Autotransfusion in aortic surgery: the Haemocell System 350 cell saver

Decreased erythrocyte deformability after transfusion and the effects of erythrocyte storage duration

BACKGROUND

Erythrocyte cell membranes undergo morphologic changes during storage, but it is unclear whether these changes are reversible. We assessed erythrocyte cell membrane deformability in patients before and after transfusion to determine the effects of storage duration and whether changes in deformability are reversible after transfusion.

METHODS

Sixteen patients undergoing posterior spinal fusion surgery were studied. Erythrocyte deformability was compared between those who required moderate transfusion (≥ 5 units erythrocytes) and those who received minimal transfusion (0-4 units erythrocytes). Deformability was measured in samples drawn directly from the blood storage bags before transfusion and in samples drawn from patients before and after transfusion (over 3 postoperative days). In samples taken from the blood storage bags, we compared deformability of erythrocytes stored for a long duration (≥ 21 days), those stored for a shorter duration (<21 days), and cell-salvaged erythrocytes. Deformability was assessed quantitatively using the elongation index (EI) measured by ektacytometry, a method that determines the ability for the cell to elongate when exposed to shear stress.

RESULTS

Erythrocyte deformability was significantly decreased from the preoperative baseline in patients after moderate transfusion (EI decreased by 12% ± 4% to 20% ± 6%; P = 0.03) but not after minimal transfusion (EI decreased by 3% ± 1% to 4% ± 1%; P = 0.68). These changes did not reverse over 3 postoperative days. Deformability was significantly less in erythrocytes stored for ≥ 21 days (EI = 0.28 ± 0.02) than in those stored for <21 days (EI = 0.33 ± 0.02; P = 0.001) or those drawn from patients preoperatively (EI = 0.33 ± 0.02; P = 0.001). Cell-salvaged erythrocytes had intermediate deformability (EI = 0.30 ± 0.03) that was greater than that of erythrocytes stored ≥ 21 days (P = 0.047), but less than that of erythrocytes stored <21 days (P = 0.03).

CONCLUSIONS

The findings demonstrate that increased duration of erythrocyte storage is associated with decreased cell membrane deformability and that these changes are not readily reversible after transfusion.

Does use of intraoperative cell-salvage delay recovery in patients undergoing elective abdominal aortic surgery?

A best evidence topic in vascular surgery was written according to a structured protocol. The question addressed was whether the use of intraoperative cell-salvage (ICS) leads to negative outcomes in patients undergoing elective abdominal aortic surgery? Altogether 305 papers were found using the reported search, of which 10 were judged to represent the best evidence to answer the clinical question. The authors, journal, date and country of publication, patient group studied, study type, relevant outcomes and results of these papers were tabulated. None of the 10 papers included in the analysis demonstrated that ICS use led to significantly higher incidence of cardiac or septic postoperative complications. Similarly, length of intensive treatment unit (ITU) or hospital stay and mortality in elective abdominal aortic surgery were not adversely affected. Indeed two trials actually show a significantly shorter hospital stay after ICS use, one a shorter ITU stay and another suggests lower rates of chest sepsis. Based on these papers, we concluded that the use of ICS does not cause increased morbidity or mortality when compared to standard practise of transfusion of allogenic blood, and may actually improve some clinical outcomes. As abdominal aortic surgery inevitably causes significant intraoperative blood loss, in the range of 661-3755 ml as described in the papers detailed in this review, ICS is a useful and safe strategy to minimise use of allogenic blood.

Intraoperative use of platelet-plasmapheresis in vascular surgery

STUDY OBJECTIVE

To determine, in a pilot study, whether pheresis of plasma and platelets before surgical blood loss, with reinfusion of the autologous plasma and platelets after completion of the aortic reconstruction, will result in decreased bleeding and decreased transfusion of allogenic blood components in patients undergoing elective aortic reconstruction.

DESIGN

Randomized study.

SETTING

University medical center.

INTERVENTIONS

Patients were randomized to perioperative (acute) platelet plasmapheresis (APP group) versus conventional blood component therapy (control group). In the APP group, blood was withdrawn after induction of anesthesia, to sequester approximately 300 mL of platelet rich plasma (PRP); platelet poor plasma (PPP) and red blood cells (RBC) were sequestered as well. An autotransfusion device was used to collect and re-infuse autologous RBC during the course of the operation in both groups. After completion of the aortic reconstruction, autologous PRP and PPP were re-infused in the APP group. Blood loss, volume of blood component transfusions, and preoperative and postoperative hemoglobin (Hb), hematocrit (Hct), platelet, international normalized ratio (INR), and activated partial thromboplastin time (aPTT) were recorded.

MEASUREMENTS AND MAIN RESULTS

There was no difference between groups in demographics, preoperative laboratory values, or surgical procedures, although more patients were treated for aneurysms (73% vs. 60%) and fewer for occlusive disease (20% vs. 40%) in the control versus APP group. Also, there were no differences between the control and APP groups in duration of operation, blood loss, volume of colloid infused, or volume of allogenic RBC and plasma transfused. Patients in the APP group received a greater volume of crystalloid solution (9.1 +/- 3.4 L vs. 6.8 +/- 3.0 L; p = 0.002), but fewer units of allogenic platelets than the control group (0.7 +/- 1.0 units vs. 0.2 +/- 0.4 units; p < 0.04). There were no differences in postoperative Hb, Hct, INR, aPTT, or fibrinogen. The platelet count was lower in the APP group than in the control group (123 +/- 40 x 10(3)/mm(3) vs. 182 +/- 51 x 10(3)/mm(3); p = 0.004).

CONCLUSIONS

Perioperative platelet plasmapheresis led to fewer allogenic platelet transfusions in patients undergoing elective aortic reconstruction. However, there was no decrease in blood loss and no reduction in transfusion of allogenic RBC or plasma. Perioperative platelet plasmapheresis is not recommended for routine use in elective aortic reconstruction.

Hematuria associated with low-volume cell saver in pediatric orthopaedics

A low-volume autotransfusion device, Haemocell System 350, was used for four consecutive pediatric orthopaedic patients. Although the initial patient evidenced no hematuria, transient hematuria was noted in three consecutive patients. Follow-up blood urea nitrogen, electrolytes, and creatinine levels were all within normal limits. After discontinuation of the device, no further hematuria has occurred in subsequent patients. Although intraoperative low-volume cell savers may have a role in pediatric orthopaedic surgery associated with low total blood volume loss, we observed three cases of postoperative hematuria by using this device in cases with large total blood volume loss [>28% estimated blood volume (EBV)]. Although all of these cases were transitory, we recommend caution in the use of low-volume intraoperative blood-salvage devices in pediatrics at this time.

Rheological properties and function of blood cells in stored bank blood and salvaged blood

The technique involving filtration of diluted blood enables the separate analysis of the flow properties of different cell subpopulations. This study was designed to assess the changes occurring in the flow properties and function of blood cells in stored bank blood and salvaged blood compared to patient blood in a given clinical situation. We measured hydrogen peroxide production by neutrophils and the filterability, through 5 microm Nucleopore filters, of isolated red blood cells and of diluted blood. Samples were obtained from patients undergoing aortic surgery and blood intended for transfusion: either salvaged during surgery or stored bank blood. Both salvaged and bank blood were much less filterable than patient blood, with reduced deformability of both red and white blood cells. However, salvaged blood contained highly activated neutrophils with a prolonged transit time of the 'fast-flowing' cells in the analysis compared to bank blood. Bank blood contained significantly more particles which acted as pore-blockers. Cells in bank and salvaged blood therefore have markedly abnormal flow and biochemical properties compared to patient blood.

Intraoperative autotransfusion in aortic surgery: comparison of whole blood autotransfusion versus cell separation

OBJECTIVE

Differences concerning alteration of hemostatic, hemolysis, and hematologic parameters after transfusion of blood from a cell-separation (CS) device or whole blood autotransfusion (WBA) were prospectively evaluated during major aortic surgery.

METHOD

Thirty-two patients were randomly selected to receive autologous retransfusion by using either WBA or a CS device. Coagulation and hematologic parameters and levels of hemolytic degradation products (HDP) were assessed in the retransfused blood and in the patients' plasma preoperatively and until 24 hours after autologous retransfusion, respectively.

RESULTS

Mean volume of retransfused blood was 1072 +/- 473 ml in the WBA group and 556 +/- 504 in the CS group. Level of HDP (bilirubin, free hemoglobin [free HB], and lactic dehydrogenase [LDH] and hemostatic disturbances (d-dimer value, fibrin degradation products) were significantly higher in the WBA device compared with the CS blood. Blood samples taken from the WBA group revealed significantly higher level of HDP (free HB, LDH) and of d-dimer values after autotransfusion compared with the CS group.

CONCLUSION

Levels of HDP and the degree of hemostatic disturbances were significantly higher in retransfused whole blood compared with CS blood. Hemostatic disturbances and levels of HDP were significantly pronounced in the patients' plasma after WBA compared with CS. CS retransfused blood seems to be of superior quality compared with WBA and the degree of hemolysis and hemostatic disturbances is minor after CS retransfusion.

Clinical and experimental studies of intraoperative autotransfusion using a new filtration device

The Haemocell S-350 device has recently been introduced for intraoperative autotransfusion. The system uses a novel membrane filter to process shed blood. In the first part of this study a 0.2-micron pore size filter was used in a randomized trial comparing the use of autotransfusion (n = 8) with bank blood controls (n = 9) during aortic reconstruction. This part of the trial was abandoned because of unexpected non-surgical bleeding. Bank blood requirements fell from a median of 3.0 (range 0.0-9.0) units to 1.5 (range 0.0-7.0) units when autotransfusion was used, but these patients had a greater perioperative blood loss (1791 (range 932-3104) versus 1140 (range 440-3840) ml). There was evidence of postoperative heparin excess with an activated partial thromboplastin time ratio of 1.3 (range 0.9-3.0) versus 1.0 (range 1.0-1.2) in controls and an activated clotting time of 206 (range 143-280) versus 137 (range 107-142) s. This was confirmed by raised plasma heparin levels and a prolonged thrombin time normalized by protamine. To improve performance a 0.6-micron pore size filter was studied in ten patients. Filtration efficiency doubled from 19 to 38 per cent. Electron micrographs demonstrated better filter clearance, but 44 per cent of the original concentration of heparin remained in the reinfusate. The S-350 device may be an attractive alternative to centrifugation for intraoperative autotransfusion but, until efficiency is improved, it should only be used for cardiovascular surgery when excess heparin can be reversed with protamine.

Acute respiratory distress syndrome following autotransfusion with the Biosurge autotransfuser

A case of acute respiratory distress syndrome in a 79-year-old man is presented in which the use of a BioSurge synchronous autotransfuser may be implicated. This has not been reported before.