The aldehyde/alcohol dehydrogenase (AdhE) in relation to the ethanol formation in Thermoanaerobacter ethanolicus JW200

Acetogen and acetogenesis for biological syngas valorization

The bioconversion of syngas using (homo)acetogens as biocatalysts shows promise as a viable option due to its higher selectivity and milder reaction conditions compared to thermochemical conversion. The current bioconversion process operates primarily to produce C2 chemicals (e.g., acetate and ethanol) with sufficient technology readiness levels (TRLs) in process engineering (as midstream) and product purification (as downstream). However, the economic feasibility of this process could be improved with greater biocatalytic options in the upstream phase. This review focuses on the Wood-Ljungdahl pathway (WLP) which is a biological syngas-utilization pathway, redox balance and ATP generation, suggesting that the use of a specific biocatalysts including Eubacterium limosum could be advantageous in syngas valorization. A pertinent strategy to mainly produce chemicals with a high degree of reduction is also provided with examples of flux control, mixed cultivation and mixotrophy. Finally, this article presents future direction of industrial utilization of syngas fermentation.

Characterization of Thermotoga neapolitana Alcohol Dehydrogenases in the Ethanol Fermentation Pathway

Hyperthermophilic Thermotoga spp. are candidates for cellulosic ethanol fermentation. A bifunctional iron-acetaldehyde/alcohol dehydrogenase (Fe-AAdh) has been revealed to catalyze the acetyl-CoA (Ac-CoA) reduction to form ethanol via an acetaldehyde intermediate in Thermotoga neapolitana (T. neapolitana). In this organism, there are three additional alcohol dehydrogenases, Zn-Adh, Fe-Adh1, and Fe-Adh2, encoded by genes CTN_0257, CTN_1655, and CTN_1756, respectively. This paper reports the properties and functions of these enzymes in the fermentation pathway from Ac-CoA to ethanol. It was determined that Zn-Adh only exhibited activity when oxidizing ethanol to acetaldehyde, and no detectable activity for the reaction from acetaldehyde to ethanol. Fe-Adh1 had specific activities of approximately 0.7 and 0.4 U/mg for the forward and reverse reactions between acetaldehyde and ethanol at a pHopt of 8.5 and Topt of 95 °C. Catalyzing the reduction of acetaldehyde to produce ethanol, Fe-Adh2 exhibited the highest activity of approximately 3 U/mg at a pHopt of 7.0 and Topt of 85 °C, which were close to the optimal growth conditions. These results indicate that Fe-Adh2 and Zn-Adh are the main enzymes that catalyze ethanol formation and consumption in the hyperthermophilic bacterium, respectively.

Transcriptomic Analysis of the Molecular Response Mechanism of Microcystis aeruginosa to Iron Limitation Stress

Iron is an essential micronutrient for cyanobacteria. It is involved in physiological activities such as photosynthesis, respiration, and the synthesis of pigments. The impact of iron limitation on planktonic algae growth occurs in surface oceans globally, as well as in freshwater ecosystems. However, the molecular and physiological effects and response mechanism of cyanobacteria under iron-limited conditions have not been reported in detail. In this study, the effects of iron limitation on the cell density, chlorophyll content, and photosynthetic activity of Microcystis aeruginosa were determined, and transcriptome sequencing was undertaken. In a severely iron-deficient environment, the cell density and chlorophyll-a content of M. aeruginosa were significantly lower than in the iron-rich group (a 55.42% and 83.51% reduction, respectively). Similarly, the photosynthetic efficiency of M. aeruginosa was also inhibited by iron deficiency, and the maximum photochemical efficiency (Fv/Fm) of the severe iron deficiency group was only 66.72% of the control group. The transcriptome results showed that to cope with the iron-deficient environment, most genes involved in iron absorption and transport in M. aeruginosa were up-regulated. In particular, the fur and perR genes that regulate the iron uptake regulatory protein (Fur) were both up-regulated. Due to the high demand for iron in the photosynthetic electron transport chain of M. aeruginosa, most photosynthesis-related genes were down-regulated, for example, petJ, which regulates iron-containing cytochrome c6. In contrast, most of the genes related to glycolysis and respiration were up-regulated. These changes in gene expression may be a survival strategy for M. aeruginosa to cope with a long-term iron-deficient environment. This study provides insights into the molecular response mechanism of M. aeruginosa under iron limitation stress.

Engineered bacteria for valorizing lignocellulosic biomass into bioethanol

Appropriate bioprocessing of lignocellulosic materials into ethanol could address the world's insatiable appetite for energy while mitigating greenhouse gases. Bioethanol is an ideal gasoline extender and is widely used in many countries in blended form with gasoline at specific ratios to improve fuel characteristics and engine performance. Although the bioethanol production industry has long been operational, finding a suitable microbial agent for the efficient conversion of lignocelluloses is still an active field of study. Among available microbial candidates, engineered bacteria may be promising ethanol producers while may show other desired traits such as thermophilic nature and high ethanol tolerance. This review provides the current knowledge on the introduction, overexpression, and deletion of the genes that have been performed in bacterial hosts to achieve higher ethanol yield, production rate and titer, and tolerance. The constraints and possible solutions and economic feasibility of the processes utilizing such engineered strains are also discussed.

Methanol and methyl group conversion in acetogenic bacteria: biochemistry, physiology and application

The production of bulk chemicals mostly depends on exhausting petroleum sources and leads to emission of greenhouse gases. Within the last decades the urgent need for alternative sources has increased and the development of bio-based processes received new attention. To avoid the competition between the use of sugars as food or fuel, other feedstocks with high availability and low cost are needed, which brought acetogenic bacteria into focus. This group of anaerobic organisms uses mixtures of CO2, CO and H2 for the production of mostly acetate and ethanol. Also methanol, a cheap and abundant bulk chemical produced from methane, is a suitable substrate for acetogenic bacteria. In methylotrophic acetogens the methyl group is transferred to the Wood-Ljungdahl pathway, a pathway to reduce CO2 to acetate via a series of C1-intermediates bound to tetrahydrofolic acid. Here we describe the biochemistry and bioenergetics of methanol conversion in the biotechnologically interesting group of anaerobic, acetogenic bacteria. Further, the bioenergetics of biochemical production from methanol is discussed.

A novel bifunctional aldehyde/alcohol dehydrogenase catalyzing reduction of acetyl-CoA to ethanol at temperatures up to 95 °C

Hyperthermophilic Thermotoga spp. are excellent candidates for the biosynthesis of cellulosic ethanol producing strains because they can grow optimally at 80 °C with ability to degrade and utilize cellulosic biomass. In T. neapolitana (Tne), a putative iron-containing alcohol dehydrogenase was, for the first time, revealed to be a bifunctional aldehyde/alcohol dehydrogenase (Fe-AAdh) that catalyzed both reactions from acetyl-coenzyme A (ac-CoA) to acetaldehyde (ac-ald), and from ac-ald to ethanol, while the putative aldehyde dehydrogenase (Aldh) exhibited only CoA-independent activity that oxidizes ac-ald to acetic acid. The biochemical properties of Fe-AAdh were characterized, and bioinformatics were analyzed. Fe-AAdh exhibited the highest activities for the reductions of ac-CoA and acetaldehyde at 80-85 °C, pH 7.54, and had a 1-h half-life at about 92 °C. The Fe-AAdh gene is highly conserved in Thermotoga spp., Pyrococcus furiosus and Thermococcus kodakarensis, indicating the existence of a fermentation pathway from ac-CoA to ethanol via acetaldehyde as the intermediate in hyperthermophiles.

Overcoming Energetic Barriers in Acetogenic C1 Conversion

Currently one of the biggest challenges for society is to combat global warming. A solution to this global threat is the implementation of a CO₂-based bioeconomy and a H₂-based bioenergy economy. Anaerobic lithotrophic bacteria such as the acetogenic bacteria are key players in the global carbon and H₂ cycle and thus prime candidates as driving forces in a H₂- and CO₂-bioeconomy. Naturally, they convert two molecules of CO₂via the Wood-Ljungdahl pathway (WLP) to one molecule of acetyl-CoA which can be converted to different C2-products (acetate or ethanol) or elongated to C4 (butyrate) or C5-products (caproate). Since there is no net ATP generation from acetate formation, an electron-transport phosphorylation (ETP) module is hooked up to the WLP. ETP provides the cell with additional ATP, but the ATP gain is very low, only a fraction of an ATP per mol of acetate. Since acetogens live at the thermodynamic edge of life, metabolic engineering to obtain high-value products is currently limited by the low energy status of the cells that allows for the production of only a few compounds with rather low specificity. To set the stage for acetogens as production platforms for a wide range of bioproducts from CO₂, the energetic barriers have to be overcome. This review summarizes the pathway, the energetics of the pathway and describes ways to overcome energetic barriers in acetogenic C1 conversion.

Construction of Recombinant Klebsiella pneumoniae to Increase Ethanol Production on Residual Glycerol Fed-Batch Cultivations

K. pneumoniae BLh-1 strain was genetically modified aiming at obtaining high ethanol productivity in cultivations using residual glycerol from biodiesel synthesis as substrate. The recombinant strain K. pneumoniae Kp17 was obtained by inserting the multicopy plasmid pTOPOBL17 containing the AdhE gene, and its own promoter, from K. pneumoniae BLh-1. Influence of Fe²⁺ supplementation and initial glycerol concentration on culture conditions were analyzed, both in rotatory shaker and in batch bioreactors. In the bioreactor cultures, K. pneumoniae Kp17 strain produced 4.5 g L^-1 of ethanol (productivity of 0.50 g L^-1 h^-1 and yields of 0.15 g g^-1) after 24-h cultivation, corresponding to an increase of approximately 40% in ethanol concentration compared to wild strain, K. pneumoniae BLh-1. Best conditions were then applied in exponential fed-batch bioreactors, with final ethanol concentration of 17.30 g L^-1 (productivity of 0.59 g L^-1 h^-1 and yields of 0.16 g g^-1) after 30 h of feeding, representing 11.5% of increment in titer of ethanol compared to the wild strain. Mutant cells kept 92.5% of the plasmids under batch in 24 h, and 71.9% under fed-batch after 27 h of exponential feeding. The findings in this work show the possibility of using a simple approach to genetically modify K. pneumoniae to be employed this versatile bacterium for the bioconversion of residual glycerol into ethanol.

Aldehyde-alcohol dehydrogenase undergoes structural transition to form extended spirosomes for substrate channeling

Aldehyde-alcohol dehydrogenase (AdhE) is an enzyme responsible for converting acetyl-CoA to ethanol via acetaldehyde using NADH. AdhE is composed of two catalytic domains of aldehyde dehydrogenase (ALDH) and alcohol dehydrogenase (ADH), and forms a spirosome architecture critical for AdhE activity. Here, we present the atomic resolution (3.43 Å) cryo-EM structure of AdhE spirosomes in an extended conformation. The cryo-EM structure shows that AdhE spirosomes undergo a structural transition from compact to extended forms, which may result from cofactor binding. This transition leads to access to a substrate channel between ALDH and ADH active sites. Furthermore, prevention of this structural transition by crosslinking hampers the activity of AdhE, suggesting that the structural transition is important for AdhE activity. This work provides a mechanistic understanding of the regulation mechanisms of AdhE activity via structural transition, and a platform to modulate AdhE activity for developing antibiotics and for facilitating biofuel production.

Aldehyde-alcohol dehydrogenase forms a high-order spirosome architecture critical for its activity

Aldehyde-alcohol dehydrogenase (AdhE) is a key enzyme in bacterial fermentation, converting acetyl-CoA to ethanol, via two consecutive catalytic reactions. Here, we present a 3.5 Å resolution cryo-EM structure of full-length AdhE revealing a high-order spirosome architecture. The structure shows that the aldehyde dehydrogenase (ALDH) and alcohol dehydrogenase (ADH) active sites reside at the outer surface and the inner surface of the spirosome respectively, thus topologically separating these two activities. Furthermore, mutations disrupting the helical structure abrogate enzymatic activity, implying that formation of the spirosome structure is critical for AdhE activity. In addition, we show that this spirosome structure undergoes conformational change in the presence of cofactors. This work presents the atomic resolution structure of AdhE and suggests that the high-order helical structure regulates its enzymatic activity.

Aldehyde-alcohol dehydrogenase (AdhE) converts acetyl-CoA to ethanol and plays an important role in bacterial fermentation. Here the authors present the 3.5 Å cryo-EM structure of full-length E. coli AdhE, which reveals a right-handed helical spirosome structure and they show that the helical structure is required for AdhE activity.

Genomic comparison of facultatively anaerobic and obligatory aerobic Caldibacillus debilis strains GB1 and Tf helps explain physiological differences

Caldibacillus debilis strains GB1 and Tf display distinct phenotypes. Caldibacillus debilis GB1 is capable of anaerobic growth and can synthesize ethanol while C. debilis Tf cannot. Comparison of the GB1 and Tf genome sequences revealed that the genomes were highly similar in gene content and showed a high level of synteny. At the genome scale, there were several large sections of DNA that appeared to be from lateral gene transfer into the GB1 genome. Tf did have unique genetic content but at a much smaller scale: 300 genes in Tf verses 857 genes in GB1 that matched at ≤90% sequence similarity. Gene complement and copy number of genes for the glycolysis, tricarboxylic acid cycle, and electron transport chain pathways were identical in both strains. While Tf is an obligate aerobe, it possesses the gene complement for an anaerobic lifestyle (ldh, ak, pta, adhE, pfl). As a species, other strains of C. debilis should be expected to have the potential for anaerobic growth. Assaying the whole cell lysate for alcohol dehydrogenase activity revealed an approximately 2-fold increase in the enzymatic activity in GB1 when compared with Tf.

State of the art review of biofuels production from lignocellulose by thermophilic bacteria

Biofuels, including ethanol and butanol, are mainly produced by mesophilic solventogenic yeasts and Clostridium species. However, these microorganisms cannot directly utilize lignocellulosic materials, which are abundant, renewable and non-compete with human demand. More recently, thermophilic bacteria show great potential for biofuels production, which could efficiently degrade lignocellulose through the cost effective consolidated bioprocessing. Especially, it could avoid contamination in the whole process owing to its relatively high fermentation temperature. However, wild types thermophiles generally produce low levels of biofuels, hindering their large scale production. This review comprehensively summarizes the state of the art development of biofuels production by reported thermophilic microorganisms, and also concludes strategies to improve biofuels production including the metabolic pathways construction, co-culturing systems and biofuels tolerance. In addition, strategies to further improve butanol production are proposed.

Ethanol production by the hyperthermophilic archaeon Pyrococcus furiosus by expression of bacterial bifunctional alcohol dehydrogenases

Ethanol is an important target for the renewable production of liquid transportation fuels. It can be produced biologically from pyruvate, via pyruvate decarboxylase, or from acetyl‐CoA, by alcohol dehydrogenase E (AdhE). Thermophilic bacteria utilize AdhE, which is a bifunctional enzyme that contains both acetaldehyde dehydrogenase and alcohol dehydrogenase activities. Many of these organisms also contain a separate alcohol dehydrogenase (AdhA) that generates ethanol from acetaldehyde, although the role of AdhA in ethanol production is typically not clear. As acetyl‐CoA is a key central metabolite that can be generated from a wide range of substrates, AdhE can serve as a single gene fuel module to produce ethanol through primary metabolic pathways. The focus here is on the hyperthermophilic archaeon Pyrococcus furiosus, which grows by fermenting sugar to acetate, CO₂ and H₂. Previously, by the heterologous expression of adhA from a thermophilic bacterium, P. furiosus was shown to produce ethanol by a novel mechanism from acetate, mediated by AdhA and the native enzyme aldehyde oxidoreductase (AOR). In this study, the AOR gene was deleted from P. furiosus to evaluate ethanol production directly from acetyl‐CoA by heterologous expression of the adhE gene from eight thermophilic bacteria. Only AdhEs from two Thermoanaerobacter strains showed significant activity in cell‐free extracts of recombinant P. furiosus and supported ethanol production in vivo. In the AOR deletion background, the highest amount of ethanol (estimated 61% theoretical yield) was produced when adhE and adhA from Thermoanaerobacter were co‐expressed.

Metabolic engineering of Clostridium autoethanogenum for selective alcohol production

Gas fermentation using acetogenic bacteria such as Clostridium autoethanogenum offers an attractive route for production of fuel ethanol from industrial waste gases. Acetate reduction to acetaldehyde and further to ethanol via an aldehyde: ferredoxin oxidoreductase (AOR) and alcohol dehydrogenase has been postulated alongside the classic pathway of ethanol formation via a bi-functional aldehyde/alcohol dehydrogenase (AdhE). Here we demonstrate that AOR is critical to ethanol formation in acetogens and inactivation of AdhE led to consistently enhanced autotrophic ethanol production (up to 180%). Using ClosTron and allelic exchange mutagenesis, which was demonstrated for the first time in an acetogen, we generated single mutants as well as double mutants for both aor and adhE isoforms to confirm the role of each gene. The aor1+2 double knockout strain lost the ability to convert exogenous acetate, propionate and butyrate into the corresponding alcohols, further highlighting the role of these enzymes in catalyzing the thermodynamically unfavourable reduction of carboxylic acids into alcohols.

•

180% improvement in C. autoethanogenum ethanol production via metabolic engineering.

•

Confirmed role of AOR in autotrophic ethanol production of acetogens.

•

Generated both aor and adhE mutants of C. autoethanogenum..

•

Demonstrated allelic exchange mutagenesis for stable deletions in acetogens.

•

Inactivation of adhE and aor2, but not aor1, improves autotrophic ethanol production.

Both adhE and a Separate NADPH-Dependent Alcohol Dehydrogenase Gene, adhA, Are Necessary for High Ethanol Production in Thermoanaerobacterium saccharolyticum

Thermoanaerobacterium saccharolyticum has been engineered to produce ethanol at about 90% of the theoretical maximum yield (2 ethanol molecules per glucose equivalent) and a titer of 70 g/liter. Its ethanol-producing ability has drawn attention to its metabolic pathways, which could potentially be transferred to other organisms of interest. Here, we report that the iron-containing AdhA is important for ethanol production in the high-ethanol strain of T. saccharolyticum (LL1049). A single-gene deletion of adhA in LL1049 reduced ethanol production by ∼50%, whereas multiple gene deletions of all annotated alcohol dehydrogenase genes except adhA and adhE did not affect ethanol production. Deletion of adhA in wild-type T.saccharolyticum reduced NADPH-linked alcohol dehydrogenase (ADH) activity (acetaldehyde-reducing direction) by 93%.IMPORTANCE In this study, we set out to identify the alcohol dehydrogenases necessary for high ethanol production in T. saccharolyticum Based on previous work, we had assumed that adhE was the primary alcohol dehydrogenase gene. Here, we show that both adhA and adhE are needed for high ethanol yield in the engineered strain LL1049. This is the first report showing adhA is important for ethanol production in a native adhA host, which has important implications for achieving higher ethanol yields in other microorganisms.

Determining the roles of the three alcohol dehydrogenases (AdhA, AdhB and AdhE) in Thermoanaerobacter ethanolicus during ethanol formation

Thermoanaerobacter ethanolicus is a promising candidate for biofuel production due to the broad range of substrates it can utilize and its high ethanol yield compared to other thermophilic bacteria, such as Clostridium thermocellum. Three alcohol dehydrogenases, AdhA, AdhB and AdhE, play key roles in ethanol formation. To study their physiological roles during ethanol formation, we deleted them separately and in combination. Previously, it has been thought that both AdhB and AdhE were bifunctional alcohol dehydrogenases. Here we show that AdhE has primarily acetyl-CoA reduction activity (ALDH) and almost no acetaldehyde reduction (ADH) activity, whereas AdhB has no ALDH activity and but high ADH activity. We found that AdhA and AdhB have similar patterns of activity. Interestingly, although deletion of both adhA and adhB reduced ethanol production, a single deletion of either one actually increased ethanol yields by 60-70%.

A novel route for ethanol oxidation in the acetogenic bacterium Acetobacterium woodii: the acetaldehyde/ethanol dehydrogenase pathway

Ethanol is a common substrate for anaerobic microorganisms despite its high redox potential (E0' etha- nol/acetaldehyde = -190mV), which does not allow for NAD(+) reduction. How this thermodynamic barrier is overcome is largely unknown. The acetogenic bacterium Acetobacterium woodii can also grow on ethanol. The genome harbours 11 genes encoding putative alcohol dehydrogenases, but only one, adhE, was upregulated during growth on ethanol. The bifunctional acetaldehyde/ethanol dehydrogenase (AdhE) was purified from ethanol-grown cells. It catalysed the NAD(+) - and CoA-dependent oxidation of ethanol via acetaldehyde to acetyl-CoA. The enzyme was regulated by free coenzyme A: in the absence of coenzyme A, the Km value for ethanol was shifted from 3.4 to 40 mM. The alcohol dehydrogenase domain could also oxidize 1-propanol and 1-butanol; however, the aldehyde dehydrogenase domain was highly specific for acetaldehyde as substrate. Apparently, the bifunctional AdhE allows for NAD(+) reduction by lowering the concentration of acetaldehyde, which makes the first oxidation reaction thermodynamically feasible.

Alcohol Selectivity in a Synthetic Thermophilic n-Butanol Pathway Is Driven by Biocatalytic and Thermostability Characteristics of Constituent Enzymes

n-Butanol is generated as a natural product of metabolism by several microorganisms, but almost all grow at mesophilic temperatures. A synthetic pathway for n-butanol production from acetyl coenzyme A (acetyl-CoA) that functioned at 70°C was assembled in vitro from enzymes recruited from thermophilic bacteria to inform efforts for engineering butanol production into thermophilic hosts. Recombinant versions of eight thermophilic enzymes (β-ketothiolase [Thl], 3-hydroxybutyryl-CoA dehydrogenase [Hbd], and 3-hydroxybutyryl-CoA dehydratase [Crt] from Caldanaerobacter subterraneus subsp. tengcongensis; trans-2-enoyl-CoA reductase [Ter] from Spirochaeta thermophila; bifunctional acetaldehyde dehydrogenase/alcohol dehydrogenase [AdhE] from Clostridium thermocellum; and AdhE, aldehyde dehydrogenase [Bad], and butanol dehydrogenase [Bdh] from Thermoanaerobacter sp. strain X514) were utilized to examine three possible pathways for n-butanol. These pathways differed in the two steps required to convert butyryl-CoA to n-butanol: Thl-Hbd-Crt-Ter-AdhE (C. thermocellum), Thl-Hbd-Crt-Ter-AdhE (Thermoanaerobacter X514), and Thl-Hbd-Crt-Ter-Bad-Bdh. n-Butanol was produced at 70°C, but with different amounts of ethanol as a coproduct, because of the broad substrate specificities of AdhE, Bad, and Bdh. A reaction kinetics model, validated via comparison to in vitro experiments, was used to determine relative enzyme ratios needed to maximize n-butanol production. By using large relative amounts of Thl and Hbd and small amounts of Bad and Bdh, >70% conversion to n-butanol was observed in vitro, but with a 60% decrease in the predicted pathway flux. With more-selective hypothetical versions of Bad and Bdh, >70% conversion to n-butanol is predicted, with a 19% increase in pathway flux. Thus, more-selective thermophilic versions of Bad, Bdh, and AdhE are needed to fully exploit biocatalytic n-butanol production at elevated temperatures.

Biochemical characterization of a bifunctional acetaldehyde-alcohol dehydrogenase purified from a facultative anaerobic bacterium Citrobacter sp. S-77

Acetaldehyde-alcohol dehydrogenase (ADHE) is a bifunctional enzyme consisting of two domains of an N-terminal acetaldehyde dehydrogenase (ALDH) and a C-terminal alcohol dehydrogenase (ADH). The enzyme is known to be important in the cellular alcohol metabolism. However, the role of coenzyme A-acylating ADHE responsible for ethanol production from acetyl-CoA remains uncertain. Here, we present the purification and biochemical characterization of an ADHE from Citrobacter sp. S-77 (ADHE(S77)). Interestingly, the ADHE(S77) was unable to be solubilized from membrane with detergents either 1% Triton X-100 or 1% Sulfobetaine 3-12. However, the enzyme was easily dissociated from membrane by high-salt buffers containing either 1.0 M NaCl or (NH(4))(2)SO(4) without detergents. The molecular weight of a native protein was estimated as approximately 400 kDa, consisting of four identical subunits of 96.3 kDa. Based on the specific activity and kinetic analysis, the ADHES77 tended to have catalytic reaction towards acetaldehyde elimination rather than acetaldehyde formation. Our experimental observation suggests that the ADHES77 may play a pivotal role in modulating intracellular acetaldehyde concentration.

Facultative Anaerobe Caldibacillus debilis GB1: Characterization and Use in a Designed Aerotolerant, Cellulose-Degrading Coculture with Clostridium thermocellum

Development of a designed coculture that can achieve aerotolerant ethanogenic biofuel production from cellulose can reduce the costs of maintaining anaerobic conditions during industrial consolidated bioprocessing (CBP). To this end, a strain of Caldibacillus debilis isolated from an air-tolerant cellulolytic consortium which included a Clostridium thermocellum strain was characterized and compared with the C. debilis type strain. Characterization of isolate C. debilis GB1 and comparisons with the type strain of C. debilis revealed significant physiological differences, including (i) the absence of anaerobic metabolism in the type strain and (ii) different end product synthesis profiles under the experimental conditions used. The designed cocultures displayed unique responses to oxidative conditions, including an increase in lactate production. We show here that when the two species were cultured together, the noncellulolytic facultative anaerobe C. debilis GB1 provided respiratory protection for C. thermocellum, allowing the synergistic utilization of cellulose even under an aerobic atmosphere.

Molecular and biochemical characterization of bifunctional pyruvate decarboxylases and pyruvate ferredoxin oxidoreductases from Thermotoga maritima and Thermotoga hypogea

Hyperthermophilic bacteria Thermotoga maritima and Thermotoga hypogea produce ethanol as a metabolic end product, which is resulted from acetaldehyde reduction catalysed by an alcohol dehydrogenase (ADH). However, the enzyme that is involved in the production of acetaldehyde from pyruvate is not well characterized. An oxygen sensitive and coenzyme A-dependent pyruvate decarboxylase (PDC) activity was found to be present in cell free extracts of T. maritima and T. hypogea. Both enzymes were purified and found to have pyruvate ferredoxin oxidoreductase (POR) activity, indicating their bifunctionality. Both PDC and POR activities from each of the purified enzymes were characterized in regards to their optimal assay conditions including pH dependency, oxygen sensitivity, thermal stability, temperature dependency and kinetic parameters. The close relatedness of the PORs that was shown by sequence analysis could be an indication of the presence of such bifunctionality in other hyperthermophilic bacteria. This is the first report of a bifunctional PDC/POR enzyme in hyperthermophilic bacteria. The PDC and the previously reported ADHs are most likely the key enzymes catalysing the production of ethanol from pyruvate in bacterial hyperthermophiles.

Cofactor Specificity of the Bifunctional Alcohol and Aldehyde Dehydrogenase (AdhE) in Wild-Type and Mutant Clostridium thermocellum and Thermoanaerobacterium saccharolyticum

Clostridium thermocellum and Thermoanaerobacterium saccharolyticum are thermophilic bacteria that have been engineered to produce ethanol from the cellulose and hemicellulose fractions of biomass, respectively. Although engineered strains of T. saccharolyticum produce ethanol with a yield of 90% of the theoretical maximum, engineered strains of C. thermocellum produce ethanol at lower yields (∼50% of the theoretical maximum). In the course of engineering these strains, a number of mutations have been discovered in their adhE genes, which encode both alcohol dehydrogenase (ADH) and aldehyde dehydrogenase (ALDH) enzymes. To understand the effects of these mutations, the adhE genes from six strains of C. thermocellum and T. saccharolyticum were cloned and expressed in Escherichia coli, the enzymes produced were purified by affinity chromatography, and enzyme activity was measured. In wild-type strains of both organisms, NADH was the preferred cofactor for both ALDH and ADH activities. In high-ethanol-producing (ethanologen) strains of T. saccharolyticum, both ALDH and ADH activities showed increased NADPH-linked activity. Interestingly, the AdhE protein of the ethanologenic strain of C. thermocellum has acquired high NADPH-linked ADH activity while maintaining NADH-linked ALDH and ADH activities at wild-type levels. When single amino acid mutations in AdhE that caused increased NADPH-linked ADH activity were introduced into C. thermocellum and T. saccharolyticum, ethanol production increased in both organisms. Structural analysis of the wild-type and mutant AdhE proteins was performed to provide explanations for the cofactor specificity change on a molecular level.

IMPORTANCE

This work describes the characterization of the AdhE enzyme from different strains of C. thermocellum and T. saccharolyticum. C. thermocellum and T. saccharolyticum are thermophilic anaerobes that have been engineered to make high yields of ethanol and can solubilize components of plant biomass and ferment the sugars to ethanol. In the course of engineering these strains, several mutations arose in the bifunctional ADH/ALDH protein AdhE, changing both enzyme activity and cofactor specificity. We show that changing AdhE cofactor specificity from mostly NADH linked to mostly NADPH linked resulted in higher ethanol production by C. thermocellum and T. saccharolyticum.

Ethanol production by engineered thermophiles

We compare a number of different strategies that have been pursued to engineer thermophilic microorganisms for increased ethanol production. Ethanol production from pyruvate can proceed via one of four pathways, which are named by the key pyruvate dissimilating enzyme: pyruvate decarboxylase (PDC), pyruvate dehydrogenase (PDH), pyruvate formate lyase (PFL), and pyruvate ferredoxin oxidoreductase (PFOR). For each of these pathways except PFL, we see examples where ethanol production has been engineered with a yield of >90% of the theoretical maximum. In each of these cases, this engineering was achieved mainly by modulating expression of native genes. We have not found an example where a thermophilic ethanol production pathway has been transferred to a non-ethanol-producing organism to produce ethanol at high yield. A key reason for the lack of transferability of ethanol production pathways is the current lack of understanding of the enzymes involved.

Bioenergetic constraints for conversion of syngas to biofuels in acetogenic bacteria

Synthesis gas (syngas) is a gas mixture consisting mainly of H2, CO, and CO2 and can be derived from different sources, including renewable materials like lignocellulose. The fermentation of syngas to certain biofuels, using acetogenic bacteria, has attracted more and more interest over the last years. However, this technology is limited by two things: (1) the lack of complete knowledge of the energy metabolism of acetogenic bacteria, and (2) the lack of sophisticated genetic tools for the modification of acetogens. In this review, we discuss the bioenergetic constraints for the conversion of syngas to different biofuels. We will mainly focus on Acetobacterium woodii, which is the best understood acetogen in terms of energy conservation. Syngas fermentation with Clostridium autoethanogenum will also be discussed, since this organism is well suited to convert syngas to certain products and already used in large-scale industrial processes.

A comparative multidimensional LC-MS proteomic analysis reveals mechanisms for furan aldehyde detoxification in Thermoanaerobacter pseudethanolicus 39E

BACKGROUND

Chemical and physical pretreatment of lignocellulosic biomass improves substrate reactivity for increased microbial biofuel production, but also restricts growth via the release of furan aldehydes, such as furfural and 5-hydroxymethylfurfural (5-HMF). The physiological effects of these inhibitors on thermophilic, fermentative bacteria are important to understand; especially as cellulolytic strains are being developed for consolidated bioprocessing (CBP) of lignocellulosic feedstocks. Identifying mechanisms for detoxification of aldehydes in naturally resistant strains, such as Thermoanaerobacter spp., may also enable improvements in candidate CBP microorganisms.

RESULTS

Thermoanaerobacter pseudethanolicus 39E, an anaerobic, saccharolytic thermophile, was found to grow readily in the presence of 30 mM furfural and 20 mM 5-HMF and reduce these aldehydes to their respective alcohols in situ. The proteomes of T. pseudethanolicus 39E grown in the presence or absence of 15 mM furfural were compared to identify upregulated enzymes potentially responsible for the observed reduction. A total of 225 proteins were differentially regulated in response to the 15 mM furfural treatment with 152 upregulated versus 73 downregulated. Only 87 proteins exhibited a twofold or greater change in abundance in either direction. Of these, 54 were upregulated in the presence of furfural and 33 were downregulated. Two oxidoreductases were upregulated at least twofold by furfural and were targeted for further investigation. Teth39_1597 encodes a predicted butanol dehydrogenase (BdhA) and Teth39_1598, a predicted aldo/keto reductase (AKR). Both genes were cloned from T. pseudethanolicus 39E, with the respective enzymes overexpressed in E. coli and specific activities determined against a variety of aldehydes. Overexpressed BdhA showed significant activity with all aldehydes tested, including furfural and 5-HMF, using NADPH as the cofactor. Cell extracts with AKR also showed activity with NADPH, but only with four-carbon butyraldehyde and isobutyraldehyde.

CONCLUSIONS

T. pseudethanolicus 39E displays intrinsic tolerance to the common pretreatment inhibitors furfural and 5-HMF. Multidimensional proteomic analysis was used as an effective tool to identify putative mechanisms for detoxification of furfural and 5-HMF. T. pseudethanolicus was found to upregulate an NADPH-dependent alcohol dehydrogenase 6.8-fold in response to furfural. In vitro enzyme assays confirmed the reduction of furfural and 5-HMF to their respective alcohols.

Structure of a bifunctional alcohol dehydrogenase involved in bioethanol generation inGeobacillus thermoglucosidasius

Bifunctional alcohol/aldehyde dehydrogenase (ADHE) enzymes are found within many fermentative microorganisms. They catalyse the conversion of an acyl-coenzyme A to an alcoholviaan aldehyde intermediate; this is coupled to the oxidation of two NADH molecules to maintain the NAD+pool during fermentative metabolism. The structure of the alcohol dehydrogenase (ADH) domain of an ADHE protein from the ethanol-producing thermophileGeobacillus thermoglucosidasiushas been determined to 2.5 Å resolution. This is the first structure to be reported for such a domain.In silicomodelling has been carried out to generate a homology model of the aldehyde dehydrogenase domain, and this was subsequently docked with the ADH-domain structure to model the structure of the complete ADHE protein. This model suggests, for the first time, a structural mechanism for the formation of the large multimeric assemblies or `spirosomes' that are observed for this ADHE protein and which have previously been reported for ADHEs from other organisms.

Microevolution from shock to adaptation revealed strategies improving ethanol tolerance and production in Thermoanaerobacter

INTRODUCTION

The molecular links between shock-response and adaptation remain poorly understood, particularly for extremophiles. This has hindered rational engineering of solvent tolerance and correlated traits (e.g., productivity) in extremophiles. To untangle such molecular links, here we established a model that tracked the microevolution from shock to adaptation in thermophilic bacteria.

METHOD

Temporal dynamics of genomes and transcriptomes was tracked for Thermoanaerobacter sp. X514 which under increasing exogenous ethanol evolved from ethanol-sensitive wild-type (Strain X) to tolerance of 2%- (XI) and eventually 6%-ethanol (XII). Based on the reconstructed transcriptional network underlying stress tolerance, genetic engineering was employed to improve ethanol tolerance and production in Thermoanaerobacter.

RESULTS

The spontaneous genome mutation rate (μg) of Thermoanaerobacter sp. X514, calculated at 0.045, suggested a higher mutation rate in thermophile than previously thought. Transcriptomic comparison revealed that shock-response and adaptation were distinct in nature, whereas the transcriptomes of XII resembled those of the extendedly shocked X. To respond to ethanol shock, X employed fructose-specific phosphotransferase system (PTS), Arginine Deiminase (ADI) pathway, alcohol dehydrogenase (Adh) and a distinct mechanism of V-type ATPase. As an adaptation to exogenous ethanol, XI mobilized resistance-nodulation-cell division (RND) efflux system and Adh, whereas XII, which produced higher ethanol than XI, employed ECF-type ϭ24, an alcohol catabolism operon and phase-specific heat-shock proteins (Hsps), modulated hexose/pentose-transport operon structure and reinforced membrane rigidity. Exploiting these findings, we further showed that ethanol productivity and tolerance can be improved simultaneously by overexpressing adh or ϭ24 in X.

CONCLUSION

Our work revealed thermophilic-bacteria specific features of adaptive evolution and demonstrated a rational strategy to engineer co-evolving industrial traits. As improvements of shock-response, stress tolerance and productivity have been crucial aims in industrial applications employing thermophiles, our findings should be valuable not just to the production of ethanol but also to a wide variety of biofuels and biochemicals.

The role of aldehyde/alcohol dehydrogenase (AdhE) in ethanol production from glycerol by Klebsiella pneumoniae

Transcriptome analysis of a K. pneumoniae GEM167 mutant strain derived by irradiation with gamma rays, which exhibited high-level production of ethanol from glycerol, showed that the mutant expressed AdhE at a high level. Ethanol production decreased significantly, from 8.8 to 0.5 g l−1, when an adhE-deficient derivative of that strain was grown on glycerol. Bacterial growth was also reduced under such conditions, showing that AdhE plays a critical role in maintenance of redox balance by catalyzing ethanol production. Overexpression of AdhE enhanced ethanol production, from pure or crude glycerol, to a maximal level of 31.9 g l−1 under fed-batch fermentation conditions; this is the highest level of ethanol production from glycerol reported to date.

Biohydrogen Production by the Thermophilic Bacterium Caldicellulosiruptor saccharolyticus: Current Status and Perspectives

Caldicellulosiruptor saccharolyticus is one of the most thermophilic cellulolytic organisms known to date. This Gram-positive anaerobic bacterium ferments a broad spectrum of mono-, di- and polysaccharides to mainly acetate, CO₂ and hydrogen. With hydrogen yields approaching the theoretical limit for dark fermentation of 4 mol hydrogen per mol hexose, this organism has proven itself to be an excellent candidate for biological hydrogen production. This review provides an overview of the research on C. saccharolyticus with respect to the hydrolytic capability, sugar metabolism, hydrogen formation, mechanisms involved in hydrogen inhibition, and the regulation of the redox and carbon metabolism. Analysis of currently available fermentation data reveal decreased hydrogen yields under non-ideal cultivation conditions, which are mainly associated with the accumulation of hydrogen in the liquid phase. Thermodynamic considerations concerning the reactions involved in hydrogen formation are discussed with respect to the dissolved hydrogen concentration. Novel cultivation data demonstrate the sensitivity of C. saccharolyticus to increased hydrogen levels regarding substrate load and nitrogen limitation. In addition, special attention is given to the rhamnose metabolism, which represents an unusual type of redox balancing. Finally, several approaches are suggested to improve biohydrogen production by C. saccharolyticus.

Teth137, a Conserved Factor of Unknown Function from Thermoanaerobacter ethanolicus JW200, Represses the Transcription of the adhE Gene In Vitro

Teth137, a 13.7 kD protein of unknown function from Thermoanaerobacter ethanolicus JW200, is encoded by 360 nucleotides and has been obtained by DNA-coupled column previously. However, no function study of Teth137 has been published. Homologous modeling of Teth137 shows the protein is comprised of a helix-turn-helix motif which is a typical DNA-binding domain. Therefore, it is speculated Teth137 is a DNA-binding protein and involved in transcription of the adhE gene (encodes alcohol dehydrogenase E). To investigate the function of Teth137, recombinant Teth137 is overexpressed in Escherichia coli JM109 and purified by DEAE column. Purified Teth137 exhibits the affinity with the adhE promoter region in gel electrophoresis mobility shift assay (GEMSA). Teth137 at the concentration of 48 μM retards the migration of 5 nM of probe in the presence of the competitor DNA. Mutant analysis indicates that S69, T70, P71 and T72 are critical to protein-DNA interface; Gly substitutions at these residues results in the loss of the binding ability with the adhE promoter region. Moreover, T. ethanolicus JW200 RNA polymerase, σ subunit and template plasmid are prepared for in vitro transcription assay to detect the regulation function of Teth137. The results of the in vitro transcription show that the transcription of 5 nM of the template plasmid is inhibited by 48 μM of Teth137.

Correlation of genomic and physiological traits of thermoanaerobacter species with biofuel yields

Thermophilic anaerobic noncellulolytic Thermoanaerobacter species are of great biotechnological importance in cellulosic ethanol production due to their ability to produce high ethanol yields by simultaneous fermentation of hexose and pentose. Understanding the genome structure of these species is critical to improving and implementing these bacteria for possible biotechnological use in consolidated bioprocessing schemes (CBP) for cellulosic ethanol production. Here we describe a comparative genome analysis of two ethanologenic bacteria, Thermoanaerobacter sp. X514 and Thermoanaerobacter pseudethanolicus 39E. Compared to 39E, X514 has several unique key characteristics important to cellulosic biotechnology, including additional alcohol dehydrogenases and xylose transporters, modifications to pentose metabolism, and a complete vitamin B₁₂ biosynthesis pathway. Experimental results from growth, metabolic flux, and microarray gene expression analyses support genome sequencing-based predictions which help to explain the distinct differences in ethanol production between these strains. The availability of whole-genome sequence and comparative genomic analyses will aid in engineering and optimizing Thermoanaerobacter strains for viable CBP strategies.

Thermoanaerobacter spp. control ethanol pathway via transcriptional regulation and versatility of key enzymes

Ethanologenic Thermoanaerobacter species produce ethanol from lignocellulose derived substrates at temperatures above 70 degrees C. In the final steps of ethanol formation, two bifunctional acetaldehyde/alcohol dehydrogenases, AdhB and AdhE, and an alcohol dehydrogenase, AdhA, catalyze redox reactions between acetyl-CoA and ethanol via an acetaldehyde intermediate. DNA cloning and analysis revealed that the dehydrogenase genes and their transcriptional regulatory regions were highly conserved in these species. As determined by real-time PCR, the transcription of adhE was activated by ethanol, while adhB was transcribed without ethanol; however, all of their transcription was reduced at higher ethanol concentrations. Under imitating physiological conditions, AdhE played a crucial role in ethanol formation, and AdhB favored ethanol consumption when ethanol concentration was high e.g. 1%. Thus, the ethanol titer of fermentation is controlled via transcriptional regulation and the properties of specific enzymes in Thermoanaerobacter. These results provide evidence for an ethanol balance model and offer the possibility to raise the ethanol titer by metabolic engineering.

Thermophilic ethanologenesis: future prospects for second-generation bioethanol production

Strategies for improving fermentative ethanol production have focused almost exclusively on the development of processes based on the utilization of the carbohydrate fraction of lignocellulosic material. These so-called 'second-generation' technologies require metabolically engineered production strains that possess a high degree of catabolic versatility and are homoethanologenic. It has been suggested that the production of ethanol at higher temperatures would facilitate process design, and as a result the engineered progeny of Geobacillus thermoglucosidasius, Thermoanerobacterium saccharolyticum and Thermoanerobacter mathranii now form the platform technology of several new biotechnology companies. This review highlights the milestones in the development of these production strains, with particular focus on the development of reliable methods for cell competency, gene deletion or upregulation.