Solubility of astaxanthin in supercritical carbon dioxide

Extraction of Valuable Biomolecules from the Microalga Haematococcus pluvialis Assisted by Electrotechnologies

The freshwater microalga Haematococcus pluvialis is well known as the cell factory for natural astaxanthin, which composes up to 4-7% of its total dry weight. The bioaccumulation of astaxanthin in H. pluvialis cysts seems to be a very complex process that depends on different stress conditions during its cultivation. The red cysts of H. pluvialis develop thick and rigid cell walls under stress growing conditions. Thus, the biomolecule extraction requires general cell disruption technologies to reach a high recovery rate. This short review provides an analysis of the different steps in H. pluvialis's up and downstream processing including cultivation and harvesting of biomass, cell disruption, extraction and purification techniques. Useful information on the structure of H. pluvialis's cells, biomolecular composition and properties and the bioactivity of astaxanthin is collected. Special emphasis is given to the recent progress in application of different electrotechnologies during the growth stages and for assistance of the recovery of different biomolecules from H. pluvialis.

Quality and Shelf Life of White Shrimp (Litopenaeus vannamei) Processed with High-Pressure Carbon Dioxide (HPCD) at Subcritical and Supercritical States

Phase changes of carbon dioxide (supercritical or subcritical) depend on its proximity to a pressure of 7.35 MPa and temperature of 31.1°C. Carbon dioxide becomes supercritical and subcritical when it is above and slightly below its critical point, respectively. This study aims to determine the effect of high-pressure CO2 treatments at a pressure of 900 psi, 950 psi (subcritical), and 1100 psi (supercritical) and at holding times of 5, 10, and 15 min on the quality parameters of white shrimp (Litopenaeus vannamei) and to determine the shelf life of white shrimp processed with the best treatment. The results showed that the interaction between pressure and holding time had a significant $\left(p<0.05\right)$ effect on cholesterol, protein, moisture content, and $b\ast$ value, but pressure had a significant effect on carotene content. The best treatment was a supercritical CO2 treatment at 1100 psi for 10 min, which was determined based on a significant reduction in the number of microorganisms and no significant changes in color, texture, and fat content were observed compared with control. The best treatment was applied to process shrimps, which were then stored at 4°C to evaluate the effectiveness of scCO2 treatment on the shelf life. No significant changes were found in PV and lipid in treated and scCO2-treated shrimps during storage, but the treatment significantly affected pH, TVBN, and microbial counts. Among the samples, there was no hedonic difference in all sensory attributes. Supercritical CO2 treatment at 1100 psi for 10 min can be an alternative method for preservation of shrimps.

Ultrahigh-pressure supercritical fluid extraction and chromatography of Moringa oleifera and Moringa peregrina seed lipids

An ultrahigh-pressure supercritical fluid extraction method was optimized and applied to extract seed oil lipids from two moringa species, namely Moringa oleifera (MO) and Moringa peregrina (MP). A full-factorial design was used to investigate the direct and interaction influence of pressure and temperature in the range of 40 to 80 MPa and 40 to 70 °C, respectively, on the extracted amount of oil from crushed seeds. The results revealed that pressure has a significant positive influence on the extracted amount of oil. The best extraction condition using neat CO₂ was found at 80 MPa and 57 °C, yielding 396 ± 23 and 529 ± 26 mg oil per gram of seeds for MO and MP, respectively. An extraction kinetics study revealed a mainly solubility-controlled extraction of oil, and 28 g of CO₂ was required to extract 400 mg of oil per gram of seeds of MO using the developed method. Addition of ethanol to the sample prior to the extraction increased the proportion of extractable polar lipids as well as the total amount of extracted oil. The developed method increased the extracted amount of oil twofold compared to a reference method based on solvent sonication. The obtained oil consisted mainly of glycerolipids, sterol esters, and phospholipids. Phospholipids, campesterol, and stigmasterol ester concentrations were found to be higher in MO while cholesterol ester was more abundant in MP.