Rescue of a viral gene from VERO cells latently infected with influenza virus B/Lee/40

MDCK and Vero cells for influenza virus vaccine production: a one-to-one comparison up to lab-scale bioreactor cultivation

Over the last decade, adherent MDCK (Madin Darby canine kidney) and Vero cells have attracted considerable attention for production of cell culture-derived influenza vaccines. While numerous publications deal with the design and the optimization of corresponding upstream processes, one-to-one comparisons of these cell lines under comparable cultivation conditions have largely been neglected. Therefore, a direct comparison of influenza virus production with adherent MDCK and Vero cells in T-flasks, roller bottles, and lab-scale bioreactors was performed in this study. First, virus seeds had to be adapted to Vero cells by multiple passages. Glycan analysis of the hemagglutinin (HA) protein showed that for influenza A/PR/8/34 H1N1, three passages were sufficient to achieve a stable new N-glycan fingerprint, higher yields, and a faster increase to maximum HA titers. Compared to MDCK cells, virus production in serum-free medium with Vero cells was highly sensitive to trypsin concentration. Virus stability at 37 degrees C for different virus strains showed differences depending on medium, virus strain, and cell line. After careful adjustment of corresponding parameters, comparable productivity was obtained with both host cell lines in small-scale cultivation systems. However, using these cultivation conditions in lab-scale bioreactors (stirred tank, wave bioreactor) resulted in lower productivities for Vero cells.

Anomalies in the influenza virus genome database: new biology or laboratory errors?

A search of the influenza virus genome database reveals anomalies associated with a nonnegligible number of submitted sequences. There are many pairs of viral segments that are very close to each other in nucleotide sequence but relatively far apart in reported time of isolation, resulting in an abnormally low evolutionary rate. Also, some sequences show clear evidence of apparent homologous recombination, a process normally assumed to be extremely rare or nonexistent in this virus. These findings may point to surprising new biology but are perhaps more readily explained by stock contamination or other errors in the sequencing laboratories.

Evaluation of a virus derived from MDCK cells infected persistently with influenza A virus as a potential live-attenuated vaccine candidate in the mouse model

A temperature-sensitive mutant virus unable to replicate at 38 degrees C was recovered from passage 189 (IVpi-189) of Madin-Darby canine kidney cells infected persistently with influenza A. Immunofluorescent staining of the IVpi-189 virus-infected cells revealed disrupted transport of the matrix (M) 1 protein into the nucleus at non-permissive temperatures, resulting in retention of the nucleoprotein (NP) in the nucleus. Upon comparison with the parental influenza A E61-24-P15 strain used to establish persistent infection, amino acid exchanges were found in the M1 protein of IVpi-189 virus; arginine to glutamine at position 72 and threonine to alanine at position 139. When mice were inoculated intranasally with IVpi-189 virus, virus growth in the lungs was restrained and terminated rapidly. Prior intranasal inoculation with only a small dose of IVpi-189 virus induced humoral and cellular immune responses and protected mice against subsequent virulent virus challenge. These results indicate that IVpi-189 virus, an avirulent temperature-sensitive mutant, is a promising candidate for use as a live-attenuated vaccine.

Influenza A virus derived from persistently virus-infected cells shows attenuated cytotoxicity in cultured cells but virulent pathogenicity in mice

The IVpi-43 strain of influenza A virus, a progeny virus derived from persistently virus-infected Madin-Darby canine kidney (MDCK) cells, showed a more attenuated nature in cytopathology in cultured cells than the parental wild-type influenza virus (IVwt) that was used for establishment of the virus carrier culture. Upon infection of MDCK cells, growth of the IVpi-43 virus was restrained with an impaired synthesis of virus structural proteins in the cells. Apoptosis induced by IVpi-43 virus was confined at a low level. The IVpi-43 virus was able to easily cause persistent infection in fresh MDCK cells. In contrast to the in vitro phenotype, the IVpi-43 virus proved highly virulent in mice, with massive and broadly disseminated virus multiplication in the lungs. It was suggested that impaired activity of the neuraminidase molecule of the IVpi-43 virus was responsible for the delayed and faint appearance of apoptosis in the IVpi-43 virus-infected respiratory cells, which made it possible for the virus to replicate for a longer period and to spread to a broader area of the lungs and that abundant numbers of the virus-infected lung cells were killed within a short period by the subsequently established virus-specific immune responses, leading to unrecoverable serious pneumonia.

Fetal calf serum inhibits virus genome expression in Madin-Darby canine kidney cells persistently infected with influenza A virus

A cell line of Madin-Darby canine kidney (MDCK) cells persistently infected with human influenza A virus has been established and designated as MDCK-IVpi cells. Production of progeny virus in MDCK-IVpi cells was suppressed when the cells were incubated in the presence of 10% fetal calf serum (FCS). FCS impaired virus mRNA synthesis in MDCK-IVpi cells, which resulted in a scarcity of virus proteins for virion formation. However, MDCK-IVpi cells well supported the growth of superinfecting heterologous influenza viruses, even in the presence of FCS. A certain fetuin-like substance in FCS might be responsible for the observed inhibition of virus replication.