Beneficial effect of intracellular trehalose on the membrane integrity of dried mammalian cells

Molecular simulation on the interaction between trehalose and asymmetric lipid bilayer mimicking the membrane of human red blood cells

Trehalose is widely acknowledged for its ability to stabilize plasma membranes during dehydration. However, the exact mechanism by which trehalose interacts with lipid bilayers remains presently unclear. In this study, we conducted atomistic molecular dynamic simulations on asymmetric model bilayers that mimic the membrane of human red blood cells at various trehalose and water contents. We considered three different hydration levels mimicking the full hydration to desiccation scenarios. Results indicate that the asymmetric distribution of lipids did not significantly influence the computed structural characteristics at full and low hydration. At dehydration, however, the order parameter obtained from the symmetric bilayer is significantly higher compared to those obtained from asymmetric ones. Analysis of hydrogen bonds revealed that the protective ability of trehalose is well described by the water replacement hypothesis at full and low hydration, while at dehydration other interaction mechanisms associated with trehalose exclusion from the bilayer may involve. In addition, we found that trehalose exclusion is not attributed to sugar saturation but rather to the reduction in hydration levels. It can be concluded that the protective effect of trehalose is not only related to the hydration level of the bilayer, but also closely tied to the asymmetric distribution of lipids within each leaflet.

Measurement of the rotational relaxation time of intracellular water in dried yeast and Jurkat cells by near infrared spectroscopy

Molecular mobility of intracellular water is a crucial parameter in the study of the mechanism of desiccation tolerance. As one of the parameters that reflecting molecular mobility, the viscosity of intracellular water has been found intimately related with the protection of the phospholipid membrane because it quantifies the diffusion ability of water and mass in the intracellular environment. In this work we measured the intracellular water relaxation time, which can be translated into water viscosity, by using a previously established NIR-dielectric method to monitor the drying process of baker's yeast and Jurkat cells with different desiccation tolerance. We found that intracellular saccharide can significantly decrease the intracellular water viscosity. Also, the intracellular water diffusion coefficient obtained from this method were found in good agreement with other reports.

Recent Developments in Cell Shipping Methods

As opposed to remarkable advances in the cell therapy industry, researches reveal inexplicable difficulties associated with preserving and post-thawing cell death. Post cryopreservation apoptosis is a common occurrence that has attracted the attention of scientists to use apoptosis inhibitors. Transporting cells without compromising their survival and function is crucial for any experimental cell-based therapy. Preservation of cells allows the safe transportation of cells between distances and improves quality control testing in clinical and research applications. The vitality of transported cells is used to evaluate the efficacy of transportation strategies. For many decades, the conventional global methods of cell transfer were not only expensive but also challenging and had adverse effects. The first determination of some projects is optimizing cell survival after cryopreservation. The new generation of cryopreservation science wishes to find appropriate and alternative methods for cell transportation to ship viable cells at an ambient temperature without dry ice or in media-filled flasks. The diversity of cell therapies demands new cell shipping methodologies and cryoprotectants. In this review, we tried to summarize novel improved cryopreservation methods and alternatives to cryopreservation with safe and viable cell shipping at ambient temperature, including dry preservation, hypothermic preservation, gel-based methods, encapsulation methods, fibrin microbeads, and osmolyte solution compositions. This article is protected by copyright. All rights reserved.

Poly(l-alanine-co-l-lysine)-g-Trehalose as a Biomimetic Cryoprotectant for Stem Cells

Poly(l-alanine-co-l-lysine)-graft-trehalose (PAK_T) was synthesized as a natural antifreezing glycopolypeptide (AFGP)-mimicking cryoprotectant for cryopreservation of mesenchymal stem cells (MSCs). FTIR and circular dichroism spectra indicated that the content of the α-helical structure of PAK decreased after conjugation with trehalose. Two protocols were investigated in cryopreservation of MSCs to prove the significance of the intracellularly delivered PAK_T. In protocol I, MSCs were cryopreserved at -196 °C for 7 days by a slow-cooling procedure in the presence of both PAK_T and free trehalose. In protocol II, MSCs were preincubated at 37 °C in a PAK_T solution, followed by cryopreservation at -196 °C in the presence of free trehalose for 7 days by the slow-cooling procedure. Polymer and trehalose concentrations were varied by 0.0-1.0 and 0.0-15.0 wt %, respectively. Cell recovery was significantly improved by protocol II with preincubation of the cells in the PAK_T solution. The recovered cells from protocol II exhibited excellent proliferation and maintained multilineage potentials into osteogenic, chondrogenic, and adipogenic differentiation, similar to MSCs recovered from cryopreservation in the traditional 10% dimethyl sulfoxide system. Ice recrystallization inhibition (IRI) activity of the polymers/trehalose contributed to cell recovery; however, intracellularly delivered PEG-PAK_T was the major contributor to the enhanced cell recovery in protocol II. Inhibitor studies suggested that macropinocytosis and caveolin-dependent endocytosis are the main mechanisms for the intracellular delivery of PEG-PAK_T. ¹H NMR and FTIR spectra suggested that the intracellular PEG-PAK_Ts interact with water and stabilize the cells during cryopreservation.

Membrane-permeable trehalose improves the freezing ability and developmental competence of in-vitro matured feline oocytes

Oocytes are highly sensitive to cryopreservation, which frequently results in an irreversible loss of developmental competence. We examined the effect of membrane-permeable trehalose on the freezing ability of feline oocytes matured in vitro. In Experiment 1, intracellular trehalose (trehalose hexaacetate; Tre-(OAc)₆) was synthesized from trehalose precursor and subjected to spectroscopic characterization. The membrane permeability of the Tre-(OAc)₆ was investigated by incubating oocytes with different concentrations of Tre-(OAc)₆ (3, 15, and 30 mM). Optimum concentration and the toxicity of Tre-(OAc)₆ were assessed in Experiment 2. The effects of Tre-(OAc)₆ on freezing ability in terms of apoptotic gene expression and developmental competence of in-vitro matured oocytes were examined in Experiments 3 and 4, respectively. The Tre-(OAc)₆ permeated into the ooplasm of cat oocytes in a dose- and time-dependent manner. The highest concentration of intracellular trehalose was detected when the oocytes were incubated for 24 h with 30 mM Tre-(OAc)₆. For the toxicity test, incubation of oocytes with 3 mM Tre-(OAc)₆ for 24 h did not affect maturation rate and embryo development. However, high doses of Tre-(OAc)₆ (15 and 30 mM) significantly reduced maturation and fertilization rates (p < 0.05). In addition, frozen-thawed oocytes treated with 3 mM Tre-(OAc)₆ significantly upregulated anti-apoptotic (BCL-2) gene expression compared with the control (0 mM) and other Tre-(OAc)₆ concentrations (15 and 30 mM). Oocyte maturation in the presence of 3 mM Tre-(OAc)₆ prior to cryopreservation significantly improved oocyte developmental competence in terms of cleavage and blastocyst rates when compared with the control group (p < 0.05). Our results lead us to infer that increasing the levels of intracellular trehalose by Tre-(OAc)₆ during oocyte maturation improves the freezing ability of feline oocytes, albeit at specific concentrations.

Development of Icephilic ACTIVE Glycopeptides for Cryopreservation of Human Erythrocytes

Ice formation and recrystallization exert severe impairments to cellular cryopreservation. In light of cell-damaging washing procedures in the current glycerol approach, many researches have been devoted to the development of biocompatible cryoprotectants for optimal bioprotection of human erythrocytes. Herein, we develop a novel ACTIVE glycopeptide of saccharide-grafted ε-poly(L-lysine), that can be credited with adsorption on membrane surfaces, cryopreservation with trehalose, and icephilicity for validity of human erythrocytes. Then, by Borch reductive amination or amidation, glucose, lactose, maltose, maltotriose, or trehalose was tethered to ε-polylysine. The synthesized ACTIVE glycopeptides with intrinsic icephilicity could localize on the membrane surface of human erythrocytes and improve cryopreservation with trehalose, so that remarkable post-thaw cryosurvival of human erythrocytes was achieved with a slight variation in cell morphology and functions. Human erythrocytes (∼50% hematocrit) in cryostores could maintain high cryosurvival above 74%, even after plunged in liquid nitrogen for 6 months. Analyses of differential scanning calorimetry, Raman spectroscopy, and dynamic ice shaping suggested that this cryopreservation protocol combined with the ACTIVE glycopeptide and trehalose could enhance the hydrogen bond network in nonfrozen solutions, resulting in inhibition of recrystallization and growth of ice. Therefore, the ACTIVE glycopeptide can be applied as a trehalose-associated "chaperone", providing a new way to serve as a candidate in glycerol-free human erythrocyte cryopreservation.

Role of Mono- and Disaccharide Combination in Cryoprotective Medium for Rooster Semen to Ensure Cryoresistance of Spermatozoa

The combination of saccharides in the composition of a cryopreservation medium may represent a promising method for the preservation of the reproductive cells of male birds. In the current study, cryoprotective media with a combined composition of mono- and di-saccharides were developed. The degree of penetration of reducing saccharide molecules (maltose—Mal20 medium) and non-reducing disaccharide molecules (trehalose—Treh20 medium) from the cryoprotective medium into the cytosol of rooster spermatozoa was studied. LCM control media without disaccharides were used as the control. The number of maltose molecules penetrating from the outside into the cytosol of the spermatozoon was 1.06 × 10⁴, and the number of trehalose molecules was 3.98 × 10⁴. Using a combination of maltose and fructose, the progressive motility of frozen/thawed semen and the fertility rates of eggs were significantly higher ((p < 0.05) 40.2% and 68.5%, respectively) than when using a combination of trehalose and fructose in a cryoprotective diluent (33.4% and 62.4%, respectively). A higher rate of chromatin integrity at the level of 92.4% was obtained when using Treh20 versus 74.5% Mal20 (p < 0.05). Maltose positively affected the preservation of frozen/thawed sperm in the genital tract of hens. On the seventh day from the last insemination when using Mal20, the fertilization of eggs was 42.6% and only 27.3% when using Treh20. Despite the same molecular weight, maltose and trehalose have different physicochemical and biological properties that determine their function and effectiveness as components of cryoprotective media.

Cryopreservation of human T lymphocytes under fast cooling with controlled ice nucleation in cryoprotective solutions of low toxicity

Cryopreservation of human T lymphocytes has become an essential tool for some cell-based immunotherapy. However, the cryopreservation procedure of the cells has not been systematically studied. In particular, the key factors of ice seeding and cryoprotective agents (CPA) driving the success of cryopreservation remain unclear. We systematically investigated the key factors, including cooling rate, ice-seeding temperature, CPA concentration, and types of CPA, during cryopreservation of human T lymphocytes with controlled ice nucleation. We found that ice seeding at below -10 °C could enable human T lymphocytes to be cooled at 90 °C min^-1 with high relative viability and recovery after rewarming, 94.9% and 90.2%, respectively, which are significantly higher than those without ice seeding (P < 0.001). After optimization, the concentration of dimethyl sulphoxide was as low as 2% (v/v) with relative viability and recovery of 95.4% and 100.8%, respectively, at the cooling rate of 90 °C min^-1 after ice seeding at -16 °C. The cryopreservation procedure developed in this study could facilitate the understanding of the mechanism for ice seeding and cell injury and offer a promising cryopreservation method with a high cooling rate and extremely low toxicity for extensive clinical application of immunotherapy.

Current Approaches of Preservation of Cells During (freeze-) Drying

The widespread application of therapeutic cells requires a successful stabilization of cells for the duration of transport and storage. Cryopreservation is currently considered the gold standard for the storage of active cells; however, (freeze-) drying cells could enable higher shelf life stability at ambient temperatures and facilitate easier transport and storage. During (freeze-) drying, freezing, (primary and secondary) drying and also the reconstitution step pose the risk of potential cell damage. To prevent these damaging processes, a wide range of protecting excipients has emerged, which can be classified, according to their chemical affiliation, into sugars, macromolecules, polyols, antioxidants and chelating agents. As many excipients cannot easily permeate the cell membrane, researchers have established various techniques to introduce especially trehalose intracellularly, prior to drying. This review aims to summarize the main damaging mechanisms during (freeze-) drying and to introduce the most common excipients with further details on their stabilizing properties and process approaches for the intracellular loading of excipients. Additionally, we would like to briefly explain recently discovered advantages of drying microorganisms, sperm, platelets, red blood cells, and eukaryotic cells, paying particular attention to the drying technique and residual moisture content.

Advanced Nanomaterials-Assisted Cell Cryopreservation: A Mini Review

Cell cryopreservation is of vital significance both for transporting and storing cells before experimental/clinical use. Cryoprotectants (CPAs) are necessary additives in the preserving medium in cryopreservation, preventing cells from freeze-thaw injuries. Traditional organic solvents have been widely used in cell cryopreservation for decades. Given the obvious damage to cells due to their undesirable cytotoxicity and the burdensome post-thaw washing cycles before use, traditional CPAs are more and more likely to be replaced by modern ones with lower toxicity, less processing, and higher efficiency. As materials science thrives, nanomaterials are emerging to serve as potent vehicles for delivering nontoxic CPAs or inherent CPAs comparable to or even superior to conventional ones. This review will introduce some advanced nanomaterials (e.g., organic/inorganic nanoCPAs, nanodelivery systems) utilized for cell cryopreservation, providing broader insights into this developing field.

Rapidly freeze-dried human red blood cells for pre-transfusion alloantibody testing reagents

Prior to transfusion of red blood cells (RBCs), recipients must be tested for the presence of alloantibodies to avoid immune complications. Liquid-preserved reagent RBCs with known blood group antigen phenotypes are used for testing. However, these reagents have practical constraints, including limited shelf-life and require constant refrigeration. To address these issues, we explore the effects of rapid freeze-drying conditions with trehalose cryoprotectant (0.1-1 M concentrations) on human RBCs and storage of freeze-dried RBCs (FDRBCs) at room temperature (RT) for up to 12 months. We report that rapid freeze-drying of RBCs for 2.5 hr with 0.5 M trehalose achieves recoverable cells with near-normal morphological shape, although size-reduced. The FDRBCs are metabolically active and functional in antibody-agglutination tests by the column agglutination test (CAT) for ABO and Rhesus-D blood group antigens. Expression of the Duffy blood group protein (CD234) decreases by 50% after freeze-drying RBCs. The initial recovery rate is ≤25%; however, 43% of these FDRBCs are still recoverable after RT storage for 12 months. In this proof-of-principle study, we show that rapid freeze-drying can stabilize RBCs. Further refinements to improve the recovery rate and preservation of antigenic epitopes will make FDRBCs a practical alternative source of reagent RBCs for pre-transfusion alloantibody identification.

Investigating solution effects injury of human T lymphocytes and its prevention during interrupted slow cooling

Cooling rate is a critical parameter affecting the success of cell cryopreservation. Fast cooling can result in intracellular ice formation (IIF), while slow cooling can bring solution effects injury, both are detrimental to the cells. Whilst most of the studies have investigated how IIF affects cells, solution effects injury has received little attention. Here, we studied the solution effects injury of human T lymphocytes by cryomicroscopy and tested the osmoprotective ability of some frequently used cryoprotective agents (CPAs) such as dimethyl sulfoxide (DMSO), glycerol, trehalose, urea and l-proline. We further investigated the relationship between cell volume, latent heat and solution effects cell injury. We found that solution effects injury during interrupted slow cooling was caused by high concentration of the extracellular solution rather than eutectic formation and solutes precipitation. DMSO, glycerol and trehalose can protect cells from solution effects injury, while l-proline and urea cannot under the same condition. The cell volume and latent heat are not crucial for causing solution effects injury in cells. This work confirms that high osmotic pressure, rather than eutectic formation, leads to cell injury. It also suggests that cell volume and latent heat may not be a key factor for explaining solution effects injury and its prevention in the cryopreservation of human T lymphocytes.

Temperature and presence of ethanol affect accumulation of intracellular trehalose in Lactobacillus plantarum WCFS1 upon pulsed electric field treatment

Pulsed electric field (PEF) treatment can be used to increase intracellular small molecule concentrations in bacteria, which can lead to enhanced robustness of these cells during further processing. In this study we investigated the effects of the PEF treatment temperature and the presence of 8% (v/v) ethanol in the PEF medium on cell survival, membrane fluidity and intracellular trehalose concentrations of Lactobacillus plantarum WCFS1. A moderate PEF treatment temperature of 21 °C resulted in a high cell survival combined with higher intracellular trehalose concentrations compared to a treatment at 10 and 35 °C. Interestingly, highest intracellular trehalose concentrations were observed upon supplementing the PEF medium with 8% ethanol, which resulted in more than a doubling in intracellular trehalose concentrations, while culture survival was retained. Overall, this study shows that treatment temperature and PEF medium optimization are important directions for improving molecule uptake upon PEF processing.

Comb-like Pseudopeptides Enable Very Rapid and Efficient Intracellular Trehalose Delivery for Enhanced Cryopreservation of Erythrocytes

Cell cryopreservation plays a key role in the development of reproducible and cost-effective cell-based therapies. Trehalose accumulated in freezing- and desiccation-tolerant organisms in nature has been sought as an attractive nontoxic cryoprotectant. Herein, we report a coincubation method for very rapid and efficient delivery of membrane-impermeable trehalose into ovine erythrocytes through reversible membrane permeabilization using pH-responsive, comb-like pseudopeptides. The pseudopeptidic polymers containing relatively long alkyl side chains were synthesized to mimic membrane-anchoring fusogenic proteins. The intracellular trehalose delivery efficiency was optimized by manipulating the side chain length, degree of substitution, and concentration of the pseudopeptides with different hydrophobic alkyl side chains, the pH, temperature, and time of incubation, as well as the polymer-to-cell ratio and the concentration of extracellular trehalose. Treatment of erythrocytes with the comb-like pseudopeptides for only 15 min yielded an intracellular trehalose concentration of 177.9 ± 8.6 mM, which resulted in 90.3 ± 0.7% survival after freeze-thaw. The very rapid and efficient delivery was found to be attributed to the reversible, pronounced membrane curvature change as a result of strong membrane insertion of the comb-like pseudopeptides. The pseudopeptides can enable efficient intracellular delivery of not only trehalose for improved cell cryopreservation but also other membrane-impermeable cargos.

Dimethyl sulfoxide-free cryopreservation for cell therapy: A review

Cell-based therapeutics promise to transform the treatment of a wide range of diseases including cancer, genetic and degenerative disorders, or severe injuries. Many of the commercial and clinical development of cell therapy products require cryopreservation and storage of cellular starting materials, intermediates and/or final products at cryogenic temperature. Dimethyl sulfoxide (Me₂SO) has been the cryoprotectant of choice in most biobanking situations due to its exceptional performance in mitigating freezing-related damages. However, there is concern over the toxicity of Me₂SO and its potential side effects after administration to patients. Therefore, there has been growing demand for robust Me₂SO-free cryopreservation methods that can improve product safety and maintain potency and efficacy. This article provides an overview of the recent advances in Me₂SO-free cryopreservation of cells having therapeutic potentials and discusses a number of key challenges and opportunities to motivate the continued innovation of cryopreservation for cell therapy.

Freeze-Dried Extracellular Vesicles From Adipose-Derived Stem Cells Prevent Hypoxia-Induced Muscle Cell Injury

Cellular therapies have tremendous potential for the successful treatment of major extremity wounds in the combat setting, however, the challenges associated with transplanting stem cells in the prolonged field care (PFC) environment are a critical barrier to progress in treating such injuries. These challenges include not only production and storage but also transport and handling issues. Our goal is to develop a new strategy utilizing extracellular vesicles (EVs) secreted by stem cells that can resolve many of these issues and prevent ischemic tissue injury. While EVs can be preserved by freezing or lyophilization, both processes result in decrease in their bioactivity. Here, we describe optimized procedures for EVs production, isolation, and lyophilization from primary human adipose-derived stem cells (hADSCs). We compared two isolation approaches that were ultrafiltration (UF) using a tangential fluid filtration (TFF) system and differential ultracentrifugation (UC). We also optimized EVs lyophilization in conjunction with trehalose and polyvinylpyrrolidone 40 (PVP40) as lyoprotectants. Bioactivity of EVs was assessed based on reversal of hypoxia-induced muscle cell injury. To this end, primary human myoblasts were subjected to hypoxic conditions for 6 h, and then treated with hADSC-derived EVs at a concentration of 50 μg/mL. Subsequently, muscle cell viability and toxicity were evaluated using MTS and LDH assays, respectively. Overall, nanoparticle tracking data indicated that UF/TFF yields threefold more particles than UC. Lyophilization of EVs resulted in a significantly reduced number of particles, which could be attenuated by adding lyoprotections to the freeze-drying solution. Furthermore, EVs isolated by UF/TFF and freeze-dried in the presence of trehalose significantly increased viability (P < 0.0193). Taken together, our findings suggest that the isolation and preservation methods presented in this study may enhance therapeutic applications of EVs.

Reversibility of membrane permeabilization upon pulsed electric field treatment in Lactobacillus plantarum WCFS1

Pulsed electric field (PEF) treatment, or electroporation, can be used to load molecules into cells. The permeabilizing effect of the PEF treatment on the cellular membrane can be either reversible or irreversible depending on the severity of the PEF treatment conditions. The influence of PEF on the reversibility of membrane permeabilization in Lactobacillus plantarum WCFS1 by two different fluorescent staining methods was investigated in this study. Whereas staining with propidium iodide (PI) before and after PEF treatment indicated small reversible permeabilized fractions of maximum 14%, the use of a double staining method with PI and SYTOX Green suggested larger reversible permeabilized fractions up to 40% of the population. This difference shows that the choice for a fluorescent staining method affects the conclusions drawn regarding reversibility of membrane permeabilization. Additionally, the effect of PEF treatment conditions on membrane integrity was compared, indicating a relation between critical electric field strength, cell size and membrane permeabilization. Overall this study showed the possibilities and limitations of fluorescent membrane integrity staining methods for PEF studies.

A histological study of mouse tissues and water loss following lyophilization

Lyophilization is a practical method for product storage and transportation; it commonly is used in the food and pharmaceutical industries. Lyophilization also is used for preserving biological samples such as serum, plasma and animal tissues. We found that lyophilization does not affect the stability of RNAs and proteins in tissue samples. To investigate histological characteristics, we prepared lyophilized tissues for paraffin sectioning and hematoxylin and eosin (H & E) staining. We also measured water loss from organs during lyophilization. We used immunohistochemistry of frozen brain sections to identify potential protective effects of three concentrations of sucrose, glucose and trehalose against the effects of lyophilization. H & E staining revealed vacuoles in heart, lung, liver, kidney, spleen and brain after lyophilization without pretreatments, especially heart and kidney. We found that 10% solutions of sucrose, glucose and trehalose helped preserve tissue morphology. Immunohistochemistry of frozen brain tissue showed that 10% glucose and 30% sucrose preserved cellular characteristics and immunogenicity following lyophilization. Lyophilization removed > 70% of the water from organs, and lyophilized tissues without protectants were not suitable for histological study. Overall, we found that 10% glucose helped preserve both optimal tissue morphology and immunogenicity of freeze-dried tissue.

Cold-Responsive Nanoparticle Enables Intracellular Delivery and Rapid Release of Trehalose for Organic-Solvent-Free Cryopreservation

Conventional cryopreservation of mammalian cells requires the use of toxic organic solvents (e.g., dimethyl sulfoxide) as cryoprotectants. Consequently, the cryopreserved cells must undergo a tedious washing procedure to remove the organic solvents for their further applications in cell-based medicine, and many of the precious cells may be lost or killed during the procedure. Trehalose has been explored as a nontoxic alternative to traditional cryoprotectants. However, mammalian cells do not synthesize trehalose or express trehalose transporters in their membranes, and the lack of an approach for the efficient intracellular delivery of trehalose has been a major hurdle for its use in cell cryopreservation. In this study, a cold-responsive polymer (poly(N-isopropylacrylamide-co-butyl acrylate)) is utilized to synthesize nanoparticles for the encapsulation and intracellular delivery of trehalose. The trehalose-laden nanoparticles can be efficiently taken up by mammalian cells. The nanoparticles quickly and irreversibly disassemble upon cold treatment, enabling the controlled and rapid release of trehalose from the nanoparticles inside cells. The latter is confirmed by an evident increase in cell volume upon cold treatment. This rapid cold-triggered intracellular release of trehalose is crucial to developing a fast protocol to cryopreserve cells using trehalose. Cells with intracellular trehalose delivered using the nanoparticles show comparable postcryopreservation viability compared to that of cells treated with DMSO, eliminating the need for the tedious and cell-damaging washing procedure required for using the DMSO-cryopreserved cells in vivo. This cold-responsive nanoparticle may greatly facilitate the use of trehalose as a nontoxic cryoprotectant for banking cells and tissues to meet their high demand by modern cell-based medicine.

Desiccation and supra-zero temperature storage of cat germinal vesicles lead to less structural damage and similar epigenetic alterations compared to cryopreservation

Understanding cellular and molecular damages in oocytes during exposure to extreme conditions is essential to optimize long-term fertility preservation approaches. Using the domestic cat (Felis catus) model, we are developing drying techniques for oocytes' germinal vesicles (GVs) as a more economical alternative to cryopreservation. The objective of the study was to characterize the influence of desiccation on nuclear envelope conformation, chromatin configuration, and the relative fluorescent intensities of histone H3 trimethylation at lysine 4 (H3K4me3) and at lysine 9 (H3K9me3) compared to vitrification. Results showed that higher proportions of dried/rehydrated GVs maintained normal nuclear envelope conformation and chromatin configuration than vitrified/warmed counterparts. Both preservation methods had a similar influence on epigenetic patterns, lowering H3K4me3 intensity to under 40% while maintaining H3K9me3 levels. Further analysis revealed that the decrease of H3K4me3 intensity mainly occurred during microwave dehydration and subsequent rehydration, whereas sample processing (permeabilization and trehalose exposure) or storage did not significantly affect the epigenetic marker. Moreover, rehydration either directly or stepwise with trehalose solutions did not influence the outcome. This is the first report demonstrating that the incidence of GV damages is lower after desiccation/rehydration than vitrification/warming.

Rapid and continuous on-chip loading of trehalose into erythrocytes

Freeze-drying is a promising approach for the long-term storage of erythrocytes at room temperature. Studies have shown that trehalose loaded into erythrocytes plays an important role in protecting erythrocytes against freeze-drying damage. Due to the impermeability of the erythrocyte membrane to trehalose, many methods have been developed to load trehalose into erythrocytes. However, these methods usually require multistep manual manipulation and long processing time; the adopted protocols are also diverse and not standardized. Thus, we develop an osmotically-based trehalose-loading microdevice (TLM) to rapidly, continuously, and automatically produce erythrocytes with loaded trehalose. In the TLM, trehalose is loaded through the erythrocyte membrane pores induced by hypotonic shock; then, the trehalose-loaded erythrocytes are rinsed to remove hemoglobin molecules and cell fragments, and the extracellular solution is restored to the isotonic state by integrating a rinsing-recovering design. First, the mixing function and the rinsing-recovering function were confirmed using a fluorescent solution. Then, the performance of the TLM was evaluated under various operating conditions with respect to the loading efficiency of trehalose, the hemolysis rate of erythrocytes (ϕ), the recovery rate of hemoglobin in erythrocytes (φ), and the separation efficiency of the TLM. Finally, the preliminary study of the freeze-drying of erythrocytes with loaded trehalose was accomplished using the TLM. The results showed that under the designated operating conditions, the loading efficiency for human erythrocytes reached ~21 mM in ~2 min with a ϕ value of ~17% and a φ value of ~74%. This study provides insights into the design of the on-chip loading of trehalose into erythrocytes and promotes the automation of life science studies on biochips.

Effect of water content on the glass transition temperature of mixtures of sugars, polymers, and penetrating cryoprotectants in physiological buffer

Long-term storage of viable mammalian cells is important for applications ranging from in vitro fertilization to cell therapy. Cryopreservation is currently the most common approach, but storage in liquid nitrogen is relatively costly and the requirement for low temperatures during shipping is inconvenient. Desiccation is an alternative strategy with the potential to enable viable cell preservation at more convenient storage temperatures without the need for liquid nitrogen. To achieve stability during storage in the dried state it is necessary to remove enough water that the remaining matrix forms a non-crystalline glassy solid. Thus, the glass transition temperature is a key parameter for design of cell desiccation procedures. In this study, we have investigated the effects of moisture content on the glass transition temperature (T_g) of mixtures of sugars (trehalose or raffinose), polymers (polyvinylpyrrolidone or Ficoll), penetrating cryoprotectants (ethylene glycol, propylene glycol, or dimethyl sulfoxide), and phosphate buffered saline (PBS) solutes. Aqueous solutions were dried to different moisture contents by equilibration with saturated salt solutions, or by baking at 95°C. The glass transition temperatures of the dehydrated samples were then measured by differential scanning calorimetry. As expected, T_g increased with decreasing moisture content. For example, in a desiccation medium containing 0.1 M trehalose in PBS, T_g ranged from about 360 K for a completely dry sample to about 220 K at a water mass fraction of 0.4. Addition of polymers to the solutions increased T_g, while addition of penetrating cryoprotectants decreased T_g. Our results provide insight into the relationship between relative humidity, moisture content and glass transition temperature for cell desiccation solutions containing sugars, polymers and penetrating cryoprotectants.

Predehydration and Ice Seeding in the Presence of Trehalose Enable Cell Cryopreservation

Conventional approaches for cell cryopreservation require the use of toxic membrane-penetrating cryoprotective agents (pCPA), which limits the clinical application of cryopreserved cells. Here, we show intentionally induced ice formation at a high subzero temperature (> -10 °C) during cryopreservation, which is often referred to as ice seeding, could result in significant cell injury in the absence of any pCPA. This issue can be mitigated by predehydrating cells using extracellular trehalose to their minimal volume with minimized osmotically active water before ice seeding. We further observe that ice seeding can minimize the interfacial free energy that drives the devastating ice recrystallization-induced cell injury during warming cryopreserved samples. Indeed, by combining predehydration using extracellular trehalose with ice seeding at high subzero temperatures, high cell viability or recovery is achieved for fibroblasts, adult stem cells, and red blood cells after cryopreservation without using any pCPA. The pCPA-free technology developed in this study may greatly facilitate the long-term storage and ready availability of living cells, tissues, and organs that are of high demand by modern cell-based medicine.

Mechanism of action of AMP-jsa9, a LI-F-type antimicrobial peptide produced by Paenibacillus polymyxa JSa-9, against Fusarium moniliforme

LI-F type peptides (AMP-jsa9) are a group of cyclic lipodepsipeptides that exhibit broad antimicrobial spectrum against Gram-positive bacteria and filamentous fungi. We sought to assess the toxicity of AMP-jsa9 and the mechanism of AMP-jsa9 action against Fusarium moniliforme. AMP-jsa9 exhibited weak hemolytic activity and weak cytotoxicity at antimicrobial concentrations (32μg/ml). Confocal laser microscopy, SEM, and TEM indicated that AMP-jsa9 primarily targets the cell wall, plasma membrane, and cytoskeleton, increases membranepermeability, and enhances cytoplasm leakage (e.g., K⁺, protein). Quantitative proteomic analysis using isobaric tags for relative and absolute quantitation (iTRAQ) detected a total of 162 differentially expressed proteins (59 up-regulated and 103 down-regulated) following treatment of F. moniliforme with AMP-jsa9. AMP-jsa9 treatment also led to reductions in chitin, ergosterol, NADH, NADPH, and ATP levels. Moreover, fumonisin B₁ expression and biosynthesis was suppressed in AMP-jsa9-treated F. moniliforme. Our results provide a theoretical basis for the application of AMP-jsa9 as a natural and effective antifungal agent in the agricultural, food, and animal feed industries.

Dry Preservation of Spermatozoa: Considerations for Different Species

The current gold standard for sperm preservation is storage at cryogenic temperatures. Dry preservation is an attractive alternative, eliminating the need for ultralow temperatures, reducing storage maintenance costs, and providing logistical flexibility for shipping. Many seeds and anhydrobiotic organisms are able to survive extended periods in a dry state through the accumulation of intracellular sugars and other osmolytes and are capable of returning to normal physiology postrehydration. Using techniques inspired by nature's adaptations, attempts have been made to dehydrate and dry preserve spermatozoa from a variety of species. Most of the anhydrous preservation research performed to date has focused on mouse spermatozoa, with only a small number of studies in nonrodent mammalian species. There is a significant difference between sperm function in rodent and nonrodent mammalian species with respect to centrosomal inheritance. Studies focused on reproductive technologies have demonstrated that in nonrodent species, the centrosome must be preserved to maintain sperm function as the spermatozoon centrosome contributes the dominant nucleating seed, consisting of the proximal centriole surrounded by pericentriolar components, onto which the oocyte's centrosomal material is assembled. Preservation techniques used for mouse sperm may therefore not necessarily be applicable to nonrodent spermatozoa. The range of technologies used to dehydrate sperm and the effect of processing and storage conditions on fertilization and embryogenesis using dried sperm are reviewed in the context of reproductive physiology and cellular morphology in different species.

Effects of trehalose vitrification and artificial oocyte activation on the development competence of human immature oocytes

Sucrose and trehalose are conventional cryoprotectant additives for oocytes and embryos. Ethanol can artificially enhance activation of inseminated mature oocytes. This study aims to investigate whether artificial oocyte activation (AOA) with ethanol can promote the development competence of in vitro matured oocytes. A total of 810 human immature oocytes, obtained from 325 patients undergoing normal stimulated oocyte retrieval cycles, were in vitro maturated (IVM) either immediately after collection (Fresh group n = 291)) or after being vitrified as immature oocytes (Vitrified group n = 519). These groups were arbitrarily assigned. All fresh and vitrified oocytes which matured after a period of IVM then underwent intra-cytoplasmic sperm injection (ICSI). Half an hour following ICSI, they were either activated by 7% ethanol (AOA group) or left untreated (Non-AOA group). Fertilization, cleavage rate, blastocyst quality and aneuploidy rate were then evaluated. High-quality blastocysts were only obtained in both the fresh and vitrified groups which had undergone AOA after ICSI. Trehalose vitrification slightly, but not significantly, increased the formation rates of high-quality embryos (21.7% VS 15.4%, P > 0.05) and blastocysts (15.7% VS 7.69%, P > 0.05)) when compared with sucrose vitrification. Aneuploidy was observed in 12 of 24 (50%) of the AOA derived high quality blastocysts. High-quality blastocysts only developed from fresh or vitrified immature oocytes if the ICSI was followed by AOA. This information may be important for human immature oocytes commonly retrieved in normal stimulation cycles and may be particularly important for certain patient groups, such as cancer patients. AOA with an appropriate concentration of ethanol can enhance the developmental competence of embryos.

Stabilization of Transfected Cells Expressing Low-Incidence Blood Group Antigens: Novel Methods Facilitating Their Use as Reagent-Cells

Background

The identification of erythrocyte antibodies in the serum of patients rely on panels of human red blood cells (RBCs), which coexpress many antigens and are not easily available for low-incidence blood group phenotypes. These problems have been addressed by generating cell lines expressing unique blood group antigens, which may be used as an alternative to human RBCs. However, the use of cell lines implies several drawbacks, like the requirement of cell culture facilities and the high cost of cryopreservation. The application of cell stabilization methods could facilitate their use as reagent cells in clinical laboratories.

Methods

We generated stably-transfected cells expressing low-incidence blood group antigens (Di^a and Lu^a). High-expresser clones were used to assess the effect of TransFix^® treatment and lyophilization as cell preservation methods. Cells were kept at 4°C and cell morphology, membrane permeability and antigenic properties were evaluated at several time-points after treatment.

Results

TransFix^® addition to cell suspensions allows cell stabilization and proper antigen detection for at least 120 days, despite an increase in membrane permeability and a reduction in antigen expression levels. Lyophilized cells showed minor morphological changes and antigen expression levels were rather conserved at days 1, 15 and 120, indicating a high stability of the freeze-dried product. These stabilized cells have been proved to react specifically with human sera containing alloantibodies.

Conclusions

Both stabilization methods allow long-term preservation of the transfected cells antigenic properties and may facilitate their distribution and use as reagent-cells expressing low-incidence antigens, overcoming the limited availability of such rare RBCs.

Increased cryosurvival of osteosarcoma cells using an amphipathic pH-responsive polymer for trehalose uptake

Amphipathic pH-responsive polymers have shown to increase the permeability of cell membranes to trehalose hence improving the cryopreservation of mammalian cells. However, the trafficking of both the polymer and trehalose across the cell membrane has not yet been thoroughly analysed. The objective of this study was to investigate the effect on cryopreservation of the trafficking of the disaccharide trehalose along PP-50, an amphipathic polymer, through an osteosarcoma cell line (SAOS-2). Confocal microscopy analysis confirmed the presence of intracellular labelled trehalose only when incubated in the presence of PP-50. Further analysis confirmed that both trehalose and PP-50 localised in the cytoplasm, accumulated mainly in the perinuclear area. Quantitative analysis of the colocalisation between trehalose and PP-50 showed Pearson and Manders coefficients of 0.862 ± 0.008 and 0.766 ± 0.033, respectively, suggesting a high degree of intracellular colocalisation between these molecules. Cryopreserved cells pre-incubated with trehalose and PP-50 showed increased cryosurvival when compared with cells pre-incubated in the absence of the polymer. PP-50 showed to be directly involved in the uptake of trehalose, a critical characteristic towards use in cryopreservation and biomedical applications.

Air-dried cells from the anhydrobiotic insect, Polypedilum vanderplanki, can survive long term preservation at room temperature and retain proliferation potential after rehydration

Pv11, a cell line derived from the anhydrobiotic insect, Polypedilum vanderplanki, was preserved in a dry form (only 6% residual moisture) at room temperature for up to 251 days and restarted proliferating after rehydration. A previous study already reported survival of Pv11 cells after desiccation, but without subsequent proliferation. Here, the protocol was improved to increase survival and achieve proliferation of Pv11 cells after dry storage. The method basically included preincubation, desiccation and rehydration processes and each step was investigated. So far, preincubation in a 600 mM trehalose solution for 48 h before dehydration was the most favourable preconditioning to achieve successful dry preservation of Pv11 cells, allowing about 16% of survival after rehydration and subsequent cell proliferation. Although the simple air-dry method established for Pv11 cells here was not applicable for successful dry-preservation of other insect cell lines, Pv11 is the first dry-preservable animal cell line and will surely contribute not only to basic but also applied sciences.

Engineered Trehalose Permeable to Mammalian Cells

Trehalose is a naturally occurring disaccharide which is associated with extraordinary stress-tolerance capacity in certain species of unicellular and multicellular organisms. In mammalian cells, presence of intra- and extracellular trehalose has been shown to confer improved tolerance against freezing and desiccation. Since mammalian cells do not synthesize nor import trehalose, the development of novel methods for efficient intracellular delivery of trehalose has been an ongoing investigation. Herein, we studied the membrane permeability of engineered lipophilic derivatives of trehalose. Trehalose conjugated with 6 acetyl groups (trehalose hexaacetate or 6-O-Ac-Tre) demonstrated superior permeability in rat hepatocytes compared with regular trehalose, trehalose diacetate (2-O-Ac-Tre) and trehalose tetraacetate (4-O-Ac-Tre). Once in the cell, intracellular esterases hydrolyzed the 6-O-Ac-Tre molecules, releasing free trehalose into the cytoplasm. The total concentration of intracellular trehalose (plus acetylated variants) reached as high as 10 fold the extracellular concentration of 6-O-Ac-Tre, attaining concentrations suitable for applications in biopreservation. To describe this accumulation phenomenon, a diffusion-reaction model was proposed and the permeability and reaction kinetics of 6-O-Ac-Tre were determined by fitting to experimental data. Further studies suggested that the impact of the loading and the presence of intracellular trehalose on cellular viability and function were negligible. Engineering of trehalose chemical structure rather than manipulating the cell, is an innocuous, cell-friendly method for trehalose delivery, with demonstrated potential for trehalose loading in different types of cells and cell lines, and can facilitate the wide-spread application of trehalose as an intracellular protective agent in biopreservation studies.

Nanoparticle-mediated intracellular delivery enables cryopreservation of human adipose-derived stem cells using trehalose as the sole cryoprotectant

In this study, pH responsive genipin-cross-linked Pluronic F127-chitosan nanoparticles (GNPs) was synthesized to encapsulate trehalose for intracellular delivery to cryopreserve primary human adipose-derived stem cells (hADSCs). Trehalose is a disaccharide of glucose used by lower organisms to survive extreme cold in nature and has been used to cryopreserve various biomacromolecules. However, it does not enter mammalian cells because of its highly hydrophilic nature, and has only been used in combination with other cell-penetrating cryoprotectants (such as dimethyl sulfoxide, DMSO) to cryopreserve mammalian cells. Our data show that trehalose can be efficiently encapsulated in our GNPs for intracellular delivery, which enables cryopreservation of primary hADSCs using the nontoxic sugar as the sole cryoprotectant. This capability is important because the conventional approach of cryopreserving mammalian cells using highly toxic (at body temperature) cell-penetrating cryoprotectants requires multistep washing of the cryopreserved cells to remove the toxic cryoprotectant for further use, which is time-consuming and associated with significant cell loss (∼10% during each washing step). By contrast, the trehalose-cryopreserved cells can be used without washing, which should greatly facilitate the wide application of the burgeoning cell-based medicine.

Dry state preservation of nucleated cells: progress and challenges

Effective stabilization of nucleated cells for dry storage would be a transformative development in the field of cell-based biosensors and biotechnologic devices, as well as regenerative medicine and other areas in which stem cells have clinical utility. Ultimately, the tremendous promise of cell-based products will only be fully realized when stable long-term storage becomes available without the use of liquid nitrogen and bulky, energetically expensive freezers. Significant progress has been made over the last 10 years toward this goal, but obstacles still remain. Loading cells with the protective disaccharide trehalose has been achieved by several different techniques and has been shown to increase cell survival at low water contents. Likewise, the protective effect of heat shock proteins and other compounds have also been explored alone and in combination with trehalose. In some cases, the benefit of these molecules is seen not initially upon rehydration, but over time during cellular recovery. Other considerations, such as inhibiting apoptosis and utilizing isotonic buffer conditions have also provided stepwise increases in cell viability and function following drying and rehydration. In all these cases, however, a low level of residual water is required to achieve viability after rehydration. The most significant remaining challenge is to protect nucleated cells such that this residual water can be safely removed, thus allowing vitrification of intra- and extracellular trehalose and stable dry state storage at room temperature.

Advancing microwave technology for dehydration processing of biologics

Our prior work has shown that microwave processing can be effective as a method for dehydrating cell-based suspensions in preparation for anhydrous storage, yielding homogenous samples with predictable and reproducible drying times. In the current work an optimized microwave-based drying process was developed that expands upon this previous proof-of-concept. Utilization of a commercial microwave (CEM SAM 255, Matthews, NC) enabled continuous drying at variable low power settings. A new turntable was manufactured from Ultra High Molecular Weight Polyethylene (UHMW-PE; Grainger, Lake Forest, IL) to provide for drying of up to 12 samples at a time. The new process enabled rapid and simultaneous drying of multiple samples in containment devices suitable for long-term storage and aseptic rehydration of the sample. To determine sample repeatability and consistency of drying within the microwave cavity, a concentration series of aqueous trehalose solutions were dried for specific intervals and water content assessed using Karl Fischer Titration at the end of each processing period. Samples were dried on Whatman S-14 conjugate release filters (Whatman, Maidestone, UK), a glass fiber membrane used currently in clinical laboratories. The filters were cut to size for use in a 13 mm Swinnex(®) syringe filter holder (Millipore(™), Billerica, MA). Samples of 40 μL volume could be dehydrated to the equilibrium moisture content by continuous processing at 20% with excellent sample-to-sample repeatability. The microwave-assisted procedure enabled high throughput, repeatable drying of multiple samples, in a manner easily adaptable for drying a wide array of biological samples. Depending on the tolerance for sample heating, the drying time can be altered by changing the power level of the microwave unit.

Polymerization effect of electrolytes on hydrogen-bonding cryoprotectants: ion-dipole interactions between metal ions and glycerol

Protectants which are cell membrane permeable, such as glycerol, have been used effectively in the cryopreservation field for a number of decades, for both slow cooling and vitrification applications. In the latter case, the glass transition temperature (T_g) of the vitrification composition is key to its application, dictating the ultimate storage conditions. It has been observed that the addition of some electrolytes to glycerol, such as MgCl₂, could elevate the T_g of the mixture, thus potentially providing more storage condition flexibility. The microscopic mechanisms that give rise to the T_g-enhancing behavior of these electrolytes are not yet well understood. The current study focuses on molecular dynamics simulation of glycerol mixed with a variety of metal chlorides (i.e., NaCl, KCl, MgCl₂, and CaCl₂), covering a temperature range that spans both the liquid and glassy states. The characteristics of the ion–dipole interactions between metal cations and hydroxyl groups of glycerol were analyzed. The interruption of the original hydrogen-bonding network among glycerol molecules by the addition of ions was also investigated in the context of hydrogen-bonding quantity and lifetime. Divalent metal cations were found to significantly increase the T_g by strengthening the interacting network in the electrolyte/glycerol mixture via strong cation–dipole attractions. In contrast, monovalent cations increased the T_g insignificantly, as the cation–dipole attraction was only slightly stronger than the original hydrogen-bonding network among glycerol molecules. The precursor of crystallization of NaCl and KCl was also observed in these compositions, potentially contributing to weak T_g-enhancing ability. The T_g-enhancing mechanisms elucidated in this study suggest a structure-enhancing role for divalent ions that could be of benefit in the design of protective formulations for biopreservation purposes.

Design of novel cell penetrating peptides for the delivery of trehalose into mammalian cells

Stabilization of cells in a desiccated state can significantly simplify the storage and transportation and save expenses for clinical applications. Introduction of the impermeable disaccharide, trehalose, into cells is an important step to improve the desiccation tolerance of cells. In this study, a novel cell penetrating peptide, KRKRWHW, was developed based on molecular simulations. The peptide exhibited little cytotoxicity and high penetrating efficiency into mammalian cells. The cell viability of mouse embryonic fibroblasts (MEFs) after the incubation with various concentrations of KRKRWHW from 0.01mM to 5mM at 37°C for 4h was maintained at around 100%. The peptide was able to penetrate into MEFs within 1h at 37°C with an efficiency of around 90% at 0.1mM. Trehalose, as a cargo coupled with the peptide of KRKRWHW through hydrogen bond and π-π bond, was successfully loaded into the MEFs. This novel peptide provides a novel approach for the delivery of trehalose into mammalian cells.

Late embryogenesis abundant proteins protect human hepatoma cells during acute desiccation

Expression of late embryogenesis abundant (LEA) proteins is highly correlated with desiccation tolerance in anhydrobiotic animals, selected land plants, and bacteria. Genes encoding two LEA proteins, one localized to the cytoplasm/nucleus (AfrLEA2) and one targeted to mitochondria (AfrLEA3m), were stably transfected into human HepG2 cells. A trehalose transporter was used for intracellular loading of this disaccharide. Cells were rapidly and uniformly desiccated to low water content (<0.12 g H(2)O/g dry weight) with a recently developed spin-drying technique. Immediately on rehydration, control cells without LEA proteins or trehalose exhibited 0% membrane integrity, compared with 98% in cells loaded with trehalose and expressing AfrLEA2 or AfrLEA3m; surprisingly, AfrLEA3m without trehalose conferred 94% protection. Cell proliferation across 7 d showed an 18-fold increase for cells dried with AfrLEA3m and trehalose, compared with 27-fold for nondried controls. LEA proteins dramatically enhance desiccation tolerance in mammalian cells and offer the opportunity for engineering biostability in the dried state.

Multiple toxicity studies of trehalose in mice by intragastric administration

In the present study, aberration, body weight, food consumption, haematology, organ coefficients, and both gross and microscopic appearance of some histiocytes were compared between the test and control groups. A sperm abnormality test, bone marrow cell micronucleus test, and a haematology study were conducted at levels of 1.25 g/kg, 2.5 g/kg, and 5 g/kg of trehalose. In both the sperm abnormality test and bone marrow cell micronucleus test, statistically significant differences were observed between the positive control and treatment groups (P<0.05), while no statistical difference was observed among the negative control, high dose, moderate dose and low dose groups (P>0.05). In the haematology study, there was no significant difference found from the controls at P>0.05. The results obtained in the present study could support the conclusion that consumption of trehalose has no adverse effects for humans.

Xeroprotectants for the stabilization of biomaterials

With the advancement of science and technology, it is crucial to have effective preservation methods for the stable long-term storage of biological material (biomaterials). As an alternative to cryopreservation, various techniques have been developed, which are based on the survival mechanism of anhydrobiotic organisms. In this sense, it has been found that the synthesis of xeroprotectants can effectively stabilize biomaterials in a dry state. The most widely studied xeroprotectant is trehalose, which has excellent properties for the stabilization of certain proteins, bacteria, and biological membranes. There have also been attempts to apply trehalose to the stabilization of eukaryotic cells but without conclusive results. Consequently, a xeroprotectant or method that is useful for the stable drying of a particular biomaterial might not necessarily be suitable for another one. This article provides an overview of recent advances in the use of new techniques to stabilize biomaterials and compare xeroprotectants with other more standard methods.