Short operational differences support granulation in a lab scale reactor in comparison to another conventional activated sludge reactor

Retention and recycling of granules in continuous flow-through system to accomplish denitrification and perchlorate reduction

This study employed a completely anoxic reactor and a gravity-settling design for continuously separating from flocculated biomass and hydraulically recycling granules back to the main reactor. The average chemical oxygen demand (COD) removal in the reactor was 98 %. Average nitrate (NO₃^--N) and perchlorate (ClO₄^-) removal efficiencies of 99 % and 74 ± 19 % were observed, respectively. Preferential utilization of NO₃^- over ClO₄^- led to COD limiting conditions, which resulted in ClO₄^- in the effluent. The average granule diameter in continuous flow-through bubble-column (CFB) anoxic granular sludge (AxGS) bioreactor was 6325 ± 2434 µm, and the average SVI₃₀/SVI₁ was > 90% throughout its operation. 16s rDNA amplicon sequencing revealed Proteobacteria (68.53% - 88.57%) and Dechloromonas (10.46% - 54.77%) to be the most abundant phylum and genus present in reactor sludge representing the denitrifying and ClO₄^- reducing microbial community. This work represents a pioneering development of CFB-AxGS bioreactor.

Anoxic granular activated sludge process for simultaneous removal of hazardous perchlorate and nitrate

An airtight, anoxic bubble-column sequencing batch reactor (SBR) was developed for the rapid cultivation of perchlorate (ClO₄^-) and nitrate (NO₃^-) reducing granular sludge (GS) in this study. Feast/famine conditions and shear force selection pressures in tandem with a short settling time (2-min) as a hydraulic section pressure resulted in the accelerated formation of anoxic granular activated sludge (AxGS). ClO₄^- and NO₃^- were efficiently (>99.9%) reduced over long-term (>500-d) steady-state operation. Specific NO₃^- reduction, ClO₄^- reduction, chloride production, and non-purgeable dissolved organic carbon (DOC) oxidation rates of 5.77 ± 0.54 mg NO₃^--N/g VSS·h, 8.13 ± 0^.74 mg ClO₄^-/g VSS·h, 2.40 ± 0.₄0 mg Cl^-/g VSS·h, and 16.0 ± 0.06 mg DOC/g VSS·h were recorded within the reactor under steady-state conditions, respectively. The AxGS biomass cultivated in this study exhibited faster specific ClO₄^- reduction, NO₃^- reduction, and DOC oxidation rates than flocculated biomass cultivated under similar conditions and AxGS biomass operated in an up-flow anaerobic sludge blank (UASB) bioreactor receiving the same influent loading. EPS peptide identification revealed a suite of extracellular catabolic enzymes. Dechloromonas species were present in high abundance throughout the entirety of this study. This is one of the initial studies on anoxic granulation to simultaneously treat hazardous chemicals and adds to the science of the granular activated sludge process.

Biodegradation of insensitive munition (IM) formulations: IMX-101 and IMX-104 using aerobic granule technology

A laboratory-scale aerobic granular sludge (AGS) sequencing batch bioreactor (SBR) was initiated in this study for the biodegradation of hazardous insensitive munition (IM) formulation constituents; 2,4-dinitroanisole (DNAN), hexahydro-1,3,5-trinitro-1,3,5-triazine (RDX), 1-nitroguanidine (NQ), and 3-nitro-1,2,4-triazol-5-one (NTO). Efficient (bio)transformation of the influent DNAN and NTO was achieved throughout reactor operation with removal efficiencies greater than 95%. An average removal efficiency of 38.4 ± 17.5% was recorded for RDX. NQ was only slightly removed (3.96 ± 4.15%) until alkalinity was provided in the influent media, which subsequently increased the NQ removal efficiency up to an average of 65.8 ± 24.4%. Batch experiments demonstrated a competitive advantage for aerobic granular biofilms over flocculated biomass for the (bio)transformation DNAN, RDX, NTO, and NQ, as aerobic granules were capable of reductively (bio)transforming each IM compound under bulk aerobic conditions while flocculated biomass could not, thus demonstrating the contribution of inner oxygen-free zones within aerobic granules. A variety of catalytic enzymes were identified in the extracellular polymeric matrix of the AGS biomass. 16 S rDNA amplicon sequencing found Proteobacteria (27.2-81.2%) to be the most abundant phyla, with many genera associated with nutrient removal as well as genera previously described in relation to the biodegradation of explosives or related compounds.

Simultaneous reduction of perchlorate and nitrate using fast-settling anoxic sludge

Fast-settling, anoxic sludge (FAS) was cultivated and utilized in this study to simultaneously reduce elevated levels of perchlorate and nitrate in an anaerobic sequencing batch reactor (AnSBR). Average perchlorate and nitrate removal efficiencies of 96.5 ± 8.44 % and 99.8 ± 0.32 %, respectively, were achieved from an average perchlorate and nitrate loading rate of 159 ± 101 g ClO₄^-/m³·d and 10.8 ± 7.25 g NO₃^--N/m³·d, respectively, throughout long-term operation (>500-d). Batch activity tests revealed a preferential utilization of nitrate over perchlorate, where significant perchlorate reduction inhibition occurred when nitrate was present as a competing electron acceptor under carbon-limiting conditions. Specific perchlorate and nitrate reduction rates were shown to increase as the hydraulic retention time (HRT) of the AnSBR was step-wise decreased and subsequently the perchlorate and nitrate loading rates were step-wise increased. Functional, mRNA-based expression of the nitrite reductase (nirS and nirK), nitrous oxide reductase (nosZ), perchlorate reductase subunit A (pcrA), and the chlorite dismutase (cld) genes illustrated the simultaneous activity of heterotrophic denitrification and perchlorate reduction occurring throughout a complete standard reactor operational cycle, and allowed for expression trends to be documented as the HRT of the AnSBR was reduced from 5-d to 1.25-d. Nitrous oxide (N₂O) production was detected as a result of incomplete denitrification, where the largest N₂O production occurred at the highest nitrate loading rates investigated in this study. Thauera species were heavily enriched at a longer HRT of 5-d, but were out-competed by Dechloromonas species as the HRT of the AnSBR was step-wise reduced to 1.25-d.

Coupling of Fe-C and aerobic granular sludge to treat refractory wastewater from a membrane manufacturer in a pilot-scale system

A novel pilot-scale system based on aerobic granular sludge (AGS) as a biological treatment step was proposed to treat refractory wastewater from a membrane manufacturer. The components of the system included a microelectrolysis Fe-C filter, a hydrolysis acidification bioreactor (HA), sequence batch reactor 1 (AGS SBR1), sequence batch reactor 2 (AGS SBR2), and a membrane bioreactor (MBR). The Fe-C filter effectively improved the biodegradability of the wastewater components and introduced some byproducts (such as Fe²⁺, Fe³⁺, and Fe minerals) that are beneficial for the cultivation and stability of the AGS. Ideal conditions for aerobic granulation were maintained in the SBR, such as alternating feast and famine conditions. A selection pressure, including a hydraulic shear force and settling time, was also created therein. The results showed that the AGS was formed successfully in both SBR1 and SBR2, the sludge volume index after 30 min (SVI₃₀) and mean particle size reached 34.2 mL/g and 720 µm, and 36.7 mL/g and 610 µm, respectively, and a satisfactory nutrient removal capacity was achieved in the system. During the entire experimental period, the microbial community changed significantly; enrichment of microbes with the secretion of extracellular polymeric substances (EPS), granule stabilization functions in the AGS, and the differentiation of microbes corresponding to the function of each unit were observed. The use of Fe-C, application of SBRs, and use of dewatered sludge as an inoculant played key roles in the cultivation and stability of the AGS.

Insight into formation and biological characteristics of Aspergillus tubingensis-based aerobic granular sludge (AT-AGS) in wastewater treatment

The long start-up time and facile biomass loss of aerobic granular sludge (AGS) impede its application for actual wastewater treatment. The present study investigates a novel assist-aggregation strategy based on Aspergillus tubingensis (AT) mycelium pellets to accelerate sludge granulation, and engineered Fe₃O₄ nanoparticles (NPs) were used to further enhance flocculent sludge (FS) aggregation. The AT mycelium pellets, modified by 0.5 g/L Fe₃O₄@SiO₂-QC NPs (AT-V), had a more compact internal structure than the unmodified group (AT-I). The content of extracellular polymeric substances (EPS) and the zeta potential values were observed to increase from 39.86 mg/gVSS and -9.19 mv for AT-I to 69.64 mg/gVSS and 2.35 mv for AT-V, respectively. In optimized cultivation conditions, the aggregated sludge biomass of AT-V reached 1.54 g/g. An original AT-based AGS (AT-AGS) with a high biological activity (64.45 mgO₂/gVSS·h as specific oxygen uptake rate) and enhanced velocity (58.22 m/h) was developed in only 9 days. The removal efficiencies of total nitrogen (TN) and total phosphorus (TP) of the AT-AGS were 12.24% and 16.29% higher than those of the inoculated FS under high feeding load. Additionally, the analysis of cyclic diguanylate (c-di-GMP) and con-focal microscope images implied that polysaccharide (PS) of EPS played an important role in maintaining the stability of the AT-AGS. Finally, the dominant functional species contributing to sludge aggregation and pollutants removal of the AT-AGS showed a larger richness and diversity than those of the inoculated FS. This study might provide a novel high-efficiency strategy for the fast formation of AGS.

Response of an aerobic granular and conventional flocculated reactors against changing feed composition from simple composition to more complex

This research evaluated the effect of changing feed composition on the performances of a conventional activated sludge (CAS) and an aerobic granular sludge (AGS) reactor operated simultaneously. Both reactors were initially fed with 100% synthetic feed. In a stepwise manner, the feed composition was slowly changed to real primary effluent collected from a local wastewater treatment plant. After an initial stabilization period, both reactors could achieve more than 90% NH₄⁺-N removal. However, PO₄^3--P removal eventually reached to a maximum of 92% in the AGS and 88% in the CAS. COD removal in both reactors was least affected, with the lowest percent removal of 81 ± 3% achieved in AGS and 62 ± 4% in CAS respectively when fed with 100% real wastewater. Despite granule breakage the AGS reactor was able to remove the pollutants (COD, N, P). The abundance of Candidatus Accumulibacter, a polyphosphate accumulating organism, in the AGS system increased over the operational phases: II (6.2%), III (10.32%), and IV (11.9%). While in CAS, it increased from phase I to phase II (12.6%), but decreased in phase III to 9.9%. Genus-based classification revealed a successive increase in the relative abundance of Nitrospira to 11.05% during Phase III and 10.3% during Phase IV in the AGS. In contrast with its presence in the CAS, which was, 3.4% during Phase III and 9.5% during Phase IV.

Effect of temperatures and alternating anoxic/oxic sequencing batch reactor (SBR) operating modes on extracellular polymeric substances in activated sludge

In order to investigate the effect of temperatures and operating modes on extracellular polymeric substances (EPS) contents, three sequencing batch reactors (SBRs) were operated at temperatures of 15, 25, and 35 °C (R_{15 °C}, R_{25 °C}, and R_{35 °C}, respectively), with two SBRs operated under alternating anoxic/oxic conditions (R_A/O and R_O/A, respectively). Results showed that higher contents of tightly bound EPS (TB-EPS) and total EPS appeared in R_{15 °C}, while loosely bound EPS (LB-EPS) dominated in R_{35 °C}. In all three kinds of EPS (LB-EPS, TB-EPS and total EPS) assessed, protein was the main component in R_{15 °C} and R_{25 °C}, while polysaccharides dominated in R_{35 °C}. Moreover, compared with R_O/A, R_A/O was favorable for the production of the three kinds of EPS. Furthermore, three kinds of EPS and their components were augmented during the nitrification process, while they declined during the denitrification process under all conditions except for R_{35 °C}.

Transcriptional responses of Candidatus Accumulibacter clades to environmental dynamics in enhanced biological phosphorus removal

The dynamic response mechanism of Candidatus Accumulibacter clades to environmental factors in enhanced biological phosphorus removal (EBPR) was unclear. This study investigated the relationship between the transcriptional responses of Candidatus Accumulibacter clades and environmental dynamics. Results suggested that Candidatus Accumulibacter clade IIA only responded in initial 20 and 30 min of P-release and P-uptake stage, respectively, and was also the first clade to stop responding among the six Candidatus Accumulibacter clades. Clade IIC and IID responded at rising stage of P-release and P-uptake rate. Clade IA and IIB responded at decreasing stage of P-release and P-uptake rate. The transcriptional response duration of clade IIF was the longest, which constantly responded throughout anaerobic, anoxic and oxic phase. The transcriptional responses of Candidatus Accumulibacter clades to environmental dynamics revealed the microorganisms actually working in P-release and P-uptake, and gave a new insight into the transcriptional responses related to the EBPR performance.

Performance and population structure of two carbon sources granular enhanced biological phosphorus removal systems at low temperature

This study explored the effect of two carbon sources on performance and population structure of granular enhanced biological phosphorus removal systems at long-term low temperature by using two sequencing batch reactors, with acetate (SBR-1) and propionate (SBR-2) as carbon sources respectively. Results showed that highly efficient EBPR were successfully achieved, and the average PO₄^3--P and COD removal efficiency of SBR-1 and SBR-2 were 94.2%, 87.1% and 98.2%, 87.0%, respectively. Moreover, the acetate system preferred to utilize intracellular Mg/K-polyP to produce ATP for VFA uptake rather than glycogen. High-throughput sequencing analysis revealed that the abundance of Rhodocyclaceae were 31.7% (SBR-1) and 71.7% (SBR-2), and genus Dechloromonas was enriched to 60.5% with propionate, evidently higher than acetate (1.2%). Furthermore, in addition to oxygen, Dechloromonas could use nitrate as electron acceptors for phosphate uptake. The study further provides support to simultaneous nitrogen and phosphorus removal at low temperature.

Integrated leachate management approach incorporating nutrient recovery and removal

This manuscript presents an integrated management scheme for leachate which employed struvite precipitation to recover ammonia nitrogen and phosphorus, aerobic granular sludge process for carbon oxidation (in the form of BOD and sCOD) and single stage anaerobic ammonia oxidation (ANAMMOX) for nitrogen management. The influent fed to the integrated treatment scheme was a mixture of anaerobic digester centrate and real leachate in 4:1 ratio. Almost 77% recovery of phosphorus and 25% removal of NH₄⁺-N were accomplished through struvite precipitation at an optimum pH of 9. High pH contributed to free ammonia loss during struvite precipitation experiments. In the aerobic granular sludge reactor overall, BOD₅, COD and NH₄⁺-N removal percentages were 74%, 45% and 35% and in the PN/A reactor, overall 35% removal of total inorganic nitrogen (TIN) was observed. More than 80% BOD removal was recorded in the granular reactor with soluble COD (sCOD) removal fluctuating between 28 and 57% depending on the operational phase. High-throughput amplicon sequencing of 16S rRNA gene targeting V4 region revealed a dominance of phylum Planctomycetes, in the PN/A reactor system. Presence of Rhodobacteraceae, Xanthomonadaceae, Flavobacteriaceae in the granular biomass confirmed the defined redox zones inside mature granules indicating simultaneous removal of nitrogen (N) and organics in aerobic granular sludge technology. Exposing the synthetically cultured aerobic granules directly to the mixture of leachate and centrate unveiled an alteration in physical characteristics of granules; however, reactor operational data and microbial community analysis ascertain the effectiveness of the treatment scheme treating two urban waste-streams.

Microbial community at transcription level in the synergy of GAOs and Candidatus Accumulibacter for saving carbon source in wastewater treatment

The microbial community in endogenous denitrification and denitrifying phosphorus removal treatment at transcription level was unknown. This study first confirmed the expression of actually active bacteria in endogenous denitrification and denitrifying phosphorus removal system to treat low C/N municipal wastewater. No external carbon source was added to influent wastewater. The cDNA high throughput sequencing showed that Candidatus Accumulibacter was the most effective polyphosphate accumulating organisms (PAOs) that actually worked rather than Dechloromonas, which was different from the result at gene level. Reverse transcriptional PCR (RT-PCR) and analysis of Variance (ANOVA) suggested that the ratios of dead or dormant bacteria could monitor wastewater treatment process. Identification of active microbial community at transcription level demonstrated that the synergy of endogenous denitrification by glycogen accumulating organisms (GAOs) and denitrifying phosphorus removal by Candidatus Accumulibacter fully utilized the internal carbon source, and effectively solved the problem of carbon source deficiency in municipal wastewater treatment.

Analysis of microbial community in a continuous flow process at gene and transcription level to enhance biological nutrients removal from municipal wastewater

In biological municipal wastewater treatment, gene level analysis of community structure could not determine functional genes that actually played a role and expression of viable microorganism. In this study, reverse transcriptional PCR (RT-PCR), cDNA high throughput sequencing and transcriptional activity analysis were conducted to investigate active microbial community with nitrogen and phosphorus removal from municipal wastewater. RT-PCR and correlation heatmap analysis suggested that transcriptional activities of bacteria had strong correlation with performance of nitrogen and phosphorus removal, they might be therefore regarded as an indicator for wastewater treatment monitoring. When DO concentration were raised from 0.6 mg/L to 2 mg/L and C/N ratio from 3-4 to 5, the increase of population abundance and transcriptional activities of denitrifying genes improved the removal efficiencies of COD and TN. The species with relatively high abundance at gene level were not really active species at transcription level, and vice versa.