Stimulation of polygalacturonase production in an immobilized system by Aspergillus sp.: effect of pectin and glucose

Effect of immobilized polygalacturonase from Mucor circinelloides ITCC-6025 on wine fermentation

Pectinases are among the most widely distributed enzymes in bacteria, fungi, and plants. Almost all the commercial preparations of pectinases are produced from fungal sources. Mucor circinelloides ITCC-6025 produced polygalacturonase when grown in Riviere's medium containing pectin (methyl ester) as the sole source of carbon. Immobilization of purified polygalacturonase was done on silica gel with 86% efficiency. The enzyme took 60 Min to bind maximally on the support. The immobilized enzyme showed maximum activity at a temperature of 45°C (4.57 U/mg) and pH 5.4. The immobilized enzyme was reused for four cycles as it retained almost 55% of its activity. The immobilized enzyme treatment increased the formation of higher alcohols and phenolics during the course of wine formation from apple and plum juices, whereas there was a decrease in the amount of carbohydrates. The enzyme treatment also resulted in clarification of wine; there was an increase in transmittance at 650 nm (201.78% in the case of apple wine and 223.4% in the case of plum wine) as compared to the control (untreated wine).

Co-production of tannase and pectinase by free and immobilized cells of the yeast Rhodotorula glutinis MP-10 isolated from tannin-rich persimmon (Diospyros kaki L.) fruits

Hyper tannase and pectinase-producing yeast Rhodotorula glutinis MP-10 was isolated from persimmon (Diospyros kaki L.) fruits. The main pectinase activity of yeast was exo-polygalacturonase. No pectin methyl esterase and too low pectin lyase activities were detected for this yeast. The maximum exo-activities of tannase and polygalacturonase were determined as 15.2 and 26.9 U/mL for free cells and 19.8 and 28.6 U/mL for immobilized cells, respectively. Immobilized cells could be reused in 13 successive reaction cycles without any loss in the maximum tannase and polygalacturonase activities. Besides, too little decreases in activities of these enzymes were recorded between 14 and 18 cycles. At the end of 18 successive reaction cycles, total 503.1 U/mL of polygalacturonase and 349.6 U/mL of tannase could be produced using the same immobilized cells. This is the first report on the use of free and/or immobilized cells of a microorganism for the co-production of tannase and pectinase.