Effect of water bath-assisted water extraction on physical and chemical properties of soybean oil body emulsion

Effect of Heat Treatment on the Digestive Characteristics of Different Soybean Oil Body Emulsions

Soybean oil body (SOB) emulsions were prepared using OBs extracted at pH 11.0 and pH 7.0. The pH 11.0-SOB comprised oleosins, whereas pH 7.0-SOB comprised extrinsic proteins and oleosins. All SOB emulsions were heated at 60-100 °C for 15 min. Heating may lead to the release of extrinsic proteins from the surface of pH 7.0-SOB due to heat-induced denaturation. The total proportion of α-helix and β-sheets gradually decreased from 77 (unheated) to 36.2% (100 °C). During stomach digestion, the extrinsic protein hydrolysis of heated pH 7.0-SOB emulsions was fast between 60 and 80 °C, and it then slowed between 90 and 100 °C; heating inhibited the oleosin hydrolysis of pH 7.0- and 11.0-SOBs. Heat treatment promoted aggregation and coalescence, and it resulted in increased particle sizes for all emulsions. Larger aggregates were found in heated pH 7.0-SOB emulsions, and larger oil droplets were found in heated pH 11.0-SOB emulsions. After intestinal digestion, the droplets of all SOB emulsions gradually dispersed, and particle sizes decreased. Different heating temperatures had lesser effects on particle sizes and microstructures. Lipolysis was affected by the extraction pH and heating. For pH 11.0-SOB emulsions, the FFA release tendency was greatly affected by the heating temperature, and heating to 80 °C resulted in the highest FFA release (74%). However, all pH 7.0-SOB emulsions had similar total FFA releases. In addition, the droplet charges of heated pH 7.0-SOB emulsions were lower than those of unheated pH 7.0-SOB emulsions in both the intestine and stomach phases; however, the charge changes in different pH 11.0-SOB emulsions showed the opposite tendency. This study will offer guidance regarding the application of SOB emulsions in food.

Soybean Oil Bodies as a Milk Fat Substitute Improves Quality, Antioxidant and Digestive Properties of Yogurt

In this experiment, the effect of replacing milk fat with soybean fat body (25%, 50%, 75%, 100%) on the quality, antioxidant capacity and in vitro digestive characteristics of yogurt was investigated while maintaining the total fat content of the yogurt unchanged. The results showed that increasing the substitution amount of soy fat body for milk fat had little effect on the pH and acidity of yogurt during the storage period, while the physicochemical properties, degree of protein gel network crosslinking, saturated fatty acid content, PV value and TBARS value of the yogurt significantly decreased (p < 0.05). Meanwhile, protein content, solids content, unsaturated fatty acid content, tocopherol content and water holding capacity significantly increased (p < 0.05). Flavor analysis revealed that yogurts with soybean oil bodies were significantly different when compared to those without soybean oil bodies (p < 0.05), and yogurt with 25% substitution had the highest sensory score. After in vitro digestion, the free fatty acid release, antioxidant capacity and protein digestibility of soybean oil body yogurt were significantly higher (p < 0.05). The SDS-PAGE results showed that the protein hydrolysis of the soybean oil body yogurt was faster. Therefore, the use of an appropriate amount of soybean oil bodies to replace milk fat is able to enhance the taste of yogurt and improve the quality of the yogurt.