Supplementation of a wheat-based diet low in phosphorus with microbial 6-phytase expressed in Aspergillus oryzae increases digestibility and plasma phosphorus but not performance in lactating sows

Effect of high-phytase supplementation in lactation diets on sow and litter performance

A total of 109 sows (Line 241; DNA, Columbus, NE) were used to evaluate the effect of increasing dietary phytase in lactation diets, already adequate in P, on sow and litter performance. On d 107 of gestation, sows were blocked by body weight and parity and allotted to 1 of 3 dietary treatments of increasing phytase concentration (0, 1,000, or 3,000 FYT/kg; Ronozyme HiPhos GT 2700, DSM Nutritional Products, Inc., Parsippany, NJ). The control diet contained no phytase and was formulated to contain 0.50% standardized total tract digestible phosphorus (STTD P; 0.45% available P) and 0.62% STTD calcium (0.90% total Ca). The phytase diets that contained 1,000 or 3,000 FYT/kg were also formulated to 0.50% STTD P and 0.62% STTD Ca including the release of 0.132% STTD P and 0.096% STTD Ca. Diets were balanced for net energy and fed from d 107 of gestation until weaning (d 18 ± 3). All farrowings were monitored, with farrowing duration starting at the time the first pig was born until the first dispersal of placental tissues with no subsequent pigs born. Litters were cross-fostered within treatment until 48 h postfarrowing to equalize litter size. There were no differences among treatments in sow body weight at d 107 of gestation, 24 h after farrowing, or at weaning. Sow average daily feed intake from farrowing to weaning tended to increase (linear, P = 0.093) as phytase increased. There was no evidence for difference in the number of total born pigs, as well as the percentage of stillborns, mummies, and born alive pigs at the completion of farrowing. Similarly, phytase supplementation did not influence (P > 0.05) wean-to-estrus interval or litter size after cross-fostering among dietary treatments. Although not significant (linear, P = 0.226), farrowing duration decreased as added phytase increased with a decrease of 47 min (12%) for 3,000 FYT compared with the control. There were no differences in pig weight at weaning, but as a result of increased survivability (linear, P = 0.002), litter weaning weight and overall litter weight gain increased (quadratic, P < 0.05) up to 1,000 FYT of added phytase with no further benefit observed in sows fed 3,000 FYT. In conclusion, sow feed intake tended to increase linearly with increasing added phytase. Feeding 1,000 FYT/kg maximized overall litter gain and weaning weight; however, a larger-scale study with more sows is needed to determine the addition of phytase in lactation diets to reduce farrowing duration.

The addition of a Buttiauxella sp. phytase to lactating sow diets deficient in phosphorus and calcium reduces weight loss and improves nutrient digestibility

Improving the efficiency of P use by pigs is especially important for lactating sows, whose metabolic requirements for P and Ca are high. The effect of a sp. phytase on lactating sow performance and nutrient digestibility was investigated using the combined data set for 6 studies. Treatments included a nutritionally adequate positive control diet (PC), a negative control diet (NC; with an average reduction of 0.16% available phosphorous and 0.15% Ca vs. PC), and NC supplemented with a sp. phytase at 250, 500, 1,000 or 2,000 phytase unit (FTU)/kg, respectively. Phosphorus and Ca deficiency in the NC resulted in significantly higher BW loss compared with the PC. All phytase treatments maintained BW loss at the same level as the PC. Increasing doses of phytase significantly ( < 0.05) reduced sow BW loss and increased energy intake, with improvements most apparent in sows older than parity 5. The positive effects on BW and energy intake were not observed in first-parity sows. This may be a consequence of fewer first parity sows in the data set. The apparent total tract digestibility of DM, OM, and CP were not affected by phytase supplementation. Digestible P and Ca were significantly improved (linear, < 0.0001; quadratic, < 0.0001) by increasing the dose of phytase supplementation. Significantly lower apparent total tract digestibility of energy, Ca, and P was found in the NC treatment vs. the PC treatment, whereas no significant differences were found between phytase treatment and the PC treatment. In conclusion, phytase supplementation at a level of 250 FTU/kg can replace 0.16% available phosphorous and 0.15% Ca; however, increasing the phytase dose can further reduce BW loss in sows fed P- and Ca- deficient diets.