Non-invasive optical method for real-time assessment of intracorneal riboflavin concentration and efficacy of corneal cross-linking

Spatial targeted delivery of riboflavin with a controlled corneal iontophoresis delivery system in theranostic-guided UV-A light photo-therapy

Seven human donor eye globes underwent corneal cross-linking using theranostic UV-A device with accessory corneal iontophoresis system for patterned delivery of a 0.22% riboflavin solution. Theranostic-guided UV-A light illumination assessed riboflavin distribution and treated corneas at 10 mW/cm2 for 9 min with a 5.0-mm beam size. Corneal topography maps were taken at baseline and 2-h post-treatment. Analysis utilized corneal topography elevation data, with results showing controlled riboflavin delivery led to a consistent gradient, with 40% higher levels centrally (248 ± 79 μg/cm3) than peripherally (180 ± 72 μg/cm3 at ±2.5 mm from the center). Theranostic-guided UV-A light irradiation resulted in significant changes in corneal topography, with a decrease in best-fit sphere value (-0.7 ± 0.2 D; p < 0.001) and consistent downward shift in corneal elevation map (-11.7 ± 3.7 μm). The coefficient of variation was 2.5%, indicating high procedure performance in achieving significant and reliable corneal flattening.

Real-time monitoring of riboflavin concentration using different clinically available ophthalmic formulations for epi-off and epi-on corneal cross-linking

PURPOSE

To assess the feasibility of theranostics to determine the riboflavin concentration in the cornea using clinically available ophthalmic formulations during epithelium-off (epi-off) and transepithelial (epi-on) corneal cross-linking procedures.

METHODS

Thirty-two eye bank human donor corneas were equally randomized in eight groups; groups 1 to 3 and groups 4 to 8 underwent epi-off and epi-on delivery of riboflavin respectively. Riboflavin ophthalmic solutions were applied onto the cornea according to the manufacturers' instructions. The amount of riboflavin into the cornea was estimated, at preset time intervals during imbibition time, using theranostic UV-A device (C4V CHROMO4VIS, Regensight srl, Italy) and expressed as riboflavin score (d.u.). Measurements of corneal riboflavin concentration (expressed as µg/cm3) were also performed by spectroscopy absorbance technique (AvaLight-DH-S-BAL, Avantes) for external validation of theranostic measurements.

RESULTS

At the end of imbibition time in epi-off delivery protocols, the average riboflavin score ranged from 0.77 ± 0.38 (the average corneal riboflavin concentration was 213 ± 190 µg/cm3) to 1.79 ± 0.07 (554 ± 103 µg/cm3). In epi-on delivery protocols, the average riboflavin score ranged from 0.17 ± 0.01 to 0.67 ± 0.19 (corneal riboflavin concentration ranged from 6 ± 5 µg/cm3 to 122 ± 39 µg/cm3) at the end of imbibition time. A statistically significant linear correlation (P ≤ 0.05) was found between the theranostic and spectrophotometry measurements in all groups.

CONCLUSIONS

Real-time theranostic imaging provided an accurate strategy for assessing permeation of riboflavin into the human cornea during the imbibition phase of corneal cross-linking, regardless of delivery protocol. A large variability in corneal riboflavin concentration exists between clinically available ophthalmic formulations both in epi-off and epi-on delivery protocols.

Predicting corneal cross-linking treatment efficacy with real-time assessment of corneal riboflavin concentration

PURPOSE

To assess predictability of tissue biomechanical stiffening induced by UV-A light-mediated real-time assessment of riboflavin concentration during corneal crosslinking (CXL) of human donor tissues.

SETTING

Studio Italiano di Oftalmologia, Rome, Italy.

DESIGN

Laboratory study.

METHODS

20 sclerocorneal tissues were randomly stratified to undergo CXL with either the epithelium intact (n = 12) or removed (n = 8). Samples underwent corneal soaking with 0.22% riboflavin formulation (RitSight) with dosing time of t = 10 minutes and t = 20 minutes in epithelium-off and epithelium-on protocols, respectively. All tissues underwent 9-minute UV-A irradiance at 10 mW/cm 2 using theranostic device (C4V CHROMO4VIS). The device used controlled UV-A light irradiation to induce both imaging and treatment of the cornea, providing a real-time measure of corneal riboflavin concentration and treatment efficacy (ie, theranostic score) during surgery. Tissue biomechanics were assessed with an air-puff device (Corvis), which was performed before and after treatment. A 3-element viscoelastic model was developed to fit the corneal deformation response to air-puff excitation and to calculate the mean corneal stiffness parameter (k c ).

RESULTS

Significant corneal tissue stiffening ( P < .05) was induced by the theranostic UV-A device in either CXL treatment protocol. Significant correlation was found between the theranostic score and the increase in k c ( R = 0.75; P = .003). The score showed high accuracy (94%) and precision (94%) to predict correctly samples that had improved tissue biomechanical strengthening.

CONCLUSIONS

Real-time assessment of corneal riboflavin concentration provided a predictive and precise approach for significant improvement of tissue strength on individual corneas, regardless of CXL treatment protocol.

A randomized clinical trial assessing theranostic-guided corneal cross-linking for treating keratoconus: the ARGO protocol

The Assessment of theranostic guided riboflavin/UV-A corneal cross-linking for treatment of keratoconus (ARGO; registration number NCT05457647) clinical trial tests the hypothesis that theranostic-guided riboflavin/UV-A corneal cross-linking (CXL) can provide predictable clinical efficacy for halting keratoconus progression, regardless of treatment protocol, i.e., either with or without epithelial removal. Theranostics is an emerging therapeutic paradigm of personalized and precision medicine that enables real-time monitoring of image-guided therapy. In this trial, the theranostic software module of a novel UV-A medical device will be validated in order to confirm its accuracy in estimating corneal cross-linking efficacy in real time. During CXL procedure, the theranostic UV-A medical device will provide the operator with an imaging biomarker, i.e., the theranostic score, which is calculated by non-invasive measurement of corneal riboflavin concentration and its UV-A light mediated photo-degradation. ARGO is a randomized multicenter clinical trial in patients aged between 18 and 40 years with progressive keratoconus aiming to validate the theranostic score by assessing the change of the maximum keratometry point value at 1-year postoperatively. A total of 50 participants will be stratified with allocation ratio 1:1 using a computer-generated stratification plan with blocks in two treatment protocols, such as epithelium-off or epithelium-on CXL. Following treatment, participants will be monitored for 12 months. Assessment of safety and performance of theranostic-guided corneal cross-linking treatment modality will be determined objectively by corneal tomography, corneal endothelial microscopy, visual acuity testing and slit-lamp eye examination.

Theranostic-guided corneal cross-linking: Preclinical evidence on a new treatment paradigm for keratoconus

Theranostics is an emerging therapeutic paradigm of personalized medicine; the term refers to the simultaneous integration of therapy and diagnostics. In this work, theranostic-guided corneal cross-linking was performed on 10 human sclero-corneal tissues. The samples were soaked with 0.22% riboflavin formulation and underwent 9 minutes UV-A irradiance at 10 mW/cm² using theranostic device, which provided both a measure of corneal riboflavin concentration and a theranostic score estimating treatment efficacy in real time. A three-element viscoelastic model was developed to fit the deformation response of the cornea to air-puff excitation of dynamic tonometry and to calculate the mean corneal stiffness parameter before and after treatment. Significant correlation was found between the theranostic score and the increase in mean corneal stiffness (R = 0.80; P < .001). Accuracy and precision of the theranostic score in predicting the induced corneal tissue stiffening were both 90%. The riboflavin concentration prior to starting the UV-A photo-therapy phase was the most important variable to allow corneal cross-linking to be effective. Theranostic UV-A light mediated imaging and therapy enables the operator to adopt a precise approach for achieving highly predictable biomechanical strengthening on individual corneas.

Long-term Effects of Riboflavin Ultraviolet-A-Induced CXL With Different Irradiances on the Biomechanics of In Vivo Rabbit Corneas

PURPOSE

To evaluate the long-term effects of ultraviolet-A corneal cross-linking (CXL) with different irrandiances on the biomechanical properties of rabbit corneas and the corresponding changes in stromal microstructure.

METHODS

The study involved the left eyes of 85 healthy white Japanese rabbits, randomly divided into five groups (n = 16 to 18 each). After removing the epithelium, the first four groups were exposed to riboflavin (0.22% concentration by volume) and ultraviolet-A (370 nm) at different CXL irradiations but with the same total dose (5.4 J/cm2). The four groups were defined as standard CXL (SCXL; 3 mW/cm2 for 30 minutes, n = 17), accelerated CXL1 (ACXL1; 9 mW/cm2 for 10 minutes, n = 16), accelerated CXL2 (ACXL2; 18 mW/cm2 for 5 minutes, n = 17), and accelerated CXL3 (ACXL3; 30 mW/cm2 for 3 minutes, n = 17). The control group (n = 18) was treated with riboflavin without ultraviolet-A exposure. Nine months after CXL, 10 corneas from each group were tested ex vivo under inflation, and the tangent modulus (Et) was estimated using an inverse analysis process. The remaining six to eight specimens in each group were examined by electron microscopy to determine the mean fibril diameter and interfibrillar spacing.

RESULTS

The SCXL and ACXL1 groups showed statistically significant differences in Et at all stresses (0.005, 0.010, and 0.015 MPa) analyzed compared to the control group (all P < .01), but the differences were non-significant in the ACXL3 group (P = 1.000, .785, and .679, respectively). For the ACXL2 group, there was no statistical difference in Et under the low stress of 0.005 MPa (P = .155), but the differences became significant at 0.010 and 0.015 MPa when compared with the control group (all P < .05).

CONCLUSIONS

CXL had a significant effect on corneal biomechanics in both standard and accelerated procedures. However, standard CXL was the most effective, and this effectiveness decreased gradually with increasing ultraviolet-A power intensity. [J Refract Surg. 2022;38(6):389-397.].

Adverse events after riboflavin/UV-A corneal cross-linking: a literature review

BACKGROUND

Riboflavin/UV-A corneal cross-linking (CXL) for treating keratoconus and iatrogenic corneal ectasia has been well-established as first treatment option to stabilize corneal tissue biomechanical instability. Although the plethora of clinical studies has been published into the field, there is no systematic review assessing the type and frequency of adverse events after CXL.

METHODS

A systemic literature review on clinical safety and adverse events after CXL in patients with keratoconus and corneal ectasia was performed using PubMed. A literature search was performed for relevant peer-reviewed publications. The main outcome measures extracted from the articles were adverse events, endothelial cell density, corrected distance visual acuity and maximum simulated keratometry.

RESULTS

The most frequent adverse events after CXL were corneal haze and corneal edema, which were mild and transient. The severe adverse events were infrequent (cumulative incidence: < 1.3%) after CXL. The clinical benefits of CXL highly outweighed the risks for the treatment of keratoconus and corneal ectasia.

CONCLUSIONS

The severe adverse events with permanent sequelae are infrequent after CXL and all are associated with corneal de-epithelialization, such as infectious keratitis and corneal scarring.

Advances in the diagnosis and treatment of keratoconus

Keratoconus had traditionally been considered a rare disease at a time when the imaging technology was inept in detecting subtle manifestations, resulting in more severe disease at presentation. The increased demand for refractive surgery in recent years also made it essential to more effectively detect keratoconus before attempting any ablative procedure. Consequently, the armamentarium of tools that can be used to diagnose and treat keratoconus has significantly expanded. The advances in imaging technology have allowed clinicians and researchers alike to visualize the cornea layer by layer looking for any early changes that might be indicative of keratoconus. In addition to the conventional geometrical evaluation, efforts are also underway to enable spatially resolved corneal biomechanical evaluation. Artificial intelligence has been exploited in a multitude of ways to enhance diagnostic efficiency and to guide treatment. As for treatment, corneal cross-linking treatment remains the mainstay preventive approach, yet the current main focus of research is on increasing oxygen availability and developing new strategies to improve riboflavin permeability during the procedure. Some new combined protocols are being proposed to simultaneously halt keratoconus progression and correct refractive error. Bowman layer transplantation and additive keratoplasty are newly emerging alternatives to conventional keratoplasty techniques that are used in keratoconus surgery. Advances in tissue engineering and regenerative therapy might bring new perspectives for treatment at the cellular level and hence obviate the need for invasive surgeries. In this review, we describe the advances in the diagnosis and treatment of keratoconus primarily focusing on newly emerging approaches and strategies.

Comparison between standard and transepithelial corneal crosslinking using a theranostic UV-A device

PURPOSE

To assess corneal concentration of riboflavin in two different corneal crosslinking protocols performed by a novel image-guided therapeutic (or "theranostic") UV-A device.

METHODS

Ten human eye bank donor tissues were used in this work. The tissues underwent corneal cross-linking according to the conventional treatment protocol (n = 5; 30 min of stromal soaking followed by 30 min of 3 mW/cm² UV-A irradiance) and the iontophoresis-assisted transepithelial protocol (n = 5; soaking for 5 min at 1 mA/min and 9 min of 10 mW/cm² UV-A irradiance) using a theranostic UV-A device (Vision Engineering Italy srl, Italy). The device provided real time assessment of riboflavin concentration by hyperspectral image analysis of the cornea. A 0.1% riboflavin hypotonic solution (Ricrolin+, Sooft Italia Spa, Italy) was used in all cases.

RESULTS

Manual application of hypotonic riboflavin for 30 min into the stroma achieved greater corneal riboflavin concentration (425 ± 77 μg/cm³) than transepithelial delivery of riboflavin by corneal iontophoresis (195 ± 35 μg/cm³; P = 0.001). In both UV-A irradiation protocols, corneal riboflavin concentration decreased exponentially with a constant energy rate of 2.3 ± 0.5 J/cm² and 1.8 ± 0.3 J/cm² respectively. At the end of treatment, the average corneal concentration of riboflavin decreased by ≥ 85%, with values of 54 ± 29 μg/cm³ and 31 ± 9 μg/cm³ (P = 0.11), respectively.

CONCLUSION

Manual application of riboflavin onto the stroma achieved almost 50% greater concentration of riboflavin than transepithelial delivery by corneal iontophoresis. The theranostic UV-A device provided a novel approach to estimate corneal concentration of riboflavin non-invasively during treatment.

Two-year outcomes of a randomized controlled trial of transepithelial corneal crosslinking with iontophoresis for keratoconus

PURPOSE

To evaluate the 2-year clinical outcomes of corneal crosslinking (CXL) using transepithelial iontophoresis CXL (T-ionto CXL) in comparison with standard CXL for the treatment of progressive keratoconus.

SETTING

Single-site study.

DESIGN

Randomized controlled clinical trial with identifier code NCT02117999.

METHODS

The eyes of the participants were randomized to have either T-ionto CXL and/or standard CXL. Assessments of uncorrected (UDVA) and corrected (CDVA) distance visual acuities (logarithm of the minimum angle of resolution [logMAR]), manifest refraction spherical equivalent, maximum simulated keratometry (K) (diopters [D]), corneal higher-order aberrations (HOAs), central corneal thickness (CCT), and endothelial cell density (ECD) were performed at 3 days, 7 days, and 1, 3, 6, 12, and 24 months postoperatively.

RESULTS

The study comprised 34 eyes (25 patients). There were 22 eyes in the T-ionto CXL group and 12 eyes in the standard CXL group. Two years after T-ionto CXL and standard CXL, the mean maximum K flattened by -1.05 ± 1.20 D (P = .07) (20 eyes) and -1.51 ± .89 D (P < .001) (11 eyes), respectively. Two study cases (10%) and no control showed maximum K steepening of more than 1.0 D at 24 months postoperatively. The mean change in CDVA was -0.08 ± 0.15 logMAR (P = .04) and -0.02 ± 0.06 logMAR (P = .34) after T-ionto CXL and standard CXL, respectively. A significant average decrease in the myopic defocus (+0.81 D; P < .05) was found in both groups. No significant differences in the outcome measures between treatments were found at 24 months. The corneal HOAs, CCT, and ECD values did not change significantly in any group at 2 years postoperatively.

CONCLUSIONS

Clinically significant topographic, visual, and refractive improvements were found 2 years after T-ionto CXL; standard CXL showed more significant corneal apex flattening than the transepithelial iontophoresis protocol.