Analysis of ecotoxic influence of waste from the biomass gasification process

Experimental research of oily sawdust air gasification

This article shows oily sawdust gasification research on countercurrent installation. Experimental research was on a laboratory scale. The main purpose of the experiment was combustible gas production with higher CH₄ concentration. Gas concentrations like CO, CO₂, CH₄, H₂, and C_nH_m determine syngas composition. The technological parameter's value defines experimental conditions. Value of this was fuel to air ratio. With fuel to air ratio change, syngas composition was a differential phenomenon where it depended on the process parameters like temperature. Additionally, evaluation of methane formation from CO, H₂, and CO₂ was done. Methanization coefficients were based on CO and CO₂ hydrogenation reactions. Component's activity was in analogs way to syngas components changed.

Gasification of Cup Plant (Silphium perfoliatum L.) Biomass–Energy Recovery and Environmental Impacts

Biomass from cup plant (Silphium perfoliatum L.) is considered a renewable energy source that can be converted into alternative fuel. Calorific syngas, a promising type of advanced fuel, can be produced through thermochemical biomass gasification. In this study, the suitability of cup plant biomass for gasification was assessed, including the process energy balance and environmental impacts of waste from syngas purification. Silphium perfoliatum L. was cultivated as a gasification feedstock in different conditions (irrigation, fertilization). The experiments were performed in a membrane gasifier. All obtained energy parameters were compared to the biomass yield per hectare. The toxic effects of liquid waste were assessed using tests analyzing germination/seed root elongation of Sinapsis alba. Leachates collected from condensation tanks of a gas generator were introduced to soil at the following doses: 100, 1000 and 10,000 mg kg−1 DM of soil. The usefulness of Silphium perfoliatum L. for gasification was confirmed. The factors of plant cultivation affected the biomass yield, the volume and calorific value of syngas and the amount of biochar. It was determined that the components found in condensates demonstrate a phytotoxic effect, restricting or inhibiting germination and root elongation of Sinapsis alba. Due to this potential hazard, the possibility of its release to the environment should be limited. Most of the biomass is only used for heating purposes, but the syngas obtained from the cup plant can be used to power cogeneration systems, which, apart from heat, also generate electricity.

Chemical Characteristics of Biomass Ashes

The aim of the conducted research was to obtain information on the main components of ashes from 35 biomass species used in combustion processes to obtain reference data for the development of utility possibilities for these ashes, with particular emphasis on agricultural use. The examined biomass samples were divided into groups depending on origin: woody biomass and energetic woody plants I-WWB, herbaceous and grassy energy plants II-EC, agricultural waste III-AR, forest waste IV-FR and waste from the agri-food industry V-AFIW. The analysis of the studied elements contents was carried out in the designated groups. The chemical composition of ash was dominated by the macroelements Ca, K, P and S, which suggests the possibility of their agricultural use. At the same time, the low content of toxic elements such as As and Pb should not be a limiting feature in their use, with the exception of wood biomass. In addition, ashes obtained from the biomass combustion were enriched with microelements such as Zn, Cu and Mn, which further increases their possibilities of fertilizer use. The potential use of ash from each type of biomass in the aspect of its chemical composition should be considered individually, regardless of the division into groups depending on the origin of biomass.