Production of 5-Hydroxymethylfurfural from Starch Through an Environmentally-Friendly Synthesis Pathway

Catalytic Conversion of Carbohydrates into 5-Hydroxymethylfurfural by Phosphotungstic Acid Encapsulated in MIL-101 (Cr, Sn) Catalyst in Deep Eutectic Solvents

Herein, we report the synthesis of bimetal-organic frameworks (BMOFs) with both Brønsted and Lewis acidities, in which phosphotungstic acid (PTA) was encapsulated in BMOFs. It is efficient in converting starch to 5-hydroxymethyl-furfural (HMF) in deep eutectic solvents (DESs) such as choline chloride and formic acid. The highest yield of HMF (37.94%) was obtained using P_0.5/BMOFs_1.0 to catalyze starch in a mixed solvent system comprising DESs and ethyl acetate (EAC) (v/v; 2:3) at 180 °C and a reaction time of 10 min. Employing a DES as a cocatalyst and solvent reduced the use of organic solvents. The catalyst showed adequate reusability, and the HMF yield only decreased by 2.88% after six cycles of reuse compared with that of the initial catalyst. This study demonstrates the application potential of BMOFs in the conversion of biomass to useful molecules with commercial and/or research value.

Synthesis, characterization, DFT studies, and adsorption properties of sulfonated starch synthesized in deep eutectic solvent

In this study, sulfonated starch (SS) was successfully synthesized using sulfamic acid as a sulfonating agent in a deep eutectic solvent (DES). Four-factor and three-level orthogonal experiments were conducted to determine the optimal preparation conditions, which were found to be a molar ratio of starch to urea of 1:20, a reaction temperature of 90 °C, a reaction time of 5 h, and a stirring speed of 200 rpm. The sulfonation reaction mechanism was extensively studied using various techniques, including Fourier transform infrared spectroscopy, elemental analysis, X-ray diffraction, molecular weight, particle distribution, X-ray photoelectron spectroscopy, scanning electron microscopy, and DFT calculations. The results showed that the sulfonation reaction slightly damaged starch granules, occurred on the surface of starch granules, and on the O6 atoms of the glucose unit. SS exhibited a wide pH range of application (5-10), a fast adsorption rate (400 s to reach adsorption equilibrium), and a high adsorption capacity (118.3 mg/g) under optimal conditions. The adsorption process of SS for methylene blue followed the pseudo-first-order kinetic model and was consistent with the Langmuir model, which was endothermic and spontaneous. The adsorption process was attributed to hydrogen bonding and electrostatic interactions.

PolyE-IL Is an Efficient and Recyclable Homogeneous Catalyst for the Synthesis of 5-Hydroxymethyl Furfural in a Green Solvent

5-Hydroxymethyl furfural (5-HMF) is a potential platform molecule with multidimensional applications and can be produced from biomass-based hexose sugars. In the present article, polyethyleneimine (PEI)-functionalized polymeric Bronsted acid ionic liquid (PolyE-IL) catalyst has been explored for fructose dehydration in the presence of isopropyl alcohol (IPA) as a green and low-boiling-point (LBP) organic solvent. The use of homogeneous PolyE-IL catalyst provides several specific advantages in terms of high yield, conversion, selectivity, ease of catalyst separation, recycle and reuse, and so forth. PEI with various Bronsted acid counterions such as H₂SO₄, H₃PO₄, TsOH, TfOH, and TFA provides the corresponding variables of PolyE-IL such as [PEI]⁺[HSO₃]^-, [PEI]⁺[H₂PO₄]^-, [PEI]⁺[CF₃CO₂]^-, [PEI]⁺[TfO]^-, and [PEI]⁺[TsO]^-, which are tested for fructose dehydration in the presence of IPA. Of the tested catalysts, only PolyE-IL with [HSO₄]^-, [CF₃CO₂]^-, [TfO]^-, and [TsO]^- counterions showed the formation of 5-HMF. [PEI]⁺[HSO₄]^- showed the maximum yield of 5-HMF (61%) and selectivity (70%) with (87%) fructose conversion. Thus, further process optimization study was conducted to obtain the maximum yield, conversion, and selectivity. The intensified process provides a maximum yield of 5-HMF of 75% with 85% fructose conversion and 90% selectivity. The catalyst recyclability study showed the consistency in 5-HMF yield (75%), conversion (85%), and selectivity (90%) for five consecutive recycle runs. However, the study of reaction kinetics showed the first-order kinetics with an activation energy of 12.4 kJ/mole by using [PEI]⁺[HSO₄]^- catalyst. Thus, the use of an easily recyclable and robust catalyst provides an efficient route for production of 5-HMF in the presence of a green solvent.

Effect of steaming process on the structural characteristics and antioxidant activities of polysaccharides from Polygonatum sibiricum rhizomes

Polygonatum sibiricum (P. sibiricum) rhizomes are widely used as a tonic and functional food, and are often processed to enhance their tonic function by repeated steaming and drying. As the most important constituent, the polysaccharide from P. sibiricum rhizomes (PSP) has demonstrated various activities, but the alteration of structural characteristics and activities of the purified PSPs during steaming process was rarely investigated. To well understand the effect of steaming process on the polysaccharides of P. sibiricum, neutral polysaccharides from P. sibiricum rhizomes (PSP0 ~ PSP9) after steaming were first isolated and purified, and then the chemical properties and antioxidant activities were determined. The results showed that the molar ratios of monosaccharides in PSPs were different. The molecular weights of PSPs were increased significantly after the fourth steaming. Morphological studies showed that the surface of PSPs became much tighter during the steaming process. Fourier transform infrared spectroscopy spectra displayed the polysaccharides had similar backbones and chemical groups. Furthermore, the antioxidant activity of PSPs was measured through radical scavenging tests. It was found that the radical scavenging activity of PSPs was elevated strikingly after steaming, and increased gradually with numbers of steaming process. The biological and chemical variance of PSPs revealed considerable segregation of PSP0, PSP1 ~ PSP4 and PSP5 ~ PSP9. In conclusion, our results proposed the fourth time as the optimal number of steaming to extract functional polysaccharide from P. sibiricum rhizomes.