Spreading of a Lidocaine Formulation on Microneedle-Treated Skin

Mussel-Inspired Adhesive Hydrogels Based on Laponite-Confined Dopamine Polymerization as a Transdermal Patch

Transdermal patch for local drug delivery has attained huge attention as an attractive alternative to existing drug delivery techniques as it is painless and user-friendly. However, most adhesive hydrogels either do not have adequate adhesion with the skin or cause discomfort while being removed from the skin surface due to excessive adhesion. To address this challenge, we developed an adhesive hydrogel based on laponite-confined dopamine polymerization as a transdermal patch. Laponite RDS nanoclay was used to control the hydrogel's viscous behavior and dopamine polymerization. The laponite polymerized polydopamine (l-PDA) was incorporated into poly(vinyl alcohol) (PVA) to make the PVA-l-PDA hydrogel. The laponite-confined polymerization improved the hydrogels' water contact angle and adhesion strength. The adhesion strength of the PVA-l-PDA hydrogel was adequate to adhere to the evaluated goat skin, glass, and polypropylene surfaces. Notably, the PVA-l-PDA hydrogel was easy to peel off from the skin. Further, we evaluated the drug release profile in goat skin using lidocaine as a model drug. We observed the controlled release of lidocaine from the PVA-l-PDA hydrogel compared to the PVA-PDA hydrogel. In addition, the nanoclay-confined adhesive hydrogel did not show any cytotoxic effect in fibroblasts. Altogether, PVA-l-PDA hydrogels offer appropriate adhesive strength, toughness, and biocompatibility. Thus, the PVA-l-PDA hydrogel has the potential to be an efficient transdermal patch.

Etodolac nanosuspension based gel for enhanced dermal delivery: in vitro and in vivo evaluation

AIM

The objective of this study was to develop dermal nanosuspension (NS) based gel formulation of etodolac (ETD).

METHODS

Etodolac nanosuspension (ETD-NS) was prepared by wet milling method and dispersed in hydroxypropyl methylcellulose (NS-HPMC) or hydroxyethyl cellulose (NS-HEC) gels. Rheologic and mechanical properties were investigated. In vitro and ex vivo permeability studies were performed. Topical anti-inflammatory and analgesic activity were evaluated in regard to carrageenan-induced inflammatory paw oedema and radiant heat tail-flick method, respectively.

RESULTS

The ETD-NS with approximately 190 nm particle size (PS), 0.16 polydispersity index (PDI), and -15 mV zeta potential (ZP) values were obtained. The work of bioadhesion values of NS-HEC and NS-HPMC gels were 0.229 mJ/cm² for both gels. Dermal permeation of ETD from NS-HEC gel (7.18%) was found significantly higher than the NS-HPMC gel (4.56%). Enhanced anti-inflammatory and analgesic activity of NS-HEC gels were observed in comparison with micronised ETD.

CONCLUSIONS

ETD-NS based gel formulation is promising for topical delivery of ETD.

Alternatives to Biological Skin in Permeation Studies: Current Trends and Possibilities

: The transdermal route of drugs has received increased attention in recent years due to numerous advantages over the oral and injectable routes, such as avoidance of the hepatic metabolism, protection of drugs from the gastrointestinal tract, sustained drug delivery, and good patient compliance. The assessment of ex vivo permeation during the pharmaceutical development process helps in understanding the product quality and performance of a transdermal delivery system. Generally, excised human skin relevant to the application site or animal skin is recommended for ex vivo permeation studies. However, the limited availability of the human skin and ethical issues surrounding the use of animal skin rendered these models less attractive in the permeation study. In the last three decades, enormous efforts have been put into developing artificial membranes and 3D cultured human skin models as surrogates to the human skin. This manuscript provides an insight on the European Medicines Agency (EMA) guidelines for permeation studies and the parameters affected when using Franz diffusion cells in the permeation study. The need and possibilities for skin alternatives, such as artificially cultured human skin models, parallel artificial membrane permeability assays (PAMPA), and artificial membranes for penetration and permeation studies, are comprehensively discussed.

Spreading and Imbibition of Vesicle Dispersion Droplets on Porous Substrates

Vesicles have recently found widespread use in applications such as conditioning of textiles, paper and hair, as well as transdermal drug delivery. The mode of treatment in several such cases involves the application of droplets of aqueous dispersions of vesicles onto dry porous substrates like paper and textiles. One of the factors which affects the performance of such treatments is the rate at which the droplets spread and imbibe on the porous substrate. Depending upon the specific purpose of the treatment either a fast or slow droplet spreading kinetics could be desired. Therefore, it is important to have a good understanding of the droplet spreading process and the factors which influence it. In this work, an experimental investigation of the simultaneous spreading and imbibition of vesicle dispersion droplets on cellulose filter papers is carried out. Two different types of vesicles which are composed of similar lipid molecules but exhibit contrasting lipid bilayer phase behavior are used. Two different grades of filter papers with comparable porosities but different thicknesses are used as porous substrate. It is found that the droplet spreading behavior is of the “complete wetting” type on the thicker porous substrate, whereas it is of the “partial wetting” type on the thinner substrate. Furthermore, it is observed that the spreading of droplets containing vesicles with liquid-crystalline phase bilayers occurs faster than that of vesicles with solid-gel phase bilayers. The secondary radial penetration which commences after the initial droplet spreading is complete is also investigated and discussed.

Evaluation of a Particulate Breast Cancer Vaccine Delivered via Skin

Breast cancer impacts female population globally and is the second most common cancer for females. With various limitations and adverse effects of current therapies, several immunotherapies are being explored. Development of an effective breast cancer vaccine can be a groundbreaking immunotherapeutic approach. Such approaches are being evaluated by several clinical trials currently. On similar lines, our research study aims to evaluate a particulate breast cancer vaccine delivered via skin. This particulate breast cancer vaccine was prepared by spray drying technique and utilized murine breast cancer whole cell lysate as a source of tumor-associated antigens. The average size of the particulate vaccine was 1.5 μm, which resembled the pathogenic species, thereby assisting in phagocytosis and antigen presentation leading to further activation of the immune response. The particulate vaccine was delivered via skin using commercially available metal microneedles. Methylene blue staining and confocal microscopy were used to visualize the microchannels. The results showed that microneedles created aqueous conduits of 50 ± 10 μm to deliver the microparticulate vaccine to the skin layers. Further, an in vivo comparison of immune response depicted significantly higher concentration of serum IgG, IgG2a, and B and T cell (CD4+ and CD8+) populations in the vaccinated animals than the control animals (p < 0.001). Upon challenge with live murine breast cancer cells, the vaccinated animals showed five times more tumor suppression than the control animals confirming the immune response activation and protection (p < 0.001). This research paves a way for individualized immunotherapy following surgical tumor removal to prolong relapse episodes.

Full-Thickness Intraoral Mucosa Barrier Models for In Vitro Drug-Permeation Studies Using Microneedles

The use of permeation enhancers such as microneedles (MNs) to increase drug penetration across intraoral mucosa has increased in recent years. Permeation studies, commonly performed using vertical diffusion cells, are a well-established way to preview formulations and enhance their performance during the development stage. However, to our knowledge, the existing intraoral mucosa barrier models do not permit permeation using MN-pretreated mucosa due to their insufficient thickness. Therefore, the objective of this study was to develop a barrier model using thick palate tissues to perform in vitro permeation studies, with physical enhancement of the permeability of intraoral mucosa by pretreatment with MNs. The adapted Franz-type cells used in the permeation experiments were validated (cell dimensions and volume, sealing effectiveness, stirring and dissolution efficiency, temperature control, and establishment of uniaxial flux). Commercially available MNs were used in the palatal mucosa. Optical images of the mucosa were acquired to analyze the microperforations created. In vitro permeation studies were conducted with the MN-pretreated mucosa. This work presents a new in vitro method for the evaluation of MNs as permeation enhancers, with the aim of improving the absorption of drug formulations topically applied within the oral cavity.