Lengthening of short bones by distraction osteogenesis--results and complications

First metatarsal shortening after hallux valgus surgery: Benefits of treatment with distraction osteogenesis

INTRODUCTION

Iatrogenic shortening and elevation of the first metatarsal (MT1) is a common complication of hallux valgus surgery, inducing metatarsalgia underneath the lesser rays, a reason for patient dissatisfaction. For resolving this problem, different types of revision surgery are described, of which lengthening MT1 by distraction osteogenesis is underreported and therefore undervalued.

MATERIALS AND METHODS

We present three cases with iatrogenic shortening after hallux valgus surgery treated by distraction osteogenesis of MT1 using a custom-made frame, made of Ilizarov equipment. To evaluate the amount of lengthening, the length of the first and second metatarsal (MT2) and the parabolic distribution of the metatarsal heads were compared before and after distraction. To evaluate correction in the sagittal plane, Meary's angle was measured pre- and post-lengthening. Pain was noted by a visual analogic score during follow-up.

RESULTS

In our series of three cases, lengthening of MT1 between 7 mm and 18 mm, resulted in an improved parabolic distribution of the MT heads. The average difference between the second and first MT-head, relative to the SM4 axis (M2-M1) improved from 9.4 mm (± 0.9 mm) to 2.8 mm (± 0.7 mm) resolving corresponding pain in all patients. Meary's angle was normalized in one case. The average duration of treatment was 116 days (± 9 days). Minimal follow up was 11 years.

CONCLUSION

Using Ilizarov equipment for distraction osteogenesis of MT1 is a low-cost and effective method. Over time, this technique has proven its utility in pronounced iatrogenic shortening of MT1. The possibility to lengthen more than 1 cm, to correct in multiple planes, as well as early mobilization and weight bearing are additional advantages, but one must be careful to avoid overcorrection. The need for strict follow-up with multiple radiographs and rigorous patient selection is mandatory.

Treatment of Fourth Metatarsal Brachymetatarsia Using Distraction Osteogenesis with External Fixator: Surgical Techniques, Outcomes and Complications

OBJECTIVE

Surgical technique in distraction osteogenesis for the treatment of brachymetatarsia can influence the final prognosis. However, there are currently no standardized guidelines for surgical procedures and complication management. The aim of this study is to investigate the effect of bone lengthening with external fixation by minimally invasive osteotomy based on Ilizarov technique in the treatment of congenital brachymetatarsia.

METHODS

A retrospective study was conducted on patients with congenital brachymetatarsia treated by metatarsal lengthening, from June 2017 to December 2020. There were 11 patients with 17 shorted fourth metatarsals, including 10 females and 1 male, with age of 24.6 ± 4.5 years (16-31 years). Six patients were bilaterally involved. Orthofix external fixator mini track was installed through dorsal approach and the fourth MTP joints were temporarily fixed by Kirschner wire. Bone lengthening was performed after a minimally invasive osteotomy at the proximal metatarsals. American Orthopedic Foot and Ankle Society (AOFAS) lesser metatarsophalangeal-interphalangeal (MTP-IP) scores, metatarsal length, complications were recorded. Statistical comparison was performed using the paired t-student test for pre- and postoperative AOFAS MTP-IP scores.

RESULTS

Patients were followed up for 55 ± 10.8 months. The mean length of the fourth metatarsal bone was 49.9 ± 2.9 mm preoperatively. The mean metatarsal shortage was 18.8 ± 3.1 mm. The mean lengthening achieved was 19.8 ± 3.3 mm, with a lengthening ratio of 39.7% ± 6.6%. The lengthened callus ossified completely at 3-4 months after operation. All patients were satisfied with the results of lengthening. The AOFAS scores were improved significantly from 83.7 ± 4.2 preoperatively to 93.2 ± 2.7 postoperatively (t = -10.27, p < 0.001). One patient with traumatic metatarsophalangeal joint subluxation was treated by joint reduction and Kirschner wire fixation. One patient had metatarsophalangeal joint release and Kirschner wire fixation due to flexion contracture. Pin tract infections were controlled by wound care and antibiotics in 6 patients. All patients had no nonunion, necrosis of toes, and sensory disturbance of toes.

CONCLUSION

Metatarsal lengthening by minimally invasive osteotomy with external fixator had satisfactory results in the treatment of congenital brachymetatarsia.

Metacarpal Lengthening Using a Mini-Ring Ilizarov Device for Thumb Reconstruction

PURPOSE

To explore the results of using the mini-ring Ilizarov external fixator for thumb metacarpal lengthening and its compatibility with a simultaneous groin flap.

METHODS

From May 2016 to June 2019, 17 adult patients with thumb loss were treated with metacarpal lengthening using a mini-ring Ilizarov device. The device was composed of 2 rings, threaded rods, nuts, and K-wires (diameter, 1.5 mm). Of these patients, 6 also underwent simultaneous groin flap transfer. Lengthening was started 3 days after surgery at a rate of 0.66 mm/d. The pedicle of the groin flap was divided 1 month after the surgery. The healing index (days per cm), which denotes the number of days the external fixator is attached to the bone per centimeter of length gained, was used to evaluate the lengthening efficiency.

RESULTS

The patients were observed for 21.9 ± 9.0 months. The lengthening continued for 29.1 ± 4.5 days, resulting in an additional length of 1.9 ± 0.3 cm.

CONCLUSIONS

The mini-ring Ilizarov external fixator is a simple device for primary metacarpal lengthening. This device can be used with a groin flap for single-stage lengthening of injured thumbs with bone exposure.

TYPE OF STUDY/LEVEL OF EVIDENCE

Therapeutic IV.

An unusual case of traumatic injury to the first metatarsal a case report

A 44-year-old male sustained trauma to his foot leading to a 5-cm defect of the first metatarsal bone and infection of the bone by Staphylococcus aureus. Osteotomy is the most suitable method for treating large metatarsal defects complicated with osteomyelitis, however few reports have been published on this challenging approach. In this case, osteotomy and external fixation for distraction were performed. Finally, the osteomyelitis of the patient was well controlled, the bone length was restored, and the patient could carry weight completely, and the treatment effect was satisfactory.

Novel Use of an Internal Distractor for Metacarpal Lengthening

BACKGROUND

In patients who have had proximal digit amputation, metacarpal distraction osteogenesis is an option to improve digital length and function. One drawback is that traditional external distraction devices are large and cumbersome; the option of a low-profile internal device is therefore appealing. Internal distractors are commonly used in craniofacial reconstruction, but use in the hand has not been reported. We describe a case series of the novel use of an internal distractor in metacarpal lengthening.

METHODS

In this single-center case series, patients who underwent metacarpal distraction by the senior author using a uniplanar internal distractor were reviewed, and indications, outcomes, and complications were analyzed.

RESULTS

There were 5 cases in 4 patients (age range: 7-33 years). Indications were traumatic amputation in 4 cases and congenital hypoplasia in 1. All were successfully distracted, with a mean final length gain of 1.3 cm (range: 1.0-1.7 mm). Mean time from device placement to consolidation was 3.5 months. Complications included activation arm site infection in 2 cases, both occurring after the distraction period, necessitating device removal before full consolidation. In these cases, the device was removed after the distraction period and replaced with a Kirschner wire for stabilization through the consolidation period.

CONCLUSIONS

Metacarpal distraction was successfully achieved with an internal distraction device. Although infection was common, it occurred after the distraction period and did not preclude length gain. We feel that this low-profile device offers advantages over cumbersome external devices typically used for metacarpal lengthening.

Aesthetic correction of short nail deformity in congenital brachydactyly Type D by distraction lengthening

Brachydactyly Type D is a congenital condition of the thumb in which there is a short and broad thumbnail. Although the thumb function is often unaffected, some patients seek surgery for cosmetic improvement. This study aimed to describe our method of distraction lengthening to correct nail deformity in brachydactyly Type D. A total of 163 thumbs in 95 patients underwent this surgery between 2018 and 2021.The mean thumbnail length improved from 9 mm to 15 mm, with a mean percentage increase of 62%. The ratio of nail length to width changed from 0.6 to 1.1, which was equal to normal. The mean increased fingernail length/width ratio was 0.5, with a percentage change of 78%. No obvious surgical scar was observed. The thumb function was not significantly affected. We conclude that aesthetic correction of short nail deformity in brachydactyly Type D can be achieved by distraction lengthening with high satisfaction and without functional impairment.Level of evidence: IV.

Age-related Outcomes and Complications of Osteodistraction in the Pediatric Upper Extremity: A Large Retrospective Single-center Study of 61 Cases

BACKGROUND

The study purpose was to assess: (1) the complication rate of osteodistraction in the pediatric upper extremity, its severity and relation to patient-specific and treatment-specific parameters, and (2) dedicated patient-reported outcome scores after these procedures.

METHODS

This retrospective study analyzed a chart of patients undergoing osteodistraction of the upper limb between 2003 and 2020. Demographics, distraction-specific parameters, healing index, and any complications graded according to the Sink grading scale (grades 1 to 5) were extracted. An additional phone interview was performed to assess patient satisfaction and functionality of the elongated limb using the Quick-DASH (Disabilities of Arm, Shoulder, and Hand) score.

RESULTS

This study included 61 cases from 48 individual patients. The mean age at the start of distraction was 11.5±3.6 years. The ulna was the most frequently lengthened bone, with 21 (34.4%) cases. Ninety-four complications were observed, with an average complication rate of 77.0%. Based on the Sink grading scale (1 to 5), grade 3 complications were most common (n=29; 47.5%) followed by grade 1 (n=14; 23.0%), 2 (n=14; 23.0%), and 4 (n=4; 6.6%). A significantly lower and thus better bone healing index was observed for the age category less than 10 years compared with the 14 to 18 years group (P=0.006). The average satisfaction was 4.2±1.0 points of 5. The mean Quick-DASH score was 14.1±12.5, indicating very good clinical outcomes.

CONCLUSIONS

Despite the occurrence of numerous complications, high patient satisfaction and good daily life functionality of the treated limb was observed. An age of more than 14 years at the beginning of therapy had a negative prognostic effect on bone healing during distraction. Thus, osteodistraction in the upper extremity may preferably be performed less than 10 years of age because of enhanced bone regeneration.

LEVEL OF EVIDENCE

Level IV-retrospective case series.

The Surgical Treatment of Brachymetatarsia

This article describes the 3 main surgical options for correction of congenital brachymetatarsia in childhood. The one-stage lengthening by lengthening osteotomy and lengthening with graft interposition are suitable for defects less than 10 mm. For the greater defects from 10 mm to more than 20 mm, gradual lengthening by callus distraction with an external or internal fixator is appropriate. Over the last years, callus distraction with an internal minifixator became commonly established because of the significantly improved aftercare with early full weight-bearing and high postoperative comfort for the child. All 3 surgical procedures are presented with comprehensive image material.

[Application of Ilizarov technique in functional reconstruction of thumb degloving injury after amputation]

Objective

To investigate the effectiveness of Ilizarov technique in reconstruction of thumb function in patients with thumb degloving injury after amputation.

Methods

Between June 2011 and September 2016, 9 cases of thumb degloving injury were treated with amputation and Ilizarov technology. There were 8 males and 1 female with an age of 18-52 years (mean, 34.7 years). The amputation plane was the level of the metacarpophalangeal joint in 5 cases, the level of the proximal metacarpophalangeal joint in 2 cases, and the level of the base of the proximal phalanx in 2 cases (the length of proximal phalanx was less than 1 cm). After amputation, the affected finger was shorter than the healthy finger by 4.0-7.5 cm, with an average of 5.7 cm. On the fifth day after operation, the semi-loop external fixation extender was applied for extension, which was extended by 0.5 mm per day, and was extended once every 6 hours.

Results

After bone lengthening surgery, the first web space elevation and contracture occurred in 8 cases. Six of them were treated with the amputation of the inner muscle of the thumb and the "Z" forming technique, postoperative thumb function recovered well; the remaining 2 cases rejected plasty. All 9 patients were followed up 14-47 months, with an average of 33 months. Bone lengthening time was 64-122 days, with an average of 86 days. The lengthening length of bone was 3.0-5.9 cm, with an average of 4.1 cm, and the average lengthening length was 71.9% of the average shortened length. The fixation time of external fixator was 169-342 days, with an average of 231 days. The healing index was 43.2-59.1 days/cm, with an average of 53.4 days/cm. One case showed prolonged mineralization delay and recovered after "accordion" treatment. Bone healing was finally achieved in all patients, with the healing time ranging from 169 to 342 days, with an average of 231 days. No replantation internal fixation and flexion contracture occurred. The two-point discrimination of extended fingertip was similar to that of normal fingertip. The grip strength reached 53%-89% of the healthy side; the kneading force reached 59%-91% of the healthy side.

Conclusion

The application of Ilizarov technology to extend the thumb metacarpal lengthening is a good method to reconstruction the thumb function after degloving injury.

Phalangeal Lengthening Techniques for Brachydactily and Posttraumatic Digital Stumps With the Use of a Modified External Mini-Fixator

Distraction osteogenesis has become the most used method for bone lengthening and deformity correction including the bones of the hand and foot. The principle techniques used for hand bone lengthening in posttraumatic and congenital conditions using available external fixators are based on this method. We present the technical specifications and surgical techniques with the use of a mini-fixator that was specially designed for short tubular bones. The surgical techniques of lengthening and web space skin stock creation for future web-pasty are supplied with the diagrams of their application to phalanges and illustrative clinical cases. Between 1999 and 2012, this mini-fixator was used for lengthening of 223 finger segments at our hospital and provided improvement of the hand esthetics and functions.

Digital Lengthening to Treat Finger Deficiency: An Experience of 201 Digits in 104 Patients

Objectives. We evaluated the results of digital lengthening by distraction and second-stage bone graft. Methods. We treated finger deficiency of 201 digits in 104 patients (68 males, 36 females) by digital distraction and second-stage bone graft. The distraction was performed with a rate of 1 mm/day (for the first ten days) and 0.5 mm/day followed by using a self-designed bilateral tubal-helical external fixator. The mean follow-up period was 42 months (range 6 to 60 months). Results. The mean lengthening was 29.2 mm (range 25 to 40 mm) and 18.7 mm (range 12 to 32 mm) for metacarpal bones and phalanges, respectively. The mean elongation rate was 174.4% (range 145% to 202%) and 184.8% (range 115% to 283%) for metacarpal bones and phalanges, respectively. The static two-point discriminations and SpO₂ showed no significant differences before and after distraction. Four complications were observed (two skin ruptures and two phalangeal splitting). No pin tract infection or tendon rupture showed. Digital lengthening improved functions of the hand. Conclusion. Digital distraction and second-stage bone graft is an effective method to compensate disabilities caused by lack of finger length. It could be an alternative plan for patients with thumb deficiency instead of toe-to-thumb transplant and patients with finger deficiency instead of ray resection.

Bone Lengthening in the Pediatric Upper Extremity

➤Bone lengthening has been used successfully for several congenital and acquired conditions in the pediatric clavicle, humerus, radius, ulna, and phalanges.➤Common indications for bone lengthening include achondroplasia, radial longitudinal deficiency, multiple hereditary exostosis, brachymetacarpia, symbrachydactyly, and posttraumatic and postinfectious growth arrest.➤Most authors prefer distraction rates of <1 mm/day for each bone in the upper extremity except the humerus, which can safely be lengthened by 1 mm/day.➤Most authors define success by the amount of radiographic bone lengthening, joint motion after lengthening, and subjective patient satisfaction rather than validated patient-related outcome measures.➤Bone lengthening of the upper extremity is associated with a high complication rate, with complications including pin-track infections, fixation device failure, nerve lesions, nonunion, fracture of regenerate bone, and joint dislocations.

Digital ray reconstruction through distraction osteogenesis: a retrospective study of 82 rays with long-term follow-up

PURPOSE

The aim of the present study was to present the long-term radiographic results with distraction osteogenesis in traumatic or congenital length discrepancies of long bones of the hand.

METHODS

The medical records and radiographs of 65 consecutive patients (27 metacarpals and 55 phalanges) with either traumatic or congenital digital length discrepancies were retrospectively reviewed. The mean follow-up was 8.2 years. The mean distraction period was 21 days with a distraction rate of 4×0.25mm/day. Callus consolidation was obtained in all patients.

RESULTS

The bones were lengthened by a mean amount of 17.5mm, with a mean increase in bone length of 68±17.3%. The mean healing index was 28.57 days/cm. Ray reconstruction with callus distraction can be applied effectively in skeletally immature or mature patients with congenital differences of the hand or amputated fingers.

CONCLUSION

A distraction rate of 1mm/day proved to be a safe rate of lengthening in both metacarpals and phalanges.

Prosthetic rehabilitation of amputated hallux after distraction osteogenesis: one-year follow-up

BACKGROUND

The great toe helps in maintaining body balance during standing, walking, running, dancing, and so on.

CASE DESCRIPTION AND METHODS

A 22 year-old female patient reported to the department, one month after losing her left hallux in a road accident. Anatomical reconstruction was performed with distraction osteogenesis. The prosthesis was constructed using a wax pattern of the normal hallux to create a silicone prosthesis. The residual limb mold was altered to increase prosthesis retention.

FINDINGS AND OUTCOMES

The procedure was economical, conserved materials, and produced lifelike anatomy without requiring artistic expertise.

CONCLUSION

Distraction osteogenesis helped in improving function and retention of the prosthesis. Satisfactory esthetic and functional results were observed at the one-year follow-up.

CLINICAL RELEVANCE

Distraction osteogenesis of the amputated hallux improved prosthetic prognosis by aiding retention. Modifications were made in the conventional prosthesis fabrication technique to increase retention, as the hallux is in constant movement and/or friction.

Percutaneous distraction lengthening in brachymetacarpia

Brachymetacarpia is a condition manifesting a shortened metacarpal that is caused by early closure of the epiphyseal plate and believed to arise idiopathically. The correction for brachymetacarpia is usually for cosmetic reasons as brachymetacarpia does not impair function. The literature indicates several different approaches to lengthening digits, including single-stage lengthening and rapid distraction lengthening with a bone graft. However, gradual distraction is the preferred method due to excellent cosmetic outcomes and few postoperative complications. This article reports a case of brachymetacarpia treated with distraction lengthening using a minimally invasive, percutaneous approach. A 16-year-old girl presented with a shortened left ring finger and underwent surgery to correct the deformity. The left ring finger measured 12 mm shorter than her right ring finger; however, there was normal mobility at the joints. In the operating room, an external fixator was attached using 4 self-drilling, self-tapping pins through several 3-mm skin incisions. The total fixation time was 14 weeks; however, the achieved length of 12 mm was achieved 6 weeks postoperatively. The healing index of the fixation period was 81 days/cm. The postoperative course and fixation period were uneventful, with no complications except for 2 pin infections that were treated with oral antibiotics. The method of gradual distraction lengthening in this case successfully achieved the desired length and yielded an excellent cosmetic result.

Problems, obstacles, and complications of metatarsal lengthening for the treatment of brachymetatarsia

Metatarsal lengthening by distraction osteogenesis is a challenging procedure that is associated with various adverse results. This article presents and classifies adverse results arising from metatarsal lengthening. Our premise of classification is that not all adverse results that occur secondary to distraction osteogenesis of the metatarsal are true complications that affect the final outcome, but rather are problems and obstacles that present hurdles to completion of treatment. Our classification differentiates among problems, obstacles, and complications during metatarsal lengthening with external fixation. The cause of each adverse result is also discussed and clinical and surgical pearls to avoid these problems, obstacles, and complications are presented.