Effect of edible surface coatings followed by dehydration on some quality attributes and antioxidants content of raw and blanched tomato slices

Effect of gum Arabic and ethanol pretreatments on drying kinetics and quality attributes of dried carrot slices

Carrot is an important root vegetable to the food industry and consumers due to its nutritional and health benefits. Given the high moisture content and low shelf life of fresh carrots, preserving this highly demanded vegetable is vital. This current research modelled the drying kinetics and evaluated the quality of ultrasonic-assisted gum Arabic and ethanol pretreated and oven-dried carrot slices. Fresh carrots were processed into thin slices and immersed in 3% gum Arabic (GA), ethanol (99.9%), and distilled water (control), followed by ultrasonication (frequency: 50 Hz, power: 500 W, temperature: 25 °C) for 10 min and drying in a hot air oven at 50 °C. The loss of moisture from the carrots was periodically recorded, converted to moisture ratio before fitted to eleven semi-theoretical thin layer drying mathematical models. The effects of the pretreatments on the retention of bioactive compounds and carrots' physical and chemical properties were also evaluated. From the tested models, the Diffusion, Modified Henderson and Pabis, and Two-term models showed the best fitting (R2 = 0.9944-0.9985; RSME = 0.0103-0.0227) to the experimental data from 3% GA and ethanol pretreated carrots, while control samples followed the Aghbasho model (R2 = 0.9999; RMSE = 0.0033). Overall, the 3% GA pretreated carrot slices exhibited better colour (yellowness: 25.82-34.50; total colour differences: 8.12-13.06), water activity (0.37-0.44), total phenolic content (1.34-2.99 mg GAE/100 g DM), β-carotene (7.63-13.07 mg/100 g DM), and DPPH radical scavenging activity (5.67-8.02 mM AAE/100 g DM) than ethanol pretreated carrot slices and control samples. At the same time, 3 % GA pretreatment did not affect the drying rate of the carrot slices. The total soluble solids/titratable acidity ratio, rehydration capacity, and shrinkage ratio did not significantly (p > 0.05) vary among the treatments. The findings of this study can be used to develop an optimal drying protocol for pretreated carrot slices and to produce shelf-stable carrot products that can be used dried, rehydrated, or in combination with other products.

Effect of different drying methods on quality attributes of beetroot (Beta vulgaris) slices

Purpose

The purpose of this paper is to evaluate the effect of different drying methods on quality attributes of beetroot slices.

Design/methodology/approach

Three drying methods (sun, oven and freeze-drying) were applied to dry fresh slices of beetroot cultivar (Beta vulgaris). The chemical composition, minerals, nitrate, betalains, total phenolic, total flavonoid and color were measured for fresh and dried slices.

Findings

The chemical composition, minerals, nitrate, bioactive compounds and color were measured for fresh and dried slices. Regardless of the drying method, the results showed that the chemical composition, total energy, minerals and nitrate of the dried slices were significantly (p=0.05) increased compared to that of fresh slices. Sun and oven drying of the slices significantly (p=0.05) reduced total betalain and betacynin. However, betaxanthin was significantly (p=0.05) increased. Total phenolics content of fresh beetroot was significantly (p=0.05) increased after sun and oven drying but total flavonoids were decreased. The 2,2,-diphenyl-2-picryl-hydrazyl (DPPH) of fresh beetroot was increased significantly (p=0.05) after sun and oven drying. The measurement of the color of the powder showed that there is a decrease in lightness (L) depending on the drying method applied. A maximum reduction in lightness was observed in powder of sun-dried slices. The color of the powder obtained from freeze-dried slices was stable compared to other drying methods.

Practical implications

Beetroot is a rich source of nutrients but with short shelf life. Dried beetroot has more keeping quality than the fresh one.

Originality/value

The study uses beetroot as a rich source of nutrients as well as natural antioxidant source. Betalain compounds are preserved in beetroot and a high source of phenolics and flavonoids. Flavonoids are a group of phenolic products of plant metabolism with high antioxidant properties to protect against diseases without side effects.