Phycoremediation of cheese whey permeate using directed commensalism between Scenedesmus obliquus and Chlorella protothecoides

Microalgal conversion of whey and lactose containing substrates: current state and challenges

Currently dairy processing by-products, such as whey, still propose a significant threat to the environment if unproperly disposed. Microalgal bioconversion of such lactose containing substrates can be used for production of valuable microalgae-derived bio-products as well as for significant reduction of environmental risks. Moreover, it could significantly reduce microalgae biomass production costs, being a significant obstacle in commercialization of many microalgae species. This review summarizes current knowledge on the use of lactose containing substrates, e.g. whey, for the production of value-added products by microalgae, including information on producer cultures, fermentation methods and cultivation conditions, bioprocess productivity and ability of microalgal cultures to produce β-galactosidases. It can be stated, that despite several limitations lactose-containing substrates can be successfully used for both-the production of microalgal biomass and removal of high amounts of excess nutrients from the cultivation media. Moreover, co-cultivation of microalgae and other microorganisms can further increase the removal of nutrients and the production of biomass. Further investigations on lactose metabolism by microalgae, selection of suitable strains and optimisation of the cultivation process is required in order to enable large-scale microalgae production on these substrates.

Whey permeate as a phosphorus source for algal cultivation

Microalgal cultivation for biodiesel and feed requires recycled nutrient resources for a sustainable long-term operation. Whey permeate (WP) from dairy processing contains high organic load (lactose, oils, and proteins) and nitrogen (resources tested for microalgal cultivation) and organic phosphorus (P) that has not yet been tested as a P source for microalgal cultivation. We explored the potential of green algae strains (brackish) and polyculture (freshwater) in exploiting P from WP added to a medium based on either seawater (7 psu) or landfill leachate. Both strains showed a capacity of using organic P in WP with equal growth rates (0.94-1.12 d^-1 ) compared with chemical phosphate treatments (0.88-1.07 d^-1 ). The polyculture had comparable growth rate (0.25-0.57 d^-1 ) and biomass yield (152.1-357.5 mg L^-1 ) and similar or higher nutrient removal rate in the leachate-WP medium (1.3-6.4 mg L^-1  day^-1 nitrogen, 0.2-1.1 mg L^-1  day^-1 P) compared with the leachate-chemical phosphate medium (1.2-4.7 mg L^-1  day^-1 nitrogen, 0.3-1.4 mg L^-1  day^-1 P). This study showed that WP is a suitable P source for microalgal cultivation over a range of salinities. To date, this is the first study demonstrating that raw WP can replace mineral P fertilizer for algal cultivation. PRACTITIONERS POINTS: Whey permeate is a comparable phosphorus source to standard fertilizers used in algal cultivation. Green algae removed phosphorus effectively from whey permeate. Microalgal cultivation is a good approach for treatment of whey permeate in combination with a nitrogen-rich wastewater.

Nitrogen and phosphate removal from dairy processing side-streams by monocultures or consortium of microalgae

Acid-casein production generates waste streams that are rich in nitrogen (in the form of protein and nitrate) and phosphate. This makes this type of waste very difficult to treat using conventional techniques resulting in a high amount of operating cost and costly investment. In this research, the application of single culture or consortium of microalgae for uptake of nitrogen and phosphate in the wastewater of an acid-casein factory was investigated. The waste was a 1:1 mixture of nanofiltered whey permeate and dairy processing wastewater. Monocultures of Chlorella vulgaris, Tetradesmus obloquus, Nonnochlropsis ocenica and a consortium of the three microalgae were analyzed. The results showed that the consortium exhibited more efficient nitrogen and phosphate removal compared to the individual species. The consortium was able to rapidly hydrolyse exogenous protein present in the waste medium, removing 88% of protein and breaking down complex protein molecules into simpler compounds (such as nitrate) for assimilation into the biomass. In the first fourteen days of cultivation, the rate of nitrate assimilation by the consortium biomass was lower than that of nitrate formation from protein degradation, leading to a net increase in nitrate concentration in the medium. As protein source was depleted and biomass concentration increased, however, the rate of nitrate assimilation began to exceed that of nitrate formation allowing for net removal of nitrate. The microalgae consortium was shown to successfully bioremediate all nitrates by day 21. It was indicated that Chlorella and Nannochloropsis species were responsible for nitrogen removal in monocultures. Phosphate, on the other hand, was efficiently removed by Tetradesmus. The results indicated that a consortium cultivation of three species of microalgae led to effective elimination of both nitrogen and phosphate. Combined flow-cytometry and microscopy analyses revealed that Chlorella overtook Tetradesmus and Nannochloropsis to emerge as the dominant population in the consortium by the end of the cultivation cycle. It can be concluded that the application of microalgae consortium for simultaneous recovery of nitrogen and phosphate is a promising approach for treating acid-casein wastewater.

Effects of the induction of anoxia in photobioreactor on effective cultivation of Scenedesmus acuminatus under mixotrophic cultivation mode

The purpose of this study was to investigate the optimum conditions of several factors (i.e. types and concentration of acetate, aeration rate, pH control) for maximizing the mixotrophic cultivation of Scenedesmus acuminatus using acetate as an organic carbon source. When acetate was used, dissolved oxygen (DO) was quickly consumed and resulted in an anoxic condition for 52 h. Then, DO increased quickly by photosynthetic reaction. Whenever we put acetate in a reactor after DO was recovered to higher than 7 mg/L, cells were quickly grown via cell respiration, which subsequently resulted in an anoxic condition. Compared to aeration, ammonium acetate, ammonium acetate with aeration tests, the highest maximum biomass productivity of 0.73 g/L/d was obtained for pH control test with ammonium acetate dosage. From this study, we found that DO was essential for the fast assimilation of acetate and depleted DO was quickly regenerated for pH control test. From this fact, we found that pH control test with ammonium acetate dosage was the best cultivation method for Scenedesmus acuminatus under mixotrophic condition. These findings could be a useful reference for maximizing the cultivation of S. acuminatus in industrial-scale applications.

The Role of Heterotrophic Microalgae in Waste Conversion to Biofuels and Bioproducts

In the last few decades, microalgae have attracted attention from the scientific community worldwide, being considered a promising feedstock for renewable energy production, as well as for a wide range of high value-added products such as pigments and poly-unsaturated fatty acids for pharmaceutical, nutraceutical, food, and cosmetic markets. Despite the investments in microalgae biotechnology to date, the major obstacle to its wide commercialization is the high cost of microalgal biomass production and expensive product extraction steps. One way to reduce the microalgae production costs is the use of low-cost feedstock for microalgae production. Some wastes contain organic and inorganic components that may serve as nutrients for algal growth, decreasing the culture media cost and, thus, the overall process costs. Most of the research studies on microalgae waste treatment use autotrophic and mixotrophic microalgae growth. Research on heterotrophic microalgae to treat wastes is still scarce, although this cultivation mode shows several benefits over the others, such as higher organic carbon load tolerance, intracellular products production, and stability in production all year round, regardless of the location and climate. In this review article, the use of heterotrophic microalgae to simultaneously treat wastes and produce high value-added bioproducts and biofuels will be discussed, critically analyzing the most recent research done in this area so far and envisioning the use of this approach to a commercial scale in the near future.

The Prospects of Agricultural and Food Residue Hydrolysates for Sustainable Production of Algal Products

The growing demand of microalgal biomass for biofuels, nutraceuticals, cosmetics, animal feed, and other bioproducts has created a strong interest in developing low-cost sustainable cultivation media and methods. Agricultural and food residues represent low-cost abundant and renewable sources of organic carbon that can be valorized for the cultivation of microalgae, while converting them from an environmental liability to an industrial asset. Biochemical treatment of such residues results in the release of various sugars, primarily glucose, sucrose, fructose, arabinose, and xylose along with other nutrients, such as trace elements. These sugars and nutrients can be metabolized in the absence of light (heterotrophic) or the presence of light (mixotrophic) by a variety of microalgae species for biomass and bioproduct production. The present review provides an up-to-date critical assessment of the prospects of various types of agricultural and food residues to serve as algae feedstocks and the microalgae species that can be grown on such residues under a range of cultivation conditions. Utilization of these feedstocks can create potential industrial applications for sustainable production of microalgal biomass and bioproducts.

Assessment upon heterotrophic microalgae screened from wastewater microbiota for concurrent pollutants removal and biofuel production

Heterotrophic microalgae, capable of converting organic carbons to biofuel, as well as assimilating nutrients, have a great prospective in wastewater treatment. Meanwhile, the knowledge about heterotrophic microalgae is still far less than the autotrophic conterpart. Hence, in this study, 20 heterotrophic microalgal strains were isolated from a domestic wastewater treatment plant, and identified according to morphology and partial 18S and 23S rRNA gene sequences. Further, their biological traits were assessed in terms of N, P, TOC removal efficiencies, growth parameters, self-settleability and lipids production, expressed through a comprehensive selection index. By such, the optimal strains were chosen and applied back to treat the real wastewater, with or without pretreatment of sterilization. An organic-adaptable strain, i.e., Botryococcus sp. NJD-1, was ultimately recommended to achieve the concurrent biofuel production (up to 61.7% lipid content) and pollutants removal (up to 64.5%, 89.8% and 67.9% for N, P and TOC) in pristine wastewater.