Removing starch granule-associated surface lipids affects structure of heat-moisture treated hull-less barley starch

Dynamic development of changes in multi-scale structure during grain filling affect gelatinization properties of rice starch

Rice was collected over the entire grain filling period (about 40 days) to explore the multi-structure evolution and gelatinization behavior changes of starch. During the early stage (DAA 6-14), the significant reduction in lamellar repeat distance (10.04 to 9.68 nm) and relative crystallinity (26.6 % to 22.7 %) was due to initial rapid accumulation of amylose (from 9.38 % to 14.05 %) and short amylopectin chains. Meanwhile, the decreased proportion of aggregation structure resulted in a decrease in the gelatinization temperature and a narrowed range of gelatinization temperature also indicated an increase in homogeneity as starch matured. Gelatinization enthalpy was mainly controlled by aggregation structure, which was negatively and positively related to the amylose content and the degree of order respectively. Peak viscosity of starch pasting increased and reached a maximum (924 cP) at DAA-21 due to larger granule size. Amylose and short amylopectin chains with degree of polymerization 6-12 showed positive and negative correlation with short-term retrogradation ability (setback value) respectively. The dynamics of different scale structure during grain filling had varying degrees of impact on gelatinization properties.

Relationship between internal structure and in vitro digestibility of A- and B-type wheat starch revealed by chemical surface gelatinization

In this study, the properties of remaining starch granules obtained with different degrees of exfoliation were explored by removing the outer layers of A- and B-type wheat starch (AWS and BWS) granules with chemical surface gelatinization. SEM images revealed significant morphological variations with increasing exfoliation. CLSM and amylose content analysis indicated a predominance of lipid complexes in the outer granule layers, particularly in BWS. The structural characteristics of AWS and BWS were analyzed using PLM, XRD, FT-IR and DSC, verifying the conclusion of the alternation of starch crystalline and amorphous zone. And the amorphous regions are proportionally higher in the inner starch layer. Moreover, raw AWS and BWS granules were more easily digested from the outside in, with the RS content decreasing from 80.65 % to 66.92 % and 49.06 % to 45.01 %, respectively. The RS content of cooked WS were affected by the internally structures, particularly lipid content (11.46 % - 19.09 %) in BWS outer layers and amylose content (13.59 % - 19.43 %) in the inner layers. These results revealed the internal radial structural differences and digestibility patterns of AWS and BWS granules.

Effect of frozen storage on the quality of frozen instant soup rice noodles: From the moisture and starch characteristics

This study aimed to simulate frozen instant soup rice noodles (FISRN) and investigate the effects of long-term frozen storage (-18 °C, 180 days) on the quality characteristics, moisture status, and starch retrogradation of FISRN. The findings indicated that the extent of starch retrogradation gradually increased over 90 days, which elevated the RS rate and inhibited starch digestibility. However, recrystallization resulted in a gradual increase in ice crystal size after 90 days, which disrupted the ordered structure formed by starch retrogradation, reduced the degree of starch order, and accelerated the rate of starch digestion. Furthermore, a longer relaxation time (T24) was detected by NMR with increasing storage time. The weakly bound water in FISRN was gradually converted to free water. Texture results suggested that the hardness of FISRN experienced a general decrease. The cooking loss increased progressively from 3.66 % to 8.10 %. Scanning electron microscope demonstrated that the internal porous network structure of FISRN became inhomogeneous, and a significant number of apertures were formed on the surface. Overall, starch retrogradation and ice recrystallization significantly impact the quality of FISRN during long-term frozen storage. The findings may potentially influence the consumption and market circulation of FISRN positively.

Strategic exploration of whole grain cereals in modulating the glycaemic response

In the current context, diabetes presents itself as a widespread and complex global health issue. This study explores the significant influence of food microstructure and food matrix components interaction (protein, lipid, polyphenols, etc.) on the starch digestibility and the glycaemic response of post-prandial glycemia, focusing on the potential effectiveness of incorporating bioactive components from whole grain cereals into dietary strategies for the management and potential prevention of diabetes. This study aims to integrate the regulation of postprandial glycaemic homeostasis, including the complexities of starch digestion, the significant potential of bioactive whole grain components and the impact of food processing, to develop a comprehensive framework that combines these elements into a strategic approach to diabetes nutrition. The convergence of these nutritional strategies is analyzed in the context of various prevalent dietary patterns, with the objective of creating an accessible approach to mitigate and prevent diabetes. The objective remains to coalesce these nutritional paradigms into a coherent strategy that not only addresses the current public health crisis but also threads a preventative approach to mitigate future prevalence and impact.

Effects of Stir-Frying and Heat-Moisture Treatment on the Physicochemical Quality of Glutinous Rice Flour for Making Taopian, a Traditional Chinese Pastry

Taopian is a traditional Chinese pastry made from cooked glutinous rice flour. The effects of heat-moisture treatment (110 °C, 4 h; moisture contents 12-36%, w/w) on the preparation of cooked glutinous rice flour and taopian made from it were compared with the traditional method of stir-frying (180 °C, 30 s). The color of heat-moisture-treated (HMT) flours was darker. HMT flours exhibited a larger mean particle size (89.5-124 μm) and a greater relative crystallinity of starch (23.08-42.92%) and mass fractal dimension (1.77-2.28). The flours exhibited water activity in the range of 0.589-0.631. Although the oil-binding capacity of HMT flours was largely comparable to that of stir-fried flours, HMT flours exhibited a lower water absorption index. Accordingly, the taopian produced with HMT flours exhibited a lower brightness, accompanied by a stronger reddening and yellowing. In addition, more firmly bound water was observed in the taopian produced with HMT flour. The taopian made with HMT flour with a moisture content of 24% exhibited moderate hardness, adhesiveness and cohesiveness and received the highest score for overall acceptability (6.80). These results may be helpful to improve the quality of taopian by applying heat-moisture treatment in the preparation of cooked glutinous rice flour.

A review of endogenous non-starch components in cereal matrix: spatial distribution and mechanisms for inhibiting starch digestion

As compared with exogenous components, non-starch components (NSCS), such as proteins, lipids, non-starch polysaccharides (NSPs), and polyphenols, inherently present in cereals, are more effective at inhibiting starch digestibility. Existing research has mostly focused on complex systems but overlooked the analysis of the in-situ role of the NSCS. This study reviews the crucial mechanisms by which endogenous NSCS inhibit starch digestion, emphasizing the spatial distribution-function relationship. Starch granules are filled with pores/channels-associated proteins and lipids, embedding in the protein matrix, and maintained by endosperm cell walls. The potential starch digestion inhibition of endogenous NSCS is achieved by altering starch gelatinization, molecular structure, digestive enzyme activity, and accessibility. Starch gelatinization is constrained by endogenous NSCS, particularly cell wall NSPs and matrix proteins. The stability of the starch crystal structure is enhanced by the proteins and lipids distributed in the starch granule pores and channels. Endogenous polyphenols greatly inhibit digestive enzymes and participate in the cross-linking of NSPs in the cell wall space, which together constitute a physical barrier that hinders amylase diffusion. Additionally, the spatial entanglement of NSCS and starch under heat and non-heat processing conditions reduces starch accessibility. This review provides novel evidence for the health benefits of whole cereals.

Formation of small-granule starch oleogels based on capillary force: Impact of starch surface lipids on lubrication performance

Starch granule oleogels were prepared and their rheological properties were precisely tuned using the capillary bridging phenomenon. The addition of a small amount of water to an oily suspension of starch granules can lead to starch granule bridging and network formation, transitioning it from a fluid-like to a gel-like state. Small-granule starches with high specific surface area and interfacial area exhibited a greater number of liquid bridges and stronger starch granules interactions, making them more prone to forming structurally stable oleogel systems. By increasing the content of water and starch granule, the starch oleogels exhibited three distinct structural states: pendular state (water ≤ 3.28 %, starch ≤ 17.85 %), pendular bridging network (water: 4.92 %, starch: 24.59 %), and capillary aggregates (water ≥ 6.56 %, starch > 24.59 %). Furthermore, the influence of starch granule surface lipids on the lubrication performance of the oleogel system was investigated. Surface roughness increased after extraction of surface lipids, and the friction coefficient also showed a significant increase. Overall, capillary suspension system can potentially be used to design novel fat food products, and our findings have established the correlation between starch granule surface properties and sensory perception in food, providing valuable insights for adjusting the oral processing characteristics of food.

Absolute Quantitative Lipidomics Reveals Different Granule-Associated Surface Lipid Roles in the Digestibility and Pasting of Waxy, Normal, and High-Amylose Rice Starches

Granule-associated surface lipids (GASLs) and internal lipids showed different lipid-amylose relationships, contents, and distributions, suggesting their differing biological origins and functions, among waxy, normal, and high-amylose rice starch. The GASL content mainly depended on the pore size, while internal lipids regulated starch biosynthesis, as indicated by correlations of internal lipids with the chain length distribution of amylopectin and amylose content. Of the 1346 lipids detected, 628, 562, and 408 differentially expressed lipids were observed between normal-waxy, high-amylose-waxy, and normal-high-amylose starch, respectively. After the removal of GASLs, the higher lysophospholipid content induced greater decreases in the peak and breakdown viscosity and swelling power, while the highest digestibility increase was found with the highest triacylglycerol content. Thus, different GASL compositions led to different digestibility, swelling, and pasting outcomes. This study sheds new light on the mechanism of the role of GASLs in the structure and properties of starch, as well as in potential modifications and amyloplast membrane development.

Extraction process, physicochemical properties, and digestive performance of red yeast rice starch

In the present study, taking red yeast rice (RYR) as the raw material, the optimum extraction process of RYR starch was investigated through a single-factor experiment and the Box-Behnken design: The liquid-to-solid ratio was 5 mL/g, the concentration of sodium hydroxide solution was 0.075 mol/L, and the extraction time was 3.1 h. Under these extraction conditions, the extraction rate of starch reached 90.077%. To explore the influence of solid-state fermentation on RYR starch, three different fermentation stages of RYR starch, raw rice starch, semi-gelatinized rice starch, and RYR starch were used as test materials to determine the changes in the physicochemical properties and glycemic index (GI) values of RYR starch during solid-state fermentation. The results showed that with the advancement of the RYR solid-state fermentation process, the starch particle size gradually increased, the light transmittance gradually decreased, and the solubility and swelling power significantly increased. In addition, the amylose content of starch gradually increased, whereas the amylopectin content gradually decreased; the content of fast digestible starch and slow digestible starch decreased, whereas the content of resistant starch increased. In parallel, during solid-state fermentation, the hydrolysis index significantly decreased, and the GI values also decreased. In summary, solid-state fermentation reduced the digestibility of RYR starch. These results provide a theoretical basis for the structural and physicochemical properties of RYR starch and lay a foundation for its subsequent application and expansion of RYR starch.

Impact of starch chain length distributions on physicochemical properties and digestibility of starches

Changing starch structure at different levels is a promising approach to promote desirable metabolic responses. Chain length distribution (CLD) is among the starch structural characteristics having a potential to determine properties of starch-based products. Therefore, the objective of the current review is to summarize recent findings on CLD and its impact on physicochemical properties and digestion. Investigations undertaken to enhance understanding of starch structure have shown clearly that CLD is a significant determining factor in modulating starch digestibility. Enzymatic modifications and processing treatments alter the CLD of starch, which in turn affects the rate of digestion, but the underlying molecular mechanisms have yet to be fully elucidated. Even though advances have been made in manipulating CLD using different methods and to correlate the changes with various functional properties, in general the area needs further investigations to open new awareness for enhancing healthiness of starchy foods.

Physicochemical properties of amorphous granular starch (AGS) prepared by non-thermal gelatinization by high hydrostatic pressure (HHP) and spray drying

Corn starch was gelatinized by high hydrostatic pressure (HHP) and spray drying to make amorphous granular starch (AGS), and their physicochemical properties were compared with the conventionally prepared (heat-gelatinized and spray dried) AGS to devise a novel AGS preparation methodology. Pressure-induced (PAGS) and heat-induced AGS (HAGS) maintained their granular shape but lost their birefringence indicating that both methods could prepare AGS. DSC (differential scanning calorimeter) and XRD (X-ray diffraction) analysis confirmed the complete loss of amylopectin double helices and crystallinity of both PAGS and HAGS. However, their swelling power, solubility, RVA pasting properties, acid/shear stability, gel forming ability and textural properties were completely different. PAGS exhibited constrained swelling, suppressed amylose leaching, and reduced viscosity. Notably, HAGS formed a gel without heating, whereas PAGS yielded a viscous paste with water-soluble attributes. Even after reheating, PAGS maintained its granular structure with comparably less swelling and weaker gel strength than HAGS. Consequently, newly developed PAGS exhibited distinctive characteristics compared to the conventional HAGS, such as lower solubility and swelling power, viscosity, textural properties, and high acid and shear stabilities, rendering it a viable option for various applications within the food industry.

The combined actions of the granule surface barrier and multiscale structural evolution of starch on in vitro digestion of oat flour

The digestive properties of oat-based food have garnered considerable interest. This study aimed to explore the internal and external factors contributing to different digestion properties of oat flour under actual processing conditions. Analysis of the ordered structure of oat starch revealed that an increase in gelatinization moisture to 60 % led to a decrease in crystallinity, R1047/1022 value, and helical structures content to 0, 0.48 %, and 1.45 %, respectively. Even when the crystal structure was completely destroyed, the short-range structure retained a certain degree of order. Surface structure observations of starch granules and penetration experiments with amylase-sized polysaccharide fluorescence probes indicated that non-starch components and small pores effectively hindered the diffusion of the probes but low-moisture (20 %) gelatinization substantially damaged this barrier. Furthermore, investigations into starch digestibility and starch molecular structure revealed that the ordered structure remaining inside the starch after high gelatinization delayed the digestion rate (0.028 min-1) and did not increase the content of resistant starch (7.10 %). It was concluded that the surface structure and non-starch components of starch granules limited the extent of starch digestion, whereas the spatial barrier of the residual ordered structure affected the starch digestion rate.

Effects of heat-moisture treatment on structural characteristics and in vitro digestibility of A- and B-type wheat starch

In this study, A- and B-type wheat starch granules (AWS and BWS) were separated and modified by heat-moisture treatment (HMT) with different moisture content (10 %-40 %). The effects of HMT on the structure characteristics and digestibility of raw/cooked AWS and BWS were investigated by SEM, FT-IR, XRD, DSC, TGA and NMR. SEM and FT-IR results showed that BWS was more sensitive to HMT than AWS. Interestingly, crystalline conformation of AWS and BWS changed from A type to A + V type after HMT, and the relative crystallinity (V-type) of starch increased to 2.7 % and 3.4 %, respectively. XRD and NMR results verified the formation of V-type crystalline structure. The resistant starch (RS) content of cooked starch was increased, especially for BWS (from 11.46 % to 28.29 %). Compared to the cooked starch, the RS content of raw AWS and BWS was affected by relative crystallinity and the size of starch granules. Furthermore, structure characteristics and digestion kinetics results indicated that the digestion rate of cooked AWS increased due to the deconstruction of starch chains, opposite to BWS (because of the more V-type crystals). The results enrich our understanding of the mechanism of digestion subjected to HMT by different grain sizes of the same wheat starch.

Heat-moisture treated waxy highland barley starch: Roles of starch granule-associated surface lipids, temperature and moisture

Roles of temperature, moisture and starch granule-associated surface lipids (SGASL) during heat-moisture treatment (HMT) of waxy highland barley starch were elucidated. Starch without SGASL showed a higher increase in ratio (1016/993 cm-1) (0.095-0.121), lamellar peak area (88), radius of gyration (Rg1, 0.9-1.8 nm) and power-law exponents (0.19-0.42) than native starch (0.038-0.047, 46, 0.1-0.6 nm, 0.04-0.14), upon the same increase in moisture or temperature. Thus, removing SGASL promoted HMT. However, after HMT (30 % moisture, 120 °C), native starch showed lower relative crystallinity (RC, 11.67 %) and lamellar peak area (165.0), longer lamellar long period (L, 14.99 nm), and higher increase in peak gelatinization temperature (9.2-13.3 °C) than starch without SGASL (12.04 %, 399.2, 14.52 nm, 4.7-6.1 °C). This suggested that the resulting SGASL-amylopectin interaction further destroyed starch structure. Starch with and without SGASL showed similar trends in RC, lamellar peak area, L and Rg1 with increasing temperature, but different trends with increasing moisture, suggesting that removing SGASL led to more responsiveness to the effects of increasing moisture. Removing SGASL resulted in similar trends (RC and lamellar peak area) with increasing moisture and temperature, suggesting that the presence of SGASL induced different effects on moisture and temperature.

Molecular structure and linear-non linear rheology relation of rice starch during milky, dough, and mature stages

Immature rice has potential to be used as healthy food. The relation between molecular structure and rheological properties was investigated. The lamellar repeating distance (8.42-8.63 nm) and crystalline thickness (4.60-4.72 nm) were not different among stages indicating a complete lamellar structure even at early stage. The relative crystallinity was higher in dough (39.62 %) than milky (36.69 %) and mature starch (35.22 %) caused by molecular structure, amylose, and amylose-lipid complex. The short amylopectin branched chains (A and B1) in dough starch were easily entangled resulted in higher Payne effect and elastic dominant. Dough starch paste exhibited higher G'_Max (738 Pa) than milky (685 Pa) and mature (645 Pa) starch. In a non-linear viscoelastic regime, small strain hardening was found in milky and dough starch. Mature starch showed the highest plasticity and shear thinning at high-shear strains as the long-branched chains (B3) microstructure was disrupted, disentangled, followed by chain orientation along shear.

Differential distribution of surface proteins/lipids between wheat A- and B-starch granule contributes to their difference in pasting and rheological properties

The distribution of surface proteins/lipids and their effect on physicochemical properties of wheat A- and B-starch were investigated. Small B-starch with higher surface protein (~1.8 %) and lipid (~0.4 %) contents did not differ significantly from specific surface area of large A-starch (~0.2 % protein and ~ 0.1 % lipid), indicating surface lipids/proteins for starch are characteristic of their biological origin, not directly related to granule size. The surface of A-starch granule was an integrated membrane structure (lipids covered by proteins). B-starch showed a greater decrease in peak and trough viscosity (130 and 82 cP) than A-starch (99 and 52 cP) after removing surface proteins, perhaps because the presence of residual surface lipid as a membrane protected the rigidity of A-starch granule. B-starch showed a greater increase in consistency coefficient (K) (47.01 Pa·sⁿ) than A-starch (20.33 Pa·sⁿ) after removing surface lipids, possibly due to the greater loss of surface lipid as complex with amylose in B-starch which retard retrogradation and reduce K. These results show that different distributions and contents of surface proteins/lipids between wheat A- and B-starch granule contribute to the pasting and rheological properties.