Mechanistic studies on the effect of easy degradable carbon on pharmaceuticals removal in intermittently fed moving bed biofilm reactors

Eat seldom is better than eat frequently: Pharmaceuticals degradation kinetics, enantiomeric profiling and microorganisms in moving bed biofilm reactors are affected by feast famine cycle times

Feast-famine (FF) regimes improved the removal of recalcitrant pharmaceuticals in moving bed biofilm reactors (MBBRs), but the optimal FF cycle remained unresolved. The effects of FF cycle time on the removal of bulk substrates (organic carbon and nitrogen) and trace pharmaceuticals by MBBR are systematically evaluated in this study. The feast to famine ratio was fixed to 1:2 to keep the same loading rate, but the time for the FF cycles varied from 18 h to 288 h. The MBBR adapted to the longest FF cycle time (288 h equaling 48 × HRT) resulted in significantly higher degradation rates (up to +183%) for 12 out of 28 pharmaceuticals than a continuously fed (non-FF) reactor. However, other FF cycle times (18, 36, 72 and 144 h) only showed a significant up-regulation for 2-3 pharmaceuticals compared to the non-FF reactor. Enantioselective degradation of metoprolol and propranolol occurred in the second phase of a two phase degradation, which was different for the longer FF cycle time. N-oxidation and N-demethylation pathways of tramadol and venlafaxine differed across the FF cycle time suggestin the FF cycle time varied the predominant transformation pathways of pharmaceuticals. The abundance of bacteria in the biofilms varied considerably between different FF cycle times, which possibly caused the biofilm to remove more recalcitrant bulk organic C and pharmaceuticals under long cycle times.

Transformation mechanisms of the antidepressant citalopram in a moving bed biofilm reactor: Substrate-depended pathways, eco-toxicities and enantiomeric profiles

Citalopram (CIT) is one of the most consumed antidepressants and frequently detected in aquatic environments worldwide. Conventional wastewater treatment cannot remove this neuronal active pharmaceutical efficiently. Past studies showed that moving bed biofilm reactors (MBBRs) can degrade CIT but the exact transformation pathways and toxicity reduction remained unclear. In this study, the effects of substrate stimulation on CIT transformation in an MBBR were systematically investigated. The results showed that a co-metabolic stimulation by acetate increased the transformation rate by 54 % and 24 % at high (300 μg/L) and environmental concentration (1.8 μg/L) of CIT, respectively. Conversely, the complex substrates in raw wastewater reduced the reaction rates by 44 %, suggesting a competitive inhibition on the enzymatic sites. The substrate stimulation changed the enantiomeric fraction (EF) of CIT from racemic (EF=0.5) to 0.60 at the high CIT concentrations, while those at lower concentrations resulted in an EF of 0.33, indicating that probably different enantioselective enzymes degraded CIT at high concentrations than at low concentrations, i.e., the presence of 300 µg/L CIT was possibly sufficient to induce the synthesis of different enantioselective enzymes, than those originally present. Through non-target and target analysis, in total 19 transformation products (TPs) including 7 TPs that were hitherto not mentioned in the literature were identified. Among these were quaternary amines, alkenes and conjugate TPs. The major transformation pathways were a) nitrile hydrolysis (up to 43 %), b) amide hydrolysis, and c) N-oxidation. Dosing acetate up-regulated significantly the amide hydrolysis, N-oxidation and conjugation pathways but inhibited the N-demethylation and α-carbon hydroxylation pathways. The in-silico toxicity assessment of CIT and its TPs suggested the overall eco-toxic potential of TPs was reduced by MBBR. Furthermore, the degradation under carbon-limited (famine) conditions favored the formation of the more toxic carboxamide, N-desmethyl and alkene TPs, while carbon-rich conditions, promoted the production of the less toxic carboxylic acid, N-oxide and ester TPs. Therefore, this study demonstrated that a) the co-metabolic stimulation of CIT metabolization by dosing a simple carbon source or b) inhibition of CIT metabolization by complex substrates; c) substrate stimulation made a difference on CIT transformation rates, enantiomeric profiles, pathways and toxic potentials. Overall, a simple-carbon co-metabolic stimulated MBBR was an efficient up-regulation strategy to minimize hazardous CIT and CIT-TPs as much as possible.

Response of biofilm-based systems for antibiotics removal from wastewater: Resource efficiency and process resiliency

Biofilm-based systems have efficient stability to cope-up influent shock loading with protective and abundant microbial assemblage, which are extensively exploited for biodegradation of recalcitrant antibiotics from wastewater. The system performance is subject to biofilm types, chemical composition, growth and thickness maintenance. The present study elaborates discussion on different type of biofilms and their formation mechanism involving extracellular polymeric substances secreted by microbes when exposed to antibiotics-laden wastewater. The biofilm models applied for estimation/prediction of biofilm-based systems performance are explored to classify the application feasibility. Further, the critical review of antibiotics removal efficiency, design and operation of different biofilm-based systems (e.g. rotating biological contactor, membrane biofilm bioreactor etc.) is performed. Extending the information on effect of various process parameters (e.g. hydraulic retention time, pH, biocarrier filling ratio etc.), the microbial community dynamics responsible of antibiotics biodegradation in biofilms, the technological problems, related prospective and key future research directions are demonstrated. The biofilm-based system with biocarriers filling ratio of ∼50-70% and predominantly enriched with bacterial species of phylum Proteobacteria protected under biofilm thickness of ∼1600 μm is effectively utilized for antibiotic biodegradation (>90%) when operated at DO concentration ≥3 mg/L. The C/N ratio ≥1 is best suitable condition to eliminate antibiotic pollution from biofilm-based systems. Considering the significance of biofilm-based systems, this review study could be beneficial for the researchers targeting to develop sustainable biofilm-based technologies with feasible regulatory strategies for treatment of mixed antibiotics-laden real wastewater.