monomer conversion. In a continuous flow polymerization system, a plug flow reactor system is recommended due to its lowest volume for maximum conversion compared to a continuously stirred tank reactor system.
Collapse
|
9
|
Ali FB, Kang DJ, Kim MP, Cho CH, Kim BJ. Synthesis of biodegradable and flexible, polylactic acid based, thermoplastic polyurethane with high gas barrier properties. POLYM INT 2014. [DOI: 10.1002/pi.4662] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
Affiliation(s)
- Fathilah Binti Ali
- Department of Chemical and Biomolecular Engineering; Korea Advanced Institute of Science and Technology (KAIST); Daejeon 305-701 Republic of Korea
| | - Dong Jin Kang
- Department of Chemical and Biomolecular Engineering; Korea Advanced Institute of Science and Technology (KAIST); Daejeon 305-701 Republic of Korea
| | - Minsoo P Kim
- Department of Chemical and Biomolecular Engineering; Korea Advanced Institute of Science and Technology (KAIST); Daejeon 305-701 Republic of Korea
| | - Chul-Hee Cho
- Department of Chemical and Biomolecular Engineering; Korea Advanced Institute of Science and Technology (KAIST); Daejeon 305-701 Republic of Korea
| | - Bumjoon J Kim
- Department of Chemical and Biomolecular Engineering; Korea Advanced Institute of Science and Technology (KAIST); Daejeon 305-701 Republic of Korea
| |
Collapse
|
10
|
Panwiriyarat W, Tanrattanakul V, Pilard JF, Pasetto P, Khaokong C. Effect of the diisocyanate structure and the molecular weight of diols on bio-based polyurethanes. J Appl Polym Sci 2013. [DOI: 10.1002/app.39170] [Citation(s) in RCA: 46] [Impact Index Per Article: 4.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
|
11
|
Chen S, Wang Q, Wang T. Damping, Thermal, and Mechanical Properties of Polycaprolactone-Based PU/EP Graft IPNs: Effects of Composition and Isocyanate Index. J MACROMOL SCI B 2011. [DOI: 10.1080/00222348.2011.565266] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/27/2022]
Affiliation(s)
- Shoubing Chen
- a State Key Laboratory of Solid Lubrication , Lanzhou Institute of Chemical Physics, Chinese Academy of Sciences , Lanzhou, China
- b Graduate University of Chinese Academy of Sciences , Beijing, China
| | - Qihua Wang
- a State Key Laboratory of Solid Lubrication , Lanzhou Institute of Chemical Physics, Chinese Academy of Sciences , Lanzhou, China
| | - Tingmei Wang
- a State Key Laboratory of Solid Lubrication , Lanzhou Institute of Chemical Physics, Chinese Academy of Sciences , Lanzhou, China
| |
Collapse
|
12
|
Pergal MV, Antić VV, Govedarica MN, Goäevac D, Ostojić S, Djonlagić J. Synthesis and characterization of novel urethane-siloxane copolymers with a high content of PCL-PDMS-PCL segments. J Appl Polym Sci 2011. [DOI: 10.1002/app.33926] [Citation(s) in RCA: 41] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
|
13
|
Sobczak M. Synthesis and Characterization of Polyurethanes Based on Oligo(ϵ-caprolactone) Prepared by Free-Metal Method. JOURNAL OF MACROMOLECULAR SCIENCE PART A-PURE AND APPLIED CHEMISTRY 2011. [DOI: 10.1080/10601325.2011.562729] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/18/2022]
|
14
|
Yeganeh H, Jangi A. Thermally curable polyurethanes containing naphthoxazine groups in the main chain. POLYM INT 2010. [DOI: 10.1002/pi.2877] [Citation(s) in RCA: 17] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
|
15
|
de Ilarduya AM, Carvalho E, Alla A, Muñoz-Guerra S. Sequence Analysis of Polyether-Based Thermoplastic Polyurethane Elastomers by 13C NMR. Macromolecules 2010. [DOI: 10.1021/ma100395x] [Citation(s) in RCA: 12] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Affiliation(s)
- Antxon Martínez de Ilarduya
- Departament d′Enginyeria Química, Universitat Politècnica de Catalunya, ETSEIB, Diagonal 647, Barcelona 08028, Spain
| | - Erica Carvalho
- Departament d′Enginyeria Química, Universitat Politècnica de Catalunya, ETSEIB, Diagonal 647, Barcelona 08028, Spain
| | - Abdelilah Alla
- Departament d′Enginyeria Química, Universitat Politècnica de Catalunya, ETSEIB, Diagonal 647, Barcelona 08028, Spain
| | - Sebastián Muñoz-Guerra
- Departament d′Enginyeria Química, Universitat Politècnica de Catalunya, ETSEIB, Diagonal 647, Barcelona 08028, Spain
| |
Collapse
|