Defining "early" cranioplasty to achieve lower complication rates of bone flap failure: resorption and infection

Subgaleal drains may be associated with decreased infection following autologous cranioplasty: a retrospective analysis

BACKGROUND

Autologous bone is often the first choice in cranioplasty following a decompressive craniectomy. However, infection is a common complication, with reported rates up to 25%. While the incidence and management of infection are well documented, the risk factors associated with infection remain less clear. The current study aims to identify predictors of infection risk following autologous cranioplasty.

METHODS

A retrospective analysis was conducted on patients who underwent decompressive craniectomy and cranioplasty using cryopreserved autologous bone flaps between 2010 and 2020. Patient demographics and factors related to both surgeries and infection rates were recorded from patient records. Logistic regressions were conducted to determine which factors were implicated in the development of infection.

RESULTS

In our cohort, 126 patients underwent autologous cranioplasty. A total of 10 patients (7.9%) developed an infection following reconstruction, with half resulting in implant failure. We did not identify any significant risk factors for infection. Regression analysis identified placement of subgaleal drain following cranioplasty as a protective factor against the development of infection (OR: 0.16, p = 0.007). On average, drains remained in for 3 days, with no difference between the length of drains for those with infection vs. those without (p = 0.757).

CONCLUSIONS

The current study demonstrates an infection rate of 7.9% in patients who receive an autologous cranioplasty following decompressive craniectomy, which is consistent with previous data. Half (4%) of patients who experienced an infection ultimately required removal of the implant. While it is common practice for neurosurgeons to use drains to prevent hematomas and fluid collections, we found that subgaleal drain placement following cranioplasty was associated with decreased infection, thus demonstrating another benefit of a commonly used tool.

Cranioplasty Outcomes from a Tertiary Hospital in a Developing Country

BACKGROUND

Decompressive craniectomy (DC) is a surgical procedure to treat refractory increase in intracranial pressure. DC is frequently succeeded by cranioplasty (CP), a reconstructive procedure to protect the underlying brain and maintain cerebrospinal fluid flow dynamics. However, complications such as seizures, fluid collections, infections, and hydrocephalus can arise from CP. Our aim is to investigate these complications and their possible risk factors and to discuss whether early or late CP has any effect on the outcome.

MATERIALS AND METHODS

A single-center retrospective cohort study was performed, including patients who underwent CP after DC between January 2014 and January 2022. Relevant information was collected such as demographics, type of brain injury, materials used in CP, timing between DC and CP, and postoperative complications. Ultimately, 63 patients were included in our study. We also compared the complication rate between patients who underwent late CP after DC (>90 days) against patients who underwent early CP (<90 days).

RESULTS

Most patients were male (78%). The sample median age was 29 years, with pediatric patients, accounting for 36% of the samples. Overall complication rate was 57% and they were seizure/epilepsy in 50% of the patients, fluid collection (28%), infections (25%), posttraumatic hydrocephalus (17%), and bone defect/resorption (3%). Twenty-two percent of patients with complications required reoperation and underwent a second CP. The median (interquartile range) duration between the craniotomy and the CP was 56 (27-102) days, with an early (≤3 months) percentage of 68%. We found no significant difference between early (≤3 months) and late (>3 months) CP regarding complication rates.

CONCLUSION

Despite CP being a simple procedure, it has a considerable rate of complications. Therefore, it is important that surgeons possess adequate knowledge about such complications to navigate these challenges more effectively.

Autologous Cranioplasty with Bone Flap Preserved in Conventional Freezers: An Adequate Option in Low Resource Settings

BACKGROUND

Autologous cranioplasty has been used for decades and is the gold standard treatment in patients who underwent decompressive craniectomy (DC). One of the most common methods to store the cranial bone flap is cryopreservation at very low temperatures (-70 to -80°). The only way to achieve these low temperatures is by using special freezers which are not always available in all medical facilities, especially in low-resource centers. This paper describes our experience with the storage of cranial bone flaps in freezers of conventional refrigerators.

METHODS

This retrospective study included patients treated with autologous cranioplasty, operated between 2015 and 2020. The cranial bone flap was stored at -18°C in the freezer of conventional refrigerators. Complications and outcomes were analyzed and compared with reports of patients in whom ultra-low temperature freezers were used for bone flap preservation.

RESULTS

Twenty-five patients were included. The average follow-up period was 33 months. Trauma was the most common cause of DC, followed by stroke. The mean age was 36.7. Aseptic bone flap resorption was observed in 4 cases (16%). No cases of infection were observed.

CONCLUSIONS

The use of freezers from conventional refrigerators may be an acceptable alternative for the preservation of the cranial bone flap in facilities where special freezers are not available. The rate of aseptic bone necrosis and infections observed in this paper was similar to the incidence of these complications reported in studies where ultra-low temperatures were used.

Bone Flap Resorption After Cranioplasty: Risk Factors and Proposal of the Flap Integrity Score

BACKGROUND

Bone flap resorption is a known complication of postdecompressive autologous cranioplasty. Although several potential etiopathogenetic factors have been investigated, their role is still under discussion. To further complicate things, resorption is not an all-or-nothing event, patients frequently presenting with different degrees of flap remodeling. Focus of this paper was to describe the elaboration of a score quantifying bone resorption according to a set of clinical and radiological criteria, hopefully allowing prompt identification of patients needing resurgery before the development of adverse events.

METHODS

In a 10-year period, 281 autologous cranioplasties were performed at our institution following decompressive craniectomy. Pertinent clinical and radiological information was registered. A set of 3 clinical and 3 radiological parameters was established to score the degree of resorption, identified under the acronym FIS (Flap Integrity Score). Three groups of patients emerged, respectively showing no (208), partial (32), and advanced (41) resorption.

RESULTS

An overall 14.6% incidence of advanced bone resorption was found in our series. Younger age, bone multifragmentation, higher postcranioplasty Glasgow Outcome Scale scores, <2 cm distance of medial craniectomy border from the midline, and cause leading to decompressive craniectomy were associated to a statistically significant higher risk of developing a relevant bone flap resorption. The first three variables were confirmed as risk factors in multivariate analysis. Flap Integrity Score well discriminated the 3 different groups.

CONCLUSIONS

Autologous bone repositioning is still a valuable, low-cost, cosmetically and functionally satisfactory procedure. Nonetheless, although resorption affects a minor percentage of patients, its early identification and treatment can improve long-term results.

Complications associated with early cranioplasty for patients with traumatic brain injury: a 25-year single-center analysis

OBJECTIVE

Cranioplasty is a technically simple procedure, although one with potentially high rates of complications. The ideal timing of cranioplasty should minimize the risk of complications, but research investigating cranioplasty timing and risk of complications has generated diverse findings. Previous studies have included mixed populations of patients undergoing cranioplasty following decompression for traumatic, vascular, and other cerebral insults, making results challenging to interpret. The objective of the current study was to examine rates of complications associated with cranioplasty, specifically for patients with traumatic brain injury (TBI) receiving this procedure at the authors' high-volume level 1 trauma center over a 25-year time period.

METHODS

A single-institution retrospective review was conducted of patients undergoing cranioplasty after decompression for trauma. Patients were identified and clinical and demographic variables obtained from 2 neurotrauma databases. Patients were categorized into 3 groups based on timing of cranioplasty: early (≤ 90 days after craniectomy), intermediate (91-180 days after craniectomy), and late (> 180 days after craniectomy). In addition, a subgroup analysis of complications in patients with TBI associated with ultra-early cranioplasty (< 42 days, or 6 weeks, after craniectomy) was performed.

RESULTS

Of 435 patients identified, 141 patients underwent early cranioplasty, 187 patients received intermediate cranioplasty, and 107 patients underwent late cranioplasty. A total of 54 patients underwent ultra-early cranioplasty. Among the total cohort, the mean rate of postoperative hydrocephalus was 2.8%, the rate of seizure was 4.6%, the rate of postoperative hematoma was 3.4%, and the rate of infection was 6.0%. The total complication rate for the entire population was 16.8%. There was no significant difference in complications between any of the 3 groups. No significant differences in postoperative complications were found comparing the ultra-early cranioplasty group with all other patients combined.

CONCLUSIONS

In this cohort of patients with TBI, early cranioplasty, including ultra-early procedures, was not associated with higher rates of complications. Early cranioplasty may confer benefits such as shorter or fewer hospitalizations, decreased financial burden, and overall improved recovery, and should be considered based on patient-specific factors.

Ten-Year Institutional Experience to Predict Risk of Calvarial Bone Flap Loss Using Long-Term Outcome Data

BACKGROUND

Calvarial bone flap (CBF) loss is a common complication following craniotomy and subsequent skull reconstruction can be challenging. Defining predictors of CBF failure not only improves patient outcomes but reduces the need for complex reconstruction often requiring plastic surgery consultation. As CBF failure can occur many years following craniotomy, this study aimed to determine risk factors of CBF loss using long-term follow-up.

MATERIALS AND METHODS

This retrospective study included patients who underwent craniotomy with CBF reinsertion between 2003 and 2013 at a tertiary academic institution. Patients were included if demographics, comorbidities, and long-term outcomes were available. Multivariable logistic regression modeled the odds of CBF failure, defined as permanent removal for bone flap-related issues. The median follow-up was 6.9 years (interquartile range: 1.8-10.8 y).

RESULTS

There were 222 patients who met inclusion criteria and underwent craniotomy with CBF reinsertion, primarily for tumor resection or intracranial pressure relief. CBF failure occurred in 76 (34.2%) patients. Up to 4 CBF reinsertions were performed in both failure and nonfailure groups. The risks of CBF loss increased with each additional CBF elevation by 17-fold (P<0.001), male sex by 3-fold (P=0.005), and tumor etiology by 3-fold (P=0.033) (C-index=0.942).

CONCLUSIONS

Each CBF reinsertion dramatically increases the risk of CBF loss. This finding may optimize patient selection and surgical planning. Early multidisciplinary discussions between plastic surgeons and neurosurgeons may avoid multiple CBF elevations and prevent the adverse sequela of high-risk calvarial reconstruction efforts.

A systematic review and meta-analysis of factors involved in bone flap resorption after decompressive craniectomy

Decompressive craniectomy (DC) is effective in controlling increasing intracranial pressure determined by a wide range of conditions, mainly traumatic brain injury (TBI) and stroke, and the subsequent cranioplasty (CP) displays potential therapeutic benefit in terms of overall neurological function. While autologous bone flap (ABF) harvested at the time of DC is the ideal material for skull defect reconstruction, it carries several risks. Aseptic bone flap resorption (BFR) is one of the most common complications, often leading to surgical failure. The aim of our study was to systematically review the literature and carry out a meta-analysis of possible factors involved in BFR in patients undergoing ABF cranioplasty after DC. A systematic review and meta-analysis was performed in accordance with the PRISMA guidelines. Different medical databases (PubMed, Embase, and Scopus) were screened for eligible scientific reports until April 30th 2021. The following data were collected for meta-analysis to assess their role in BFR: sex, age, the interval time between DC and CP, the presence of systemic factors, the etiology determining the DC, CP surgical time, CP features, VP shunt placement, CP infection. Studies including pediatric patients or with less than 50 patients were excluded. Fifteen studies were included. There was a statistically significant increased incidence of BFR in patients with CPF > 2 compared to patients with CPF ≤ 2 (54.50% and 22.76% respectively, p = 0.010). TBI was a significantly more frequent etiology in the BFR group compared to patients without BFR (61.95% and 47.58% respectively, p < 0.001). Finally, patients with BFR were significantly younger than patients without BFR (39.12 ± 15.36 years and 47.31 ± 14.78 years, respectively, p < 0.001). The funnel plots were largely symmetrical for all the studied factors. Bone flap fragmentation, TBI etiology, and young age significantly increase the risk of bone resorption. Further studies are needed to strengthen our results and to clarify if, in those cases, a synthetic implant for primary CP should be recommended.

A Novel Titanium Cranioplasty Technique of Marking the Coronal and Squamosoparietal Sutures in Three-Dimensional Titanium Mesh as Anatomical Positioning Markers to Increase the Surgical Accuracy and Reduce Postoperative Complications

Objective: The objective of this research is to modify the titanium cranioplasty (Ti-CP) technique to increase the surgical accuracy and preliminarily verify the effectiveness and safety of this improvement.

Methods: We developed a novel technique of marking the coronal and squamosoparietal sutures in three-dimensional (3D) titanium mesh as anatomical positioning markers and designed a prospective trial in patients with a unilateral frontotemporoparietal skull defect. Patients were randomly divided into two groups by the presence or absence of the anatomical positioning markers, and the therapeutic effects of these two groups were compared.

Results: Forty-four patients were included in this study, including 28 (64%) males and 16 (36%) females. The mean age was 44.8 ± 15.2 years (range, 13–75 years). Overall postoperative complication rate of the intervention group (18%) was significantly (P = 0.03) lower than the control group (50%). Surgical accuracy of the intervention group (97.8%) was significantly (P < 0.001) higher than the control group (94%). Visual analog scale for cosmesis (VASC) of the intervention group (8.4) was significantly (P < 0.001) higher than the control group (7). The overall postoperative complication rate was 34%. Multivariate analyses showed that surgical accuracy <95.8% (OR = 19.20, 95% CI = 3.17–116.45, P = 0.001) was significantly associated with overall postoperative complications. Independent predictor of overall postoperative complications was surgical accuracy (OR = 0.57, 95% CI = 0.40–0.82, P = 0.002).

Conclusions: This novel technique for repairing frontotemporoparietal skull defects increases surgical accuracy, improves cosmetic prognosis, and reduces postoperative complications. Therefore, it is a safe and effective improvement for Ti-CP.

A Multilayered Dural Repair Technique Using Duragen for Early Cranioplasty Following Decompressive Craniotomy

Decompressive craniotomy is a neurosurgical emergency procedure in which a large skull bone is removed and the dura matter is extensively opened. Duraplasty is required to avoid cerebrospinal fluid (CSF) leakage during the decompressive craniotomy. DuraGen® is a safe and effective type I collagen matrix graft, which is frequently used in decompressive craniotomy procedures. Since DuraGen® does not require labor-intensive suturing, the operative time is shortened by DuraGen® closure with sufficient tightness preventing CSF leakage. Recently, early cranioplasty is preferred to achieve efficient rehabilitation after decompressive craniotomy. Although evidence of efficacy and safety of DuraGen® has been increasing in the management of duraplasty, no reports have previously discussed the condition of DuraGen® during the second surgery (cranioplasty) at this early timing. DuraGen®-derived neodura develops a mature dura 1 year post its placement, and the neodura remain fragile at this early time point. A deconstructed fragile neodura may result in postoperative CSF leakage. Here, we illustrated a multilayered dural repair technique with DuraGen® to avoid disruption of the fragile neodura during early cranioplasty.

Cranioplasty Following Severe Traumatic Brain Injury: Role in Neurorecovery

PURPOSE OF REVIEW

Decompressive craniectomy (DC) is a life-saving procedure performed in refractory intracranial pressure increase and mass lesion due to severe traumatic brain injury (TBI). Cranioplasty primarily intends to maintain cerebral protection and reconstruct aesthetic appearance. Also, cranioplasty can enable neurological rehabilitation and potentially augment neurological recovery. This article reviews recent studies on the effect of cranioplasty on neurological recovery in severe TBI.

RECENT FINDINGS

Recent findings suggested that cranioplasty has the potential to enhance neurological recovery after severe TBI. Cranioplasty may alleviate cognitive and functional deficits by reinstating the regular cerebrospinal fluid dynamics and improving brain perfusion. Analyses on the effects of cranioplasty timing on neurological recovery likely favor early cranioplasty. Also, materials used during cranioplasty, autologous and exogenous, were suggested to have similar effects in recovery. Although neurological therapy of TBI patients is still a serious challenge, recent findings represent the possible enhancing effect of cranioplasty on neurological recovery.

Complications of cranioplasty in relationship to traumatic brain injury: a systematic review and meta-analysis

Despite being a common procedure, cranioplasty (CP) is associated with a variety of serious, at times lethal, complications. This study explored the relationship between the initial injury leading to decompressive craniectomy (DC) and the rates and types of complications after subsequent CP. It specifically compared between traumatic brain injury (TBI) patients and patients undergoing CP after DC for other indications.A comprehensive search of PubMed, Scopus, and the Cochrane Library databases using PRISMA guidelines was performed to include case-control studies, cohorts, and clinical trials reporting complication data for CP after DC. Information about the patients' characteristics and the rates of overall and specific complications in TBI and non-TBI patients was extracted, summarized, and analyzed.A total of 59 studies, including the authors' institutional experience, encompassing 9264 patients (4671 TBI vs. 4593 non-TBI) met the inclusion criteria; this total also included 149 cases from our institutional series. The results of the analysis of the published series are shown both with and without our series 23 studies reported overall complications, 40 reported infections, 10 reported new-onset seizures, 13 reported bone flap resorption (BFR), 5 reported post-CP hydrocephalus, 10 reported intracranial hemorrhage (ICH), and 8 reported extra-axial fluid collections (EFC). TBI was associated with increased odds of BFR (odds ratio [OR] 1.76, p < 0.01) and infection (OR 1.38, p = 0.02). No difference was detected in the odds of overall complications, seizures, hydrocephalus, ICH, or EFC.Awareness of increased risks of BFR and infection after CP in TBI patients promotes the implementation of new strategies to prevent these complications especially in this category of patients.

Cranioplasty with Autologous Bone Flaps Cryopreserved with Dimethylsulphoxide: Does Tissue Processing Matter

OBJECTIVE

The aim of this article was to study the outcome of patients who underwent cranioplasty with cryopreserved autologous bone after decompressive craniectomy.

METHODS

Data from 74 patients were retrospectively analyzed. They were divided into groups according to the storage time and the age at cranioplasty. To assess the predictive potential for complication, factors were related to successive stages (preoperative, craniectomy, tissue processing, cranioplasty, and postoperative). Cooling and warming rates applied on bone flap were calculated. The ability to inhibit microbial growth was determined exposing bone fragments to a panel of microorganisms. The concentration of antibiotics eluted from the bone was also determined. A bone explant culture method was used to detect living cells in the thawed cranial bone.

RESULTS

Hydrocephalus was significantly more frequent in pediatric patients (26.7%) than in adults (5.1%). The overall rate of bone flap resorption was 21.6% (43.7% of which required reoperation). Surgical site infection after cranioplasty was detected in 6.8% of patients. There was no correlation between infection as a postoperative complication and previous microbiological-positive culture during processing. The cause of craniectomy did not influence the risk of bone flap contamination. Vancomycin was the only antibiotic detected in the supernatant where the bone was incubated. Outgrowth from bone explants was observed in 36.8% of thawed skulls. An early start of bone flap processing at the tissue bank had a positive effect on cell viability.

CONCLUSIONS

The outcome after autologous cranioplasty is a multifactorial process, which is modulated by patient-related, surgery-related, and bone-related factors.

The storage of skull bone flaps for autologous cranioplasty: literature review

The use of autologous bone flap for cranioplasty after decompressive craniectomy is a widely used strategy that allows alleviating health expenses. When the patient has recovered from the primary insult, the cranioplasty restores protection and cosmesis, recovering fluid dynamics and improving neurological status. During this time, the bone flap must be stored, but there is a lack of standardization of tissue banking practices for this aim. In this work, we have reviewed the literature on tissue processing and storage practices. Most of the published articles are focused from a strictly clinical and surgical point of view, paying less attention to issues related to tissue manipulation. When bone resorption is avoided and the risk of infection is controlled, the autograft represents the most efficient choice, with the lowest risk of complication. Otherwise, depending on the degree of involvement, the patient may have to undergo new surgery, assuming further risks and higher healthcare costs. Therefore, tissue banks must implement protocols to provide products with the highest possible clinical effectiveness, without compromising safety. With a centralised management of tissue banking practices there may be a more uniform approach, thus facilitating the standardization of procedures and guidelines.

Early cranioplasty associated with a lower rate of post-traumatic hydrocephalus after decompressive craniectomy for traumatic brain injury

BACKGROUND

Post-traumatic hydrocephalus (PTH) is one of the primary complications during the course of traumatic brain injury (TBI). The aim of this study was to define factors associated with the development of PTH in patients who underwent unilateral decompressive craniectomy (DC) for TBI.

METHODS

A total of 126 patients, who met the inclusion criteria of the study, were divided into two groups: patients with PTH (n = 25) and patients without PTH (n = 101). Their demographic, clinical, radiological, operative, and postoperative factors, which may be associated with the development of PTH, were compared.

RESULTS

Multivariate logistic regression analysis revealed that cranioplasty performed later than 2 months following DC was significantly associated with the requirement for ventriculoperitoneal shunting due to PTH (p < 0.001). Also, a significant unfavorable outcome rate was observed in patients with PTH at 1-year follow-up according to the Glasgow Outcome Scale-Extended (p = 0.047).

CONCLUSIONS

Our results show that early cranioplasty within 2 months after DC was associated with a lower rate of PTH development after TBI.

Aseptic bone-flap resorption after cranioplasty - incidence and risk factors

Objective

One of the common complications occurring after cranioplasty (CP) is aseptic bone-flap resorption (ABFR). Reoperation necessary because of the development of ABFR can lead to unfavorable complications during subsequent surgery using a synthetic skull implant, and also necessarily leads to higher costs. The aim of this study is to identify prognostic factors that may help to predict the development of ABFR.

Methods

In this study, 303 CP surgeries performed between 2002 and 2017 were examined retrospectively to identify factors predicting the occurrence of ABFR. A number of these factors (e.g., time lapse between decompressive craniectomy (DC) and CP, bone-flap size, specific laboratory signs, and the reason for the original DC) were analyzed as possibly influencing the risk of developing ABFR.

Results

ABFR of an autologous bone flap that subsequently required a CP with synthetic skull implants occurred in 10 of 303 patients (3.0%). CP timing and patients' Karnofsky Performance Scores (KPS) (p = 0.008; p = 0.012) were identified as significant factors with an impact on the development of ABRF. Age did not reveal a significant value, but statistical analysis shows a clear trend. The younger the age, the more likely it was that an ABFR would develop.

Conclusion

The risk of ABFR lessens the longer the period of time elapsed between DC and CP. Age does not reveal a significant value, but statistical analysis shows that there is a clear trend.

Deformation of cranioplasty titanium mesh in a paediatric patient following head trauma

Decompressive craniectomy is a life-saving procedure performed to treat intracranial hypertension caused by a variety of conditions. Subsequent cranioplasty reconstruction is needed for brain protection. Different alloplastic materials with different advantages and disadvantages are available for cranial reconstruction. We present the first case of a deformed titanium cranioplasty mesh in a paediatric patient following head trauma. Children who have undergone cranioplasty reconstruction should be counselled to wear a protective helmet when involved in contact sports or activities that may put their implant at risk of trauma.