Autoclavable low cost serum-free cell culture media: the growth of established cell lines and production of viruses

Influence of Primatone RL supplementation on sialylation of recombinant human interferon-gamma produced by Chinese hamster ovary cell culture using serum-free media

Although serum-free media have been widely used in mammalian cell culture for therapeutic protein production, the effects of serum-substitutes on product quality have not been extensively examined. This study observed an adverse effect of Primatone RL, an animal tissue hydrolysate commonly used as a serum-substitute to promote cell growth, on sialylation of interferon-gamma (IFN-gamma) derived from Chinese hamster ovary (CHO) cell culture in both batch and fed-batch modes. In batch cultures, decreased sialylation was observed at each of the glycosylation sites (i.e., Asn(25) and Asn(97)) of IFN-gamma with the use of elevated concentrations of the peptone. Although poorest sialylation was obtained with the use of a growth-inhibiting concentration of Primatone RL, diminished sialylation was observed at the optimal peptone concentration for cell growth and product yield. Since incubation of the product in Primatone RL-supplemented acellular medium did not result in decreased sialylation, the negative effect of Primatone RL could not be attributed to extracellular desialylation of IFN-gamma by components of the peptone. In the fed-batch mode, a culture utilizing a serum-free feeding medium supplemented with Primatone RL demonstrated poorer sialylation than a similar culture not fed the peptone. The results of both the batch and fed-batch experiments indicate that the adverse effect of the peptone was not due solely to ammonia accumulation. (c) 1997 John Wiley & Sons, Inc. Biotechnol Bioeng 56: 353-360, 1997.

Effects of peptone on hybridoma growth and monoclonal antibody formation

Hybridoma WuT3 secreting a monoclonal antibody against T lymphocytes was grown in RPMI 1640 medium supplemented with 1% human serum. The effect of the concentration of peptone, as an additive, was investigated on cell growth, monoclonal antibody formation, and cell metabolism over 0-10 g l-1 range. It was found that 1-5 g l-1 peptone can significantly promote the growth of cells and increase the formation of monoclonal antibody, especially at 3-5 g l-1, when both the accumulating level and secretion rate of monoclonal antibody are higher than that at other peptone concentrations. Based on glucose, lactate and ammonia analysis data, the efficiency of glycolysis was assessed and the utilization of amino acids was more efficient at 3-5 g l-1 peptone. The cell growth and monoclonal antibody formation were inhibited at higher peptone concentrations, e.g. 10 g l-1.

Peptone, a low-cost growth-promoting nutrient for intensive animal cell culture

The effect of addition of peptone to serum-free and serum supplemented media for the growth of hybridoma cells in various systems was studied. Supplementation of defined medium with either proteose peptone or meat peptone resulted in significant increases in cell number and specific monoclonal antibody production in batch culture system. Other peptones were either inactive or less effective. In continuous culture, using medium supplemented with new born calf serum, the addition of peptone resulted in 125% and 150% increases in cell and antibody concentrations respectively. Similar increase in cell number (128%) was also obtained in spin-filter perfusion culture when medium was supplemented with peptone. By comparison, the substitution of a defined 1 x MEM amino acids mixture resulted in only a 50% increase. At higher perfusion rates the cell number maintained in steady state using peptone supplement could be increased to 1.3 x 10(7) cells ml-1 while the serum concentration was reduced from 5% to 1% at a perfusion rate of 2.5 volumes per day.

Cell aggregate suspension culture for large-scale production of biomolecules

A method is described for the rapid reversible conversion of a number of continuous cell lines from anchorage-dependent growth to growth as aggregates of cells in suspension culture. Employing this technique, an inoculum of three 75-cm2 flasks of BALB/c SV3T3 cells was grown to 60 liters of aggregate suspension in 14 days. This yielded 120 ml of packed cells or 9.1 x 10(10) cells. Similar results were obtained for other cell lines. Biomolecules such as migration-inhibition factor (MIF) and plasminogen activator were produced from these cultures.

The growth of L-cells and Vero cells on an autoclavable MEM-peptone medium

The growth of L-60TM cells (a suspension culture adapted L-cell) on media composed of MEM (minimum essential medium (Eagle)) and bactopeptone autoclaved together or separately under a variety of conditions has veen determined. It has been found that MEM autoclaved with 0.5% bactopeptone at 15 psi for 20 min, cooled and then neutralized with NaHCO3, consistently supported good cell growth of L-60TM and L-929 cells. Similar results were obtained when the MEM and bactopeptone were autoclaved separately. The cells grew initially as a monolayer, subsequently becoming a stationary suspension. Some experiments were carried out with agitated suspension culture of L-60TM cells in the autoclaved MEM-bactopeptone combination with and without added methylcellulose and results were obtained which indicate that large scale suspension culture is possible in this system. Other peptones were also found to support cell growth. The autoclaved MEM-bactopeptone combination also supported the growth of Chang liver and Vero cells. The Chang liver cells rapidly dissociated from the plastic surface but the Vero cells remained sufficiently securely attached so that it was possible to grow them near to confluency in roller bottles.