A Rapid and sensitive method for estimation of galactose in parmesan cheese

Disintegration of the agricultural by-product wheat bran under subcritical conditions

BACKGROUND

The disintegration of destarched wheat bran in water and sulfuric acid (pH 3) under subcritical conditions (275-300 °C) and at short reaction times (1-4 min) was investigated. A cascade process comprising a stepwise separation of the liquid was applied to reduce the formation of undesired degradation products.

RESULTS

The highest degree of biomass disintegration (67% dry mass solubilization) was achieved by application of a cascade process at 275 °C (pH 3). Regarding the dissolution of carbohydrates (monomeric and oligomeric form), the total glucose yields remained below 60%, while the total xylose and arabinose yields were about 76% and 67%. Approximately 74% of the protein and 95% of the mineral fraction could be extracted. The application of the cascade process enabled a substantially reduced formation of degradation products.

CONCLUSION

When operating hydrothermally and subcritically in order to avoid some problematic aspects of a biorefinery, an extensive disintegration and monomerization of wheat bran and its constituents remains difficult even under the tested conditions (300 °C, pH 3). However, the applied cascade process proved to be useful to increase the yields and to substantially reduce the formation of undesired degradation products. Despite this fact, increased water consumption has to be conceded. © 2018 Society of Chemical Industry.

Lactose, galactose and glucose determination in naturally "lactose free" hard cheese: HPAEC-PAD method validation

A chromatographic method by HPAEC-PAD was developed and in-house validated for the quantification of low sugar levels in hard cheese, specifically Grana Padano PDO cheese. Particular attention was paid to the extraction procedure, due to residual microbial and enzymatic activities. Specificity in detection and linearity were verified. Recoveries ranged from 93% for lactose to 98% for glucose and galactose. The obtained LOD and LOQ values were, respectively, 0.25 and 0.41mg/100g for lactose, 0.14 and 0.27mg/100g for galactose, and 0.16 and 0.26mg/100g for glucose. The method was applied to 59 samples of Grana Padano PDO cheese: galactose showed the highest concentration and variability among the samples (1.36±0.89), compared to both lactose (0.45±0.12) and glucose (0.46±0.13). Considering the very low levels of sugars detected, authentic PDO Grana Padano could be safely included in the diet of people suffering from lactose intolerance.

A re-evaluation of life-long severe galactose restriction for the nutrition management of classic galactosemia

The galactose-restricted diet is life-saving for infants with classic galactosemia. However, the benefit and extent of dietary galactose restriction required after infancy remain unclear and variation exists in practice. There is a need for evidence-based recommendations to better standardize treatment for this disorder. This paper reviews the association between diet treatment and outcomes in classic galactosemia and evaluates the contribution of food sources of free galactose in the diet. Recommendations include allowing all fruits, vegetables, legumes, soy products that are not fermented, various aged cheeses and foods containing caseinates. Further research directions are discussed.

Galactose content of legumes, caseinates, and some hard cheeses: implications for diet treatment of classic galactosemia

There are inconsistent reports on the lactose and/or galactose content of some foods traditionally restricted from the diet for classic galactosemia. Therefore, samples of cheeses, caseinates, and canned black, pinto, kidney, and garbanzo beans were analyzed for free galactose content using HPLC with refractive index or pulsed amperometric detection. Galactose concentrations in several hard and aged cheeses and three mild/medium Cheddars, produced by smaller local dairies, was <10 mg/100 g sample compared to 55.4 mg/100 g sample in four sharp Cheddars produced by a multinational producer. Galactose in sodium and calcium caseinate ranged from undetectable to 95.5 mg/100 g sample. Free galactose level in garbanzo beans was lower than previously reported at 24.6 mg/100 g sample; black beans contained 5.3 mg/100 g, and free galactose was not detected in red kidney or pinto beans. These data provide a basis for recommending inclusion of legumes, caseinate-containing foods, and some aged hard cheeses that had been previously restricted in the diet for individuals with galactosemia.

Wheat bran biorefinery--a detailed investigation on hydrothermal and enzymatic treatment

Due to the enormous quantities arising in the milling industry and its specific properties, wheat bran can be considered as a feedstock for future biorefineries. In the present work, a detailed investigation was carried out on the hydrothermal (140-200°C) and enzymatic treatment of wheat bran. After hydrothermal pretreatment and a subsequent enzymatic hydrolysis a glucose yield of 65% and 90% was achieved, respectively. Interestingly, the hemicelluloses could be disintegrated to monomers only to approx. 50%. About 70% of the proteins were dissolved, however, practically no free amino acids were obtained under given conditions. Severe treatment conditions induce elevated losses of some amino acids. Minerals could be extracted almost completely. To disintegrate fat into glycerol and fatty acids severe process conditions were necessary. The formation of undesired by-products such as furfural or hydroxymethylfurfural starts at approx. 180°C.