Factors affecting the ethanol stability of bovine casein micelles: 3. Substitution of ethanol by other organic solvents

Method to prepare aqueous propolis dispersions based on phase separation

Propolis has many benefits for human health. To facilitate its oral consumption, we designed propolis-in-water dispersions to be used as nutraceuticals. Propolis was first dissolved either in ethanol or in a hydroalcoholic solution. Water being a non-solvent for propolis, its addition produced propolis precipitation. We explored the ternary phase diagram of water, propolis and ethanol to identify the line separating the one phase region where propolis is fully dissolved, and the two-phase region where a concentrated propolis solution coexists with a dilute one. Droplets rich in propolis were produced during the phase separation process under mechanical stirring induced by a rotor-stator device or a microfluidizer, and they were stabilized using gum Arabic as an emulsifier. Ethanol was finally removed by distillation under reduced pressure. Propolis dispersions in the micron and submicron size range could be obtained. They contained between 1.75 and 10.5 wt% polyphenols relative to the total mass.

Casein maps: effect of ethanol, pH, temperature, and CaCl2 on the particle size of reconstituted casein micelles

Although conditions favoring casein micelle aggregation are well known, factors promoting the dissociation of the casein micelle are not fully understood. It was our objective to investigate the ethanol-induced dissociation of micellar casein as affected by temperature and a wide range of pH, along with the concentrations of calcium and casein. Two different concentrations of casein micelles were dispersed in imidazole buffer with 0 to 80% ethanol (vol/vol) and 2 and 10mM calcium. Apparent micelle size was determined by dynamic light scattering at 5, 30, and 60°C. In the absence of ethanol, casein precipitation occurred at pH 4.6 in imidazole buffer. Ten to forty percent ethanol promoted casein aggregation (>1,000 nm) and higher temperature (30 and 60°C) enhanced this effect. Higher ethanol concentrations at 50 to 80% induced the dissociation (<40 nm) of the casein micelle upon acidification (pH <5) and alkalization (pH>8) in imidazole buffer. In addition, higher concentrations of casein (0.25mg/mL) and calcium (20mM) caused the formation of larger aggregates (>1,000 nm) in the presence of ethanol when comparing with the initial lower concentrations of casein (0.1mg/mL) and calcium (2mM). Casein micelle dissociation can be achieved near the isoelectric pH by modifying the solvent composition and temperature.

Milk stability in ethanolic solutions

We have investigated the role of pH in the destabilization of milk and sodium caseinate solutions by ethanol. Ethanol shifted the pH of minimum stability of both caseinate and milk to higher values. A linear relation between this pH and the reciprocal dielectric constant of the mixture was observed. The addition of calcium to these alcoholic mixtures also increased the pH of minimum stability. The results are discussed in terms of the alcohol-induced shifts in the pK values of important constituent amino acids and of the effect of alcohol on soluble Ca levels.

Rennet coagulation of milk in the presence of sucrose

The aim of this work was to test the diffusion-controlled hypothesis of milk coagulation kinetics by reducing the diffusion coefficient of casein micelles. This has been achieved by increasing the solvent viscosity of milk through sucrose addition. Milk was reconstituted from skim milk powder and sucrose added at 100–300 g kg–1. Hydrolysis and coagulation were followed by chromatographic determination of caseinomacropeptide content and optical, thermal and viscoelastic measurements. Soluble and ionic calcium were determined by atomic absorption spectrophotometry and ionometry and micelle size was measured by dynamic light scattering. Addition of sucrose resulted in a substantial retardation of both enzymic and aggregation steps, a re-equilibration of calcium because of water reduction, and a micelle size increase. The enzymic rate constant was inversely proportional to the viscosity, according to a diffusion-controlled model, and the lag or characteristic times for the aggregation reaction were inversely proportional to the viscosity. These results are consistent with the involvement of diffusion-controlled steps in the sequence of reactions.

Factors affecting the ethanol stability of bovine milk: V. Effects of chemical modification of milk protein

The effect of chemical modification of milk protein on the ethanol (EtOH) stability of skim-milk has been investigated. Modification of lysine residues by reaction with anhydrides increased the EtOH stability whereas amidation of carboxyl groups destabilized the milk. Lysine modification also counteracted destabilization induced by Ca2+addition. By using multiple linear regression techniques these latter effects can be accounted for in terms of the changes they bring about in micellar charge. These results provide a further verification and an extension of the previously proposed mechanism for EtOH-induced coagulation of skim-milk.

Ethanol stability of casein micelles – a hypothesis concerning the role of calcium phosphate

The ethanol (EtOH) stability of skim milk and the stability towards aggregation of casein micelles diluted into ethanolic buffer solutions were compared using data obtained from previously published experiments. Differences in absolute stability and in relative response were observed when Ca2+ level and pH were adjusted, the buffer system results lying below those from skim milk in both cases. Increasing the ionic strength of skim milk adjusted to pH 7·0 lowered its EtOH stability whereas increasing the ionic strength of the diluting buffer increased the stability of the casein micelles. The hypothesis is put forward that the differences are due to the simultaneous precipitation of Ca phosphate when EtOH is added to skim milk. This draws calcium from the caseinate sites of the micelle, counteracting the destabilizing effects of the EtOH towards the micelle. Such removal and the consequent restructuring are kinetically controlled and micellar precipitation in skim milk finally occurs when the micellar coagulation time falls within the time scale of the restructuring reactions.

Stability and rheology of emulsions containing sodium caseinate: combined effects of ionic calcium and alcohol

We have investigated the combined effect of ionic calcium and ethanol on the visual creaming behavior and rheology of sodium caseinate-stabilized emulsions (4 wt% protein, 30 vol% oil, pH 6.8, mean droplet diameter 0.4 microm). A range of ionic calcium concentrations, expressed as a calcium/caseinate molar ratio R, was adjusted prior to homogenization and varying concentrations of ethanol were added shortly after homogenization. A stability map was produced on the basis of visual creaming behavior over a minimum period of 8 h for different calcium/caseinate/ethanol emulsion compositions. A single narrow stable (noncreaming) region was identified, indicating limited cooperation between calcium ions and ethanol. The shear-thinning behavior of the caseinate-stabilized emulsions is typical of systems undergoing depletion flocculation. Addition of calcium ions and/or ethanol was found to lead to a pronounced reduction in viscosity and the onset of Newtonian flow. The state of aggregation was correlated with emulsion microstructure from confocal laser scanning microscopy. Time-dependent rheology (18 h) with a density-matched oil phase (1-bromohexadecane) revealed that the visually stable emulsions were time-independent low-viscosity fluids. Surface coverage data showed that increasing amounts of caseinate were associated with the oil-water interface with increasing R and ethanol content. A decrease in free calcium ions in the aqueous phase with moderate increases in R and ethanol content was observed, which is consistent with greater calcium-caseinate binding (aggregation). Ostwald ripening occurred at the high-ethanol emulsion compositions that were stable to depletion flocculation. While the coarsening rate was low, this can account for the cream plug formation observed during gravity creaming experiments. The caseinate emulsion with no ionic calcium or ethanol exhibits depletion flocculation from excess nonadsorbed caseinate submicelles. Addition of calcium ions reduces the submicelle number density via specific calcium-binding in the aqueous phase (fewer, larger calcium-caseinate aggregates) and at the droplet surface (increased surface coverage). Nonspecific ethanol-induced (calcium-dependent) caseinate submicelle aggregation in the bulk phase and on the droplet surface (increased surface coverage) culminates in a reduction in the number density of caseinate submicelles. A narrow window of inhibition of depletion flocculation occurs in systems containing both calcium ions and ethanol, both species combining to aggregate the protein and so reduce the density of free submicelles.

Mechanism for the ethanol-dependent heat-induced dissociation of casein micelles

An explanation as to how casein micelles dissociate when heated in the presence of ethanol is presented. Dissociation of casein micelles in milk-ethanol mixtures was studied using (1)H NMR, and the effects of addition of CaCl(2), NaCl, or EDTA or alteration of milk pH on this dissociation were studied. It is proposed that at low temperatures, ethanol reduces the solvent quality of milk serum, but above a critical temperature (approximately 30 degrees C in a 35% ethanol solution), ethanol enhances solvent quality and dissociates the casein micelles. Ethanol reduced protein hydrophobicity and increased the pK(a) value of phosphoserine, effects that are likely to be significant in the dissociating effect of ethanol at elevated temperatures.