Inactivation kinetics of anaerobic wastewater biofilms by free nitrous acid

Corrosion mitigation by nitrite spray on corroded concrete in a real sewer system

Microbially influenced concrete corrosion (MICC) in sewers is caused by the activity of sulfide-oxidizing microorganisms (SOMs) on concrete surfaces, which greatly deteriorates the integrity of sewers. Surface treatment of corroded concrete by spraying chemicals is a low-cost and non-intrusive strategy. This study systematically evaluated the spray of nitrite solution in corrosion mitigation and re-establishment in a real sewer manhole. Two types of concrete were exposed at three heights within the sewer manhole for 21 months. Nitrite spray was applied at the 6th month for half of the coupons which had developed active corrosion. The corrosion development was monitored by measuring the surface pH, corrosion product composition, sulfide uptake rate, concrete corrosion loss, and the microbial community on the corrosion layer. Free nitrous acid (FNA, i.e. HNO₂), formed by spraying a nitrite solution on acidic corrosion surfaces, was shown to inhibit the activity of SOMs. The nitrite spray reduced the corrosion loss of concrete at all heights by 40-90% for six months. The sulfide uptake rate of sprayed coupons was also reduced by about 35%, leading to 1-2 units higher surface pH, comparing to the control coupons. The microbial community analysis revealed a reduced abundance of SOMs on nitrite sprayed coupons. The long-term monitoring also showed that the corrosion mitigation effect became negligible in 15 months after the spray. The results consistently demonstrated the effectiveness of nitrite spray on the MICC mitigation and identified the re-application frequencies for full scale applications.

Dosing Free Nitrous Acid as an Alternative Sulphide Control Technology for Pressure Sewers in Germany

Sulphide build-up in pressure sewers has been identified as the main cause for the occurrence of odour and corrosion in sewer systems. Despite the efforts to optimize commonly used control technologies such as nitrate and iron salts to reduce sulphide emission, continuous addition of these chemicals is still required. A biocidal agent such as free nitrous acid can be added intermittently, less frequently, and in smaller quantities whilst achieving total sulphide control. So far, laboratory and field studies in Australia and the USA have successfully proven and applied the use of this control technology, exhibiting its strong biocidal effects during intermittent addition. In this study, nine trials were made to assess the application of the free nitrous acid (FNA) as an alternative sulphide control technology in Germany. The sewer pilot plant of the Berlin Water Utility Company was used to perform the trials at a technical scale using a supply of raw sewage. FNA exposure times ranging from 5 to 24 h in varying concentrations were investigated. The effectiveness of the FNA treatment was monitored using the online hydrogen sulphide (H2S) gas and dissolved-sulphide sensors installed in the sewer pilot plant. Effective sulphide control was only possible during dosing periods, with rapid resumption of sulphide production for the trials with exposure times of <12 h and concentrations ranging from 0.08 to 0.56 mg HNO2-N L−1 suggesting a slight inhibitory effect. A more pronounced biocidal effect was observed for the trials exposed to FNA treatment for 24 h at concentrations >0.29 mg HNO2-N L−1. Overall, the trials of this study demonstrated that the biofilms were FNA resistant and that the concentrations and exposure times used were inadequate to develop an effective intermittent dosing strategy.

Improving wastewater management using free nitrous acid (FNA)

Free nitrous acid (FNA), the protonated form of nitrite, has historically been an unwanted substance in wastewater systems due to its inhibition on a wide range of microorganisms. However, in recent years, advanced understanding of FNA inhibitory and biocidal effects on microorganisms has led to the development of a series of FNA-based applications that improve wastewater management practices. FNA has been used in sewer systems to control sewer corrosion and odor; in wastewater treatment to achieve carbon and energy efficient nitrogen removal; in sludge management to improve the sludge reduction and energy recovery; in membrane systems to address membrane fouling; and in wastewater algae systems to facilitate algae harvesting. This paper aims to comprehensively and critically review the current status of FNA-based applications in improving wastewater management. The underlying mechanisms of FNA inhibitory and biocidal effects are also reviewed and discussed. Knowledge gaps and current limitations of the FNA-based applications are identified; and perspectives on the development of FNA-based applications are discussed. We conclude that the FNA-based technologies have great potential for enhancing the performance of wastewater systems; however, further development and demonstration at larger scales are still required for their wider applications.

Free nitrous acid pretreatment of sludge to achieve nitritation: The effect of sludge concentration

This study investigated the effect of sludge concentration (expressed by mixed liquor volatile suspended solids, MLVSS) on free nitrous acid (FNA) pretreatment strategy to achieve nitritation. Results showed when FNA was 0.308 mgHNO₂-N/L, nitrite oxidizing bacteria (NOB) activity increased by 70.2% as MLVSS increased from 8.4 to 16.8 g/L. Nitrite accumulation ceased as MLVSS increased to 12.6 g/L, indicating that FNA inhibition of NOB gradually weakened with increasing MLVSS. When FNA was higher than 0.770 mgHNO₂-N/L, NOB activity was completely inhibited and the effect of MLVSS on FNA inhibition was negligible, with nitrite accumulation potential (NAP) varying from 88.1% to 90.0%. Mechanism investigation demonstrated flocs sizes distinctly declined, with more extracellular polymeric substances (EPS) released to resist FNA inactivation. Linear fitting showed NAP increased with FNA/MLVSS increment. Therefore, MLVSS affected FNA pretreatment performance, with FNA/MLVSS proposed as a more valuable criterion in FNA pretreatment strategy development, than the solely FNA.

Stability of Illicit Drugs as Biomarkers in Sewers: From Lab to Reality

Systematic sampling and analysis of wastewater samples are increasingly adopted for estimating drug consumption in communities. An understanding of the in-sewer transportation and transformation of illicit drug biomarkers is critical for reducing the uncertainty of this evidence-based estimation method. In this study, biomarkers stability was investigated in lab-scale sewer reactors with typical sewer conditions. Kinetic models using the Bayesian statistics method were developed to simulate biomarkers transformation in reactors. Furthermore, a field-scale study was conducted in a real pressure sewer pipe with the systematical spiking and sampling of biomarkers and flow tracers. In-sewer degradation was observed for some spiked biomarkers over typical hydraulic retention time (i.e., a few hours). Results indicated that sewer biofilms prominently influenced biomarker stability with the retention time in wastewater. The fits between the measured and the simulated biomarkers transformation demonstrated that the lab-based model could be extended to estimate the changes of biomarkers in real sewers. Results also suggested that the variabilities of biotransformation and analytical accuracy are the two major contributors to the overall estimation uncertainty. Built upon many previous lab-scale studies, this study is one critical step forward in realizing wastewater-based epidemiology by extending biomarker stability investigations from laboratory reactors to real sewers.

A novel and simple treatment for control of sulfide induced sewer concrete corrosion using free nitrous acid

Improved technologies are currently required for mitigating microbially induced concrete corrosion caused by the oxidation of sulfide to sulfuric acid in sewer systems. This study presents a novel strategy for reducing H2S oxidation on concrete surfaces that accommodate an active corrosion biofilm. The strategy aims to reduce biological oxidation of sulfide through treating the corrosion biofilm with free nitrous acid (FNA, i.e. HNO2). Two concrete coupons with active corrosion activity and surface pH of 3.8 ± 0.3 and 2.7 ± 0.2 were sprayed with nitrite. For both coupons, the H2S uptake rates were reduced by 84%-92% 15 days after the nitrite spray. No obvious recovery of the H2S uptake rate was observed during the entire experimental period (up to 12 months after the spray), indicating the long-term effectiveness of the FNA treatment in controlling the activity of the corrosion-causing biofilms. Live/Dead staining tests on the microorganisms on the concrete coupon surfaces demonstrated that viable bacterial cells decreased by > 80% 39 h after the nitrite spray, suggesting that biofilm cells were killed by the treatment. Examination of a corrosion layer within a suspended solution, containing the corrosion-causing biofilms, indicated that biological activity (ATP level and ratio of viable bacterial cells) was severely decreased by the treatment, confirming the bactericidal effect of FNA on the microorganisms in the biofilms. While field trials are still required to verify its effectiveness, it has been demonstrated here that the FNA spray is potentially a very cheap and effective strategy to reduce sewer corrosion.