1
|
Li J, Usman M, Arslan M, Gamal El-Din M. Molecular and microbial insights towards anaerobic biodegradation of anionic polyacrylamide in oil sands tailings. WATER RESEARCH 2024; 258:121757. [PMID: 38768520 DOI: 10.1016/j.watres.2024.121757] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/10/2024] [Revised: 04/22/2024] [Accepted: 05/08/2024] [Indexed: 05/22/2024]
Abstract
Anionic polyacrylamide (A-PAM) is widely used as a flocculant in the management of oil sands tailings. Nevertheless, apprehensions arise regarding its potential biodegradation and environmental consequences within the context of oil sands tailings. Consequently, it is imperative to delve into the anaerobic biodegradation of A-PAM in oil sands tailings to gain a comprehensive understanding of its influence on tailings water quality. This work explored the dynamics of A-PAM biodegradation across concentrations: 50, 100, 250, 500, 1000, and 2000 mg/kg TS. The results showed a significant decrease in A-PAM concentration and molecular weight at lower concentrations (50 and 100 mg/kg TS) compared to higher ones, suggesting enhanced degradation efficiency. Likewise, the organic transformation and methane production exhibited dependency on A-PAM concentrations. The peak concentrations observed were 20.0 mg/L for volatile fatty acids (VFAs), 0.07 mg/L for acrylamide (AMD), and 8.9 mL for methane yield, with these maxima being recorded at 50 mg/kg TS. The biodegradation efficiency diminishes at higher concentrations of A-PAM, potentially due to the inhibitory effects of polyacrylic acid accumulation. A-PAM biodegradation under anaerobic condition did not contribute to acute toxicity or genotoxicity. SEM-EDS, FT-IR and XRD analyses further revealed that higher concentrations of A-PAM inhibited the biodegradation by altering floc structure and composition, thereby restricting the microbial activity. Major microorganisms, including Smithella, Candidatus_Cloacimonas, W5, XBB1006, and DMER64 were identified, highlighting A-PAM's dual role as a source of carbon and nitrogen under anaerobic conditions. The above findings from this research not only significantly advance understanding of A-PAM's environmental behavior but also contribute to the effective management practices in oil sands tailings.
Collapse
Affiliation(s)
- Jia Li
- Department of Civil and Environmental Engineering, University of Alberta, Edmonton, Alberta, T6G 1H9, Canada
| | - Muhammad Usman
- Department of Civil and Environmental Engineering, University of Alberta, Edmonton, Alberta, T6G 1H9, Canada
| | - Muhammad Arslan
- Department of Civil and Environmental Engineering, University of Alberta, Edmonton, Alberta, T6G 1H9, Canada
| | - Mohamed Gamal El-Din
- Department of Civil and Environmental Engineering, University of Alberta, Edmonton, Alberta, T6G 1H9, Canada.
| |
Collapse
|
2
|
Wang Z, Zhang S, Geng Z, Li C, Sun L, Zhang L, Cao Z. Soil bacterial community diversity and life strategy during slope restoration on an uninhabited island: changes under the aggregate spray-seeding technique. J Appl Microbiol 2024; 135:lxae132. [PMID: 38830801 DOI: 10.1093/jambio/lxae132] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/07/2024] [Revised: 05/29/2024] [Accepted: 05/31/2024] [Indexed: 06/05/2024]
Abstract
AIMS We investigated the effects of the aggregate spray-seeding (ASS) technique on soil bacterial community diversity, life strategies, and seasonal change. METHODS AND RESULTS Soil from six plots with original vegetation (CK, n = 6) was compared to soil from 15 plots with spray-seeding restoration (SR, n = 15) using environmental DNA sequencing. The bacterial Shannon and Chao1 indices of SR soils were significantly greater (P < 0.05) than those of CK soils. The Chao1 index for the SR soil bacterial community was significantly greater in summer (P < 0.05) than in winter. The ratio of the relative abundance of bacterial K-strategists to r-strategists (K/r) and the DNA guanine-cytosine (GC) content in the SR soil were significantly lower (P < 0.05) than those in the CK soil. Principal coordinate analysis revealed significant differences between the SR and CK bacterial communities. The GC content was positively correlated with the K/r ratio. Soil conductivity was negatively associated with the K/r ratio and GC content, indicating that ionic nutrients were closely related to bacterial life strategies. CONCLUSIONS The ASS technique improved soil bacterial diversity, altered community composition, and favored bacterial r-strategists.
Collapse
Affiliation(s)
- Zhikang Wang
- Key Laboratory of Plant Nutrition and the Agri-environment in Northwest China, Ministry of Agriculture; College of Natural Resources and Environment, Northwest A & F University, Yangling 712100, China
- Qingdao Greensum Ecology Co., Ltd., Qingdao 266102, China
| | - Shilei Zhang
- Qingdao Greensum Ecology Co., Ltd., Qingdao 266102, China
| | - Zengchao Geng
- Key Laboratory of Plant Nutrition and the Agri-environment in Northwest China, Ministry of Agriculture; College of Natural Resources and Environment, Northwest A & F University, Yangling 712100, China
| | - Chunlin Li
- Qingdao Greensum Ecology Co., Ltd., Qingdao 266102, China
| | - Linting Sun
- Qingdao Greensum Ecology Co., Ltd., Qingdao 266102, China
| | | | - Zhiquan Cao
- Qingdao Greensum Ecology Co., Ltd., Qingdao 266102, China
| |
Collapse
|
3
|
Song T, Zhang F, Chen Q, Tao Y, Chang W, Xia W, Ding W, Jin J. Acceleration of the biodegradation of cationic polyacrylamide by the coupling effect of thermophilic microorganisms and high temperature in hyperthermophilic composting. Bioprocess Biosyst Eng 2024; 47:403-415. [PMID: 38421394 DOI: 10.1007/s00449-024-02972-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/23/2023] [Accepted: 01/20/2024] [Indexed: 03/02/2024]
Abstract
As a flocculant of sewage sludge, cationic polyacrylamide (CPAM) enters the environment with sludge and exists for a long time, posing serious threats to the environment. Due to the environmental friendliness and high efficiency in the process of organic solid waste treatment, hyperthermophilic composting (HTC) has received increasing attention. However, it is still unclear whether the HTC process can effectively remove CPAM from sludge. In this study, the effects of HTC and conventional thermophilic composting (CTC) on CPAM in sludge were compared and analyzed. At the end of HTC and CTC, the concentrations of CPAM were 278.96 mg kg-1 and 533.89 mg kg-1, respectively, and the removal rates were 72.17% and 46.61%, respectively. The coupling effect of thermophilic microorganisms and high temperature improved the efficiency of HTC and accelerated the biodegradation of CPAM. The diversity and composition of microbial community changed dramatically during HTC. Geobacillus, Thermobispora, Pseudomonas, Brevundimonas, and Bacillus were the dominant bacteria responsible for the high HTC efficiency. To our knowledge, this is the first study in which CPAM-containing sludge is treated using HTC. The ideal performance and the presence of key microorganisms revealed that HTC is feasible for the treatment of CPAM-containing sludge.
Collapse
Affiliation(s)
- Tianwen Song
- College of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, 266033, China.
| | - Fan Zhang
- College of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, 266033, China
| | - Qu Chen
- Medical College, Qingdao Binhai University, Qingdao, 266555, China
| | - Yinglu Tao
- College of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, 266033, China
| | - Wei Chang
- College of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, 266033, China
| | - Wenxiang Xia
- College of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, 266033, China.
| | - Wande Ding
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, China
| | - Jiafeng Jin
- Key Laboratory of Unconventional Oil & Gas Development (China University of Petroleum (East China)), Ministry of Education, Qingdao, 266580, China
| |
Collapse
|
4
|
Lu Y, Lin D, Liu G, Luo H, Zhang R, Luan T. Sustainable in situ ammonia recovery from municipal solid waste leachate in a single-stream microbial desalination cell. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2024; 349:119610. [PMID: 37992664 DOI: 10.1016/j.jenvman.2023.119610] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/18/2023] [Revised: 11/05/2023] [Accepted: 11/11/2023] [Indexed: 11/24/2023]
Abstract
Municipal solid waste (MSW) leachate is one of the most hazardous waste streams leading to great potential risk to environment, and a renewable resource with high concentrations of organic contaminant and ammonia. High energy consumption and chemical input are still the challenges for ammonia recovery from MSW leachate. Here, a single-stream microbial desalination cell (SMDC) was successfully developed for simultaneous energy extraction from organic contaminant and in-situ energy utilization for ammonia recovery. 70% of the organic contaminant from the actual MSW leachate was removed, and 24.9% of the total ammonia was recovered as high-purity (NH4)2SO4. The additional desalination chamber introduced into the SMDC can potentially enhance the NH4+ migration that was determined by the NH4+ concentration gradient and electric field. More than 30% of the total nitrogen was lost, as revealed by nitrogen mass balance analysis, probably resulting from the anodic denitrification process driven by denitrifying microorganisms, e.g., Thauera, which thrived in the anode chamber. Concomitantly, the chemical input for ammonia stripping can be reduced by up to 68% due to the relatively low buffer capacity of the catholyte and the OH- production from the cathode reaction. This SMDC can be an effective and environmentally sustainable solution for MSW leachate treatment and resource recovery.
Collapse
Affiliation(s)
- Yaobin Lu
- Guangdong Provincial Key Laboratory of Water Quality Improvement and Ecological Restoration for Watersheds, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou, 510006, China; Guangdong Laboratory of Chemistry and Fine Chemical Engineering Jieyang Center, Jieyang, 515200, China.
| | - Dong Lin
- Guangdong Provincial Key Laboratory of Water Quality Improvement and Ecological Restoration for Watersheds, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou, 510006, China
| | - Guangli Liu
- Guangdong Provincial Key Laboratory of Environmental Pollution Control and Remediation Technology, School of Environmental Science and Engineering, Sun Yat-sen University, Guangzhou, 510275, China
| | - Haiping Luo
- Guangdong Provincial Key Laboratory of Environmental Pollution Control and Remediation Technology, School of Environmental Science and Engineering, Sun Yat-sen University, Guangzhou, 510275, China
| | - Renduo Zhang
- Guangdong Provincial Key Laboratory of Environmental Pollution Control and Remediation Technology, School of Environmental Science and Engineering, Sun Yat-sen University, Guangzhou, 510275, China
| | - Tiangang Luan
- Guangdong Provincial Key Laboratory of Water Quality Improvement and Ecological Restoration for Watersheds, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou, 510006, China; Guangdong Laboratory of Chemistry and Fine Chemical Engineering Jieyang Center, Jieyang, 515200, China
| |
Collapse
|
5
|
Wang Z, Li K, Gui X, Li Z. Acidovorax PSJ13, a novel, efficient polyacrylamide-degrading bacterium by cleaving the main carbon chain skeleton without the production of acrylamide. Biodegradation 2023; 34:581-595. [PMID: 37395852 DOI: 10.1007/s10532-023-10036-3] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/14/2023] [Accepted: 05/30/2023] [Indexed: 07/04/2023]
Abstract
Given the environmental challenge caused by the wide use of polyacrylamide (PAM), an environmental-friendly treatment method is required. This study demonstrates the role of Acidovorax sp. strain PSJ13 isolated from dewatered sludge in efficiently degrading PAM. To be specific, the strain PSJ13 can degrade 51.67% of PAM in 96 h (2.39 mg/(L h)) at 35 °C, pH 7.5 and 5% inoculation amount. Besides, scanning electron microscope, X-ray photoelectron spectroscopy, liquid chromatography-mass spectrometry and high-performance liquid chromatography were employed to analyze samples, and the nitrogen present in the degradation products was investigated. The results showed that the degradation of PAM by PSJ13 started from the side chain and then mainly the -C-C- main chain, which produced no acrylamide monomers. As the first study to report the role of Acidovorax in efficiently degrading PAM, this work may provide a solution for industries that require PAM management.
Collapse
Affiliation(s)
- Zhengjiang Wang
- Chongqing Key Lab of Soil Multi-Scale Interfacial Process, and College of Resources and Environment, Southwest University, Chongqing, 400716, China
| | - Kaili Li
- School of Chemical Engineering, The University of Queensland, Brisbane, QLD, 4067, Australia
| | - Xuwei Gui
- Chongqing Key Lab of Soil Multi-Scale Interfacial Process, and College of Resources and Environment, Southwest University, Chongqing, 400716, China
| | - Zhenlun Li
- Chongqing Key Lab of Soil Multi-Scale Interfacial Process, and College of Resources and Environment, Southwest University, Chongqing, 400716, China.
| |
Collapse
|
6
|
Zhang H, Shangguan M, Zhou C, Peng Z, An Z. Construction of a mycelium sphere using a Fusarium strain isolate and Chlorella sp. for polyacrylamide biodegradation and inorganic carbon fixation. Front Microbiol 2023; 14:1270658. [PMID: 37869678 PMCID: PMC10585063 DOI: 10.3389/fmicb.2023.1270658] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/01/2023] [Accepted: 09/12/2023] [Indexed: 10/24/2023] Open
Abstract
In the context of global demand for carbon reduction, the formation of inorganic carbon (IC) in the wastewater from oil flooding becomes a potential threat. In this study, Chlorella sp. and Fusarium sp. were used to assemble a fungal-algal pellet to degrade polyacrylamide (PAM) and fix IC in synthetic oil-flooding wastewater. The results showed that the combination of Chlorella sp. and Fusarium sp. was more effective at degrading PAM and removing carbon than a monoculture. With PAM as the sole nitrogen source, the degradation of PAM by the consortium was enhanced up to 35.17 ± 0.86% and 21.63 ± 2.23% compared with the monocultures of fungi or microalgae, respectively. The degradation of the consortium was significantly enhanced by the addition of an external nitrogen source by up to 27.17 ± 2.27% and 22.86 ± 2.4% compared with the monoculture of fungi or microalgae, respectively. This may depend on the effect of synergy between the two species. For the removal of IC from the water, the removal efficiency of the consortium was higher than that of the microalgae by 38.5 ± 0.08%, which may be attributed to the ability of the fungi to aid in the adsorption of nutrients and its assimilation by the microalgae. Therefore, the Fusarium-Chlorella consortium can effectively degrade PAM, while simultaneously fixing carbon, which provides a feasible scheme for the treatment and carbon neutralization of the wastewater that contains PAM.
Collapse
Affiliation(s)
- Huichao Zhang
- School of Civil Engineering, Yantai University, Yantai, China
| | - Mohan Shangguan
- School of Civil Engineering, Yantai University, Yantai, China
| | - Chang Zhou
- School of Civil Engineering, Yantai University, Yantai, China
| | - Zhaoyang Peng
- The Architectural Design and Research Institute of HIT Co., Ltd., Harbin, China
| | - Zhongyi An
- School of Civil Engineering, Yantai University, Yantai, China
| |
Collapse
|
7
|
Wei D, Zhang X, Li C, Ma Z, Zhao M, Wei L. Efficiency and microbial community characteristics of strong alkali ASP flooding produced water treated by composite biofilm system. Front Microbiol 2023; 14:1166907. [PMID: 37303803 PMCID: PMC10247963 DOI: 10.3389/fmicb.2023.1166907] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/15/2023] [Accepted: 05/05/2023] [Indexed: 06/13/2023] Open
Abstract
Strong alkali alkali-surfactant-polymer (ASP) flooding produced water is a by-product of oil recovery, and it is a stable system composed of petroleum, polyacrylamide, surfactant, and inorganic salts. Efficient, green, and safe ASP produced water treatment technology is essential for oilfield exploitation and environmental protection. In this study, an anaerobic/anoxic/moving bed biofilm reactor with a microfiltration membrane was established and assessed for the real strong alkali ASP flooding produced water (pH 10.1-10.4) treatment. The results show that the average removal rates of COD, petroleum, suspended solids, polymers and surfactants in this process are 57, 99, 66, 40, and 44%, respectively. GC-MS results show that most of the organic compounds such as alkanes and olefins in the strong alkali ASP produced water are degraded. Microfiltration membrane can significantly improve the efficiency and stability of sewage treatment system. Paracoccus (AN), Synergistaceae (ANO) and Trichococcus (MBBR) are the main microorganisms involved in the degradation of pollutants. This study reveals the potential and adaptability of composite biofilm system in treating the produced water of strong alkali ASP produced water.
Collapse
Affiliation(s)
- Dong Wei
- College of Life Science, Northeast Forestry University, Harbin, Heilongjiang, China
| | - Xinxin Zhang
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, Heilongjiang, China
- Guangzhou HKUST Fok Ying Tung Research Institute, Guangzhou, Guangdong, China
| | - Chunying Li
- School of Energy and Civil Engineering, Harbin University of Commerce, Harbin, Heilongjiang, China
| | - Zhongting Ma
- PetroChina Karamay Petrochemical Co., Ltd., Karamay, China
| | - Min Zhao
- College of Life Science, Northeast Forestry University, Harbin, Heilongjiang, China
| | - Li Wei
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, Heilongjiang, China
- Guangzhou HKUST Fok Ying Tung Research Institute, Guangzhou, Guangdong, China
| |
Collapse
|
8
|
Algonin A, Zhao B, Cui Y, Xie F, Yue X. Enhancement of iron-based nitrogen removal with an electric-magnetic field in an upflow microaerobic sludge reactor (UMSR). ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2023; 30:35054-35063. [PMID: 36525195 DOI: 10.1007/s11356-022-23836-6] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/26/2022] [Accepted: 10/21/2022] [Indexed: 06/17/2023]
Abstract
Traditional denitrification often produces high operating costs and excessive sludge disposal expenses due to conventional carbon sources. A novel electric-magnetic field (MF) 48 mT with Fe0 and C-Fe0 powder in an upflow microaerobic sludge reactor (UMSR) improved nitrogen removal from wastewater without organic carbon resources and gave richness to the heterotrophic bacterial community. In the current study, the reactor was operated for 78 ± 2 days, divided into five stages (without Fe0, with Fe0, coupling with MF, without coupling with MF, and coupling with MF again), at a hydraulic retention time (HRT) of 2.5 h, with an influent loading of ammonium (NH4+-N) 50 ± 2 mg/L, at 25-27 °C, and less than 1.0 mg/L dissolved oxygen (DO). The results demonstrated nitrogen removal efficiency enhanced after coupling with MF on the levels of NO3--N by 76% with an effluent concentration of 8.7 mg/L, NH4+-N by 72% with an effluent concentration of 13.6 mg/L, and total nitrogen removal (TN) by 76%, respectively. After coupling the MF with the reactor, the microbial community data analysis showed the dominant abundance of ammonia-oxidizing bacteria, heterotrophic nitrifying bacteria, and denitrifying bacteria on the level of Anaerolineaceae_uncultured 2%, which is capable of denitrification that uses Fe2+ as an electron source, Gemmatimonadaceae_uncultured 4%, Hydrogenophaga 4% which is capable of catalyzing hydrogenotrophic denitrification and correlating to nitrate removal, denitrification and desulfurization bacteria SBR1031_norank 18%, anammox-bacteria Saccharimonadales_norank 2%, and (AOM) Limnobacter 3% in the sludge.
Collapse
Affiliation(s)
- Abdulatti Algonin
- College of Environmental Science and Engineering, Taiyuan University of Technology, 79 Yingzexi Road, Taiyuan, 030024, Shanxi Province, People's Republic of China
| | - Bowei Zhao
- College of Environmental Science and Engineering, Taiyuan University of Technology, 79 Yingzexi Road, Taiyuan, 030024, Shanxi Province, People's Republic of China
| | - Ying Cui
- College of Environmental Science and Engineering, Taiyuan University of Technology, 79 Yingzexi Road, Taiyuan, 030024, Shanxi Province, People's Republic of China
| | - Fei Xie
- College of Environmental Science and Engineering, Taiyuan University of Technology, 79 Yingzexi Road, Taiyuan, 030024, Shanxi Province, People's Republic of China
| | - Xiuping Yue
- College of Environmental Science and Engineering, Taiyuan University of Technology, 79 Yingzexi Road, Taiyuan, 030024, Shanxi Province, People's Republic of China.
| |
Collapse
|
9
|
Huo Q, Li R, Chen C, Wang C, Long T, Liu X. Study on potential microbial community to the waste water treatment from bauxite desilication process. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2023; 30:15438-15453. [PMID: 36169826 DOI: 10.1007/s11356-022-23150-1] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/19/2022] [Accepted: 09/17/2022] [Indexed: 06/16/2023]
Abstract
Discharging waste water from the bauxite desilication process will bring potential environmental risk from the residual ions and organic compounds, especially hydrolyzed polyacrylamide. Characterization of the microbial community diversity in waste water plays an important role in the biological treatment of waste water. In this study, eight waste water samples from five flotation plants in China were investigated. The microbial community and functional profiles within the waste water were analyzed by a metagenomic sequencing method and associated with geochemical properties. The results revealed that Proteobacteria and Firmicutes were the dominant bacterial phyla. Both phylogenetical and clusters of orthologous groups' analyses indicated that Tepidicella, Paracoccus, Pseudomonas, and Exiguobacterium could be the dominant bacterial genera in the waste water from bauxite desilication process for their abilities to biodegrade complex organic compounds. The results of the microbial community diversity and functional gene compositions analyses provided a beneficial orientation for the biotreatment of waste water, as well as regenerative using of water resources. Besides, this study revealed that waste water from bauxite desilication process was an ideal ecosystem to find novel microorganisms, such as efficient strains for bio-desilication and bio-desulfurization of bauxite.
Collapse
Affiliation(s)
- Qiang Huo
- Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection (Guangxi Normal University), Ministry of Education, No. 1, Yanzhong Road, Guilin, 541006, China
- Guangxi Key Laboratory of Landscape Resources Conservation and Sustainable Utilization in Lijiang River Basin, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
- College of Environment and Resources, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
| | - Ruoyang Li
- Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection (Guangxi Normal University), Ministry of Education, No. 1, Yanzhong Road, Guilin, 541006, China
- College of Environment and Resources, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
| | - Chunqiang Chen
- Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection (Guangxi Normal University), Ministry of Education, No. 1, Yanzhong Road, Guilin, 541006, China
- Guangxi Key Laboratory of Landscape Resources Conservation and Sustainable Utilization in Lijiang River Basin, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
- College of Environment and Resources, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
| | - Chenquan Wang
- Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection (Guangxi Normal University), Ministry of Education, No. 1, Yanzhong Road, Guilin, 541006, China
- College of Environment and Resources, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
| | - Tengfa Long
- Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection (Guangxi Normal University), Ministry of Education, No. 1, Yanzhong Road, Guilin, 541006, China
- Guangxi Key Laboratory of Landscape Resources Conservation and Sustainable Utilization in Lijiang River Basin, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
- College of Environment and Resources, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China
| | - Xi Liu
- Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection (Guangxi Normal University), Ministry of Education, No. 1, Yanzhong Road, Guilin, 541006, China.
- Guangxi Key Laboratory of Landscape Resources Conservation and Sustainable Utilization in Lijiang River Basin, Guangxi Normal University, No. 1, Yanzhong Road, Guilin, 541006, China.
- School of Economics and Management, Guangxi Normal University, Guilin, 541006, China.
| |
Collapse
|
10
|
Yang G, Xu H, Luo Y, Hei S, Song G, Huang X. Novel electro-assisted micro-aerobic cathode biological technology induces oxidative demethylation of N, N-dimethylformamide for efficient ammonification of refractory membrane-making wastewater. JOURNAL OF HAZARDOUS MATERIALS 2023; 442:130001. [PMID: 36152543 DOI: 10.1016/j.jhazmat.2022.130001] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/27/2022] [Revised: 09/03/2022] [Accepted: 09/14/2022] [Indexed: 06/16/2023]
Abstract
Recalcitrant and toxicological membrane-making wastewater displays negative impacts on environment, and this is difficult to treat efficiently using conventional hydrolytic acidification. In this study, a novel electro-assisted biological reactor with micro-aerobic cathode (EABR-MAC) was developed to improve the biodegradation and ammonification of N, N-dimethylformamide (DMF) in membrane-making wastewater, and the metabolic mechanism using metagenomic sequencing as comprehensively illustrated. The results showed that EABR-MAC significantly improved the ammonification of refractory organonitrogen and promoted DMF oxidative degradation by driving the electron transferred to the cathode. Additionally, the inhibition rates of oxygen uptake rate and nitrification in EABR-MAC were both lower under different cathode aeration frequency conditions. Microbial community analysis indicated that the functional fermentation bacteria and exoelectrogens, which were correlated with COD removal, ammonification, and detoxification, were significantly enriched upon electrostimulation, and the positive biological connections increased to form highly connected communities instead of competition. The functional genes revealed that EABR-MAC forcefully intervened with the metabolic pathway, so that DMF converted to formamide and ammonia by oxidative demethylation and formamide hydrolysis. The results of this study provide a promising strategy for efficient conversion of organonitrogen into ammonia nitrogen, and offer a new insight into the effects of electrostimulation on microbial metabolism.
Collapse
Affiliation(s)
- Guang Yang
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
| | - Hui Xu
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
| | - Yudong Luo
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
| | - Shengqiang Hei
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
| | - Guangqing Song
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China; Technical Centre for Soil, Agriculture and Rural Ecology and Environment, Ministry of Ecology and Environment, Beijing 100012, China.
| | - Xia Huang
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China; Research and Application Center for Membrane Technology, School of Environment, Tsinghua University, Beijing 100084, China.
| |
Collapse
|
11
|
Treatment of polyacrylamide-containing wastewater by ionizing radiation: Efficient reduction of viscosity and degradation of polyacrylamide. Radiat Phys Chem Oxf Engl 1993 2023. [DOI: 10.1016/j.radphyschem.2022.110547] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
12
|
Al-Kindi S, Al-Bahry S, Al-Wahaibi Y, Taura U, Joshi S. Partially hydrolyzed polyacrylamide: enhanced oil recovery applications, oil-field produced water pollution, and possible solutions. ENVIRONMENTAL MONITORING AND ASSESSMENT 2022; 194:875. [PMID: 36227428 PMCID: PMC9558033 DOI: 10.1007/s10661-022-10569-9] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/31/2021] [Accepted: 03/19/2022] [Indexed: 05/27/2023]
Abstract
Polymers, such as partially hydrolyzed polyacrylamide (HPAM), are widely used in oil fields to enhance or improve the recovery of crude oil from the reservoirs. It works by increasing the viscosity of the injected water, thus improving its mobility and oil recovery. However, during such enhanced oil recovery (EOR) operations, it also produces a huge quantity of water alongside oil. Depending on the age and the stage of the oil reserve, the oil field produces ~ 7-10 times more water than oil. Such water contains various types of toxic components, such as traces of crude oil, heavy metals, and different types of chemicals (used during EOR operations such as HPAM). Thus, a huge quantity of HPAM containing produced water generated worldwide requires proper treatment and usage. The possible toxicity of HPAM is still ambiguous, but its natural decomposition product, acrylamide, threatens humans' health and ecological environments. Therefore, the main challenge is the removal or degradation of HPAM in an environmentally safe manner from the produced water before proper disposal. Several chemical and thermal techniques are employed for the removal of HPAM, but they are not so environmentally friendly and somewhat expensive. Among different types of treatments, biodegradation with the aid of individual or mixed microbes (as biofilms) is touted to be an efficient and environmentally friendly way to solve the problem without harmful side effects. Many researchers have explored and reported the potential of such bioremediation technology with a variable removal efficiency of HPAM from the oil field produced water, both in lab scale and field scale studies. The current review is in line with United Nations Sustainability Goals, related to water security-UNSDG 6. It highlights the scale of such HPAM-based EOR applications, the challenge of produced water treatment, current possible solutions, and future possibilities to reuse such treated water sources for other applications.
Collapse
Affiliation(s)
- Shatha Al-Kindi
- Department of Biology, College of Science, Sultan Qaboos University, Muscat, Oman
| | - Saif Al-Bahry
- Department of Biology, College of Science, Sultan Qaboos University, Muscat, Oman
- Oil & Gas Research Center, Sultan Qaboos University, Muscat, Oman
| | - Yahya Al-Wahaibi
- A'Sharqiyah University, Postal Code: 400, P.O. Box 42, Ibra, Oman
| | - Usman Taura
- Oil & Gas Research Center, Sultan Qaboos University, Muscat, Oman
| | - Sanket Joshi
- Oil & Gas Research Center, Sultan Qaboos University, Muscat, Oman.
| |
Collapse
|
13
|
Guo H, He T, Chang JS, Liu P, Lee DJ. Nitrogen removal from low C/N wastewater in a novel Sharon&DSR (denitrifying sulfide removal) reactor. BIORESOURCE TECHNOLOGY 2022; 362:127789. [PMID: 35985461 DOI: 10.1016/j.biortech.2022.127789] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/12/2022] [Revised: 08/10/2022] [Accepted: 08/11/2022] [Indexed: 06/15/2023]
Abstract
Denitrification reactions commonly remove nitrate and other reactive nitrogen (Nr) from wastewater. The C/N ratio indicates the sufficiency of organic carbons to drive heterotrophic denitrification; a low C/N ratio frequently leads to poor denitrification performance in wastewater treatment. This study proposed and tested a novel Sharon&DSR (denitrifying sulfide removal) process, with nitrite generated by the Sharon reactions and sulfide from sulfur-reducing reactions for promoting the following nitrite-based denitrification and denitrifying sulfide removal (DSR) process. The present reactor can remove nitrate at an efficiency of 97.7 %-93.5 % at an influent C/N ratio of 0.646-0.737 over a 96-d continuous-flow test. The microbial community study reveals the functional strains corresponding to individual groups of critical reactions. The stoichiometry analysis reveals the potential to apply the nitrite-based DSR process for Nr removal from ultra-low C/N (<0.64) wastewaters, experimentally demonstrated in the present study with a C/N ratio of 0.16-0.39.
Collapse
Affiliation(s)
- Hongliang Guo
- College of Forestry, Northeast Forestry University, Harbin 150040, China
| | - Tongyuan He
- College of Forestry, Northeast Forestry University, Harbin 150040, China
| | - Jo-Shu Chang
- Research Center for Smart Sustainable Circular Economy, Tunghai University, Taichung 407, Taiwan; Department of Chemical Engineering, National Cheng Kung University, Tainan, Taiwan; Department of Chemical and Materials Engineering, Tunghai University, Taichung 407, Taiwan
| | - Peng Liu
- College of Forestry, Northeast Forestry University, Harbin 150040, China
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tong, Hong Kong; Department of Chemical Engineering and Materials Science, Yuan Ze University, Chung-li 32003, Taiwan.
| |
Collapse
|
14
|
Song X, Lu G, Wang J, Zheng J, Sui S, Li Q, Zhang Y. Molecular Dynamics-Assisted Design of High Temperature-Resistant Polyacrylamide/Poloxamer Interpenetrating Network Hydrogels. MOLECULES (BASEL, SWITZERLAND) 2022; 27:molecules27165326. [PMID: 36014564 PMCID: PMC9414860 DOI: 10.3390/molecules27165326] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 07/15/2022] [Revised: 08/13/2022] [Accepted: 08/18/2022] [Indexed: 11/16/2022]
Abstract
Polyacrylamide has promising applications in a wide variety of fields. However, conventional polyacrylamide is prone to hydrolysis and thermal degradation under high temperature conditions, resulting in a decrease in solution viscosity with increasing temperature, which limits its practical effect. Herein, combining molecular dynamics and practical experiments, we explored a facile and fast mixing strategy to enhance the thermal stability of polyacrylamide by adding common poloxamers to form the interpenetrating network hydrogel. The blending model of three synthetic polyacrylamides (cationic, anionic, and nonionic) and poloxamers was first established, and then the interaction process between them was simulated by all-atom molecular dynamics. In the results, it was found that the hydrogen bonding between the amide groups on all polymers and the oxygen-containing groups (ether and hydroxyl groups) on poloxamers is very strong, which may be the key to improve the high temperature resistance of the hydrogel. Subsequent rheological tests also showed that poloxamers can indeed significantly improve the stability and viscosity of nonionic polyacrylamide containing only amide groups at high temperatures and can maintain a high viscosity of 3550 mPa·S at 80 °C. Transmission electron microscopy further showed that the nonionic polyacrylamide/poloxamer mixture further formed an interpenetrating network structure. In addition, the Fourier transform infrared test also proved the existence of strong hydrogen bonding between the two polymers. This work provides a useful idea for improving the properties of polyacrylamide, especially for the design of high temperature materials for physical blending.
Collapse
Affiliation(s)
- Xianwen Song
- State Key Laboratory of Shale Oil and Gas Enrichment Mechanism and Effective Development, Beijing 100083, China
- Research and Development Center for the Sustainable Development of Continental Sandstone Mature Oilfield by National Energy Administration, Beijing 100083, China
- Hunan Provincial Key Laboratory of Micro & Nano Materials Interface Science, College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China
| | - Gang Lu
- Research and Development Center for the Sustainable Development of Continental Sandstone Mature Oilfield by National Energy Administration, Beijing 100083, China
| | - Jingxing Wang
- Hunan Provincial Key Laboratory of Micro & Nano Materials Interface Science, College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China
| | - Jun Zheng
- Hunan Provincial Key Laboratory of Micro & Nano Materials Interface Science, College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China
| | - Shanying Sui
- Hunan Provincial Key Laboratory of Micro & Nano Materials Interface Science, College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China
| | - Qiang Li
- Hunan Provincial Key Laboratory of Micro & Nano Materials Interface Science, College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China
| | - Yi Zhang
- Hunan Provincial Key Laboratory of Micro & Nano Materials Interface Science, College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China
- Correspondence:
| |
Collapse
|
15
|
Zheng LL, Zhang J, Liu XZ, Tian L, Xiong ZS, Xiong X, Chen P, Wu DS, Zou JP. Degradation of pesticide wastewater with simultaneous resource recovery via ozonation coupled with anaerobic biochemical technology. CHEMOSPHERE 2022; 300:134520. [PMID: 35398067 DOI: 10.1016/j.chemosphere.2022.134520] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/21/2021] [Revised: 03/23/2022] [Accepted: 04/02/2022] [Indexed: 06/14/2023]
Abstract
The effective treatment of pesticide wastewater with high organic content, complex composition and high-toxicity has attracted enormous attention of researchers. This work proposes a new idea for removing the pesticide wastewater with simultaneous resource recovery, which is different from the traditional view of mineralization of pesticide wastewater via composite technology. This novel strategy involved a sequential three-step treatment: (a) acidic Ozonation process, to remove the venomous aromatic heterocyclic compounds; (b) hydrolysis and ozonation in alkaline conditions, enhancing the biodegradability of pesticide wastewater, mainly due to the dehalogenation, elimination of C=C bonds and production of low molecular-weight carboxylate anions; (c) the final step is anaerobic biological reactions. Based on the characterizations, this two-stage acidic-alkaline ozonation can efficiently degraded the virulence of pesticide wastewater and enhance its biodegradability from 0.08 to 0.32. The final anaerobic biochemical treatment can stably remove the residuals and convert the low molecular-weight organics into CH4, achieving the resource recovery. This work explored the pH-dependent of ozonized degradation of pesticide wastewater and gives a new perspective of wastewater treatment.
Collapse
Affiliation(s)
- Ling-Ling Zheng
- Key Laboratory of Poyang Lake Environment and Resource Utilization of Ministry of Education, School of Resources & Environment, Nanchang University, Nanchang, 330031, PR China; Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China
| | - Jun Zhang
- Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China
| | - Xiao-Zhen Liu
- Key Laboratory of Poyang Lake Environment and Resource Utilization of Ministry of Education, School of Resources & Environment, Nanchang University, Nanchang, 330031, PR China.
| | - Lei Tian
- Key Laboratory of Poyang Lake Environment and Resource Utilization of Ministry of Education, School of Resources & Environment, Nanchang University, Nanchang, 330031, PR China; Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China
| | - Zhen-Sheng Xiong
- Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China
| | - Xin Xiong
- Key Laboratory of Poyang Lake Environment and Resource Utilization of Ministry of Education, School of Resources & Environment, Nanchang University, Nanchang, 330031, PR China; Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China
| | - Peng Chen
- Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China
| | - Dai-She Wu
- Key Laboratory of Poyang Lake Environment and Resource Utilization of Ministry of Education, School of Resources & Environment, Nanchang University, Nanchang, 330031, PR China
| | - Jian-Ping Zou
- Key Laboratory of Poyang Lake Environment and Resource Utilization of Ministry of Education, School of Resources & Environment, Nanchang University, Nanchang, 330031, PR China; Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, Nanchang Hangkong University, Nanchang, 330063, PR China.
| |
Collapse
|
16
|
Li E, Zheng L, Li Y, Fan L, Zhao S, Liu S. Investigation of the drag reduction of hydrolyzed polyacrylamide–xanthan gum composite solution in turbulent flow. ASIA-PAC J CHEM ENG 2022. [DOI: 10.1002/apj.2791] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
Affiliation(s)
- Entian Li
- Jiangsu Key Laboratory of Oil and Gas Storage and Transportation Technology Changzhou University Changzhou China
| | - Lehua Zheng
- Jiangsu Key Laboratory of Oil and Gas Storage and Transportation Technology Changzhou University Changzhou China
| | - Yingping Li
- Jiangsu Key Laboratory of Oil and Gas Storage and Transportation Technology Changzhou University Changzhou China
| | - Liutong Fan
- Sinopec Petroleum Engineering Zhongyuan Corporation Co., Ltd Zhengzhou China
| | - Shushi Zhao
- Jiangsu Key Laboratory of Oil and Gas Storage and Transportation Technology Changzhou University Changzhou China
| | - Songling Liu
- Jiangsu Key Laboratory of Oil and Gas Storage and Transportation Technology Changzhou University Changzhou China
| |
Collapse
|
17
|
Liu L, Lu Y, Yuan J, Zhu H, Huang S, Yang B, Xiong J, Feng Z. Effects of chloramphenicol on denitrification in single-chamber microbial fuel cell: comprehensive performance and bacterial community structure. Biochem Eng J 2022. [DOI: 10.1016/j.bej.2022.108429] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
|
18
|
Zheng X, Hou S, Amanze C, Zeng Z, Zeng W. Enhancing microbial fuel cell performance using anode modified with Fe 3O 4 nanoparticles. Bioprocess Biosyst Eng 2022; 45:877-890. [PMID: 35166901 DOI: 10.1007/s00449-022-02705-z] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/03/2021] [Accepted: 02/03/2022] [Indexed: 11/25/2022]
Abstract
Low electricity generation efficiency is one of the key issues that must be addressed for the practical application of microbial fuel cells (MFCs). Modification of microbial electrode materials is an effective method to enhance electron transfer. In this study, magnetite (Fe3O4) nanoparticles synthesized by co-precipitation were added to anode chambers in different doses to explore its effect on the performance of MFCs. The maximum power density of the MFCs doped with 4.5 g/L Fe3O4 (391.11 ± 9.4 mW/m2) was significantly increased compared to that of the undoped MFCs (255.15 ± 24.8 mW/m2). The COD removal efficiency of the MFCs increased from 85.8 ± 2.8% to 95.0 ± 2.1%. Electrochemical impedance spectroscopy and cyclic voltammetry tests revealed that the addition of Fe3O4 nanoparticles enhanced the biocatalytic activity of the anode. High-throughput sequencing results indicated that 4.5 g/L Fe3O4 modified anodes enriched the exoelectrogen Geobacter (31.5%), while control MFCs had less Geobacter (17.4%). Magnetite is widely distributed worldwide, which provides an inexpensive means to improve the electrochemical performance of MFCs.
Collapse
Affiliation(s)
- Xiaoya Zheng
- School of Minerals Processing and Bioengineering, Central South University, Changsha, 410083, Hunan, China
- Key Laboratory of Biometallurgy of Ministry of Education, Central South University, Changsha, 410083, Hunan, China
| | - Shanshan Hou
- School of Minerals Processing and Bioengineering, Central South University, Changsha, 410083, Hunan, China
- Key Laboratory of Biometallurgy of Ministry of Education, Central South University, Changsha, 410083, Hunan, China
| | - Charles Amanze
- School of Minerals Processing and Bioengineering, Central South University, Changsha, 410083, Hunan, China
- Key Laboratory of Biometallurgy of Ministry of Education, Central South University, Changsha, 410083, Hunan, China
| | - Zichao Zeng
- School of Minerals Processing and Bioengineering, Central South University, Changsha, 410083, Hunan, China
| | - Weimin Zeng
- School of Minerals Processing and Bioengineering, Central South University, Changsha, 410083, Hunan, China.
- Key Laboratory of Biometallurgy of Ministry of Education, Central South University, Changsha, 410083, Hunan, China.
| |
Collapse
|
19
|
Braun O, Coquery C, Kieffer J, Blondel F, Favero C, Besset C, Mesnager J, Voelker F, Delorme C, Matioszek D. Spotlight on the Life Cycle of Acrylamide-Based Polymers Supporting Reductions in Environmental Footprint: Review and Recent Advances. Molecules 2021; 27:42. [PMID: 35011281 PMCID: PMC8746853 DOI: 10.3390/molecules27010042] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/26/2021] [Revised: 12/16/2021] [Accepted: 12/20/2021] [Indexed: 11/18/2022] Open
Abstract
Humankind is facing a climate and energy crisis which demands global and prompt actions to minimize the negative impacts on the environment and on the lives of millions of people. Among all the disciplines which have an important role to play, chemistry has a chance to rethink the way molecules are made and find innovations to decrease the overall anthropic footprint on the environment. In this paper, we will provide a review of the existing knowledge but also recent advances on the manufacturing and end uses of acrylamide-based polymers following the "green chemistry" concept and 100 years after the revolutionary publication of Staudinger on macromolecules. After a review of raw material sourcing options (fossil derivatives vs. biobased), we will discuss the improvements in monomer manufacturing followed by a second part dealing with polymer manufacturing processes and the paths followed to reduce energy consumption and CO2 emissions. In the following section, we will see how the polyacrylamides help reduce the environmental footprint of end users in various fields such as agriculture or wastewater treatment and discuss in more detail the fate of these molecules in the environment by looking at the existing literature, the regulations in place and the procedures used to assess the overall biodegradability. In the last section, we will review macromolecular engineering principles which could help enhance the degradability of said polymers when they reach the end of their life cycle.
Collapse
Affiliation(s)
| | | | | | | | | | | | | | | | | | - Dimitri Matioszek
- SNF SA, ZAC de Milieux, 42160 Andrézieux-Bouthéon, France; (O.B.); (C.C.); (J.K.); (F.B.); (C.F.); (C.B.); (J.M.); (F.V.); (C.D.)
| |
Collapse
|
20
|
Cui L, Shen H, Kang P, Guo X, Li H, Wang Y, Wan J, Dagot C. Stability and nutrients removal performance of a Phanerochaete chrysosporium-based aerobic granular sludge process by step-feeding and multi A/O conditions. BIORESOURCE TECHNOLOGY 2021; 341:125839. [PMID: 34523562 DOI: 10.1016/j.biortech.2021.125839] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/05/2021] [Revised: 08/18/2021] [Accepted: 08/21/2021] [Indexed: 06/13/2023]
Abstract
A Phanerochaete chrysosporium-based aerobic granular sludge (PC-AGS) was developed by inoculating fungal mycelial pellets into a lab-scale aerobic granular sequencing batch reactor (AGSBR). A strategy using step-anaerobic feeding coupled with multi A/O conditions was adopted. The results showed that the removal efficiencies for total phosphorus (TP) and total inorganic nitrogen (TIN) were 94.56 ± 2.92% and 75.20 ± 7.74%, respectively, under relatively low aeration time. Compared with original AGS, the content of extracellular proteins for PC-AGS obviously increased from 18.61 to 41.44 mg/g MLSS by the end of phase I. Moreover, the mature granules had a larger size and better stability during the 100 days operation. Furthermore, the analysis of microbial diversity detected many key functional groups in PC-AGS granules that were beneficial to nutrients removal. This work demonstrated that the addition of fungal pellets not only enhanced the removal performance, but also improved the stability of the AGS system.
Collapse
Affiliation(s)
- Lihui Cui
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China
| | - Hao Shen
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China
| | - Pengfei Kang
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China
| | - Xiaoying Guo
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China; Henan International Joint Laboratory of Environment and Resources, Zhengzhou University, Zhengzhou 450001, PR China
| | - Haisong Li
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China; Henan International Joint Laboratory of Environment and Resources, Zhengzhou University, Zhengzhou 450001, PR China
| | - Yan Wang
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China; Henan International Joint Laboratory of Environment and Resources, Zhengzhou University, Zhengzhou 450001, PR China
| | - Junfeng Wan
- School of Ecology and Environment, Zhengzhou University, Zhengzhou 450001, PR China; GRESE EA 4330, Université de Limoges, 123 avenue Albert Thomas, F-87060 Limoges Cedex, France.
| | - Christophe Dagot
- GRESE EA 4330, Université de Limoges, 123 avenue Albert Thomas, F-87060 Limoges Cedex, France; INSERM, U1092, Limoges, France
| |
Collapse
|
21
|
Zhang X, Wei D, Li C, Wei L, Zhao M. Effectiveness of sodium sulfite as an electron acceptor for bioenhanced treatment of salt-containing water produced from ASP flooding. CHEMOSPHERE 2021; 282:131002. [PMID: 34118632 DOI: 10.1016/j.chemosphere.2021.131002] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/30/2021] [Revised: 05/19/2021] [Accepted: 05/24/2021] [Indexed: 06/12/2023]
Abstract
The wastewater produced from alkaline-surfactant-polymer (ASP) flooding is a complex multiphase mixture that contains oil, polymers, surfactants and other pollutants and is thus a salt-containing industrial waste recalcitrant to treatments. Through laboratory tests, this study assessed the effectiveness of using sodium sulfite as an electron acceptor for a modified anaerobic baffled reactor (ABR) for removing oil, suspended solids, polymers and surfactants from salt-containing wastewater produced from ASP flooding. During the 90-day operation, the method established in this study successively removed 52.8%, 98.6%, 77.0%, 21.2% and 21.5% of the chemical oxygen demand (COD), oil, suspended solids, polymers and surfactants, respectively, from the wastewater. The changes in organic compounds in the reactor during the treatment were monitored through gas chromatography-mass spectrometry (GC-MS), and the results showed that the established method was very effective in removing alkanes, alkenes, cycloalkanes, aromatic hydrocarbons and esters, and the organic macromolecules in the wastewater were degraded to small molecules. The main bacterial species and microbial communities in the reactor were characterized using molecular biological techniques, and the results indicated that under the stress of high pH and salts, Halomonas sp. gradually dominated and played a major role in degrading hydrocarbons. The findings of this study can aid the development of a cost-effective biological system to treat the water produced from ASP flooding.
Collapse
Affiliation(s)
- Xinxin Zhang
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China; Guangzhou HKUST Fok Ying Tung Research Institute, Guang zhou, 511458, China
| | - Dong Wei
- College of Life Sciences, Northeast Forestry University, Harbin, 150040, China
| | - Chunying Li
- School of Energy and Civil Engineering, Harbin University of Commerce, Harbin, 150028, China
| | - Li Wei
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China; Guangzhou HKUST Fok Ying Tung Research Institute, Guang zhou, 511458, China.
| | - Min Zhao
- College of Life Science, Northeast Forestry University, No. 26, Hexing Road, Harbin, 150040, China.
| |
Collapse
|
22
|
Li P, Li K, Xu P, Liu X, Pu Y. Treatment of wastewater with high carbon-to-nitrogen ratio using a waterfall aeration biofilm reactor combined with sequencing batch reactor: Microbial community structure and metabolism analysis. BIORESOURCE TECHNOLOGY 2021; 337:125450. [PMID: 34192637 DOI: 10.1016/j.biortech.2021.125450] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/28/2021] [Revised: 06/16/2021] [Accepted: 06/19/2021] [Indexed: 06/13/2023]
Abstract
A low-cost and high-efficiency waterfall aeration biofilm reactor (WABR) combined with a sequencing batch reactor (SBR) was established to treat wastewater with a C/N ratio of 50. Three WABR-SBR systems with different fillers were used. In the stable operation phase, the removal efficiency of chemical oxygen demand was R1 (approximately 99%), R2 (97-99%), and R3 (96-99%); the effluent concentration of NH4+-N was 0.5 mg/L without nitrite or nitrate accumulation. High-throughput 16S rRNA sequencing revealed that the dominant phyla in the microbial community structure were Proteobacteria, Bacteroidetes, and Planctomycetes. Quantitative PCR was used to quantify the nitrification and denitrification gene expressions (Nitrobacter, nirS, and nirK) to evaluate the simultaneous nitrification and denitrification processes. Both anammox and denitrifying bacteria were abundant. Metagenomic annotation of genes that revealed the metabolic pathways of carbohydrates, amino acids, and the two dominant enzymes (GH and GT) provide valuable information for microbial ecology analysis.
Collapse
Affiliation(s)
- Peijun Li
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, China
| | - Kai Li
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, China
| | - Pan Xu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, China
| | - Xianchang Liu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, China
| | - Yuewu Pu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, China.
| |
Collapse
|