Comparison of cobalt ferrate-based nanoparticles for promoting biomethane evolution from lactic acid anaerobic digestion

Mechanistic exploration of COVlD-19 antiviral drug ritonavir on anaerobic digestion through experimental validation coupled with metagenomics analysis

Aggregation of antiviral drugs (ATVs) in waste activated sludge (WAS) poses considerable environmental risk, so it is crucial to understand the behavior of these agents during WAS treatment. This study investigated the effects of ritonavir (RIT), an ATV used to treat human immunodeficiency virus infection and coronavirus disease 2019, on anaerobic digestion (AD) of WAS to reveal the mechanisms by which it interferes with anaerobic flora. The dosage influence results showed that methane production in AD of WAS decreased by 46.56 % when RIT concentration was increased to 1000 μg/kg total suspended solids (TSS). The AD staging test revealed that RIT mainly stimulated microbial synthesis of the extracellular polymeric substance (EPS), limiting organic matter solubilization. At 500 μg/kg TSS, RIT decreased CHO and CHON levels in dissolved organic matter by 23.12 % and 56.68 %, respectively, significantly reducing substrate availability to microorganisms. Metagenomic analysis of microbial functional gene sets revealed that RIT had greater inhibitory effects on protein and amino acid metabolism than on carbohydrate metabolism. Under RIT stress, methanogens switched from hydrogenotrophic and acetotrophic methanogenesis to methylotrophic and acetotrophic methanogenesis.

Complete 2,4,6-trichlorophenol degradation by anaerobic sludge acclimated with 4-chlorophenol: Synergetic effect of nZVI@BMPC and sodium lactate as an external nutrient

Ball-milled plastic char supported nano zero-valent iron (nZVI@BMPC) and their application combined with anaerobic sludge for microbial dechlorination of 2,4,6-trichlorophenol (2,4,6-TCP) were investigated. The XRD and FTIR analysis proved composition of zero valent states of iron, and the BET and SEM analysis showed that nZVI was uniformly distributed on the surface of BMPC. Successive addition of 1000 mg/L sodium lactate and nZVI@BMPC enhanced the acclamation of anaerobic sludge and resulted in the degradation of 4-CP within 80 days. The acclimated consortium with nZVI@BMPC completely degraded 2,4,6-TCP into CH4 and CO2, and the key dechlorination route was through 4-CP dechlorinaion and mineralization. The degradation rate of 2,4,6-TCP with nZVI@BMPC was 0.22/d, greater than that without nZVI@BMPC. The dechlorination efficiency was enhanced in the Fe2+/Fe3+ system controlled by nZVI@BMPC and iron-reducing bacteria. Metagenomic analysis result showed that the dominant de-chlorinators were Chloroflexi sp., Desulfovibrio, and Pseudomonas, which could directly degrade 2,4,6-TCP to 4-CP, especially, Chloroflexi bacterium could concurrently be used to mineralize 4-CP. The relative abundance of the functional genes cprA, acoA, acoB, and tfdB increased significantly in the presence of the nZVI@BMPC. This study provides a new strategy can be a good alternative for possible application in groundwater remediation.

Improved microalgae growth and lipid production in anaerobic digestate with ultraviolet radiation pretreatment

Inappropriate sterilization strategies inhibit microalgal growth when culturing microalgae with anaerobic digestate. This study aimed to scientifically select a low-cost disinfection pretreatment of anaerobic digestate for large-scale microalgae cultivations. In this work, three different methods, including autoclaving, ultraviolet or NaClO treatments, were employed to sterilize the municipal anaerobic digestate. Scenedesmus quadricauda was then cultured in diluted liquid digestate for the simultaneous lipid production and nutrient removal. The results indicated that the growth of S. quadricauda was inhibited after NaClO treatment due to the residual free chlorine. The 15-min ultraviolet effectively mitigated microbial contamination and increasing nutrient availability, enhancing the electron transport of microalgal photosynthesis. After 6-days cultivation, the microalgal biomass concentration of the ultraviolet group was 1.09 g/L, comparable to that of the autoclaving group (1.15 g/L). High nutrient removal efficiency was observed: COD (93.30 %), NH4+-N (92.56 %), TN (85.82 %) and TP (95.12 %). Moreover, S. quadricauda outcompeted the indigenous microorganisms, contributing to its dominance in the culture system of ultraviolet group. The facultative anaerobe Comamonadaceae and aerobes Moraxellaceae, rather than strict anaerobe Paludibacteraceae and Bacteroidetes_vadinHA17, played vital roles in synergistic removal of contaminants by bacteria and algae. The potential competition for nitrogen and phosphorus by bacteria contributed to the ultraviolet group having the greatest lipid content (48.19 %). Therefore, this work suggested using 15-min ultraviolet treatment for anaerobic digestate in large-scale microalgae cultivation.

Comparative investigations on the incorporation of biogenic Fe products into anaerobic granular sludge of different sources: Fe loading capacity, physicochemical properties, microbial community and long-term methanogenesis performance

Anaerobic granular sludge (AGS) has been regarded as the core of lots of advanced anaerobic reactors. Formation of biogenic Fe products and their incorporation into AGS could influence interspecies electron transfer and methanogenesis performance. In this study, with anaerobic granular sludge (AGS) from different sources (brewery, chemical plant, paper mill, citric acid factory, and food factory) as the research targets, the formation of biogenic iron products in AGS through the biologically induced mineralization process was studied. Furthermore, the influences of physicochemical properties and microbial community on methanogenesis were investigated. Results showed that all the AGS of different sources possessed the capacity to form biogenic Fe products through dissimilatory iron-reduction process, and diverse Fe minerals including magnetite (Fe3O4), hematite (Fe2O3), goethite (FeOOH), siderite (FeCO3) and wustite (FeO) were incorporated into AGS. The AGS loaded with Fe minerals (Fe-AGS) showed increased conductivity, magnetism and zeta-potential comparing to the control. Those Fe-AGS of different sources demonstrated different methanogenesis performance during the long-term operation (50 days). Methane production was increased for the Fe-AGS of citric acid (6.99-32.50%), food (8.33-37.46%), chemical (2.81-7.22%) and brewery plants (2.27-2.81%), but decreased for the Fe-AGS of paper mill (54.81-72.2%). The changes of microbial community and microbial correlations in AGS as a response to Fe minerals incorporation were investigated. For the Fe-AGS samples with enhanced methane production capability, it was widely to find the enriched populations of fermentative and dissimilatory iron reducing bacteria Clostridium_sensu_stricto_6, Bacteroidetes_vadinHA17 and acetoclastic methanogens Methanosaeta, and positive correlations between them. This study provides comprehensive understanding on the effects of incorporation biogenic Fe products on AGS from different sources.

Insights into the roles and mechanisms of a green-prepared magnetic biochar in anaerobic digestion of waste activated sludge

Methane is one of the most promising renewable energies to alleviate energy crisis or replace fossil fuels, which can be recovered from anaerobic digestion of bio-wastes. However, the engineering application of anaerobic digestion is always hindered by low methane yield and production rate. This study revealed the roles and mechanisms of a green-prepared magnetic biochar (MBC) in promoting methane production performance from waste activated sludge. Results showed that the methane yield reached 208.7 mL/g volatile suspended solids with MBC additive dosage of 1 g/L, increasing by 22.1 % compared to that in control. Mechanism analysis demonstrated that MBC could promote hydrolysis, acidification, and methanogenesis stages. This was because the properties of biochar were upgraded by loading nano-magnetite, such as specific surface area, surface active sites, and surface functional groups, which made MBC have greater potential to mediate electron transfer. Correspondingly, the activity of α-glucosidase and protease respectively increased by 41.7 % and 50.0 %, and then the hydrolysis performances of polysaccharides and proteins were improved. Also, MBC improved the secretion of electroactive substances like humic substances and cytochrome C, which could promote extracellular electron transfer. Furthermore, Clostridium and Methanosarcina, as well-known electroactive microbes, were selectively enriched. The direct interspecies electron transfer between them was established via MBC. This study provided some scientific evidences to comprehensively understand the roles of MBC in anaerobic digestion, with important implications for achieving resource recovery and sludge stabilization.

Co-treatment with free nitrous acid and calcium peroxide regulates microbiome and metabolic functions of acidogenesis and methanogenesis in sludge anaerobic digestion

Wasted activated sludge (WAS) is a promising feedstock for carbon management because of its abundance and carbon-neutral features. Currently, the goal is to maximize the energy in WAS and avoid secondary toxic effects or accumulation of harmful substances in the environment. Chemical pretreatment is an effective strategy for enhancing WAS disintegration and production of short chain fatty acids (SCFAs). However, the role of pretreatment in shaping the core microbiome and functional metabolism of anaerobic microorganisms remains obscure. Here, the mechanisms of SCFA synthesis and microbiome response to free nitrous acid (FNA) and calcium peroxide (CaO₂) co-treatment during sludge anaerobic digestion (AD) were investigated. The combination of FNA and CaO₂ enriched acidogenic Macellibacteroides, Petrimonas, and Sedimentibacter to a relative abundance of 15.0%, 10.3%, and 7.3%, respectively, resulting in an apparent increase in SCFA production. Metagenome analysis indicated that FNA + CaO₂ co-treatment facilitated glycolysis, phosphate acetyltransferase-acetate kinase pathway, amino acid metabolism, and acetate transport, but inhibited CO₂ reduction and common pathway of methanogenesis compared with the untreated control. This work provides theoretical insights into the functional activity and interaction of microorganisms with ecological factors.

Novel lanthanum-iron oxide nanoparticles alleviate the inhibition of anaerobic digestion by carbamazepine through adsorption and bioaugmentation

Several reports have shown that pharmaceuticals and personal care products (PPCPs) have some negative effects on anaerobic digestion (AD), yet there are no convenient and efficient strategies for mitigating the adverse influences. The typical PPCPs of carbamazepine have a strong negative effect on lactic acid AD process. Therefore, in this work, novel lanthanum-iron oxide (LaFeO₃) nanoparticles (NPs) were used for adsorption and bioaugmentation to weak the negative effects of carbamazepine. The adsorption removal of carbamazepine increased from 0 to 44.30% as the dosage of LaFeO₃ NPs was increased from 0 to 200 mg/L, providing the necessary prerequisites for bioaugmentation. Adsorption reduced the probability of direct contact between carbamazepine and anaerobes, partly alleviating the inhibition of carbamazepine on microbes. The highest methane (CH₄) yield induced by LaFeO₃ NPs (25 mg/L) was 226.09 mL/g lactic acid, increasing by 30.06% compared to the control yield with a recovery to 89.09% of the normal CH₄ yield. Despite the ability of LaFeO₃ NPs to restore normal AD performance, the biodegradation rate of carbamazepine remained below 10% due to its anti-biodegradability. Bioaugmentation was primarily reflected in the enhanced bioavailability of dissolved organic matter, while the intracellular LaFeO₃ NPs promoted coenzyme F420 activity through binding to humic substances. Under the mediation of LaFeO₃, a direct interspecies electron transfer system with Longilinea and Methanosaeta as functional bacteria was successfully constructed and the corresponding electron transfer rate was accelerated from 0.021 s^-1 to 0.033 s^-1. LaFeO₃ NPs eventually recovered AD performance under carbamazepine stress in an adsorption and bioaugmentation manner.

Enhancement of Anaerobic Digestion with Nanomaterials: A Mini Review

In recent years, the number of articles reporting the addition of nanomaterials to enhance the process of anaerobic digestion has exponentially increased. The benefits of this addition can be observed from different aspects: an increase in biogas production, enrichment of methane in biogas, elimination of foaming problems, a more stable and robust operation, absence of inhibition problems, etc. In the literature, one of the current focuses of research on this topic is the mechanism responsible for this enhancement. In this sense, several hypotheses have been formulated, with the effect on the redox potential caused by nanoparticles probably being the most accepted, although supplementation with trace materials coming from nanomaterials and the changes in microbial populations have been also highlighted. The types of nanomaterials tested for the improvement of anaerobic digestion is today very diverse, although metallic and, especially, iron-based nanoparticles, are the most frequently used. In this paper, the abovementioned aspects are systematically reviewed. Another challenge that is treated is the lack of works reported in the continuous mode of operation, which hampers the commercial use of nanoparticles in full-scale anaerobic digesters.