Nitrogen and phosphorus removal from wastewater by sand with wheat straw

Synergistic treatment of digested wastewater with high ammonia nitrogen concentration using straw and microalgae

Microalgae as a promising approach for wastewater treatment, has challenges in directly treating digested piggery wastewater (DPW) with high ammonia nitrogen (NH4+-N) concentration. To improve the performance of microalgae in DPW treatment, straw was employed as a substrate to form a straw-microalgae biofilm. The results demonstrated that the straw-microalgae biofilm achieved the highest NH4+-N removal rate of 193.2 mg L-1 d-1, which was 28.8 % higher than that of culture system without straw. The final NH4+-N concentration in the effluent met the discharge standard of 5 mg L-1. Furthermore, the total organic carbon (TOC) released from straw facilitated bacterial proliferation and the secretion of extracellular polymeric substances (EPS). The EPS and TOC increased the suspension viscosity and surface tension, thereby enhancing the residence time of CO2 in the liquid phase and promoting CO2 fixation. This study presented a novel method for the biological treatment of high-ammonia-nitrogen DPW.

Scaling-up of the adsorption process of ammonia nitrogen onto expanded vermiculite using fixed-bed columns

Expanded vermiculite was used as an adsorbent to remove ammonia nitrogen from landfill leachate. Bench and pilot-scale adsorption experiments were performed with leachate collected from a closed sanitary landfill located in Curitiba, southern Brazil. At the bench-scale, two different heights of vermiculite and three different flow rates were tested using a fixed-bed column. These tests produced an average uptake capacity of 33.4 mg g^-1 for the ammonia nitrogen concentration of 2,560 mg L^-1. The Yan model was used to determine the breakthrough and the exhaustion times due to the best fit of the data to this model. At the pilot-scale, the flow rate was determined from the shortest length of the mass transfer zone obtained from bench-scale experiments. Tests were performed using one stainless-steel column filled with 26.2 kg of expanded vermiculite, which resulted in a bed height of 1.6 m. A leachate flow rate of approximately 350 L d^-1 was applied to achieve the required contact time of 8.3 h. At this scale, an average uptake capacity of 18.1 mg g^-1 was obtained for the ammonia nitrogen concentration of 1,193 mg L^-1. It is worth mentioning that the flow rate and the concentration of the adsorbate in the feeding solution are fundamental to improve the operational time of the fixed-bed column. The main goal of this research was the determination of operating conditions to scale-up the adsorption process of ammonia nitrogen onto expanded vermiculite. The contact time was a key parameter to reach this goal.

Competitive adsorption of nitrate, phosphate, and sulfate on amine-modified wheat straw: In-situ infrared spectroscopic and density functional theory study

Amine-modified wheat straw (AMWS) has already been reported as a promising adsorbent for nitrate (NO₃) removal due to its cost-effectiveness and high efficiency. However, the NO₃ removal mechanism has not been well understood, especially in the presence of co-existing ions. Here, the effect of co-existing anions on NO₃ removal by AMWS was investigated and the underlying mechanisms were revealed using a combination of in-situ infrared (IR) spectroscopy and computational modeling. The in-situ IR results indicated that NO₃, sulfate (SO₄), and phosphate (PO₄) are all adsorbed as outer-sphere complexes on AMWS. The two-dimensional-correlation spectroscopy analysis implied the adsorption sequence of SO₄ > PO₄ > NO₃. The adsorption energies obtained from density functional theory calculation range from -0.24 to 0.51 eV (-23.2 to 49.2 kJ/mol), confirming that these anions adsorb on AMWS as outer-sphere complexes. For the first time, this study provides direct spectroscopic evidence of the outer-sphere adsorption of NO₃ on AMWS, as well as identifies the adsorption sequence, confirmed by computational modeling. The competitive mechanism of NO_3, SO₄, and PO₄ revealed in this study is helpful to understand and predict the applications of AMWS.

Study on Water Purification Effect and Operation Parameters of Various Units of Wastewater Circulation

The discharge of wastewater from aquaculture ponds causes a certain degree of damage to the environment. It is necessary to continuously improve the treatment efficiency of wastewater treatment devices. The purpose of this study is to obtain an optimal ratio of wastewater circulation devices in order to obtain the best operating parameters and to reduce the discharge of polluted water. We constructed an experimental wastewater circulation device consisting of three units. The primary unit contained modified attapulgite (Al@TCAP-N), volcanic stone, and activated carbon for precipitation. The secondary and tertiary units used biological methods to enhance removal rates of nitrogen and phosphorus. Water quality indicators of total phosphorus (TP), total nitrogen (TN), ammonia (NH3-N), permanganate (CODMn), and total suspended solids (TSS) were detected. Water quality was tested under different matching ratios for three units of different hydraulic retention time (HRT) and load Results showed that the removal rate of TP, TN, NH3-N, and TSS reached 20–60%, 20%, 30–70%, and 10–80%, respectively. The average reduction efficiencies of secondary module chlorella and filler on TP, TN, NH3-N, CODMn, and TSS were 56.88%, 30.09%, 0.43%, 46.15%, and 53.70%, respectively. The best removal rate can be achieved when the matching ratio of each unit becomes 2:1:1 and the hydraulic retention time is maintained within 2 h in the high-concentration load. Finally, the average removal rates of TP, TN, NH3-N, and TSS reached 58.87%, 15.96%, 33.99%, and 28.89%, respectively. The second unit obtained the enhanced removal effect in this wastewater treatment system when adding microorganisms and activated sludge.

Wheat straw decomposition stage has little effect on the removal of inorganic N and P from wastewater leached through sand-straw mixes

Wheat straw amendment to sandy soil can remove nitrogen (N) and phosphorus (P) from wastewater but it is unclear whether prior decomposition affects removal. Sand mixed with finely ground wheat straw at 12.5 g straw kg^-1 was placed in leaching columns. Wastewater was added either immediately after mixing with straw (fresh straw) or after the sand-straw mix had been incubated moist for 7 or 14 days (7D or 14D straw). Sand alone was considered as control. Leaching was carried out 4, 8 or 16 days after addition of wastewater and inorganic N and P were analysed after leaching in both leachate and sand. In the amended treatments, nitrate and available P in the sand-straw mix were not detectable throughout the experiment. On day 16, inorganic N in the sand-straw mix was highest in fresh straw where it was three-fold higher than in 14D straw and 30% higher than in sand alone and 7D straw on day 16. Straw decomposition stage had no consistent effect on microbial biomass N and P. Released CO₂ was lower in 14D straw than in fresh straw and 7D straw. With straw amendment, > 95% of inorganic N added with wastewater was removed compared to 40-50% with sand alone. Inorganic P leaching was reduced by about 30% compared to sand alone on day 16. In conclusion, wheat straw addition reduced leaching of N compared to sand alone, but the decomposition stage of the straw had little effect on the removal of N and P from wastewater.