The effects of solid lignin on the anaerobic digestion of microcrystalline cellulose and application of smoothing splines for extended data analysis of its inhibitory effects

Characterization of bovine ruminal content focusing on energetic potential use and valorization opportunities

This work characterized the bovine ruminal content excluding stomach tissue obtained from a slaughterhouse plant located in Cordoba, Colombia. The goal is to establish possible energetic uses and valorization potential instead of risky local current contaminant practices. Samples of ruminal content (RC) were collected under two conditions as-fresh and dry. Microbiological and bromatological quality, density, proximate and elemental analysis, and calorific power values were measured. There were complemented with optical microscopy, SEM, XEDS, FTIR, TGA, and TGA-MS analysis for both conditions. Ashes of combustion products from mixtures of natural gas and RC were studied, using XRD and XRF techniques. Results showed that fresh-state RC has an important microbiological quality without some human risk pathogens, such as Salmonella sp, E. coli, and vegetable risk pathogens, such as nematodes. Dry and sieved state RC is lignin-cellulosic heterogeneous biomass, with a real density of 164 kg/m³, a calorific power between 12 and 15 kJ/kg, and ashes rich in alkaline-earth elements. These results indicate that RC might have a good potential in co-combustion, gasification, and other energy processes. However, important considerations should be done about management of RC, because its direct application as fertilizer could carry out a negative effect, which was demonstratred in the growth of a model plant.

Technological and Energetic Aspects of Multi-Component Co-Digestion of the Beverage Industry Wastes and Municipal Sewage Sludge

In the present study, the co-digestion effectiveness of the selected beverage wastes and municipal sewage sludge in two- and three-component mixtures was evaluated. Orange peels and orange pulp, as well as brewery spent grain were applied as co-substrates to sewage sludge at the following doses: 1.5 and 3.0 g of orange peels, 2.5 and 5 g of orange pulp, and 1.5 g brewery spent grain. Mono-digestion of sewage sludge was used as a control. The experiments were performed under mesophilic conditions in batch reactors. As compared to the control, only in the presence of the highest dose of pulp, brewery spent grain and sewage sludge was the increased methane production of 395 mL CH4 g−1 VS accompanying an additional energy profit of 82% observed. Moreover, in this case, the enhanced volatile solids removal and lower accumulation of p-cymene were found. These results were despite the increased limonene and phenol content in the feedstock, confirming a synergistic effect at the highest dose of pulp, brewery spent grain and sewage sludge.

Energy Potential of Biogas from Sewage Sludge after Thermal Hydrolysis and Digestion

This paper presents the energy potential of biogas obtained from the anaerobic digestion (AD) of sewage sludge (SS) preceded by thermal hydrolysis (THP) using Cambi THP® technology. The presented data are for the Tarnów (Poland) wastewater treatment plant for the year 2020. A detailed energy balance of biogas and its use in the cogeneration process and in the production of heat in the water boiler and the steam boiler is presented. The article contains data on the amount of processed SS and the content of dry matter and dry organic matter at different stages of the technological process. The annual plant operation resulted in the production of 3,276,497 Nm3 of biogas as a result of processing 8684 tonnes of dry solids (tDS) of municipal SS from the Tarnów wastewater treatment plant (WWTP) and regional WWTPs. The energy potential of the produced biogas was 75,347.06 GJ. The average calorific value of biogas was 23,021 kJ/Nm3.. The obtained biogas production allowed us to cover the thermal energy demand of the THP 100%. The annual average specific biogas conversion rate during the study period was 0.761 Nm3/kg of dry organic matter reduced and the average organic matter content reduction in the sludge was 64.60%.

Biodiesel, biogas and fermentable sugars production from Spent coffee Grounds: A cascade biorefinery approach

Spent coffee grounds are rich in high-value compounds, such as saturate and unsaturated fatty acids, and polysaccharides. Therefore, this work investigated a cascade biorefinery to produce: i) biodiesel from coffee oils, ii) cellulose- and hemicellulose-derived fermentable sugars and iii) biomethane from the residual solid fraction after sugars extraction. Transesterification reached the best performances of 86% w/w of fatty acid methyl esters using 1:8 coffee oil/methanol ratio and 2% w/w of KOH as catalyst. The use of glycerol for the pretreatment of spent coffee grounds allowed the internal circulation of a process leftover from transesterification; thus, avoiding the use of clean water. In the best conditions, the total released fermentable sugars were about 40-50% (w/w) on dry weight basis. The low content of easily degradable compounds led to a low methane production of 50 L_CH4/kg_VS, indicating the need to search for better performing alternatives to close the biorefinery loop.