Polymer nanoparticle-based controlled pulmonary drug delivery

Cobalt Iron Oxide (CoFe2O4) Nanoparticles Induced Toxicity in Rabbits

The market for nanoparticles has grown significantly over the past few decades due to a number of unique qualities, including antibacterial capabilities. It is still unclear how nanoparticle toxicity works. In order to ascertain the toxicity of synthetic cobalt iron oxide (CoFe2O4) nanoparticles (CIONPs) in rabbits, this study was carried out. Sixteen rabbits in total were purchased from the neighborhood market and divided into two groups (A and B), each of which contained eight rabbits. The CIONPs were synthesized by the co-precipitation method. Crystallinity and phase identification were confirmed by X-ray diffraction (XRD). The average size of the nanoparticles (13.2 nm) was calculated by Scherrer formula (Dhkl = 0.9 λ/β cos θ) and confirmed by TEM images. The saturation magnetization, 50.1 emug-1, was measured by vibrating sample magnetometer (VSM). CIONPs were investigated as contrast agents (CA) for magnetic resonance images (MRI). The relaxivity (r = 1/T) of the MRI was also investigated at a field strength of 0.35 T (Tesla), and the ratio r2/r1 for the CIONPs contrast agent was 6.63. The CIONPs were administrated intravenously into the rabbits through the ear vein. Blood was collected at days 5 and 10 post-exposure for hematological and serum biochemistry analyses. The intensities of the signal experienced by CA with CIONPs were 1427 for the liver and 1702 for the spleen. The treated group showed significantly lower hematological parameters, but significantly higher total white blood cell counts and neutrophils. The results of the serum biochemistry analyses showed significantly higher and lower quantities of different serum biochemical parameters in the treated rabbits at day 10 of the trial. At the microscopic level, different histological ailments were observed in the visceral organs of treated rabbits, including the liver, kidneys, spleen, heart, and brain. In conclusion, the results revealed that cobalt iron oxide (CoFe2O4) nanoparticles induced toxicity via alterations in multiple tissues of rabbits.

Influence of amine-modified poly(vinyl alcohol)s on vibrating-membrane nebulizer performance and lung toxicity

A suitable aerosol droplet size and formulation output rate is essential for the therapy of lung diseases under application of nebulizers. The current study investigated the potential of amine-modified poly(vinyl alcohol)s as excipients for inhalation delivery. A change of conductivity (effective at <0.1mg/ml) and viscosity (effective at >0.1mg/ml) of samples that were supplemented with charge-modified polymers had a significant influence on the generated droplet size (shift from ~8 to ~4 μm) and formulation throughput rate (shift from ~0.2 to ~1.0 g/min), where polymers with a higher amine density (and molecular weight) showed an elevated activity. Biocompatibility assessment of polymers in A549 cells and an isolated lung model resulted in cell lysis and lung edema formation dependent on the type (degree of amine substitution) and dose of polymer applied. Suitable compositions and concentrations of amine-modified poly(vinyl alcohol)s were identified with respect to an optimized nebulizer performance and acceptable biocompatibility. Charge-modified polymers represent novel excipients with potential to improve inhalation therapy.

Pulmonary delivered polymeric micelles--pharmacokinetic evaluation and biodistribution studies

Polymeric micelles represent interesting delivery systems for pulmonary sustained release. However, little is known about their in vivo release and translocation profile after delivery to the lungs. In the present study, curcumin acetate (CA), which is an ester prodrug of curcumin, or the mixture of CA and Nile red was encapsulated into PEG–PLGA micelles by a solvent evaporation method. The micellar formulation increased the stability of CA in water and physiologically relevant fluids and led to a sustained drug release in vitro. Following intratracheal (IT) administration to rats, CA loaded micelles achieved not only prolonged pulmonary retention with AUC values almost 400-fold higher than by IV route, but also local sustained release up to 24 h. In addition, IT delivery of micelles appeared to facilitate the uptake into the pulmonary vascular endothelium and efficiently translocate across the air–blood barrier and penetrate into the brain. Co-localization of CA and Nile red confirmed that micelles in lung and brain tissue were still intact. This study is the first to demonstrate that aerosolized PEG–PLGA micelles are a promising carrier for both pulmonary and non-invasive systemic sustained release of labile drugs.

Systematic aging of degradable nanosuspension ameliorates vibrating-mesh nebulizer performance

CONTEXT

The process of vibrating-mesh nebulization is affected by sample physicochemical properties. Exemplary, electrolyte supplementation of diverse formulations facilitated the delivery of adequate aerosols for deep lung deposition.

OBJECTIVE

This study addressed the impact of storage conditions of poly(lactide-co-glycolide) nanosuspension on aerosol properties when nebulized by the eFlow®rapid.

MATERIALS AND METHODS

First, purified nanosuspensions were supplemented with electrolytes (i.e. sodium chloride, lactic and glycolic acid). Second, the degradable nanoparticles (NP) were incubated at different temperatures (i.e. 4, 22 and 36 °C) for up to two weeks. The effect of formulation supplementation and storage on aerosol characteristics was studied by laser diffraction and correlated with the sample conductivity.

RESULTS AND DISCUSSION

Nebulization of purified nanosuspensions resulted in droplet diameters of >7.0 µm. However, electrolyte supplementation and storage, which led to an increase in sample conductivity (>10-20 µS/cm), were capable of providing smaller droplet diameters during vibrating-mesh nebulization (≤5.0 µm). No relevant change of NP properties (i.e. size, morphology, remaining mass and molecular weight of the employed polymer) was observed when incubated at 22 °C for two weeks.

CONCLUSION

Sample aging is an alternative to electrolyte supplementation in order to ameliorate the aerosol characteristics of degradable NP formulations when nebulized by vibrating-mesh technology.