Role of malate transporter in lipid accumulation of oleaginous fungus Mucor circinelloides

Enhanced fatty acid storage combined with the multi-factor optimization of fermentation for high-level production of docosahexaenoic acid in Schizochytrium sp

Schizochytrium sp. hasreceived much attention for itsability to synthesize and accumulate high-level docosahexaenoic acid (DHA), which can reach nearly 40 % of total fatty acids. In this study, the titer of DHA in Schizochytrium sp. was successfully improved by enhancing DHA storage through overexpressing the diacylglycerol acyltransferase (ScDGAT2C) gene, as well as optimizing the supply of precursors and cofactors required for DHA synthesis by response surface methodology. Notably, malic acid, citric acid, and biotin showed synergistic and time-dependent effects on DHA accumulation. The maximum lipid and DHA titers of the engineered Schizochytrium sp. strain reached 84.28 ± 1.02 g/L and 42.23 ± 0.69 g/L, respectively, with the optimal concentration combination (1.62 g/L malic acid + 0.37 g/L citric acid + 8.28 mg/L biotin) were added 48 h after inoculation. This study provides an effective strategy for improving lipid and DHA production in Schizochytrium sp.

The role of areA in lipid accumulation in high lipid-producing fungus Mucor circinelloides WJ11

In the oleaginous fungus Mucor circinelloides, lipid accumulation is regulated by nitrogen metabolism, which is regulated by the areA gene, a member of the GATA zinc finger transporter family and a major regulator for nitrogen metabolism. However, the role of areA in lipid accumulation in this fungus has not been reported. In order to explore the regulatory effect of areA gene on nitrogen metabolism and lipid accumulation in M. circinelloides, we constructed areA gene knockout and overexpression strains. Then, the recombinant strains were cultured and their biochemical indexes were measured. Simultaneously, transcriptomic studies on the recombinant strains were conducted to infer the regulatory mechanism of areA. The results showed that the areA knockout strain accumulated more lipid, which is 42 % higher than the control. While the areA overexpressing strain obtained the higher biomass accumulation (23 g/L) and used up the nitrogen source in the medium earlier than the control strain and knockout strain. Transcriptome data analysis showed that nr and nit-6 genes related to nitrogen metabolism were up-regulated. And the expression levels of key genes acc and aclY were higher in the areA knockout strain than others, which was positively correlated with the increased lipid accumulation. In addition, in knockout strains, protein catabolism tended to provide substrates for the lipid production, and the expression levels of the related genes were also higher than others. These results indicated that the areA gene not only controls the transcription level of genes related to nitrogen metabolism but also affects lipid accumulation.

AMP deaminase: A crucial regulator in nitrogen stress and lipid metabolism in Mucor circinelloides

Lipid biosynthesis is a significant metabolic response to nitrogen starvation in oleaginous fungi. The oleaginous fungus Mucor circinelloides copes with nitrogen stress by degrading AMP through AMP deaminase (AMPD). However, the mechanism of AMPD in regulating lipogenesis remains largely unclear. To elucidate the mechanism of AMPD in lipid synthesis in this M. circinelloides, we identified two genes (ampd1 and ampd2) encoding AMPD and constructed an ampd double knockout mutant. The engineered M. circinelloides strain elevated cell growth and lipid accumulation, as well as the content of oleic acid (OA) and gamma-linolenic acid (GLA). In addition to the expected increase in transcription levels of genes associated with lipid and TAG synthesis, we observed suppression of lipid degradation and reduced amino acid biosynthesis. This suggested that the deletion of AMPD genes induces the redirection of carbon towards lipid synthesis pathways. Moreover, the pathways related to nitrogen metabolism, including nitrogen assimilation and purine metabolism (especially energy level), were also affected in order to maintain homeostasis. Further analysis discovered that the transcription factors (TFs) related to lipid accumulation were also regulated. This study provides new insights into lipid biosynthesis in M. circinelloides, indicating that the trigger for lipid accumulation is not entirely AMPD-dependent and suggest that there may be additional mechanisms involved in the initiation of lipogenesis.

Overexpression of Citrate-Malate Carrier Promoted Lipid Accumulation in Oleaginous Filamentous Fungus Mortierella alpina

The mitochondrial citrate-malate carrier is responsible for the transport of citrate and malate between the mitochondria and cytosol, ensuring citrate supply substrate for fatty acid synthesis. In this study, we investigated the overexpression of the citrate-malate carrier coded by three genes (MaCT1/MaCT2/MaTCT) in Mortierella alpina to enhance lipid accumulation. Our results showed that the overexpression of MaCT1, MaCT2, and MaTCT increased the fatty acid content by up to 21.7, 29.5, and 12.8%, respectively, compared with the control strain, but had no effect on the growth. Among them, the MaCT2-overexpressing strain performed the best, and its total fatty acid yield was increased by 51.6% compared to the control. Furthermore, the relative transcription level of MaCT2 indeed increased significantly in the recombinant strains. These findings are beneficial to understanding the citrate transport system and improve the industrial applications of the oleaginous filamentous fungus M. alpina.

Homologous Overexpression of Diacylglycerol Acyltransferase in Oleaginous Fungus Mucor circinelloides WJ11 Enhances Lipid Accumulation under Static Solid Cultivation

Diacylglycerol acyltransferase (DGAT) catalyzes the binding of acyl-CoA to diacylglycerol to form triacylglycerol (TAG). Previous studies strongly indicate that DGAT2, rather than DGAT1, is crucial for TAG accumulation in the oleaginous fungus Mucor circinelloides. To increase the lipid content of M. circinelloides WJ11, McDGAT2 was overexpressed by homologous recombination; compared to the control strain Mc2075, transformants McDGAT2d showed a significant increase in biomass for both spores and mycelia (from 87.7 to 101.2 mg/g in spores and from 75.6 to 93.1 mg/g in mycelia). McDGAT2 overexpression under static solid fermentation gave a greater boost to lipid accumulation in mycelia than in spores. Total fatty acid content in mycelia increased by 68.0% (from 13.6 to 22.8%) and in spores by 26.3% (from 10.6 to 13.4%). However, under submerged fermentation, the lipid content of McDGAT2d was the same as the control, while biomass was slightly reduced. Transcriptomics showed that NADPH was derived mainly from the pentose phosphate pathway, acetyl-CoA was from multiple pathways, and leucine metabolism played an important role in substrate supply for fatty acid biosynthesis. Static solid fermentation may be the more suitable fermentation method for microbial oil production by filamentous fungi due to its lower fermentation costs.

Overexpression of the Mitochondrial Malic Enzyme Genes (malC and malD) Improved the Lipid Accumulation in Mucor circinelloides WJ11

Mucor circinelloides serves as a model organism to investigate the lipid metabolism in oleaginous microorganisms. It is considered as an important producer of γ-linolenic acid (GLA) that has vital medicinal benefits. In this study, we used WJ11, a high lipid-producing strain of M. circinelloides (36% w/w lipid, cell dry weight, CDW), to examine the role in lipid accumulation of two mitochondrial malic enzyme (ME) genes malC and malD. The homologous overexpression of both malC and malD genes enhanced the total lipid content of WJ11 by 41.16 and 32.34%, respectively. In parallel, the total content of GLA was enhanced by 16.73 and 46.76% in malC and malD overexpressing strains, respectively, because of the elevation of total lipid content. The fact that GLA content was enhanced more in the strain with lower lipid content increase and vice versa, indicated that engineering of mitochondrial MEs altered the fatty acid profile. Our results reveal that mitochondrial ME plays an important role in lipid metabolism and suggest that future approaches may involve simultaneous overexpression of distinct ME genes to boost lipid accumulation even further.

Production, Biosynthesis, and Commercial Applications of Fatty Acids From Oleaginous Fungi

Oleaginous fungi (including fungus-like protists) are attractive in lipid production due to their short growth cycle, large biomass and high yield of lipids. Some typical oleaginous fungi including Galactomyces geotrichum, Thraustochytrids, Mortierella isabellina, and Mucor circinelloides, have been well studied for the ability to accumulate fatty acids with commercial application. Here, we review recent progress toward fermentation, extraction, of fungal fatty acids. To reduce cost of the fatty acids, fatty acid productions from raw materials were also summarized. Then, the synthesis mechanism of fatty acids was introduced. We also review recent studies of the metabolic engineering strategies have been developed as efficient tools in oleaginous fungi to overcome the biochemical limit and to improve production efficiency of the special fatty acids. It also can be predictable that metabolic engineering can further enhance biosynthesis of fatty acids and change the storage mode of fatty acids.

Genetic Manipulation in Mucorales and New Developments to Study Mucormycosis

The study of the Mucoralean fungi physiology is a neglected field that the lack of effective genetic tools has hampered in the past. However, the emerging fungal infection caused by these fungi, known as mucormycosis, has prompted many researchers to study the pathogenic potential of Mucorales. The main reasons for this current attraction to study mucormycosis are its high lethality, the lack of effective antifungal drugs, and its recent increased incidence. The most contemporary example of the emergence character of mucormycosis is the epidemics declared in several Asian countries as a direct consequence of the COVID-19 pandemic. Fortunately, this pressure to understand mucormycosis and develop new treatment strategies has encouraged the blossoming of new genetic techniques and methodologies. This review describes the history of genetic manipulation in Mucorales, highlighting the development of methods and how they allowed the main genetic studies in these fungi. Moreover, we have emphasized the recent development of new genetic models to study mucormycosis, a landmark in the field that will configure future research related to this disease.

Overexpression of Shinorhizobium meliloti flavohemoglobin improves cell growth and fatty acid biosynthesis in oleaginous fungus Mucor circinelloides

Oxygen availability is a limiting factor for lipid biosynthesis in eukaryotic microorganisms. Two bacterial hemoglobins from Vitreoscilla sp. (VHb) and Shinorhizobium meliloti (SHb), which deliver oxygen to the respiratory chain to produce more ATP, were introduced into Mucor circinelloides to alleviate oxygen limitation, thereby improving cell growth and fatty acid production. The VHb and SHb genes were integrated into the M. circinelloides MU402 genome by homologous recombination. VHb and SHb protein expression was verified by carbon monoxide difference spectrum analysis. The biomass was increased by ~ 50% in the strain expressing SHb compared with VHb. The total fatty acid (TFA) content of the strain expressing SHb reached 15.7% of the dry cell weight (~ 40% higher than that of the control strain) during flask cultivation. The biomass and TFA content were markedly increased (12.1 g/L and 21.1% dry cell weight, respectively) in strains expressing SHb than strains expressing VHb during fermenter cultivation. VHb and SHb expression also increased the proportion of polyunsaturated fatty acids. Overexpressed bacterial hemoglobins, especially SHb, increased cell growth and TFA content in M. circinelloides at low and high aeration, suggesting that SHb improves fatty acid production more effectively than VHb in oleaginous microorganisms.

Role of Cytosolic Malic Enzyme in Oleaginicity of High-Lipid-Producing Fungal Strain Mucor circinelloides WJ11

Mucor circinelloides, an oleaginous filamentous fungus, is gaining popularity due to its ability to synthesize significant amounts of lipids containing γ-linolenic acid (GLA) that have important health benefits. Malic enzyme (ME), which serves as the main source of NADPH in some fungi, has been found to regulate lipid accumulation in oleaginous fungi. In the present study, the role of two cytosolic ME genes, cmalA and cmalB, in the lipid accumulation of the M. circinelloides high-lipid-producing strain WJ11, was evaluated. Strains overexpressing cmalA and cmalB showed a 9.8- and 6.4-fold rise in specific ME activity, respectively, and an elevation of the lipid content by 23.2% and 5.8%, respectively, suggesting that these genes are involved in lipid biosynthesis. Due to increased lipid accumulation, overall GLA content in biomass was observed to be elevated by 11.42% and 16.85% in cmalA and cmalB overexpressing strains, respectively. Our study gives an important insight into different studies exploring the role of the cmalA gene, while we have for the first time investigated the role of the cmalB gene in the M. circinelloides WJ11 strain.

Mucor circinelloides: a model organism for oleaginous fungi and its potential applications in bioactive lipid production

Microbial oils have gained massive attention because of their significant role in industrial applications. Currently plants and animals are the chief sources of medically and nutritionally important fatty acids. However, the ever-increasing global demand for polyunsaturated fatty acids (PUFAs) cannot be met by the existing sources. Therefore microbes, especially fungi, represent an important alternative source of microbial oils being investigated. Mucor circinelloides—an oleaginous filamentous fungus, came to the forefront because of its high efficiency in synthesizing and accumulating lipids, like γ-linolenic acid (GLA) in high quantity. Recently, mycelium of M. circinelloides has acquired substantial attraction towards it as it has been suggested as a convenient raw material source for the generation of biodiesel via lipid transformation. Although M. circinelloides accumulates lipids naturally, metabolic engineering is found to be important for substantial increase in their yields. Both modifications of existing pathways and re-formation of biosynthetic pathways in M. circinelloides have shown the potential to improve lipid levels. In this review, recent advances in various important metabolic aspects of M. circinelloides have been discussed. Furthermore, the potential applications of M. circinelloides in the fields of antioxidants, nutraceuticals, bioremediation, ethanol production, and carotenoids like beta carotene and astaxanthin having significant nutritional value are also deliberated.

Tricarboxylate Citrate Transporter of an Oleaginous Fungus Mucor circinelloides WJ11: From Function to Structure and Role in Lipid Production

The citrate transporter protein (CTP) plays an important role in citrate efflux from the mitochondrial matrix to cytosol that has great importance in oleaginous fungi. The cytoplasmic citrate produced after citrate efflux serves as the primary carbon source for the triacylglycerol and cholesterol biosynthetic pathways. Because of the CTP's importance, our laboratory has extensively studied its structure/function relationships in Mucor circinelloides to comprehend its molecular mechanism. In the present study, the tricarboxylate citrate transporter (Tct) of M. circinelloides WJ11 has been cloned, overexpressed, purified, kinetically, and structurally characterized. The Tct protein of WJ11 was expressed in Escherichia coli, isolated, and functionally reconstituted in a liposomal system for kinetic studies. Our results showed that Tct has a high affinity for citrate with Km 0.018 mM. Furthermore, the tct overexpression and knockout plasmids were created and transformed into M. circinelloides WJ11. The mitochondria of the tct-overexpressing transformant of M. circinelloides WJ11 showed a 49% increase in citrate efflux, whereas the mitochondria of the tct-knockout transformant showed a 39% decrease in citrate efflux compared to the mitochondria of wild-type WJ11. To elucidate the structure-function relationship of this biologically important transporter a 3D model of the mitochondrial Tct protein was constructed using homology modeling. The overall structure of the protein is V-shaped and its 3D structure is dimeric. The transport stability of the structure was also assessed by molecular dynamics simulation studies. The activity domain was identified to form hydrogen bond and stacking interaction with citrate and malate upon docking. Tricarboxylate citrate transporter has shown high binding energy of −4.87 kcal/mol to citric acid, while −3.80 kcal/mol to malic acid. This is the first report of unraveling the structural characteristics of WJ11 mitochondrial Tct protein and understanding the approach of the transporting toward its substrate. In conclusion, the present findings support our efforts to combine functional and structural data to better understand the Tct of M. circinelloides at the molecular level and its role in lipid accumulation.

Heterologous Expression of Two Malate Transporters From an Oleaginous Fungus Mucor circinelloides Improved the Lipid Accumulation in Mucor lusitanicus

The fungus, Mucor lusitanicus, is of great interest for microbial lipids, because of its ability to accumulate intracellular lipid using various carbon sources. The biosynthesis of fatty acid requires the reducing power NADPH, and acetyl-CoA, which is produced by the cleavage of citrate in cytosol. In this study, we employed different strategies to increase lipid accumulation in the low lipid-producing fungi via metabolic engineering technology. Hence, we constructed the engineered strain of M. lusitanicus CBS 277.49 by using malate transporter (mt) and 2-oxoglutarate: malate antiporter (sodit) from M. circinelloides WJ11. In comparison with the control strain, the lipid content of the overexpressed strains of mt and sodit genes were increased by 24.6 and 33.8%, respectively. These results showed that mt and sodit can affect the distribution of malate in mitochondria and cytosol, provide the substrates for the synthesis of citrate in the mitochondria, and accelerate the transfer of citrate from mitochondria to cytosol, which could play a significant regulatory role in fatty acid synthesis leading to lipids over accumulation.

Acute carbohydrate overfeeding: a redox model of insulin action and its impact on metabolic dysfunction in humans

A role for fat overfeeding in metabolic dysfunction in humans is commonly implied in the literature. Comparatively less is known about acute carbohydrate overfeeding (COF). We tested the hypothesis that COF predisposes to oxidative stress by channeling electrons away from antioxidants to support energy storage. In a study of 24 healthy human subjects with and without obesity, COF was simulated by oral administration of excess carbohydrates; a two-step hyperinsulinemic clamp was used to evaluate insulin action. The distribution of electrons between oxidative and reductive pathways was evaluated by the changes in the reduction potentials (Eh) of cytoplasmic (lactate, pyruvate) and mitochondrial (β-hydroxybutyrate, acetoacetate) redox couples. Antioxidant redox was measured by the ratio of reduced to oxidized glutathione. We used cross-correlation analysis to evaluate the relationships between the trajectories of Eh, insulin, glucose, and respiratory exchange during COF. DDIT3 and XBP1s/u mRNA were measured as markers of endoplasmic reticulum stress (ER stress) in adipose tissue before and after COF. Here, we show that acute COF is characterized by net transfer of electrons from mitochondria to cytoplasm. Circulating glutathione is oxidized in a manner that significantly cross-correlates with increasing insulin levels and precedes the decrease in cytoplasmic Eh. This effect is more pronounced in overweight individuals (OW). Markers of ER stress in subcutaneous fat are detectable in OW within 4 h. We conclude that acute COF contributes to metabolic dysfunction through insulin-dependent pathways that promote electron transfer to the cytoplasm and decrease antioxidant capacity. Characterization of redox during overfeeding is important for understanding the pathophysiology of obesity and type 2 diabetes.NEW & NOTEWORTHY Current principles assume that conversion of thermic energy to metabolically useful energy follows fixed rules. These principles ignore the possibility of variable proton uncoupling in mitochondria. Our study shows that the net balance of electron distribution between mitochondria and cytoplasm is influenced by insulin in a manner that reduces proton leakage during overfeeding. Characterization of the effects of insulin on redox balance is important for understanding obesity and insulin resistance.

Aspergillus caespitosus ASEF14, an oleaginous fungus as a potential candidate for biodiesel production using sago processing wastewater (SWW)

Background

Oleaginous microorganisms are sustainable alternatives for the production of biodiesel. Among them, oleaginous fungi are known for their rapid growth, short life cycles, no light requirement, easy scalability, and the ability to grow in cheap organic resources. Among all the sources used for biodiesel production, industrial wastewater streams have been least explored. We used oleaginous fungi to decontaminate sago processing wastewater and produce biodiesel.

Results

Among the 15 isolates screened for lipid production and starch utilization using the Nile red staining assay and amylase plate screening, three isolates accumulated > 20% (w/w) of their dry cell mass as lipids. The isolate ASEF14 exhibited the highest lipid accumulation (> 40%) and was identified as Aspergillus caespitosus based on the 28S rRNA gene sequencing. The maximum lipid content of 54.4% in synthetic medium (SM) and 37.2% in sago processing wastewater (SWW) was produced by the strain. The Fourier-transform infrared (FTIR) spectroscopy of the fungal oil revealed the presence of functional peaks corresponding to major lipids. Principal component analysis (PCA) of the FTIR data revealed major changes in the fatty acid composition during the transition from the growth phase (Days 1–3) to the lipid accumulation phase (Days 4–7). The fatty acid methyl esters (FAME) analysis of fungal oil from SWW contained 43.82% and 9.62% of saturated and monounsaturated fatty acids, respectively. The composition and percentage of individual FAME derived from SWW were different from SM, indicating the effect of nutrient and fermentation time. The fuel attributes of the SM- and SWW-grown fungal biodiesel (kinematic viscosity, iodine value, cetane number, cloud and pour point, linolenic acid content, FA > 4 double bonds) met international (ASTM D6751, EN 14214) and national (IS 15607) biodiesel standards. In addition to biodiesel production, the strain removed various contaminants such as total solids (TS), total suspended solids (TSS), total dissolved solids (TDS), dissolved oxygen (DO), chemical oxygen demand (COD), biological oxygen demand (BOD), total nitrogen (TN), total phosphorus (TP), and cyanide up to 58.6%, 53.0%, 35.2%, 94.5%, 89.3%, 91.3%, 74.0%, 47.0%, and 53.84%, respectively, from SWW.

Conclusion

These findings suggested that A. caespitosus ASEF14 is a potential candidate with high lipid accumulating ability (37.27%), capable of using SWW as the primary growth medium. The medium and incubation time alter the FAME profile of this fungus. The physical properties of fungal oil were in accordance with the biodiesel standards. Moreover, it decontaminated SWW by reducing several polluting nutrients and toxicants. The fungal biodiesel produced by this cost-effective method could serve as an alternate path to meet global energy demand.

Deletion of Plasma Membrane Malate Transporters Increased Lipid Accumulation in the Oleaginous Fungus Mucor circinelloides WJ11

Malate as an important intermediate metabolite, its subcellular location, and concentration have a significant impact on fungal lipid metabolism. Previous studies showed that the mitochondrial malate transporter plays an important role in lipid accumulation in Mucor circinelloides by manipulating intracellular malate concentration. However, the role of plasma membrane malate transporters in oleaginous fungi remains unexplored. Therefore, in this work, two plasma membrane malate transporters "2-oxoglutarate:malate antiporters" (named SoDIT-a and SoDIT-b) of M. circinelloides WJ11 were deleted, and the consequences in growth capacity, lipid accumulation, and metabolism were analyzed. The results showed that deletion of sodit-a or/and sodit-b reduced the extracellular malate, confirming that the products of both genes participate in malate transportation. In parallel, the lipid contents in mutants increased approximately 10-40% higher than that in the control strain, suggesting that the defect in plasma membrane malate transport results in an increase of malate available for lipid biosynthesis. Furthermore, transcriptional analysis showed that the expression levels of multiple key genes involved in the lipid biosynthesis were also increased in the knockout mutants. To the best of our knowledge, this is the first report that demonstrated the association between plasma membrane malate transporters and lipid accumulation in M. circinelloides.

Improved glucose and xylose co-utilization by overexpression of xylose isomerase and/or xylulokinase genes in oleaginous fungus Mucor circinelloides

Most of the oleaginous microorganisms cannot assimilate xylose in the presence of glucose, which is the major bottleneck in the bioconversion of lignocellulose to biodiesel. Our present study revealed that overexpression of xylose isomerase (XI) gene xylA or xylulokinase (XK) gene xks1 increased the xylose consumption by 25 to 37% and enhanced the lipid content by 8 to 28% during co-fermentation of glucose and xylose. In xylA overexpressing strain Mc-XI, the activity of XI was 1.8-fold higher and the mRNA level of xylA at 24 h and 48 h was 11- and 13-fold higher than that of the control, respectively. In xks1 overexpressing strain Mc-XK, the mRNA level of xks1 was 4- to 11-fold of that of the control strain and the highest XK activity of 950 nmol min^-1 mg^-1 at 72 h which was 2-fold higher than that of the control. Additionally, expression of a translational fusion of xylA and xks1 further enhanced the xylose utilization rate by 45%. Our results indicated that overexpression of xylA and/or xks1 is a promising strategy to improve the xylose and glucose co-utilization, alleviate the glucose repression, and produce lipid from lignocellulosic biomass in the oleaginous fungus M. circinelloides. KEY POINTS: • Overexpressing xylA or xks1 increased the xylose consumption and the lipid content. • The xylose isomerase activity and the xylA mRNA level were enhanced in strain Mc-XI. • Co-expression of xylA and xks1 further enhanced the xylose utilization rate by 45%.

Enhanced lipid production by addition of malic acid in fermentation of recombinant Mucor circinelloides Mc-MT-2

In our previous work, we reported a novel approach for increasing lipid production in an oleaginous fungus Mucor circinelloides by overexpression of mitochondrial malate transporter protein. This transporter plays a vital role in fatty acid biosynthesis during malate and citrate transport systems in oleaginous fungi. In this study, the controlling metabolic supplementation strategy was used to improve the lipid production by overexpression of malate transporter protein in M. circinelloides strain coded as Mc-MT-2. The effects of different metabolic intermediates on lipid production in batch fermentation by Mc-MT-2 were investigated. The optimal lipid production was obtained at 0.8% malic acid after 24 h of fermentation. Furthermore, in fed-batch bioreactors containing glucose as a carbon source supplemented with malic acid, the highest cell growth, and lipid production were achieved. The resulting strain showed the fungal dry biomass of 16 g/L, a lipid content of 32%, lipid yield of 5.12 g/L in a controlled bench-top bioreactor, with 1.60-, 1.60- and 2.56-fold improvement, respectively, compared with the batch control without supplementation of malic acid. Our findings revealed that the addition of malic acid during fermentation might play an important role in lipid accumulation in the recombinant M. circinelloides Mc-MT-2. This study provides valuable insights for enhanced microbial lipid production through metabolic supplementation strategy in large scale and industrial applications.

The Potential of Single-Cell Oils Derived From Filamentous Fungi as Alternative Feedstock Sources for Biodiesel Production

Microbial lipids, also known as single-cell oils (SCOs), are highly attractive feedstocks for biodiesel production due to their fast production rates, minimal labor requirements, independence from seasonal and climatic changes, and ease of scale-up for industrial processing. Among the SCO producers, the less explored filamentous fungi (molds) exhibit desirable features such as a repertoire of hydrolyzing enzymes and a unique pellet morphology that facilitates downstream harvesting. Although several oleaginous filamentous fungi have been identified and explored for SCO production, high production costs and technical difficulties still make the process less attractive compared to conventional lipid sources for biodiesel production. This review aims to highlight the ability of filamentous fungi to hydrolyze various organic wastes for SCO production and explore current strategies to enhance the efficiency and cost-effectiveness of the SCO production and recovery process. The review also highlights the mechanisms and components governing lipogenic pathways, which can inform the rational designs of processing conditions and metabolic engineering efforts for increasing the quality and accumulation of lipids in filamentous fungi. Furthermore, we describe other process integration strategies such as the co-production with hydrogen using advanced fermentation processes as a step toward a biorefinery process. These innovative approaches allow for integrating upstream and downstream processing units, thus resulting in an efficient and cost-effective method of simultaneous SCO production and utilization for biodiesel production.

Role of g6pdh and leuB on Lipid Accumulation in Mucor circinelloides

Mucor circinelloides is a valuable oleaginous filamentous fungus rich in γ-linolenic acid (GLA, 18:3; n-6), which is beneficial for human health. Our previous comparative proteomic analysis between high lipid-producing M. circinelloides WJ11 and low lipid-producing M. circinelloides CBS 277.49 indicated that glucose 6-phosphate dehydrogenase (G6PDH) and β-isopropylmalate dehydrogenase (IPMDH) were closely involved in lipid accumulation. Transcription analysis suggested that in the strain WJ11, g6pdh1 and g6pdh2, which encode G6PDH, and leuB, which encodes IPMDH, could be the key genes regulating lipid accumulation. To further analyze the effects of these three genes (i.e., g6pdh1, g6pdh2, and leuB) on lipid accumulation, we respectively overexpressed these genes from M. circinelloides WJ11 in defective CBS 277.49 strains in this study. The results showed that overexpression of g6pdh1 and g6pdh2 genes from strain WJ11 increased the fatty acid content of cell dry weight by 23-38 and 41-47%, respectively, compared with the control strain. Furthermore, overexpression of the leuB gene from strain WJ11 increased the fatty acid content of cell dry weight by up to 67-73%. These results suggest that g6pdh1, g6pdh2, and especially leuB genes play important roles in regulating fatty acid synthesis in M. circinelloides.

Mitochondrial Citrate Transport System in the Fungus Mucor circinelloides: Identification, Phylogenetic Analysis, and Expression Profiling During Growth and Lipid Accumulation

The mitochondrial citrate transport system, composed of citrate and malate transporters (MTs), can regulate the citrate efflux from mitochondria to cytosol, and then citrate is cleaved into OAA and acetyl-CoA which can be used for fatty acid (FA) biosynthesis. However, in the fungus Mucor circinelloides the molecular mechanism of citrate efflux from the mitochondria by this system and its role in FA synthesis is unclear. In the present study, we have analyzed the genome of high lipid-producing strain WJ11 and the low lipid-producing strain CBS 277.49 to find the potential genes involving in this system. Five potential genes are present in the genome of WJ11. These genes encode one citrate transport protein (CT), one tricarboxylate carrier (TCT), one MT, and two 2-oxoglutarate:malate antiporters (SoDIT-a and SoDIT-b). However, the genome of CBS 277.49 contains the same set of genes, except for the presence of just one SoDIT. The proteins from WJ11 had similar properties as their counterparts in CBS 277.49. Moreover, phylogenetic analyses revealed the evolutionary relationship of these proteins and illuminated their typical motifs related to potential functions. Additionally, the expression of these genes was analyzed to predict the possible functions in lipid metabolism in M. circinelloides. This is the first study to report the in silico analysis of structures and functions of the mitochondrial citrate transport system in M. circinelloides. This work showed a new strategy for research for the selection of candidate genes for further detailed functional investigation of the mitochondrial citrate transport system in lipid accumulation.

13C metabolic flux analysis on roles of malate transporter in lipid accumulation of Mucor circinelloides

Background

Mitochondrial and cytoplasmic malate transporter proteins are responsible for transmembrane transport of malate, thereby linking malate metabolism in various subcellular regions of the cell. These transporters play an important role in fatty acid biosynthesis of oleaginous microorganisms. Our previous studies have found that lipid content of the recombinant Mucor circinelloides (M. circinelloides) strain with mitochondrial malate transporter (mt) gene overexpression was increased by 70%, while that of strain with mt gene knockout was decreased by 27%. However, the mechanism of malate transporter promoting the transport of mitochondrial malate and citrate related to lipid accumulation is not clear. Therefore, ¹³C-labeled glucose metabolic flux analysis was carried out to identify the metabolic network topology and estimate intracellular fluxes of genetically engineered M. circinelloides strains for the purpose of better understanding the roles of malate transporters in citrate transport systems and lipid accumulation.

Results

The metabolic flux distribution analysis suggested that tricarboxylic acid (TCA) cycle flux ratio of mt-overexpression strains was decreased compared to that of the control strain, but in contrast, glyoxylic acid (GOX) cycle flux ratio was increased. Accordingly, the mt-knockout strain showed an opposite phenomenon with a higher TCA cycle flux ratio and a lower GOX cycle flux ratio than the control strain. GOX cycle might be more effective than TCA cycle in producing malate and oxaloacetate replenishment. Moreover, a relatively higher flux ratio of the pentose phosphate (PP) pathway was obtained in mt-overexpression strains, but no significant difference in the malic enzyme flux between recombinant strains and the control strain. Our results confirmed that PP pathway might play an important role for supplying NADPH and malic enzyme is not a limiting factor for fatty acid synthesis in oleaginous fungus M. circinelloides strains.

Conclusion

Intracellular metabolic flux information suggested that mt-overexpression strains had higher flux in PP pathway and GOX cycle, lower flux in TCA cycle, and no difference in malic enzyme cycle. Together, the role of malate transporter was assumed to further participate in transporting cycle of acetyl-CoA and drive PP pathway to supply NADPH required for lipid accumulation in recombinant M. circinelloides strains.

Genetic Modification of Mucor circinelloides to Construct Stearidonic Acid Producing Cell Factory

Stearidonic acid (SDA; 18:4, n-3) is the delta 15-desaturase product of gamma linolenic acid (GLA; 18:3, n-6) and delta 6-desaturase product of alpha linolenic acid (ALA; 18:3, n-3). Construction of engineered oleaginous microbes have been attracting significant interest in producing SDA because of its nutritional value and pharmaceutical applications. Mucor circinelloides is a GLA producing filamentous fungus, which can be a useful tool to produce SDA. This study has, therefore, overexpressed the delta-15 desaturase (D15D) gene from Mortierella alpina in this fungus to construct a SDA-producing cell factory. To produce SDA in M. circinelloides, the homologous overexpression of D15D gene was analyzed. When the gene was overexpressed in M. circinelloides CBS 277.49, up to 5.0% SDA was accumulated in this strain. According to current knowledge, this is the first study describing the construction of a SDA-producing cell factory by overexpression of D15D gene in oleaginous fungus M. circinelloides. A new scope for further research has been established by this work to improve SDA production in this fungus, specifically in its high lipid-producing strain, WJ11.

Critical applications of Mucor circinelloides within a biorefinery context

The establishment of an efficient and feasible biorefinery model depends on, among other factors, particularly the selection of the most appropriate microorganism. Mucor circinelloides is a dimorphic fungus species able to produce a wide variety of hydrolytic enzymes, lipids prone to biodiesel production, carotenoids, ethanol, and biomass with significant nutritional value. M. circinelloides also has been selected as a model species for genetic modification by being the first filamentous oleaginous species to have its genome fully characterized, as well as being a species characterized as a potential bioremediation agent. Considering the potential of replacing several nonrenewable feedstocks is widely dependent on fossil fuels, the exploitation of microbial processes and products is a desirable solution for promoting a green and sustainable future. Here, we introduce and thoroughly describe the recent and critical applications of this remarkable fungus within the context of developing a fungal-based biorefinery.

Molecular Tools for Carotenogenesis Analysis in the Mucoral Mucor circinelloides

The carotene producer Mucor circinelloides is the fungus within the Mucoromycota phylum with the widest repertoire of molecular tools to manipulate its genome. The initial development of an effective procedure for genetic transformation and later improvements have resulted in an expansion of available tools, which include gene replacement, inactivation of gene expression by RNA silencing, gene overexpression, and functional genomics. Moreover, sequencing of its genome has given a definitive boost to these techniques making attainable the study of genes involved in many physiological or developmental processes, including carotenoid biosynthesis. Here, we describe in detail the latest molecular techniques currently used in M. circinelloides that have made it a valuable model for studying gene function within its phylum.

Comparative Proteome Analysis between High Lipid-Producing Strain Mucor circinelloides WJ11 and Low Lipid-Producing Strain CBS 277.49

Mucor circinelloides is one of few oleaginous fungi that produces a useful oil rich in γ-linolenic acid, but it usually only produces <25% total lipid. Nevertheless, we isolated a new strain WJ11 that can produce up to 36% lipid of cell dry weight. In this study, we have systematically analyzed the global changes in protein levels between the high lipid-producing strain WJ11 and the low lipid-producing strain CBS 277.49 (15%, lipid/cell dry weight) at lipid accumulation phase through comparative proteome analysis. Proteome analysis demonstrated that the branched-chain amino acid and lysine metabolism, glycolytic pathway, and pentose phosphate pathway in WJ11 were up-regulated, while the activities of tricarboxylic acid cycle and branch point enzyme for synthesis of isoprenoids were retarded compared with CBS 277.49. The coordinated regulation at proteome level indicate that more acetyl-CoA and NADPH are provided for fatty acid biosynthesis in WJ11 compared with CBS 277.49.

High-efficiency extracellular release of free fatty acids from Aspergillus oryzae using non-ionic surfactants

Free fatty acids (FFAs) are useful for generating biofuel compounds and functional lipids. Microbes are increasingly exploited to produce FFAs via metabolic engineering. However, in many microorganisms, FFAs accumulate in the cytosol, and disrupting cells to extract them is energy intensive. Thus, a simple cost-effective extraction technique must be developed to remove this drawback. We found that FFAs were released from cells of the filamentous fungus Aspergillus oryzae with high efficiency when they were cultured or incubated with non-ionic surfactants such as Triton X-100. The surfactants did not reduce hyphal growth, even at 5% (w/v). When the faaA disruptant was cultured with 1% Triton X-100, more than 80% of the FFAs synthesized de novo were released. When the disruptant cells grown without surfactants were incubated for 1h in 1% Triton X-100 solution, more than 50% of the FFAs synthesized de novo were also released. Other non-ionic surfactants in the same ether series, such as Brij 58, IGEPAL CA-630, and Tergitol NP-40, elicited a similar FFA release. The dry cell weight of total hyphae decreased when grown with 1% Triton X-100. The decrement was 4.9-fold greater than the weight of the released FFAs, implying release of other intracellular compounds. Analysis of the culture supernatant showed that intracellular lactate dehydrogenase was also released, suggesting that FFAs are not released by a specific transporter. Therefore, ether-type non-ionic surfactants probably cause non-specific release of FFAs and other intracellular compounds by increasing cell membrane permeability.