International validation of the determination of saturated hydrocarbon mineral oil in vegetable oils

A Study on Mineral Oil Hydrocarbons (MOH) Contamination in Pig Diets and Its Transfer to Back Fat and Loin Tissues

This study assessed saturated mineral oil hydrocarbons (MOSH) and aromatic mineral oil hydrocarbons (MOAH) levels in grower-finisher feeds for pigs supplemented with 5% crude palm oil (CP), crude olive pomace oil (COP), olive pomace acid oil (OPA), or a blend of CP and OPA (50:50, w/w); the contribution of the lipid source to that contamination; and the ability of pigs to accumulate MOH in back fat and loin tissues after 60 days of trial. MOSH and MOAH were analyzed with liquid chromatography (LC)-gas chromatography (GC)-flame ionization detection (FID) after sample preparation. Among the lipid sources, CP had the lowest MOH levels, but CP feeds showed the highest contamination. This, along with the different MOSH profiles, indicated the presence of more significant contamination sources in the feeds than the lipid source. The higher MOH contamination in CP feeds was reflected in the highest MOSH levels in pig back fat, whereas MOAH were not detected in animal tissues. Also, MOSH bioaccumulation in pig tissues was influenced by the carbon chain length. In conclusion, feed manufacturing processes can determine the MOSH contamination present in animal adipose tissues that can be included in human diets.

Optimization of sample clean-up for the determination of small amounts of MOSH and MOAH in edible oils - method DGF C-VI 22 (20)

Methods for determining MOSH and MOAH in edible oils showed major problems with interlaboratory comparability of analytical results, especially in the lower concentration range below 10 mg/kg. However, a method with improved sensitivity and reproducibility is urgently needed to obtain a valid data basis for minimization efforts. To cope this problem a new method was created in 2020. The method was established as the standard method DGF C-VI 22 (20) of the German Society for Fat Science e.V. (DGF). For the development of this method different sample epoxidation approaches have been performed, evaluated and improved. Additionally, a saponification, a decision tree for sample preparation, an upstream clean-up column and a system suitability test were introduced. The focus was on reliability and interlaboratory comparability over all edible oil matrices up to a LOQ of 1 mg/kg. The optimized method was validated in terms of trueness and precision in a collaborative trail with 11 laboratories. The achieved recovery rates of 89-105% MOSH and 70-105% MOAH met the JRC requirements. Method and validation results were obtained with HorRat values between 1.3 and 1.8 for MOSH and MOAH.

Screening for mineral oil hydrocarbons in vegetable oils by silver ion-planar solid phase extraction

The analysis of mineral oil hydrocarbons in vegetable oils is challenging especially regarding the analysis of mineral oil aromatic hydrocarbons (MOAH) since native terpenes like squalene or β-carotene are usually extracted along with the MOAH fraction and interfere their detection. When applying a recently developed screening method for the analysis of mineral oil saturated hydrocarbons (MOSH) and MOAH in paper and cardboard by planar solid phase extraction (pSPE) to vegetable oils, native terpenes expectably interfered with MOAH analysis. Thus, an adaption of pSPE employing silver ions, named silver ion-planar solid phase extraction (Ag-pSPE), was developed in this study. Impregnation of thin-layers with silver nitrate (AgNO₃) was found to be very successful in retaining squalene and β-carotene. MOAH analysis of vegetable oils after saponification showed good repeatability (relative standard deviation (%RSD) <10%) and recoveries of 73.4-112.4% at a spiking level of 4.5 mg/kg (n = 4). For MOSH analysis, a simple solid phase extraction (SPE) clean-up with aluminum oxide removed native n-alkanes prior to Ag-pSPE. Recoveries for MOSH were 55.3-84.5% with %RSD <11% at a spiking level of 45.5 mg/kg (n = 4). Limits of decision and quantitation were at 7.2 and 22.2 ng/zone for MOSH and 1.1 and 3.4 ng/zone for MOAH, respectively, which corresponded to the recently introduced pSPE method, thus showing that analytes were not affected by the impregnation of HPTLC plates with AgNO₃. The method comparison with LC-GC showed similar results for MOSH, while the amounts for MOAH determined by Ag-pSPE were higher.

Occurrence of n-Alkanes in Vegetable Oils and Their Analytical Determination

Vegetable oils contain endogenous linear hydrocarbons, namely n-alkanes, ranging from n-C21 to n-C35, with odd chain lengths prevalent. Different vegetable oils, as well as oils of the same type, but of different variety and provenience, show typical n-alkane patterns, which could be used as a fingerprint to characterize them. In the first part of this review, data on the occurrence of n-alkanes in different vegetable oils (total and predominant n-alkanes) are given, with a focus on obtaining information regarding variety and geographical origin. The second part aims to provide the state of the art on available analytical methods for their determination. In particular, a detailed description of the sample preparation protocols and analytical determination is reported, pointing out the main drawbacks of traditional sample preparation and possible solutions to implement the analysis with the aim to shift toward rapid and solvent-sparing methods.