Complement activation during cardiopulmonary bypass: effects of immobilized heparin

Complement activation during cardiopulmonary bypass and association with clinical outcomes

In this prospective, single-centre observational study of 30 patients undergoing cardiopulmonary bypass (CPB), the effect of unfractionated heparin (UFH), CPB surgery and protamine sulphate on complement and on post-operative blood loss were assessed. Although C3 and C4 levels decreased significantly immediately following the administration of UFH, C3a, C5a, Bb fragment and SC5b-9 remained unchanged. During CPB, C3 and C4 continued to fall whilst both alternative and classical pathways activation markers, Bb, C3a, C5a and SC5b-9 increased significantly. Protamine sulphate had no effect on classical pathway components or activation markers but decreased alternative pathway activation marker Bb. Over the 12-24 h post-surgery, both classical and alternative pathway activation markers returned to baseline, whilst C3 and C4 levels increased significantly but not to baseline values. Total drain volume 24 h after the surgery showed a moderate inverse correlation with post-protamine C3 (r = -0.46, p = 0.01) and C4 (r = -0.57, p = 0.0009) levels, whilst a moderate positive correlation was observed with post-protamine C3a (r = 0.46, p = 0.009), C5a (r = 0.37, p = 0.04) and SC5b-9 (r = 0.56, p = 0.001) levels but not with Bb fragment (r = 0.25, p = 0.17). Thus, inhibition of complement activation may be a therapeutic intervention to reduce post-operative blood in patients undergoing CPB.

Ex Vivo Testing of Heparin-Coated Extracorporeal Circuits: Bovine Experiments

In this study the intrinsic thrombogenicity of the extracorporeal circuits and the benefit of heparin-bonded circuits in an extracorporeal life support system without full systemic heparinization and with minimal interference of the so called material-independent factors was tested in four calves. In two circuits (group A) all blood-contacting surfaces were coated with end-point-attached heparin and the other two were non-coated (group B). Under standardized conditions the calves were perfused at a blood flow rate of 2 L/min. After only one bolus injection of heparin (250 IU/kg body weight) before cannulation, plasma heparin activity rapidly decreased in both groups: half life of about 55 minutes. This decrease of the heparin activity was accompanied by a fall of the activated clotting time (ACT) level to baseline values. The experiments using a heparin-coated circuit, had a runtime of more than 360 minutes, whereas the experiments using a non-coated circuit had to be terminated after a runtime of 255 minutes, because massive fibrin formation was noticed in the circuit. This formation was accompanied by a rapid increase in the line pressure, measured just before the inlet of the oxygenator. The macroscopic inspections after terminating the experiments and rinsing the circuit showed a clean circuit in group A. The fibrinopeptide A (FPA) level increased faster during perfusion with the non-coated circuit than in the heparin coated circuit. Lung histopathological examinations of the lungs of the animals in group A showed no fibrin deposition, whereas most of the blood vessels of the lung preparations of the animals in group B were partially or completely occluded with fibrin. These results suggest that heparin-bonding greatly reduces the thrombogenicity of the extracorporeal circuit, and therefore it can reduce the need for systemic heparinization in an extracorporeal life support system.

Performance of polymethyl pentene oxygenators for neonatal extracorporeal membrane oxygenation: a comparison with silicone membrane oxygenators

Objective: To review the performance of polymethyl pentene versus silicone oxygenators in terms of efficiency in priming and oxygenation, oxygenator resistance, requirements for coagulation proteins and consumption of blood products, for neonatal extracorporeal membrane oxygenation (ECMO) patients.

Study design: Forty consecutive neonates were selected retrospectively pre- and post-introduction of the new polymethyl pentene (PMP) oxygenators. They formed two equal groups. After calculation of the sample size, data were collected from ELSO registry forms and patient records. Results were analysed using parametric and non-parametric tests.

Results: Neonatal PMP (N-PMP) oxygenators were smaller, faster and easier to prime. They were less efficient than silicone oxygenators, especially in carbon dioxide elimination, and, therefore, required higher sweeps. The preservation of coagulation proteins was significantly better, but there was no reduction in the consumption of blood products, despite having less than half the surface area and significantly lower blood path resistance.

Conclusion: Small PMP oxygenators (Medos Hilite 800 LT) provide adequate gas exchange and offer technical advantages in terms of more efficient priming, reduced haemodynamic resistance and better control and preservation of coagulation proteins than silicone oxygenators.

Currently available biomaterials for use in cardiopulmonary bypass

Cardiopulmonary bypass (CPB) represents one of the most important technical innovations in healthcare history, yet the systemic responses to CPB remain a fundamentally unresolved problem. Study of the blood-biomaterial interaction and development of biocompatible materials is intimately related to efforts to optimize patient outcome following CPB. This article reviews the design innovations in biomaterial surfaces that have been introduced into clinical practice in an attempt to ameliorate the detrimental consequences of CPB, contrasting the actual clinical improvements and patient benefits achieved against those predicted on the basis of theory and in vitro testing. Some discussion of the underlying mechanisms of action as presently understood is provided and the current limitations of biomaterial-dependent strategies to improve outcome following CPB are addressed.

CD62L (L-selectin) shedding for assessment of perioperative immune sensitivity in patients undergoing cardiac surgery with cardiopulmonary bypass

OBJECTIVE

To investigate the suitability of blood granulocyte and monocyte sensitivity, as measured by the quantity of different agonists required to induce CD62L shedding, for assessment of perioperative immune changes in patients undergoing cardiac surgery with cardiopulmonary bypass.

METHODS

Patients scheduled for aortocoronary bypass grafting or for valve surgery were included in this prospective observational study. Blood samples were drawn before anesthesia induction, directly after surgery and 48 hours after anesthesia induction. We determined the concentration of two different inflammatory stimuli--lipoteichoic acid (LTA) and tumor necrosis factor alpha (TNF)--required to induce shedding of 50% of surface CD62L from blood granulocytes and monocytes. In parallel monocyte surface human leukocyte antigen (HLA)-DR, and plasma interleukin (IL)-8, soluble (s)CD62L, soluble (s)Toll-like receptor (TLR)-2 and ADAM17 quantification were used to illustrate perioperative immunomodulation.

RESULTS

25 patients were enrolled. Blood granulocytes and monocytes showed decreased sensitivity to the TLR 2/6 agonist Staphylococcus aureus LTA immediately after surgery (p = 0.001 and p = 0.004 respectively). In contrast, granulocytes (p = 0.01), but not monocytes (p = 0.057) displayed a decreased postoperative sensitivity to TNF. We confirmed the presence of a systemic inflammatory response and a decreased immune sensitivity in the post-surgical period by measuring significant increases in the perioperative plasma concentration of IL-8 (p ≤ 0.001) and sTLR (p = 0.004), and decreases in monocyte HLA-DR (p<0.001), plasma sCD62L (p ≤ 0.001). In contrast, ADAM17 plasma levels did not show significant differences over the observation period (p = 0.401).

CONCLUSIONS

Monitoring granulocyte and monocyte sensitivity using the "CD62L shedding assay" in the perioperative period in cardiac surgical patients treated with the use of cardiopulmonary bypass reveals common changes in sensitivity to TLR2/6 ligands and to TNF stimulus. Further long-term follow-up studies will address the predictive value of these observations for clinical purposes.

A randomized study of coronary artery bypass surgery performed with the Resting Heart™ System utilizing a low vs a standard dosage of heparin

OBJECTIVES

Allogeneic blood transfusion and reoperation for postoperative bleeding after the coronary artery bypass grafting have a negative impact on the patient outcome. This study aimed at evaluating the effects of reduced doses of heparin and protamine on the patient outcome, using a heparin-coated mini-cardiopulmonary bypass (CPB) system.

METHODS

Sixty patients undergoing elective first-time CPB were prospectively randomized either to have a reduced systemic heparinization [activated clotting time (ACT) = 250 s] or to a control group perfused with a full heparin dose (ACT = 420 s). Blood transfusions, ventilation time, early postoperative bleeding, ICU stay, reoperations for bleeding, postoperative cognitive status and the level of mobilization were registered.

RESULTS

Twenty-nine patients were randomized to the control group, 27 patients to the low-dose group and 4 patients were excluded because of protocol violations. Four patients in the control group received a total of 10 units of packed red blood cells, and in the low-dose group, no transfusions were given, P = 0.046. No patient was reoperated because of bleeding. The ICU stay was significantly shorter in the low-dose group (8.4 vs 13.7 h, P = 0.020), less dependent on oxygen on the first postoperative day (78 vs 97%, P = 0.034), better mobilized (89 vs 59%, P = 0.006) and had less pain (visual analogue scale 2.0 vs 3.5, P = 0.019) compared with the control group.

CONCLUSIONS

The use of a mini-CPB system combined with a low dose of heparin reduced the need for blood transfusions and may facilitate the faster mobilization of the patients.

The artificial surface-induced whole blood inflammatory reaction revealed by increases in a series of chemokines and growth factors is largely complement dependent

Exposing blood to an artificial surface results in a systemic inflammatory response, including cytokine release and complement activation. We studied the artificial surface-induced inflammation in human whole blood using an extensive panel of inflammatory mediators including proinflammatory cytokines, chemokines and growth-factors and investigated the role of the complement system in the induction of this response. Using multiplex technology, 27 different inflammatory mediators were measured after circulating blood for 4 hours in polyvinyl chloride tubing. The C3 inhibitor compstatin was used to block complement activation. A significant (p < 0.05) increase in 14 of the 27 mediators was induced by the surface, of which 7 were chemokines (IL-8, MCP-1, MIP-1alpha, MIP-1beta, RANTES, eotaxin and IP-10) and 5 were growth-factors (G-CSF, GM-CSF, VEGF, PDGF and FGF). The traditional proinflammatory cytokines like IL-1beta, TNFalpha and IL-6 were not induced, although IL-6, as well as IL-15 and IL-17 increased if the surface was coated with highly bioincompatible laminaran. Inhibition of complement activation with compstatin significantly (p < 0.05) reduced the formation of 12 of the 14 mediators. For 10 of the 12 mediators, the inhibition was by 2/3 or more, for the remaining two the inhibition was more moderate. A highly biocompatible heparin-coated PVC surface was used as negative control and completely abolished the whole inflammatory response. The artificial surface PVC markedly induced a broad spectrum of chemokines and growth-factors, which was largely dependent on activation of complement.

A comparison of radiographic signs of pulmonary inflammation during ECMO between silicon and poly-methyl pentene oxygenators

INTRODUCTION

The inflammatory response caused by extracorporeal membrane oxygenation (ECMO) is clearly visible within the first 24 h of cannulation. The inflammatory process affects all areas of the lung, even areas previously spared by the primary disease.

OBJECTIVE

To compare the change in the radiographic signs of inflammatory response to ECMO between poly-methyl pentene and silicon oxygenators.

STUDY DESIGN

Retrospective review of neonates and adults pre- and post-replacement of silicon oxygenators with poly-methyl pentene devices. Data were collected from Extracorporeal Life Support Organisation (ELSO) registry forms and patient records. Results were analysed by quantitative and semi-quantitative methods.

RESULTS

There was a significant reduction in the radiographic signs of inflammatory response to ECMO, and a reduction in the time taken to revert to pre-ECMO state in the neonatal poly-methyl pentene group compared to silicon. However, there was no significant reduction in the duration of ECMO runs and the percentage survival between these groups in the neonates. In adults, there was no difference in severity of radiographic signs between groups. However, the inflammatory changes were relatively delayed in the adult poly-methyl pentene group.

CONCLUSION

Polymethyl pentene (Medos) oxygenators have reduced the host's response phenomenon 'white out' in neonates, and caused a delayed response in adults. This is most likely a consequence of smaller blood contact surface area combined with the effect of heparin coating of the oxygenator membrane. However, recovery was not a function of the type of gas exchange device used.

Differential Expression in Markers for Thrombin, Platelet Activation, and Inflammation in Cell Saver Versus Systemic Blood in Patients Undergoing On-Pump Coronary Artery Bypass Graft Surgery

OBJECTIVE

Elimination of cardiotomy suction increases reliance on cell-saver blood-conservation techniques. Reinfusion of processed cell-saver blood (PCSB) even without using cardiotomy field suction may contribute to thrombin, cytokines, platelet activators, and hemolytic factors measured systemically.

DESIGN

This study was designed as a prospective, unblinded observational study of patients undergoing first-time, nonemergent on-pump coronary artery bypass graft surgery.

SETTING

A university medical center.

PARTICIPANTS

Fourteen patients were enrolled after informed consent.

INTERVENTIONS

Arterial blood was sampled (1) before cardiopulmonary bypass, (2) immediately after bypass, and (3) 4 hours after bypass. PCSB, using the AutoLog (Medtronic, Inc, Minneapolis, MN), was sampled after bypass.

MEASUREMENTS AND MAIN RESULTS

Blood and PCSB levels of prothrombin fragments 1.2, beta-thromboglobulin, interleukin-6, interleukin-8, polymorphonuclear leukocyte-elastase, neuron-specific enolase, and S-100beta were assayed by using enzyme-linked immunosorbent assay. Paired comparisons were performed by using paired t tests. Compared with postbypass blood, processed cell-saver blood (prepatient infusion) had higher levels of polymorphonuclear leukocyte-elastase, interleukin-8, neuron-specific enolase, and S-100beta (p <or= 0.05).

CONCLUSIONS

Reinfusion of PCSB directly and independently contributes to systemic elevations in interleukin-8, polymorphonuclear elastase, neuron-specific enolase, and S-100beta, augmenting and perhaps accentuating the postoperative inflammatory response. Further evaluation and improvement in cell-salvaging technology and processing techniques are warranted.

Poly-methyl pentene oxygenators have improved gas exchange capability and reduced transfusion requirements in adult extracorporeal membrane oxygenation

The performance of poly-methyl pentene (PMP) oxygenators (Medos Hilite 7000LT) was compared with that of silicone membrane (SM) oxygenators (Medtronic 1-4500-2A) for adult extracorporeal membrane oxygenation (ECMO). Forty consecutive patients were selected retrospectively pre- and post-introduction of PMP oxygenators. They were selected according to the dates they received ECMO and were separated into two equal groups with similar backgrounds. The flow path resistance, gas and heat exchange efficiency, consumption of coagulation factors and platelets, blood transfusion requirements, and incidence of clots for each oxygenator type was assessed. Adult PMP oxygenators showed lower blood path resistance than SM oxygenators. However, lower consumption of blood products in these oxygenators was a direct result of their smaller surface area and heparin coated design, reducing contact activation of coagulation factors. These oxygenators are noticeably smaller, require lower priming volumes, and have better gas exchange capability than SM oxygenators. They showed greater stability and preservation of coagulation factors and platelets compared with SM oxygenators. They also had the advantage of a functioning integrated heat exchanger. Using a single PMP oxygenator in the first instance may be adequate for the majority of patients and would significantly reduce red blood cell consumption during ECMO.

Cardiopulmonary bypass technology transfer: musings of a cardiac surgeon

The development of cardiopulmonary bypass (CPB) has been one of the greatest technical advancements in cardiovascular medicine. With heparin anticoagulation, this device can safely replace the circulatory and gas-exchanging functions of the heart and lung, facilitating complex cardiac operations. Limitations still exist however, related to blood reactions at the biomaterial surface, such as cell activation, inflammation and low-grade thrombosis. In this brief review, the thought processes which paralleled the development of CPB biocompatible surfaces such as heparin-coating, will be explored, as well as current theories on the suspected mechanisms by which heparin-coated surfaces act as an anti-inflammatory device during CPB. Results with new surfaces for CPB designed to capitalize on superior protein adsorption properties, such as surface modifying additive (SMA) and poly (2-methoxyethylacrylate) (PMEA), will also be described. Finally, the significance of biomaterial-independent blood activation will be discussed, emphasizing the current need to develop strategies utilizing optimal biomaterials, modified surgical technique and pharmacologic therapy to minimize the systemic complications of CPB.

Therapeutic potential of targeting the complement cascade in critical care medicine

Caring for the critical care patient involves many different areas of clinical expertise and serves a diverse patient population. Novel therapeutics for the critically ill must be approached with caution, because the underlying molecular mechanisms of the disease process for several commonly seen types of patients (i.e., sepsis, shock, ischemia/reperfusion) are not fully understood. A potentially new and advancing area of therapeutics that may hold promise for the critically ill is inhibition of the complement system. Various novel complement inhibitors are being developed and several are in clinical trials. The advancement of this novel area of therapeutics may one day aid the clinician by providing several different complement inhibitors/antagonists for controlling complement activation or its biologically active mediators.

Surface Modified Cardiopulmonary Bypass Circuits: Modifying the Inflammatory Response

As a consequence of an aging population demographic, now more than ever, researchers in cardiac surgery must focus on means to improve the methods and technologies related to cardiopulmonary bypass. This review presents a classification of the currently available options for biomaterial modification for cardiopulmonary bypass circuits. Hypotheses are given relating the mechanism of action by which some of these surfaces afford improved biocompatibility. Finally, nonpharmacologic biomaterial-independent strategies for minimizing the effects of cardiopulmonary bypass, such as the use of hemofiltration and leukocyte filtration, and the minimization of the use of cardiotomy suction blood are outlined.

Limitation of thrombin generation, platelet activation, and inflammation by elimination of cardiotomy suction in patients undergoing coronary artery bypass grafting treated with heparin-bonded circuits

OBJECTIVE

Reports evaluating the efficacy of heparin-bonded circuits to blunt inflammation, platelet dysfunction, and thrombin generation in response to cardiopulmonary bypass have varied. We hypothesized that this variability may in part be related to the use of cardiotomy suction, which has been demonstrated to reintroduce procoagulant and proinflammatory factors into the systemic circulation during cardiopulmonary bypass. A prospective, randomized study was undertaken to evaluate the specific effects of cardiotomy suction.

METHODS

Thirty-six patients undergoing first-time, nonemergency coronary artery bypass grafting with cardiopulmonary bypass were randomly assigned to one of three treatment groups: group I, non-heparin-bonded circuits with the use of cardiotomy suction (n = 12); group II, Duraflo II (BCR-3500; Jostra Bentley Corp, Irvine, Calif) heparin-bonded circuits with cardiotomy suction (n = 12); and group III, Duraflo II heparin-bonded circuits without cardiotomy suction (n = 12). Thrombin generation, neutrophil activation (polymorphonuclear elastase), platelet activation (beta-thromboglobulin), and neuronal injury (neuron-specific enolase) were analyzed by enzyme-linked immunosorbent assays after cardiopulmonary bypass and compared with prebypass levels. Results are presented as mean +/- SEM.

RESULTS

Prebypass levels of all markers were similar among treatment groups. However, postbypass levels were significantly and consistently highest in group I relative to groups II and III. Thrombin generation levels were 5.0 +/- 0.9 nmol/L in group I, 3.0 +/- 0.6 nmol/L in group II, and 1.5 +/- 0.1 nmol/L in group III (P <.05 vs group II and P <.001 vs group I). Polymorphonuclear elastase levels were 307 +/- 64 microg/L in group I, 128 +/- 24 microg/L in group II (P <.05 vs group I), and 75 +/- 14 microg/L in group III (P <.001 vs group I). beta-Thromboglobulin levels were 2692 +/- 401 IU/mL in group I, 912 +/- 99 IU/mL in group II (P =.001 vs group I), and 646 +/- 133 IU/mL in group III (P =.001 vs group I). Neuron-specific enolase levels were 9.8 +/- 0.9 ng/mL in group I, 10.5 +/- 1.6 ng/mL in group II, and 4.2 +/- 0.5 ng/mL in group III (P =.001 vs groups I and II).

CONCLUSIONS

Use of cardiotomy suction resulted in significant increases in thrombin, neutrophil, and platelet activation, as well as the release of neuron-specific enolase, after cardiopulmonary bypass. Limiting increases in these markers would be best accomplished by eliminating cardiotomy suction and routinely using heparin-bonded circuits whenever possible.

Heparin-coated extracorporeal circulation with full and low dose heparinization: comparison of thrombin related coagulatory effects

Thrombin related coagulatory effects of a heparin-coated cardiopulmonary bypass system combined with full and low dose systemic heparinization were investigated in a prospective, randomized study in coronary bypass surgery patients. One hundred nineteen patients were divided into 3 groups. Group A (n = 39) had a standard uncoated extracorporeal circulation (ECC) set, and systemic heparin was administered in an initial dose of 400 IU/kg body weight. During ECC activated clotting time (ACT) was maintained at > or =480 s. Group B (n = 42) had the same ECC set completely coated with low molecular weight heparin. Intravenous heparin was given in the same dose as in Group A, and ACT was kept at the same level. Group C (n = 38) had the same coated ECC set as Group B, but intravenous heparin was reduced to 150 IU/kg, and during ECC, ACT was set to be > or =240 s. The same ECC components were used in all 3 groups including roller pumps, coronary suction, and an open cardiotomy reservoir. Thrombin generation as indicated by F1/F2 was significantly elevated at an ECC duration >60 min if heparin-coated ECC combined with low dose systemic heparinization was employed. Complexed thrombin (TAT) was significantly elevated after administration of protamine. Release of D-dimers indicating fibrinolysis was not significantly different between groups. Signs of clinical thromboembolism, i.e., postoperative neurological deficit, occurred in 2 patients in Group A and 1 patient in Group C. We conclude that heparin-coated extracorporeal circulation combined with reduced systemic heparinization intraoperatively leads to significantly increased thrombin generation, but not to increased fibrinolysis.

Comparison of two heparin-coated extracorporeal circuits with reduced systemic anticoagulation in routine coronary artery bypass operations

OBJECTIVES

The use of heparin-coated circuits for cardiopulmonary bypass attenuates the postperfusion inflammatory response. Postoperative bleeding and the need for allogeneic blood transfusions are reduced, particularly in combination with lowered systemic anticoagulation. The two most commonly used heparin-coated systems are the Carmeda BioActive Surface (Medtronic Inc, Minneapolis, Minn) and the Duraflo II coating (Baxter Healthcare Corp, Bentley Laboratories Division, Irvine, Calif). The 2 surfaces are technically unequal, and previous experimental studies have demonstrated disparities in effects on the immune system and the blood cells. However, no larger comparative studies of relevant clinical end points have thus far been reported.

METHODS

Over a 24-month period, all patients undergoing coronary artery bypass were prospectively randomized to one of the two heparin-coated circuits. Altogether, 1336 consecutive patients were included. The heparin dose was reduced in all cases, with an activated coagulation time of more than 250 seconds. Clinical data were consecutively collected and stored on a computer for comparative analyses.

RESULTS

There were no statistically significant differences in any demographic or operative parameters. The Duraflo II patients required less heparin to keep the target-activated clotting time, confirming the previous finding of some leakage of heparin from the surface to the circulation. Otherwise, there were no significant differences in time for ventilatory support (Duraflo II, 1.7 +/- 1.3 hours; Carmeda BioActive Surface, 1.6 +/- 1.0 hours; P =.37), amount of postoperative mediastinal drainage (Duraflo II, 665 +/- 257 mL; Carmeda BioActive Surface, 688 +/- 243 mL; P =.07), need for allogeneic blood-plasma transfusions (Duraflo II, 4.2% of the patients; Carmeda BioActive Surface, 4.4% of the patients; P =.93), or hemoglobin concentration at hospital discharge (Duraflo II, 120 +/- 13 g/L; Carmeda BioActive Surface, 119 +/- 13 g/L; P =.08). The effects on renal function and platelets were similar, as were the incidences of perioperative myocardial infarction (Duraflo II, 1.5%; Carmeda BioActive Surface, 1.5%; P =.96), stroke (Duraflo II, 1.3%; Carmeda BioActive Surface, 1.2%; P =.47), and hospital mortality (Duraflo II, 1 [0.14%] patient; Carmeda BioActive Surface, 3 [0.45%] patients; P =.31).

CONCLUSIONS

Despite differences in technology, complexity, and effects on biologic markers, no clinical differences were observed between the Carmeda BioActive Surface system and the Duraflo II coating after coronary artery bypass operations. The overall clinical results were favorable in both groups, confirming the safety and feasibility of routine use of heparin-coated circuits in combination with reduced systemic anticoagulation.

Clinical evaluation of heparin-coated circuits for routine coronary artery bypass grafting surgery: a prospective randomized study

The aim of this study was to demonstrate the clinical and biological benefits of heparin-coated circuits in routine coronary artery bypass grafting (CABG). A prospective, randomized study was conducted in 80 patients undergoing routine CABG. Patients were randomized to either noncoated circuits (Group 1) or heparin-coated circuits (Group 2). A complete clinical evaluation was performed preoperatively at Days 0, 1, 2, and 3 and at discharge day and combined with extensive laboratory tests for hemostasis and inflammatory response. This study did not prove any major statistically significant clinical benefit of heparin-coated circuits in low risk patients. Postoperative bleeding, significantly less in the heparin-coated group, did not decrease significantly the number of transfused patients. Biological values were not changed significantly except for factor II and monocytes, which were higher in Group 2. Heparin-coated circuits offer minimal clinical and biological benefits for routine CABG surgery. However, they may prove beneficial for complex procedures or at-risk patients.

Clinical performance of a new high-flux synthetic membrane

The clinical performance during first use of a new membrane manufactured from a blend of polyarylethersulfone and polyvinylpyrrolidone (Arylane; Hospal Renal Care, Lyon, France), in which the microstructure of the membrane has been tailored by the manufacturing process and polymer blend, has been compared with Fresenius Polysulfone (Fresenius Medical Care, Bad Homburg, Germany) in a prospective, randomized, crossover study. Small-molecular clearances were similar. A reduction in plasma beta(2)-microglobulin levels was present using both membranes, with a significantly greater removal by Arylane such that the mean postdialysis plasma level difference between the membranes at the end of dialysis was 8. 7 mg/L (95% confidence interval, 3.9 to 13.5; P = 0.004). Recovery of beta(2)-microglobulin from the dialysis fluid was similar: 170 +/- 70 mg for Arylane and 110 +/- 60 mg for Fresenius Polysulfone (P = 0.04). Both membranes were impermeable to albumin but allowed the passage of low-molecular-weight proteins, with 10,046 +/- 3,239 mg for Arylane and 7,285 +/- 2,353 mg for Fresenius Polysulfone recovered from the dialysis fluid (P = 0.07). Neutropenia and platelet adhesion to the membrane were minimal, and time-averaged complement levels during dialysis for C3a and C5b-9 were 207 +/- 92 and 62 +/- 24 ng/mL for Arylane and 223 +/- 68 and 45 +/- 24 ng/mL for Fresenius Polysulfone, respectively, and were membrane independent. This study indicates that the membrane using polyarylethersulfone in conjunction with PVP has complement-activation potential and neutropenia similar to Fresenius Polysulfone but has an enhanced capacity to remove beta(2)-microglobulin. This enhanced removal arises from transmembrane transport augmented by adsorption within the membrane matrix.

Impact of heparin bonding on pediatric cardiopulmonary bypass: a prospective randomized study

BACKGROUND

Heparin-coated circuits reduce the inflammatory response to cardiopulmonary bypass in adult patients; however, little is known about its effects in the pediatric population. Two studies were performed to assess this technology's impact on inflammation and clinical outcomes.

METHODS

In a pilot study, complement and interleukins were measured in 19 patients who had either uncoated cardiopulmonary bypass circuits or heparin-bonded circuits. Subsequently, 23 additional patients were studied in a randomized fashion. Respiratory function and blood product utilization were recorded.

RESULTS

In the pilot study, heparin-bonded circuit patients had less complement 3a (p < 0.001) and interleukin-8 (p < 0.05) compared with uncoated cardiopulmonary bypass circuit patients. The randomized study revealed that the heparin-bonded circuit was associated with reduced complement 3a (p = 0.02). Multiple variable analysis revealed that the following postoperative variables were increased with bypass time (p = 0.01) and diminished with heparin-bonded circuits: interleukins (p = 0.01), peak airway pressures (p = 0.05), and prothrombin time (p = 0.03).

CONCLUSIONS

Heparin-bonded circuits significantly reduce cytokines and complement during cardiopulmonary bypass and lower interleukin levels postbypass; they were also associated with improved pulmonary and coagulation function. Heparin-bonded circuits ameliorate the systemic inflammatory response in pediatric patients from cardiopulmonary bypass.

Reduced release of tissue factor by application of a centrifugal pump during cardiopulmonary bypass

The application of a centrifugal pump might lead to a reduced release of tissue factor (TF) due to less blood cell damage. This could result in a decrease in activation of the extrinsic pathway of coagulation and embolus formation. In the present study, 60 patients undergoing coronary artery bypass grafting were randomly assigned to a centrifugal or a roller pump. Plasma concentrations of TF, thrombin-antithrombin complex (TAT), and prothrombin fragments F1 + 2 were investigated before, during, and after cardiopulmonary bypass (CPB). Embolus detection was performed at the arterial line of CPB and transcranially by Doppler ultrasound. The centrifugal pump group revealed a lower TF release (area under the curve during CPB) when compared with the roller pump group [5661 (696-10359) vs 12681 (6383-17538) microg x min/l; median (lower - upper quartiles); P = 0.009]. In contrast, TAT and F1 + 2 formation did not differ between the groups, and neither did the total embolus count of both Doppler systems. Embolus counts did not correlate with TAT or F1 + 2 formation. In conclusion, the reduction in TF release by the application of a centrifugal pump seems to have little consequence on total thrombin formation. Since the applied Doppler systems seem to detect mainly microbubbles, conclusions regarding differences between the two pumps in the formation of thrombofibrinous clots cannot be drawn.

A prospective randomized trial of Duraflo II heparin-coated circuits in cardiac reoperations

BACKGROUND

Heparin-coated circuits in cardiopulmonary bypass have been shown to decrease the systemic inflammatory responses associated with cardiopulmonary bypass. Previous clinical studies on low-risk patients who had coronary artery bypass grafting (CABG) and received full-dose systemic heparin did not have clearly improved clinical outcomes. We hypothesized that the beneficial effects of heparin-coated circuits might be seen in patients who had cardiac reoperations.

METHODS

Three hundred fifty patients who had reoperation with CABG only (58%), or with valve operations (42%) were randomly assigned to receive either a heparin-coated (Duraflo II; study group) or uncoated (control group) circuit. Clinical outcomes were compared and the variables were analyzed using the following three groups: entire populations of study group and control group, subgroup of patients who had CABG reoperation only, and a subgroup who had valve reoperation or combined valve and CABG reoperation.

RESULTS

Preoperative variables were the same in both groups. No difference in clinical outcomes could be demonstrated except that the percentage of patients with major bleeding episodes was significantly lower in the study group (1.2% versus 5.4%, p = 0.035). In the subgroup analysis of patients who had valve reoperations, lower blood transfusion requirements in the intensive care unit (p = 0.013) were found in the study group. When the subgroup of patients who had CABG reoperations was analyzed separately, there was a trend toward less reoperation for bleeding in the study group (0% versus 4.0%, p = 0.058).

CONCLUSIONS

We conclude that the use of heparin-coated circuits was safe and imparted protection from reoperations for bleeding and major bleeding episodes. Material-independent blood activation (eg, blood-air interface and cardiotomy suction) blunted the total effect of the heparin-coated surface.

Heparin-coated circuits for high-risk patients: a multicenter, prospective, randomized trial

BACKGROUND

Heparin-coated circuits (HCCs) in low-risk cardiac patients who have coronary revascularization have a limited impact on postoperative outcome. In this prospective, randomized investigation, we studied high-risk patients who had cardiac operations with or without HCCs.

METHODS

A total of 886 patients who had cardiac operations with cardiopulmonary bypass and at least one patient-related or procedure-related risk factor were enrolled in a multicenter study. They were randomly allocated to have cardiopulmonary bypass with Duraflo II HCCs (HCC group, n = 442) or conventional circuits (control group, n = 444). Postoperative outcome was investigated with respect to the occurrence of organ dysfunction.

RESULTS

HCCs are associated with a shorter intensive care unit and postoperative hospital stay and with a lower rate of patients having a severely impaired clinical outcome (stay in intensive care unit for more than 5 days or death) (relative risk 0.66, p = 0.045). Lung dysfunction rate was significantly lower for the patients in HCC group affected by chronic obstructive pulmonary disease or who had mitral procedure (relative risk, respectively, 0.31, p = 0.018 and 0.05, p = 0.02). Renal dysfunction rate was significantly (p = 0.05) lower for diabetics in the HCC group (relative risk 0.28).

CONCLUSIONS

When HCCs were used postoperative times decreased and they had a protective effect on lung and kidney function in high-risk patients.

Inflammatory response to cardiopulmonary bypass using two different types of heparin-coated extracorporeal circuits

Previous reports have highlighted the disparity in biocompatibility of two differently engineered heparin coatings during the cardiopulmonary bypass (CPB) procedure. The aim of this prospective study was to evaluate the impact of the difference in haemocompatibility provided by either the Duraflo II equipment or the Carmeda equipment in the terminal inflammatory response observed after coronary artery surgery. Thirty patients were randomly allocated to two groups to be operated on using either Duraflo II equipment (group I) or Carmeda equipment (group 2) for extracorporeal circulation (ECC). Initial inflammatory response was assessed by terminal complement complex activation (SC5b-9). The late inflammatory response observed in the postoperative period was assessed by measuring cytokine production (tumour factor necrosis (TNF alpha), interleukin IL-6, interleukin IL-8) and circulating concentrations of adhesion molecules (ELAM-1, ICAM-1). The release of SC5b-9 after CPB and after protamine administration was lower in group 2 than in group 1 (p = 0.0002 and p = 0.006, respectively). A significant production of cytokines was detected in both groups with peak values observed within the time range of 4-6 h after the start of CPB.

Measures to control blood activation during assisted circulation

Major improvements in heart assist devices have allowed prolonged mechanical circulatory support with successful subsequent weaning or heart transplantation. The contact of blood with biomaterials used in life-sustaining devices and numerous biomaterial-independent factors elicit a systemic inflammatory response, which involves activation of various plasma protein systems and blood cells. Prolonged mechanical circulatory support elicits a systemic inflammatory response and hemostatic perturbations similar to that reported during cardiopulmonary bypass. However, in the setting of prolonged assistance, time has a complex and ill-known influence on blood activation. Methods to reduce blood activation during prolonged assisted circulation are derived from cardiopulmonary bypass investigations. Improving the biocompatibility of artificial devices can be achieved either by biomaterial surface modifications, by inhibition of biologic cascades leading to blood activation, or by controlling end points of biologic cascades. However, the necessity to respect the integrity of the organism during prolonged assistance precludes most systemic interventions and limits the control of blood activation to the area of the device.

Heparin-bonded circuits: clinical outcomes and costs

The aim of this study was to use meta-analysis to combine the results of numerous studies and examine the impact of heparin-bonded circuits on clinical outcomes and the resulting costs. Heparin-bonded circuits, both ionically and covalently bonded, are examined separately. The results of the study provide evidence that heparin-bonded circuits result in improved clinical outcomes when compared to the identical nonheparin-bonded circuits. These improved clinical outcomes result in subsequent lower costs per patient with their use. However, differences are apparent in the significance and magnitude of these outcomes between ionically and covalently bonded circuits. Covalently bonded circuits provide a greater magnitude and significance of improvement in clinical outcomes than ionically bonded circuits. Total cost savings can be expected to be three times greater with covalently bonded circuits ($3231 versus $1068). It was concluded that the choice regarding the use of a heparin-bonded circuits and the type of heparin-bonded circuit used has the potential to alter clinical outcomes and subsequent costs. Cost consideration cannot be ignored, but clinical benefits should be the main rationale for the choice of cardiopulmonary bypass circuit. This analysis provides evidence that clinical benefits and cost savings can both be derived from use of the same technology-covalently bonded circuits.

Effect of anticoagulation protocol on outcome in patients undergoing CABG with heparin-bonded cardiopulmonary bypass circuits

BACKGROUND

We have demonstrated that the use of heparin-bonded cardiopulmonary bypass circuits (HBCs) combined with a lower anticoagulation protocol as an adjunct to an integrated blood conservation strategy decreases the incidence and magnitude of homologous transfusion and improves clinical outcome in patients undergoing primary coronary artery bypass grafting. It is not known whether it is the lower anticoagulation protocol that influences outcome in patients treated with HBCs. Furthermore, the thrombogenic risk of using lower anticoagulation with HBCs still is debated.

METHODS

To answer these questions, a prospective randomized study was conducted in which 244 patients undergoing primary coronary artery bypass grafting were treated with HBCs and randomized to undergo either a full (activated clotting time, > 450 seconds) or a lower (activated clotting time, > 250 seconds) anticoagulation protocol. In addition to clinical outcome, levels of thrombin generation markers during and after cardiopulmonary bypass were assessed in a consecutive subset of 58 patients (full anticoagulation profile = 28, lower anticoagulation profile = 30) by measuring thrombin-antithrombin complexes and prothrombin fragment 1.2. Levels of these markers also were correlated with the activated clotting time during cardiopulmonary bypass.

RESULTS

Preoperative and intraoperative risk profiles and other characteristics were similar in both groups, with more than 60% of patients undergoing nonelective operation. Compared with the full anticoagulation protocol group, patients in the lower anticoagulation protocol group were less likely to require blood products (24.2% versus 35.8%, respectively; p = 0.047) and received substantially fewer homologous donor units (0.50 +/- 0.92 versus 1.08 +/- 2.10 U, respectively; p = 0.005). Clinical outcomes were uniformly outstanding (but similar) in both treatment groups, with a modest reduction in the length of the hospital stay in the lower anticoagulation protocol group (5.26 +/- 1.23 versus 5.63 +/- 1.73 days, respectively; p = 0.05). The use of HBCs with a lower anticoagulation protocol was not associated with any adverse clinical events. Thrombin generation increased during cardiopulmonary bypass in both treatment groups, but was unrelated to the anticoagulation protocol or the activated clotting time (r2 = 0.03). No differences between the full and lower anticoagulation protocol groups were noted in the number of microemboli detected by transcranial Doppler analyses during cardiopulmonary bypass (n = 40) or in the postoperative neurologic and neuropsychologic outcomes (n = 30).

CONCLUSIONS

This study definitively demonstrates that, when used appropriately, patients who are treated with HBCs and a lower anticoagulation protocol have a lower incidence and magnitude of homologous transfusion and are not at any added risk for clinical, hematologic (thrombin-antithrombin complex and fragment 1.2 measurements), or microscopic (transcranial Doppler analyses) thromboembolic complications or for neurologic or neuropsychologic deficits.

Inhibition of complement activation by soluble recombinant CR1 under conditions resembling those in a cardiopulmonary circuit: reduced up-regulation of CD11b and complete abrogation of binding of PMNs to the biomaterial surface

The influence of soluble recombinant CR1 (sCR1) on complement activation, and its indirect effects on the coagulation system and cellular responses were assessed in two models for the study of blood/surface and blood/air interactions, as are encountered in e.g. cardiopulmonary bypass circuits. The concentrations of C3a and sC5b-9 and the amount of bound C3/C3 fragments were analyzed as indicators of complement activation. Thrombin-antithrombin complexes, the platelet count, surface-ATP, beta-thromboglobulin, and the expression of CD11b on leukocytes were the parameters analyzed to reflect coagulation and cellular responses. In addition, immunochemical analyses of the phenotypes of surface-bound leukocytes and platelets were performed. Recombinant sCR1, at doses ranging between 0.1-0.25 mg/ml, was found to completely inhibit the generation of sC5b-9, and of C3a by two thirds; the binding of C3 and/or C3 fragments to the surface was almost entirely abolished. As a result of the inhibition of complement activation, the expression of CD11b on PMNs, and the binding of these cells to the biomaterial surface was almost completely lost. In contrast, the thrombin-antithrombin complexes, the platelet count, and the adherence of platelets to the surface, as reflected by the ATP binding and the release of beta-thromboglobulin, were not affected. These data show that complement activation, in association with extra-corporeal treatment, causes activation and binding of PMNs to the biomaterial and that these effects can be completely abolished by the addition of soluble recombinant sCR1.

Does heparin coating improve biocompatibility? A study on complement, blood cells and postoperative morbidity during cardiac surgery

To evaluate whether the effect of heparin coating the extracorporeal circuit resulted in differences in patient outcome and haemostatic alteration, 24 patients undergoing elective, isolated coronary artery bypass were randomized prospectively to cardiopulmonary bypass (CPB) with heparin-coated circuits (group H, n = 12) or uncoated circuits (group C, n = 12). The technique of CPB, heparinization and its reversal were the same in both groups. We studied complement status (C3d, C3, C3d/C3, C4 and C-function), white blood cell counts with differentiation and the postoperative morbidity. The results confirmed that CPB activates complement and increases neutrophils in both the H and C groups. A significantly lower level of leucocytosis was seen in group H compared to the C group (p < 0.05). The complement function via the classical pathway (C-function), expressed as a percentage of the function of a reference serum pool (the values of normal sera were 75-125%), was significantly reduced in both heparin-coated and uncoated circuits (p < 0.05). There was no significant intergroup difference regarding C3, C3d/C3, C4 and C-function during the study period. A lower frequency of postoperative morbidity was present in the H group. We conclude that heparin-coated surfaces elicit less leucocytosis and decrease postoperative morbidity in patients undergoing cardiac surgery but do not cause a significant difference regarding activation of the complement system as reported by many other investigators.

Heparin-bonded circuits improve clinical outcomes in emergency coronary artery bypass grafting

Compared to patients undergoing elective or urgent coronary artery bypass grafting (CABG), those undergoing emergency CABG (EM-CABG) have a higher morbidity and mortality. The use of heparin-bonded circuits (HBC) has been shown to improve clinical outcomes in nonemergent CABG patients. It is not known, however, whether the improved hemostasis and attenuation of the inflammatory response to cardiopulmonary bypass, conferred by HBC, can overcome the high incidence of comorbid risk factors in (EM-CABG) patients and improve their outcomes. A retrospective analysis of 206 consecutive patients undergoing EM-CABG over 4 years (1993-1997) at one institution was performed. Eighty-one patients were treated with conventional non-heparin-bonded circuits (NHBC) with full anticoagulation protocol (FAP, activated clotting time [ACT] > 480 sec); 125 patients were treated with HBC and a lower anticoagulation protocol (LAP, ACT > 280 seconds). Outcomes and results were collected prospectively and are presented as mean +/- SD. Preoperative risk profiles were similar in both treatment groups. Postoperatively, compared with the NHBC group, patients treated with HBC/LAP required fewer homologous donor units (4.1 +/- 10.7 vs 8.2 +/- 13.6 units, p = 0.005), were less likely to require inotropic support (18.6% vs 38.3%, p = 0.005), and had a lower incidence of perioperative myocardial infarction (MI, 3.2% vs 12.3%, p = 0.04) and pulmonary complications (4.0% vs 12.3%, p = 0.04). The use of HBC/LAP resulted in a decreased incidence of postoperative complications (12.8% vs 28.4%, p = 0.01, odds ratio 0.37 with 95% confidence interval [CI] 0.18-0.76). This resulted in a shorter duration of ventilatory support (30.5 +/- 54.0 vs 72.8 +/- 16.7 hours, p = 0.009), ICU stay (38.2 +/- 36.5 vs 91.5 +/- 68.7 hours, p = 0.009), hospital stay (8.0 +/- 7.1 vs 11.0 +/- 8.9 days, p = 0.008), and therefore cost. In conclusion, the use of HBC/LAP in EM-CABG resulted in a reduction of homologous transfusion and postoperative complications associated with decreased hospital stays and cost.

Inflammatory response to cardiopulmonary bypass: mechanisms involved and possible therapeutic strategies

BACKGROUND

Recent study of the inflammatory reactions occurring during and after cardiopulmonary bypass (CPB) has improved our understanding of the involvement of the inflammatory cascade in perioperative injury. However, the exact mechanisms of this complex response remain to be fully determined.

METHODS

Literature on the inflammatory response to CPB was reviewed to define current knowledge on the possible pathways and mediators involved, and to discuss recent developments of therapeutic interventions aimed at attenuating the inflammatory response to CPB.

RESULTS

CPB has been shown to induce complement activation, endotoxin release, leukocyte activation, the expression of adhesion molecules, and the release of many inflammatory mediators including oxygen-free radicals, arachidonic acid metabolites, cytokines, platelet-activating factor, nitric oxide, and endothelins. Therapies aimed at interfering with the inflammatory response include the administration of pharmacologic agents such as corticosteroids, aprotinin, and antioxidants, as well as modification of techniques and equipment by the use of heparin-coated CPB circuits, intraoperative leukocyte depletion, and ultrafiltration.

CONCLUSIONS

Improved understanding of the inflammatory reactions to CPB can lead to improved patient outcome by enabling the development of novel therapies aimed at limiting this response.

Cell activation and thrombin generation in heparin bonded cardiopulmonary bypass circuits using a novel in vitro model

OBJECTIVE

It is generally agreed that when the blood contact surfaces of a cardiopulmonary bypass circuit are treated with a layer of heparin molecules the activation of the humoral pathways is attenuated. However, there is still debate as to whether heparin-bonded circuits reduce thrombin generation. This study aims to examine the effects of immobilized heparin on cell activation and thrombin generation in a novel, well controlled model of cardiopulmonary bypass.

METHODS

The model used consisted of a heparin-bonded and a non-bonded cardiopulmonary bypass circuit perfused in tandem with the same unit of fresh heparinized (3.3 U/ml) human blood for a period of 6 h. Samples were taken for analysis from the bag just prior to perfusion and at 30, 60, 120 and 360 min of perfusion. Whole blood was used to analyse platelet and white blood cell count, haematocrit and activated coagulation time. Plasma samples were prepared for batch analysis of the cell activation markers p-selectin, elastase and interleukin-8, and the thrombin generation markers thrombin-antithrombin and prothrombin fragment F1 + 2. A sample of tubing was taken from each circuit at the end of the perfusion and prepared for visualization by scanning electron microscopy.

RESULTS

Platelet counts were significantly reduced in the non-bonded circuits compared with the heparin-bonded circuits at 30 (22 versus 200 x 10(9)/L P < 0.01), 60 (26 versus 193 x 10(9)/L P < 0.01) and 120 min (28 versus 193 x 10(9)/L P < 0.01) as were white blood cell counts at 30(1.5 versus 2.7 x 10(9)/L P < 0.01), 60 (0.9 versus 2.4 x 10(9)/L P < 0.01), 120 (0.9 versus 1.8 x 10(9)/L P < 0.01) and 360 min (0.4 versus 0.9 x 10(9)/L P < 0.05). The concentration of p-selectin was found to be significantly higher in the non-bonded circuits than in the heparin-bonded circuits at 30 (37 versus 29 ng/ml P < 0.01), 60 (37 versus 28 ng/ml P < 0.01). 120 (42 versus 27 ng/ml P < 0.01) and at 360 min (72 versus 46 ng/ml P < 0.01). Elastase was elevated in the non-bonded circuits at 30 (570 versus 145 micrograms/l P < 0.01), 60 (646 versus 278 micrograms/l P < 0.01) and 120 min (613 versus 403 micrograms/l P < 0.05) and interleukin-8 at 120 (705 versus 520 pg/ml P < 0.05) and 360 min (11326 versus 9910 pg/ml P < 0.05). A similar picture was found for the thrombin generation markers. Thrombin-antithrombin complexes were raised in the non-bonded circuits compared with heparin-bonded circuits at 60 (24 versus 13 micrograms/l P < 0.05) and 120 min (46 versus 17 micrograms/l P < 0.05) as was prothrombin fragment F1 + 2 at 30 (1.1 versus 0.7 nmol/l P < 0.01), 60 (1.3 versus 0.7 nmol/l P < 0.01), 120 (1.8 versus 0.9 nmol/l P < 0.01) and 360 min (15.0 versus 13.6 nmol/l P < 0.05). Scanning electron microscopy revealed a greater amount of adherent material on the non-bonded surface relative to the heparin-bonded surface.

CONCLUSIONS

In a cardiopulmonary bypass circuit perfused with human blood the activation of platelets and white blood cells has been seen to be significantly reduced in the presence of a heparin-bonded surface. Thrombin generation due to contact activation of the intrinsic coagulation pathway is also reduced.

Biocompatibility in cardiopulmonary bypass

Recent advances in surgical techniques and perfusion technology allow cardiac operations to be performed routinely with low mortality rates. However, patients undergoing cardiac operations with cardiopulmonary bypass (CPB) are still associated with bleeding disorders, thrombotic complications, massive fluid shifts, and the activation of blood components that are collectively known as the whole body inflammatory response. In this review, the effect of cardiopulmonary bypass on various humoral and cellular components of blood is examined. Blood activation caused by interaction with artificial materials of extracorporeal circuit and by material-independent stimuli is discussed. Methods to control blood activation during and after cardiopulmonary bypass are described. These include surface modification of extracorporeal circuit, control of flow dynamics in the circuit, pharmacological intervention, and the use of extracorporeal devices to remove inflammatory mediators. Recent findings on the effects of heparin-coated circuits on inflammatory response and clinical outcome are reviewed. It appears that the causes of inflammatory response to cardiopulmonary bypass are multifactorial and that an integrated strategy is needed to control and eliminate the negative effects of CPB.

Release of lipopolysaccharide toxicity-modulating proteins in patients undergoing cardiopulmonary bypass using noncoated and heparin-coated extracorporeal circuits. A clinical pilot study

STUDY OBJECTIVE

Cardiopulmonary bypass (CPB) induces a generalized inflammatory response, including activation of leukocytes, contributing to postoperative morbidity. The inflammatory pathways leading to this systemic inflammatory response syndrome are considered identical to those involved in septic shock. Therefore, we studied the release of bactericidal/permeability-increasing protein (BPI), lipopolysaccharide binding protein (LBP), and soluble CD14 (sCD14)-all proteins that modulate the effects of lipopolysaccharide (LPS)-in patients undergoing CPB. In addition, the effect of heparin coating of the extracorporeal bypass circuit on the release of these parameters was assessed.

DESIGN

Prospective, randomized clinical pilot study.

SETTING

Cardiothoracic Surgery Department in a university hospital.

PATIENTS

Fourteen patients undergoing elective coronary artery bypass grafting were included. Seven patients underwent CPB using a standard, noncoated extracorporeal circuit, and seven patients had CPB using a heparin-coated extracorporeal circuit (Duraflo II).

INTERVENTIONS

Blood samples were taken after induction of anesthesia, just before aortic crossclamping, and 0, 0.5, 1.5, 3, 6, 12, and 24 h after declamping.

MEASUREMENTS AND RESULTS

CPB with a noncoated extracorporeal circuit induced a sharp increase in neutrophil-derived BPI, manifest directly after release of the aortic crossclamp, which was significantly attenuated using a heparin-coated system. Also, CPB induced a gradual increase of the acute-phase reactant LBP, which was identical in the noncoated and heparin-coated groups. Systemic release of sCD14 after crossclamp release was significantly higher in the noncoated group compared with the heparin-coated group, but did not rise above baseline levels.

CONCLUSIONS

These data confirm that CPB-induced leukocyte activation is attenuated using a heparin-treated extracorporeal circuit and point to the possible role of LPS toxicity-modulating proteins in the systemic inflammatory response after bypass surgery.

Duraflo II coating of cardiopulmonary bypass circuits reduces complement activation, but does not affect the release of granulocyte enzymes : a European multicentre study

OBJECTIVE

This study was carried out to: (a) compare complement and granulocyte activation during cardiac operations in patients operated with cardiopulmonary bypass coated with heparin by the Duraflo II method, with activation in patients operated with uncoated circuits; and (b) relate complement, and granulocyte activation to selected adverse effects.

METHODS

In a multicentre study among Rikshospitalet, Ullevaal Hospital in Norway and Uppsala University Hospital in Sweden, plasma concentrations of the complement activation products C4b/iC4b/C4c (C4bc), C3b/iC3b/C3c (C3bc), the terminal SC5b-9 complement complex (TCC), and the granulocyte proteins myeloperoxidase and lactoferrin were assessed in two groups of patients undergoing aortocoronary bypass. Seventy-six patients underwent surgery operated with circuits coated by the Duraflo II heparin coating and 75 uncoated circuits. The same amount of systemic heparin was administered to all patients.

RESULTS

In both groups a significant increase in C4bc was first seen by the end of operation, from 86.7 +/- 12.5 to 273.0 +/- 277.4 nM in controls and from 86.9 +/- 18.5 to 320.2 +/- 190.5 nM in the control group, confirming previous documentation that the classical pathway is not activated during CPB, but as a consequence of protamin administration. The formation of C4bc did not differ significantly between the two groups. In the uncoated group the C3bc concentration increased from 124.0 +/- 15.3 to a maximum of 1176.1 +/- 64.7 nM (P < 0.01) and in the coated group it increased from 129.8 +/- 16.1 to a maximum of 1019.4 +/- 54.9 nM (P < 0.01) during CPB. Summary values but not peak values differed significantly between the groups. In the uncoated group the TCC concentration increased from 0.52 +/- 0.03 to a maximum value of 8.09 +/- 0.57 AU/ml (P < 0.01) while in the coated group the TCC concentration increased from a baseline of 0.53 +/- 0.03 to a peak value of 5.2 +/- 0.24 AU/ml (P <0.01). The difference between the peak values was statistically significant (P = 0.00002). In both groups a significant increase in myeloperoxidase and lactoferrin release was observed by the end of operation. There was no difference in myeloperoxidase or lactoferrin release between the two groups. TCC levels were compared to the occurrence of perioperative infarction, development of lung or renal failure, postoperative bleeding, time on ventilator and days in hospital. Three patients developed perioperative infarction; the peak levels of TCC were significantly higher in these patients than in the 148 patients that did not develop infarction. The reduction in TCC formation in the heparin-coated group was not associated with differences in any of the other clinical parameters. Few adverse effects occurred in the study. The peak values of C3bc were higher in the patients needing inotropic support that in those who did not, the relevance of this finding remains uncertain.

CONCLUSION

It is concluded that the Duraflo II heparin coating reduces complement activation, particularly TCC formation, during CPB, but not the release of specific neutrophil granule enzymes. No certain correlation was established between complement and granulocyte activation and clinical outcome.

Extracorporeal circulation, hemocompatibility, and biomaterials

BACKGROUND

Performance of a majority of cardiac surgical procedures requires the use of extracorporeal circulation. Contact of the patients' blood with the nonendothelial surface of the cardiopulmonary bypass circuit is responsible for several, potentially harmful systemic reactions.

METHODS

The patients' response to extracorporeal circulation is reviewed briefly. The interactions between patient and circuit are discussed not only as they relate to blood-material contact, but also from a mechanical and rheologic standpoint. The theoretic benefits of the newer, more hemocompatible materials are presented, along with a review of published clinical experience with heparinized cardiopulmonary bypass circuits.

RESULTS

The response to extracorporeal circulation extends far beyond a simple derangement of hemostasis. This inflammatory response is strongly influenced by the rheologic design of the circuit and by the physical and chemical properties of the surface. Heparinized circuits decrease inflammation, but the clinical benefits of this reduction remain unclear, except for extended cardiopulmonary support. The safe use of these circuits requires full heparinization and does not reduce allogeneic transfusions.

CONCLUSIONS

Clinicians are still in the search of the ideal material and the ideal extracorporeal circuit design. Newer, heparinized materials offer real but limited clinical benefits.

Heparinized cardiopulmonary bypass and full heparin dose marginally improve clinical performance

BACKGROUND

The use of completely heparin coated cardiopulmonary bypass circuits in combination with a reduced systemic heparin dose has previously been shown to reduce postoperative bleeding after cardiac operations. However, it has remained unknown whether this effect was related to the improved biocompatibility of the heparin-treated surfaces per se or to the reduced exposure to circulating heparin. Therefore we investigated patients undergoing heparin-coated extracorporeal circulation and full systemic heparinization.

METHODS

Two hundred seventeen patients having first-time myocardial revascularization were prospectively randomized either to a group in which a completely ("tip-to-tip") heparin-coated circuit (Duraflo II) was used for perfusion (n = 107) or to a control group (n = 110) in which an uncoated, but otherwise identical, circuit was used. Full systemic heparinization was induced in both groups (activated clotting time, > 480 seconds). The postoperative blood loss, requirements for homologous blood transfusions, clinical performance, and complications were recorded.

RESULTS

The amount of postoperative mediastinal drainage was nearly identical in the two groups. The mean 18-hour drainage was 694 +/- 313 mL in the heparin-coated group and 679 +/- 269 mL in the control group (p = not significant). Three patients in the heparin-coated group and 6 patients in the control group received homologous red blood cell transfusions (p = not significant). The incidence of postoperative atrial fibrillation was significantly lower in the heparin-coated group (21.8%) than in the control group (43.1%) (p = 0.002). Otherwise, there were no significant differences in the extubation times, the incidence of perioperative myocardial infarction, the creatinine concentration, the incidence of neurologic dysfunction, the progress in physical rehabilitation, or the hemoglobin concentration at discharge.

CONCLUSIONS

The use of completely heparin coated cardiopulmonary bypass circuits and full systemic heparinization in patients undergoing coronary artery bypass procedures did not reduce postoperative bleeding or change clinical performance, except for a significant decrease in the incidence of postoperative atrial fibrillation.

Enhanced blood conservation and improved clinical outcome after valve surgery using heparin-bonded cardiopulmonary bypass circuits

BACKGROUND

Recently, heparin-bonded (HBC) cardiopulmonary bypass circuits (CPB) were formed to be associated with improved outcome after coronary artery bypass grafting. There are very few reports on the efficacy and safety of these circuits in valve surgery.

METHODS

A retrospective cohort study of all patient populations undergoing first time valve surgery from 1992 to 1995 in a tertiary teaching hospital. Outcomes of 120 patients undergoing valve surgery using HBC and lower anticoagulation HBC were compared to 232 patients treated with conventional circuits and full heparinization (nonheparin-bonded-circuit [NHBC]).

RESULTS

Postoperative 24-hour chest tube drainage (558 +/- 466 mL vs 1054 +/- 911 mL, p < 0.00001), and reoperation for bleeding (2.5% vs 8.2%, p = 0.04) were lower in the HBC group. HBC patients required significantly less transfusions (total donor exposure of 6.9 +/- 13.0 units vs 18.6 +/- 26.2 units, p < 0.00001). Multiple linear regression analysis identified CPB time as a predictor of increased homologous blood transfusions, and the use of HBC, a large body surface area, and elective procedure as predictors of decreased transfusions. Perioperative mortality was similar (HBC 2.5%, NHBC 4.7%, p = 0.24). Overall complications were lower in the HBC group (42% vs 56.2%, p = 0.02). Perioperative myocardial infarction (0.8% vs 1.3%, p = 0.58) and cerebrovascular accident (3.3% vs 3.9%, p = 0.53) were similar. Two (1.7%) HBC patients had valve re-replacement compared to none in the NHBC (p = 0.22). Multiple logistic regression model revealed that age and CPB time were associated with increased complications, and the use of HBC with reduced complications.

CONCLUSION

Use of HBCs with lower anticoagulation in valve surgery resulted in a significant reduction of transfusion requirements and improved clinical outcome. Because of a potential for early mechanical valve thrombosis, until further data is available, conventional levels of systemic anticoagulation should be achieved when using HBC in valve surgery.

Biocompatibility of heparin-coated extracorporeal bypass circuits: a randomized, masked clinical trial

Cardiopulmonary bypass circuits cause morbidity during cardiac operations. Plasma proteins and cellular components are stimulated by contact with the cardiopulmonary bypass circuit and can cause bleeding and postperfusion syndrome. This is especially true in patients undergoing reoperative cardiac procedures, which carries a higher risk of postoperative bleeding and prolonged ventilation compared with primary cardiac surgical procedures. Recently, cardiopulmonary bypass circuit surfaces have been coated with antithrombotic agents to improve their biocompatibility. This study evaluated the effect of a heparin-coated cardiopulmonary bypass system (Duraflo II, Baxter Bentley Healthcare Systems, Irvine, Calif.) on thrombin formation, platelet stimulation, and leukocyte activation in patients undergoing reoperative coronary artery bypass grafting or valve operation. Fifty patients were selected and randomly assigned to a standard noncoated control system (n = 26) or the Duraflo heparin-coated system (n = 24). Similar heparin doses were used in both groups (3 mg/kg). The heparin-coated group used a completely heparin-coated bypass circuit including the cardiotomy reservoir; arterial filters were heparin-coated in both groups. Samples were obtained before cardiopulmonary bypass, 30 minutes into cardiopulmonary bypass, 5 minutes after crossclamp removal, and 5 minutes after protamine administration. Thrombin formation (thrombin-antithrombin III by enzyme-linked immunosorbent assays) and platelet activation (beta-thromboglobulin by enzyme-linked immunosorbent assays; P-selectin expression by flow cytometry) were assayed. Leukocyte activation was determined by quantitative and qualitative analysis of arterial filters by scanning electron microscopy in six patients from each group. In both circuits, thrombin values increased markedly 30 minutes into cardiopulmonary bypass compared with baseline values (p < 0.001) (heparin-coated, 7 +/- 5 to 96 +/- 115 ng/ml; noncoated, 10 +/- 9 to 115 +/- 125 ng/ml). Platelet activation as measured by beta-thromboglobulin (heparin-coated, 104 +/- 100 to 284 +/- 166 IU/ml; noncoated, 81 +/- 74 to 288 +/- 277 IU/ml) and P-selectin expression (heparin-coated, 1.5% +/- 1.5% to 6.4% +/- 6.1%; noncoated, 1.4% +/- 1.1% to 6.2% +/- 4.3%) also significantly increased 30 minutes into cardiopulmonary bypass compared with baseline values (p < 0.001). Platelet activation and thrombin generation did not differ between the two circuits at any time. Granulocyte activation and platelet deposition did not differ between the two circuits when arterial filters were evaluated. Both groups had similar heparin and protamine administration, blood transfusions, postoperative alveolar-arterial oxygen gradient, time to extubation, length of intensive care unit stay, and overall morbidity and mortality. Clinical outcome and blood loss did not differ between the groups. We conclude that heparin-coated cardiopulmonary bypass circuits did not improve biochemical or clinical markers of biocompatibility in a reoperative patient population.

Tubing loops as a model for cardiopulmonary bypass circuits: both the biomaterial and the blood-gas phase interfaces induce complement activation in an in vitro model

We describe here a model for the study of blood/surface and blood/air interaction as encountered in cardiopulmonary bypass (CPB) circuits. Polyethylene tubing was filled with serum or blood and closed end to end into loops whereby the volume of the remaining air bubble was inversely varied with respect to that of the fluid. The loops were rotated vertically in a water bath at 37 degrees C. The profiles of C3a, iC3, and TCC generation were similar to those observed at surgery, involving CPB. Soluble heparin and heparan sulfate inhibited both C3a and TCC formation, but surface-conjugated heparin had only a minor effect. Binding of C3 and/or C3 fragments to the heparin surface was much reduced compared to the amine matrix to which heparin was linked, but compared with the polyethylene surface the effect was less pronounced. These data suggest that, in addition to the biomaterial surface, the blood-gas interface seems to play an important role in the activation of complement and that this activation is inhibitable by high concentrations of soluble glucose aminoglycans.

Heparin-coated circuits and aprotinin prime for coronary artery bypass grafting

BACKGROUND

The biocompatibility of an extracorporeal circuit is improved by heparin bonding onto its inner surface. To determine the effect of heparin-coated circuits for cardiopulmonary bypass with aprotinin prime on postoperative recovery and resource utilization, a prospective study was done in 102 patients undergoing coronary artery bypass grafting with full systemic heparinization.

METHODS

Patients were randomly allocated to be treated with either a heparin-coated circuit (n = 51) or an uncoated circuit (n = 51). Differences in blood loss, need for blood transfusion, morbidity, and intensive care stay were analyzed.

RESULTS

No differences in blood loss and need for blood transfusion were found between the groups. The relative risk for adverse events in the heparin-coated group was 0.29 (95% confidence interval ranging from 0.10 to 0.80). Adverse events included myocardial infarction (2 patients in the uncoated group versus 0 in the heparin-coated group), rethoracotomy for excessive bleeding (1 versus 2), rhythm disturbance (7 versus 2), respiratory insufficiency (4 versus 0), and neurologic dysfunction (2 versus 0). The lower incidence of adverse events in the heparin-coated group was associated with a shorter intensive care stay (median, 2 days; range, 2 to 5 days) compared with the uncoated group (median, 3 days; range, 2 to 19 days, p = 0.03). The cost savings of 1 day of intensive care stay counterbalanced the additional costs of heparin-coated circuits.

CONCLUSIONS

The use of heparin-coated circuits for cardiopulmonary bypass with aprotinin prime resulted in a significant reduction in mobidity in the early postoperative phase and a concomitant decrease in intensive care stay, resulting in important cost savings.

Heparin-coated bypass circuits in cardiopulmonary bypass: improved biocompatibility or not

Heparin bonding to bypass circuits has been found to reduce bleeding complications. Here, this process is reviewed with special attention to markers of inflammation and clinical outcome. Indicators of inflammation (i.e. cytokine levels, elastase and complement components) are decreased when using heparin bonded circuits compared to conventional bypass circuits. The decrease in the levels of these response modifiers appears minimal. Clinical outcomes, other than bleeding complications, have not been studied to any great extent with this technology. These lower levels of the various biological response modifiers are not correlated with lower levels of complications or shorter hospital stays. We conclude based on this data that it is not clear if this decrease translates into a clinical benefit in routine operative cases that require cardiopulmonary bypass.

Risk factors for postoperative morbidity

OBJECTIVE

Analysis of outcomes after coronary artery bypass grafting has focused on risk factors for operative mortality. Nonfatal perioperative morbidity is far more costly and more common after operation. To identify the risk factors that lead to postoperative morbidity, we evaluated 938 patients undergoing coronary artery bypass grafting at Albany Medical Center Hospital during 1993.

METHODS

Multivariate statistical analysis was performed on preoperative patient variables to identify risk factors for either serious postoperative morbidity or increased hospital length of stay. Variables were considered both individually and in combination. For example, age was considered individually or in combination with other variables, including parameters of blood volume (i.e., age divided by red blood cell volume or Age/RBCVOL). Similar multivariate analysis was performed to identify independent risk factors for hospital mortality.

RESULTS

In order of decreasing importance, the following patient variables were significantly associated with increased length of stay by stepwise Cox regression analysis: Age/RBCVOL, history of congestive heart failure, hypertension, femoral-popliteal peripheral vascular disease, chronic obstructive lung disease, and renal dysfunction. The combination variable, Age/RBCVOL, was an important risk factor for both increased length of stay and serious postoperative morbidity. Variables that were significant independent predictors of increased mortality, such as preoperative shock, and redo operation, were not risk factors for either serious morbidity or increased length of stay.

CONCLUSIONS

We conclude that risk factors for postoperative morbidity are different from those for postoperative mortality. These results suggest that older patients with preoperative anemia and low blood volume who also have other comorbidities (congestive heart failure, stroke, chronic obstructive pulmonary disease, or hypertension) are at increased risk for postoperative complications. This allows identification of a high-risk cohort of patients who are likely candidates for interventions to lessen postoperative morbidity.