1
|
Tsertou E, Caluwé M, Goettert D, Goossens K, Seguel Suazo K, Vanherck C, Dries J. Impact of low and high temperatures on aerobic granular sludge treatment of industrial wastewater. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2024; 89:548-561. [PMID: 38358488 PMCID: wst_2024_024 DOI: 10.2166/wst.2024.024] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/16/2024]
Abstract
The goal of this study was to unravel the impact of high and low temperatures (T) on glycogen-accumulating microorganisms (GAOs) which were stimulated in an aerobic granular sludge plant fed with industrial wastewater, which is derived from the cleaning of trucks transporting chocolate and beer. Among GAOs, Candidatus Competibacter (Ca. Competibacter) was the most abundant. The long-term impact on (1) anaerobic dissolved organic carbon (DOC) uptake, (2) sludge morphology, and (3) microbial community composition was investigated. In addition, the short-term impact of T changes on the anaerobic uptake rate was evaluated. High T (above 38 °C) and low T (below 11 °C) had a negative impact on the relative read abundance of Ca. Competibacter and the anaerobic DOC uptake. Nevertheless, the carbon removal efficiency and the settleability of the biomass were not affected. Denitrifiers such as Thauera and Zoogloea were promoted over Ca. Competibacter under high T and low T, respectively, indicating their positive contribution to granulation maintenance.
Collapse
Affiliation(s)
- Eirini Tsertou
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium E-mail:
| | - Michel Caluwé
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium
| | - Dorothee Goettert
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium
| | - Koen Goossens
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium
| | - Karina Seguel Suazo
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium
| | - Catharina Vanherck
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium
| | - Jan Dries
- Research Group BioWAVE, Biochemical Wastewater Valorization & Engineering, Faculty of Applied Engineering, University of Antwerp, Campus Groenenborger, Groenenborgerlaan 171-2020, Antwerp, Belgium
| |
Collapse
|
2
|
Liu S, Zhou M, Daigger GT, Huang J, Song G. Granule formation mechanism, key influencing factors, and resource recycling in aerobic granular sludge (AGS) wastewater treatment: A review. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 338:117771. [PMID: 37004484 DOI: 10.1016/j.jenvman.2023.117771] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/02/2023] [Revised: 03/14/2023] [Accepted: 03/18/2023] [Indexed: 06/19/2023]
Abstract
The high-efficiency and additionally economic benefits generated from aerobic granular sludge (AGS) wastewater treatment have led to its increasing popularity among academics and industrial players. The AGS process can recycle high value-added biomaterials including extracellular polymeric substances (EPS), sodium alginate-like external polymer (ALE), polyhydroxyfatty acid (PHA), and phosphorus (P), etc., which can serve various fields including agriculture, construction, and chemical while removing pollutants from wastewaters. The effects of various key operation parameters on formation and structural stability of AGS are comprehensively summarized. The degradable metabolism of typical pollutants and corresponding microbial diversity and succession in the AGS wastewater treatment system are also discussed, especially with a focus on emerging contaminants removal. In addition, recent attempts for potentially effective production of high value-added biomaterials from AGS are proposed, particularly concerning improving the yield, quality, and application of these biomaterials. This review aims to provide a reference for in-depth research on the AGS process, suggesting a new alternative for wastewater treatment recycling.
Collapse
Affiliation(s)
- Shuli Liu
- School of Environmental and Municipal Engineering, North China University of Water Resources and Electric Power, Zhengzhou, 450000, China; Zhongzhou Water Holding Co., Ltd., Zhengzhou, 450046, China; Civil and Environmental Engineering, University of Michigan, 2350 Hayward St, G.G. Brown Building, Ann Arbor, MI, 48109, USA.
| | - Miao Zhou
- School of Environmental and Municipal Engineering, North China University of Water Resources and Electric Power, Zhengzhou, 450000, China.
| | - Glen T Daigger
- Civil and Environmental Engineering, University of Michigan, 2350 Hayward St, G.G. Brown Building, Ann Arbor, MI, 48109, USA.
| | - Jianping Huang
- School of Environmental and Municipal Engineering, North China University of Water Resources and Electric Power, Zhengzhou, 450000, China.
| | - Gangfu Song
- School of Environmental and Municipal Engineering, North China University of Water Resources and Electric Power, Zhengzhou, 450000, China; Zhongzhou Water Holding Co., Ltd., Zhengzhou, 450046, China.
| |
Collapse
|
3
|
Zahra SA, Purba LDA, Abdullah N, Yuzir A, Iwamoto K, Lei Z, Hermana J. Characteristics of algal-bacterial aerobic granular sludge treating real wastewater: Effects of algal inoculation and alginate-like exopolymers recovery. CHEMOSPHERE 2023; 329:138595. [PMID: 37023906 DOI: 10.1016/j.chemosphere.2023.138595] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/01/2022] [Revised: 03/16/2023] [Accepted: 04/02/2023] [Indexed: 05/03/2023]
Abstract
Limited information is available on the characteristics of algal-bacterial aerobic granular sludge (AGS) treating real wastewater, especially on its alginate-like exopolymers (ALE) production. In addition, the effect of target microalgae species inoculation on the system performance has not been fully understood. This study aimed to reveal the effect of microalgae inoculation on the characteristics of algal-bacterial AGS and its ALE production potential. Two photo-sequencing batch reactors (PSBR) were employed, namely R1 with activated sludge and R2 with Tetradesmus sp. and activated sludge being inoculated, respectively. Both reactors were fed with locally sourced municipal wastewater and operated for 90 days. Algal-bacterial AGS were successfully cultivated in both reactors. No significant difference was observed between the performances of R1 and R2, reflecting that the inoculation of target microalgae species may not be crucial for the development of algal-bacterial AGS when treating real wastewater. Both reactors achieved an ALE yield of about 70 mg/g of volatile suspended solids (VSS), indicating that a substantial amount of biopolymer can be recovered from wastewater. Interestingly, boron was detected in all the ALE samples, which might contribute to granulation and interspecies quorum sensing. The enrichment of lipids content in ALE from algal-bacterial AGS treating real wastewater reveals its high resource recovery potential. Overall, the algal-bacterial AGS system is a promising biotechnology for simultaneous municipal wastewater treatment and resource (like ALE) recovery.
Collapse
Affiliation(s)
- Sasmitha Aulia Zahra
- Department of Chemical and Environmental Engineering, Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Laila Dina Amalia Purba
- Department of Chemical and Environmental Engineering, Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Norhayati Abdullah
- Department of Chemical and Environmental Engineering, Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia; UTM International, Aras 8, Menara Razak, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia.
| | - Ali Yuzir
- Department of Chemical and Environmental Engineering, Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Koji Iwamoto
- Department of Chemical and Environmental Engineering, Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Zhongfang Lei
- Faculty of Life and Environmental Sciences, University of Tsukuba, Ibaraki, 305-8572, Japan
| | - Joni Hermana
- Department of Environmental Engineering, Faculty of Civil, Planning and Geoengineering, Institut Teknologi Sepuluh Nopember, Surabaya, 60111, Indonesia
| |
Collapse
|
4
|
Alves OIM, Araújo JM, Silva PMJ, Magnus BS, Gavazza S, Florencio L, Kato MT. Formation and stability of aerobic granular sludge in a sequential batch reactor for the simultaneous removal of organic matter and nutrients from low-strength domestic wastewater. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 843:156988. [PMID: 35772566 DOI: 10.1016/j.scitotenv.2022.156988] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/16/2022] [Revised: 06/13/2022] [Accepted: 06/22/2022] [Indexed: 06/15/2023]
Abstract
Simultaneous removal of organic matter, nitrogen, and phosphorus, via simultaneous nitrification and denitrification (SND) and enhanced biological phosphorus removal processes, was evaluated in a pilot-scale sequential batch reactor. The focus was on granule's morphology, stability, microbiological composition, and reactor performance while treating diluted domestic wastewater with total chemical oxygen demand (CODt) of ≈ 200 mg.L-1. The applied organic loading rate was 0.9 ± 0.3 kg CODt.m-3.d-1 in the experiment. Aerobic granular sludge developed gradually. After 87-day operation, granules (diameter ≥ 0.2 mm) were ≥ 50 % of the biomass, and after 168 days, complete granulation was obtained (≥ 80 % of biomass). In the third period (days 168-247, complete granulation), mixed liquor biomass reached a volatile suspended solids (VSS) concentration of 1.2 ± 0.3 g VSS.L-1, with the granules remaining stable until the experimental end. In this period, low effluent concentrations of COD, nitrogen (NH4+-N, NO2--N and NO3--N) and phosphate (PO43-P) were obtained (mg.L-1): 36 ± 11; 4 ± 5; 3 ± 3, 4 ± 5; and 0.9 ± 0.4, respectively. COD, NH4+-N, and PO43--P removal efficiencies (%) were 80 ± 11; 83 ± 20; and 55 ± 24, respectively. Heterotrophic nitrification and SND were observed, resulting in a process efficiency of 31 % even with dissolved oxygen applied to saturation. The phosphate removal was mainly attributed to denitrifying phosphorus accumulating organisms. Pseudomonas, the dominant genus found, acted in nitrogen and phosphorus removal. Pseudoxanthomonas also assisted in phosphorus removal. Bacterial communities in the flocs (≈ 20 % of biomass) during the last period were similar to those in the granules; therefore, they constituted the basis for granule formation, directly contributed to the simultaneous good removal of organic matter and nutrients.
Collapse
Affiliation(s)
- Oucilane I M Alves
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil
| | - Julliana M Araújo
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil; Federal Institute of Education, Science and Technology of Sertão Pernambucano, Campus Ouricuri, Estrada do Tamboril s/n, Zona Rural, Ouricuri, Pernambuco, Brazil
| | - Poliana M J Silva
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil
| | - Bruna S Magnus
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil.
| | - Sávia Gavazza
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil.
| | - Lourdinha Florencio
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil.
| | - Mario T Kato
- Department of Civil and Environmental Engineering, Federal University of Pernambuco, Recife, Pernambuco, Brazil.
| |
Collapse
|