Effect of ozone on microbial, chemical and sensory attributes of shucked mussels

The potential use of ozone as antifungal and antiaflatoxigenic agent in nuts and its effect on nutritional quality

Abstract Ozone gas is considered as a safe antimicrobial agent in food industries. Here, we evaluated the antifungal and antiaflatoxigenic activities of ozone against fungal contamination in nuts. The most predominant fungal genera in nuts were Aspergillus, Penicillium, Fusarium, and Rhizopus. Ozone (4 ppm) significantly reduced the fungal sporulation of A. flavus and their aflatoxin production. Interestingly, ozone treatment of nuts reduced the total fungal count and increased aflatoxins degradation by approximately 95% and 85%, respectively. Ozone displayed high efficiency to increase the permeability of cell membrane and injury of cell wall of fungi. Increasing the exposure time of ozone in nuts up to 180 minutes showed to reduce the total lipid, carbohydrates, and protein by around 41.2%, 42.7% and 38.4% respectively, in pistachio, almond and peanuts. In conclusion, ozonation is a suitable decontaminating approach for reducing the microbial load in nuts, when used with suitable exposure time.

Strategies to improve the postharvest management of flat oyster (Ostrea edulis) from aquaculture using the short-term storage and package in an innovative closed-circuit system

This study aimed to improve postharvest management of flat oysters reared in a longline system in the mid Adriatic Sea, using short-term storage and package in an innovative closed-circuit system. For the trial, 870 oysters were employed, divided into three experimental groups (A, B, and C), N = 270 oysters each group, whereas the remaining 60 oysters were used for the 2 controls. Each group differed in relation to the time spent in the depuration tank and the time of packaging: group A was packed and immediately transferred to the cell; group B was depurated in a tank for 48 h, then packed and transferred to the cell; group C was depurated in a tank for 48 h and then packed, depurated for another 24 h and transferred to a cell. Samples of each group were sampled at different times of permanence in cell (t0) up until 12 days (t12) for biomorphometric, sensorial, nutritional, and microbiological analysis. Although the nutritional and sensorial quality of the oysters was more pronounced in group A, B and C groups also showed good results. In these two groups, thanks to the use of the modern water recirculation system the quality and safety of oysters was improved by reducing the presence of sludge and eliminating fecal contaminants completely than A treatment and seawater control. These results were also confirmed by the tank control, where a more extended depuration period positively influenced the same parameters emphasizing the importance of the adequate depuration processes in oyster production.

Understanding the Effect of Ozone on Listeria monocytogenes and Resident Microbiota of Gorgonzola Cheese Surface: A Culturomic Approach

The occurrence of Listeria monocytogenes on Gorgonzola cheese surface was reported by many authors, with risks arising from the translocation of the pathogen inside the product during cutting procedures. Among the novel antimicrobial strategies, ozone may represent a useful tool against L. monocytogenes contamination on Gorgonzola cheese rind. In this study, the effect of gaseous ozone (2 and 4 ppm for 10 min) on L. monocytogenes and resident microbiota of Gorgonzola cheese rind stored at 4 °C for 63 days was evaluated. A culturomic approach, based on the use of six media and identification of colonies by MALDI-TOF MS, was used to analyse variations of resident populations. The decrease of L. monocytogenes was less pronounced in ozonised rinds with final loads of ~1 log CFU/g higher than controls. This behaviour coincided with a lower maximum population density of lactobacilli in treated samples at day 28. No significant differences were detected for the other microbial determinations and resident microbiota composition among treated and control samples. The dominant genera were Candida, Carnobacterium, Staphylococcus, Penicillium, Saccharomyces, Aerococcus, Yarrowia, and Enterococcus. Based on our results, ozone was ineffective against L. monocytogenes contamination on Gorgonzola rinds. The higher final L. monocytogenes loads in treated samples could be associated with a suppressive effect of ozone on lactobacilli, since these are antagonists of L. monocytogenes. Our outcomes suggest the potential use of culturomics to study the ecosystems of complex matrices, such as the surface of mould and blue-veined cheeses.

Effects of Individual and Block Freezing on the Quality of Pacific Oyster (Crassostrea gigas) during Storage under Different Pretreatment Conditions

In this study, a series of pretreatments, including ice-glazing, polyphosphate impregnated, and both ice-glazing and polyphosphate impregnated, were employed to pretreat shucked oysters in order to explore the optimal processing conditions for long-time storage. The effect of repeated freezing-thawing cycles on the quality of oysters was evaluated. Several quality indicators were used to investigate the effects of pretreatment. For the VBN (volatile salt-based nitrogen) value, the lowest value was 9.1 ± 0.2 of BPG (block oyster with polyphosphate impregnated and ice-glazing), which was significantly lower than 9.6 ± 0.2 of IPG (individual oyster with polyphosphate impregnated and ice-glazing). In terms of drip loss, there was no significant difference between the IPG (21.0 ± 0.2%) and the BPG (20.8 ± 0.2%). In addition, the highest WHC% (water holding capacity) was IPG (65.5 ± 0.5%) which was slightly lower than BPG (67.6 ± 0.6%). As compared to the experimental control, the IPG and BPG had the best appearance and color. In terms of TAPC (total aerobic plate count), with the increase of freezing storage time, each group showed a slight downward trend, but the difference was not statistically significant. After repeated freezing-thawing of block frozen oysters, there were significant differences in drip loss, WHC, and cooked taste with the increasing number of times, and there was a trend of deterioration (p < 0.05). Repeated freezing and thawing can seriously degrade the quality of oysters, so individual freezing (especially IPG) should be the most appropriate processing method.

Decontamination technologies for medicinal and aromatic plants: A review

Microbial quality assurance has always been an important subject in the production, trade, and consumption of medicinal and aromatic plants (MAPs). Most MAPs have therapeutic and nutritional properties due to the presence of active substances such as essential oils, flavonoids, alkaloids, etc. However, MAPs can become infected with microorganisms due to poor hygienic conditions during cultivation and postharvest processes. This problem reduces the shelf life and effective ingredients of the product. To overcome these problems, several technologies such as using ethylene oxide gas, gamma irradiation, and steam heating have been used. However, these technologies have disadvantages such as the formation of toxic by-products, low consumer acceptance, or may have a negative effect on the quality of MAPs. This requires a need for novel decontamination technology which can effectively reduce the biological contamination and minimize the food quality losses. In recent years, new technologies such as ozonation, cold plasma, ultraviolet, infrared, microwave, radiofrequency and combination of these technologies have been developed. In this review, biological contamination of MAPs and technologies used for their decontamination were studied. Also, the mechanism of inactivation of microorganisms and the efficacy of decontamination techniques on the qualitative and microbial characteristics of MAPs were investigated.

Ozonization of Water, Retention of Ozone and Devitalization of Escherichia Coli in Water By Ozone

The aim of this study was to observe the efficiency of ozone transferred by an airstone bubble diffuser, using two ozone generators with different output of ozone (5 g.h–1 ‒ G1; 15 g.h–1 ‒ G2). The retention of ozone in ozonised distilled and potable water and the devitalisation effects on E. coli in the water were also noted. Ozone was introduced to two types of potable water of different composition intended for mass consumption, (MC)a and (MC)b, distilled water, and well water intended for individual consumption. The devitalisation effect of ozone on E. coli in well water (WW) and added to potable and distilled water was observed. The results of our study showed that under the conditions used, the level of ozone during ozonisation with G1 increased more rapidly in distilled water and after termination of ozonisation, the retention of ozone in distilled water was a little lower in comparison with the potable water. The devitalisation of E. coli either naturally present in the water or added to it required the level of ozone close to or equal to 0.25 mg.l–1.

Validation of process technologies for enhancing the safety of low-moisture foods: A review

The outbreaks linked to foodborne illnesses in low-moisture foods are frequently reported due to the occurrence of pathogenic microorganisms such as Salmonella Spp. Bacillus cereus, Clostridium spp., Cronobacter sakazakii, Escherichia coli, and Staphylococcus aureus. The ability of the pathogens to withstand the dry conditions and to develop resistance to heat is regarded as the major concern for the food industry dealing with low-moisture foods. In this regard, the present review is aimed to discuss the importance and the use of novel thermal and nonthermal technologies such as radiofrequency, steam pasteurization, plasma, and gaseous technologies for decontamination of foodborne pathogens in low-moisture foods and their microbial inactivation mechanisms. The review also summarizes the various sources of contamination and the factors influencing the survival and thermal resistance of pathogenic microorganisms in low-moisture foods. The literature survey indicated that the nonthermal techniques such as CO₂ , high-pressure processing, and so on, may not offer effective microbial inactivation in low-moisture foods due to their insufficient moisture content. On the other hand, gases can penetrate deep inside the commodities and pores due to their higher diffusion properties and are regarded to have an advantage over thermal and other nonthermal processes. Further research is required to evaluate newer intervention strategies and combination treatments to enhance the microbial inactivation in low-moisture foods without significantly altering their organoleptic and nutritional quality.

Effects of different ozone treatments on the storage quality and stability of fresh peeled garlic

In order to understand their impacts on the preservation of fresh garlic, varying concentrations of ozone gas and different storage temperatures were tested for this experiment. The results demonstrated that freshly peeled garlic was best preserved by an ozone concentration of 5 ppm and storage at 4 °C compared to other treatment groups. With these optimized conditions, after 25 days of storage, the weight of garlic decreased by only 1.89% and, under the same storage conditions, the water loss rate was only 65.17% that of the control group, with a decay rate of only 12.50%. The rate of decay in the blank control group was three times that of this group. The germination rate was also low: only 30.26%, which was 57.69% that of the blank control group. The hardness was measured at 7.48 kg cm-2, 19.79% higher than that of the blank group. The content of soluble solids was 9.15 g 100 mL-1, which was 10.27% higher than that of the blank group, again proving that the above storage parameters were effective. At the same time, the titratable acid (TA) in the garlic was 15.48%, which was 1.17 times that of the blank group and corresponds to the vitamin C content. Also, the content of diallyl trisulfide only decreased by 3.98% and was 11.2% higher (P < 0.01) than that of the blank group. Finally, the validity of this optimal result was also confirmed by sensory evaluation. These results, for garlic, support the application of ozone as a safe, non-thermal preservation technique benefiting both producers and consumers.

Does the treatment of dried herbs with ozone as a fungal decontaminating agent affect the active constituents?

Herbs and spices are food crops susceptible to contamination by toxigenic fungi. Ozone, as a decontamination approach in the industry, has attractive benefits over traditional food preservation practices. A contribution to the studying of ozone as an antifungal and anti-mycotoxigenic agent in herbs and spices storage processes is achieved in this research. Nine powdered sun-dried herbs and spices were analyzed for their fungal contamination. The results indicate that licorice root and peppermint leaves were found to have the highest population of fungi while black cumin and fennel record the lowest population. The most dominant fungal genera are Aspergillus, Penicillium, Fusarium, and Rhizopus. Ozone treatment was performed at a concentration of 3 ppm applied for exposure times of 0, 30, 90, 150, 210, and 280 min. After 280 min of exposure to ozone, the reduction of fungal count ranged from 96.39 to 98.26%. The maximum reduction in spore production was achieved in the case of A. humicola and Trichderma viride exposed for 210 min ozone gas. There was a remarkable reduction in the production of the total mycotoxin, reaching 24.15% in aflatoxins for the 150 min-treated inoculum in the case of A. flavus. The total volume of essential oil of chamomile and peppermint was reduced by 57.14 and 26.67%, respectively, when exposed to 3 ppm. For 280 min. In conclusion, fumigation with ozone gas can be used as a suitable method for achieving sanitation and decreasing microbial load in herbs and spices. Still, it is crucial to provide precautions on ozone's effect on major active constituents before recommending this method for industrial application.

Innovative Seafood Preservation Technologies: Recent Developments

Fish and fishery products are among the food commodities of high commercial value, high-quality protein content, vitamins, minerals and unsaturated fatty acids, which are beneficial to health. However, seafood products are highly perishable and thus require proper processing to maintain their quality and safety. On the other hand, consumers, nowadays, demand fresh or fresh-like, minimally processed fishery products that do not alter their natural quality attributes. The present article reviews the results of studies published over the last 15 years in the literature on: (i) the main spoilage mechanisms of seafood including contamination with pathogens and (ii) innovative processing technologies applied for the preservation and shelf life extension of seafood products. These primarily include: high hydrostatic pressure, natural preservatives, ozonation, irradiation, pulse light technology and retort pouch processing.

Exploring the Potential of the Microbiome as a Marker of the Geographic Origin of Fresh Seafood

Geographic food fraud – misrepresenting the geographic origin of a food item, is very difficult to detect, and therefore this type of fraud tends to go undetected. This potentially negatively impacts the health of Canadians and economic success of our seafood industry. Surveillance studies have shown that up to a significant portion of commercially sold seafood items in Canada are mislabeled or otherwise misrepresented in some way. The current study aimed to determine if the microbiome of fresh shellfish could be used as an accurate marker of harvest location. Total DNA was extracted from the homogenate of 25 batches of fresh soft-shell clams (Mya arenaria) harvested in 2015 and 2018 from two locations on the East Coast of Canada and the microbiome of each homogenate was characterized using 16S rRNA targeted amplicon sequencing. Clams harvested from Nova Scotia in both years had a higher abundance of Proteobacteria and Acidobacteria (p < 0.05), but a lower abundance of Actinobacteria (p < 0.05) than those from Quebec. Alpha-diversity also differed significantly between sites. Samples harvested from Nova Scotia had greater diversity (p < 0.0001) than those from Quebec. Beta-diversity analysis showed that the microbial community composition was significantly different between the samples from Nova Scotia and Quebec and indicated that 16S rRNA targeted amplicon sequencing might be an effective tool for elucidating the geographic origin of unprocessed shellfish. To evaluate if the microbiome of shellfish experiences a loss of microbial diversity during processing and storage – which would limit the ability of this technique to link retail samples to geographic origin, 10 batches of retail clams purchased from grocery stores were also examined. Microbial diversity and species richness was significantly lower in retail clams, and heavily dominated by Proteobacteria, a typical spoilage organism for fresh seafood, this may make determining the geographic origin of seafood items more difficult in retail clams than in freshly harvested clams.

Functionalization of water as a nonthermal approach for ensuring safety and quality of meat and seafood products

Meat and seafood products present a viable medium for microbial propagation, which contributes to foodborne illnesses and quality losses. The development of novel and effective techniques for microbial decontamination is therefore vital to the food industry. Water presents a unique advantage for large-scale applications, which can be functionalized to inactivate microbial growth, ensuring the safety and quality of meat and seafood products. By taking into account the increased popularity of functionalized water utilization through electrolysis, ozonation and cold plasma technology, relevant literature regarding their applications in meat and seafood safety and quality are reviewed. In addition, the principles of generating functionalized water are presented, and the safety issues associated with their uses are also discussed.Functionalization of water is a promising approach for the microbiological safety and quality of meat and seafood products and possesses synergistic effects when combined with other decontamination approaches. However, functionalized water is often misused since the active antimicrobial component is applied at a much higher concentration, despite the availability of applicable regulations. Functionalized water also shows reduced antimicrobial efficiency and may produce disinfection by-products (DBPs) in the presence of organic matter, especially at a higher concentration of active microbial component. Utilization should be encouraged within regulated guidelines, especially as hurdle technology, while plasma functionalized water which emerges with great potentials should be exploited for future applications. It is hoped that this review should encourage the industry to adopt the functionalized water as an effective alternative technique for the food industry.

Ozone-Based Interventions To Improve the Microbiological Safety and Quality of Poultry Carcasses and Parts: A Review

HIGHLIGHTS

Ozone treatment achieved microbial population reductions. Gaseous ozone was most commonly used on poultry parts. Carcasses were treated exclusively with aqueous ozone or ozonated water. Ozone treatment can extend poultry product shelf life without significant quality effects.

Improved Microbial Safety of Direct Ozone-Depurated Shellstock Eastern Oysters (Crassostrea virginica) by Superchilled Storage

The effect of superchilled storage at -1°C on the microbial safety of oyster depurated with 0.2, 0.4, and 0.6 mg/L ozone was studied for 14 days. Fecal coliforms (4,100–16,000 MPN/100 g), Escherichia coli (1,500–3,650 MPN/100 g), Vibrio cholerae non-O1/non-O139 (13.0–102.0 MPN/g), and Salmonella spp. (2.270–3.035 × 10³ CFU/g) were initially present in raw oysters. After 6 h depuration, fecal coliform counts decreased (P < 0.05) to 300, 20 and 20 MPN/100 g for 0.2, 0.4, and 0.6 mg/L treatments, while a 0.3 log decrease in control oysters was observed. Initial E. coli counts decreased (P < 0.05) in oysters to 50, 20, and 20 MPN/100 g for 0.2, 0.4, and 0.6 mg/L treatments, respectively. A 1 log reduction in V. cholerae non-O1/non-139 levels were observed in 0.4 and 0.6 mg/L-treatments after 2 and 4 h depuration. Salmonella spp. was not detected in oyster samples after 6 h depuration in 0.4 and 0.6 mg/L-ozone treatments. Considering the bacterial loads after depuration, at the end of superchilled storage the 0.4 mg/L-ozonated oysters attained lower (P < 0.05) fecal coliform levels (280 MPN/100 g) and E. coli counts in 0.4 and 0.6 mg/L-ozonated oysters (20 and 95 MPN/100 g, respectively). A 2-log decrease in V. cholerae non-O1/non-O139 levels on day 5 in 0.4 and 0.6 mg/L-ozonated oysters (< 0.3 MPN/g) was attained. V. cholerae non-O1/non-O139 counts in control oysters decreased 1 log on day 9 of superchilled storage. Salmonella spp. was not detected in ozonated and superchilled stored oysters. Levels of fecal coliforms, E. coli, Salmonella spp., and V. cholerae non-O1/non-O139 in non-ozone depurated oyster samples were higher than in control, 0.4 and 0.6 mg/L ozonated oyster samples during superchilled storage. The cumulative mortality rates after 14 days of storage for superchilled oysters (22.2%) was higher (P < 0.05) than 0.6 mg/L O₃ (7.2%) and 0.4 mg/L O₃ (5.8%) treatments, and control oysters (5.6%). pH values in control oysters decreased significantly (P < 0.05) throughout the storage period but not in oysters of both ozone treatments, indicating no detrimental effects on oyster survival. The results of this study suggest that superchilled storage enables ozonated shellstock oysters (0.4 mg/L-6 h) stored for 9 days to be safe human consumption.

Inactivation of Escherichia coli O157:H7 by ozone in different substrates

Ozone has a broad antimicrobial spectrum and each microorganism species has inherent sensitivity to the gas. The objective of this study was to evaluate the effect of ozone gas on Escherichia coli O157:H7 inoculated on an organic substrate, and the efficacy of ozonated water in controlling the pathogen. For the first experiment, E. coli O157:H7 (ATCC® 43890™) was inoculated in milk with different compositions and in water, which was ozonated at concentrations of 35 and 45 mg L^-1 for 0, 5, 15, and 25 min. In the second experiment, water was ozonated at 45 mg L^-1 for 15 min. E. coli O157:H7 was exposed for 5 min to the ozonated water immediately after ozonation, and after storage for 0.5, 1.0, 1.5, 3.0, and 24 h at 8 °C. The results showed that the composition of the organic substrate interfered with the action of ozone on E. coli O157:H7. In lactose-free homogenized skim milk, reductions of 1.5 log cycles were obtained for ozonation periods of 25 min at the concentrations tested. Ozonated water was effective in inactivating of E. coli O157:H7 in all treatments. The efficiency of ozone on E. coli O157:H7 is influenced by the composition of the organic substrates, reinforcing the need for adequate removal of organic matter before sanitization. Furthermore, refrigerated ozonated water stored for up to 24 h is effective in the control of E. coli O157:H7.

Effects of different ozonized slurry-ice treatments and superchilling storage (-1°C) on microbial spoilage of two important pelagic fish species

Combining different preservative treatments for improving quality and safety of fishery products increasingly receives global research attention. Consistent with this pursuit, the current research was undertaken to determine the effects of different ozonized slurry-ice treatments and superchilling (-1°C) storage on microbial spoilage of European anchovy (Eugraulis encrasicolus) and sardine (Sardina pilchardus), which are two commercially important pelagic fish species. After the catch (within <5 hr) and at defined scheduled storage times, ozone has been discharged once on sardine (herein referred to as "One-T") and repeatedly/sequentially on European anchovy (herein referred to as "Seq-T"). Microbiological analyses enumerated total viable count (TVC), Bacillus spp., Enterobacteriaceae, Lactobacillus spp., Moraxella spp., Shewanella spp., Listeria monocytogenes and Pseudomonas spp. Independent of potential antimicrobial effects of ozone during superchilling storage, no Listeria spp., Shewanella spp., Moraxella spp., and Bacillus spp. were found in all processed samples. While Enterobacteriaceae and Lactobacillus spp. were detected at below 1 log cfu/g, both TVC and Pseudomonas spp. proliferated at different rates throughout superchilling storage. The repeated ozone-treated ("Seq-T") showed lower TVC and Pseudomonas spp. values compared with one-time treated ("One-T") slurry-iced and control samples. Thus, combined slurry-ice and superchilling storage at Seq-T produced improved antimicrobial activity over One-T application. Largely, ozonized slurry-ice outcomes/results appear promising thanks to superchilling storage.

Ozone in the food industry: Principles of ozone treatment, mechanisms of action, and applications: An overview

The food contamination issue requires continuous control of food at each step of the production process. High quality and safety of products are equally important factors in the food industry. They may be achieved with several, more or less technologically advanced methodologies. In this work, we review the role, contribution, importance, and impact of ozone as a decontaminating agent used to control and eliminate the presence of microorganisms in food products as well as to extend their shelf-life and remove undesirable odors. Several researchers have been focusing on the ozone's properties and applications, proving that ozone treatment technology can be applied to all types of foods, from fruits, vegetables, spices, meat, and seafood products to beverages. A compilation of those works, presented in this review, can be a useful tool for establishing appropriate ozone treatment conditions, and factors affecting the improved quality and safety of food products. A critical evaluation of the advantages and disadvantages of ozone in the context of its application in the food industry is presented as well.

Oxidation-reduction potential and lipid oxidation in ready-to-eat blue mussels in red sauce: criteria for package design

BACKGROUND

Ready-to-eat in-package pasteurized blue mussels in red sauce requires refrigerated storage or in combination with an aerobic environment to prevent the growth of anaerobes. A low barrier packaging may create an aerobic environment; however, it causes lipid oxidation in mussels. Thus, evaluation of the oxidation-reduction potential (Eh) (aerobic/anaerobic nature of food) and lipid oxidation is essential. Three packaging materials with oxygen transmission rate (OTR) of 62 (F-62), 40 (F-40) and 3 (F-3) cm³ m^-2 day^-1 were selected for this study. Lipid oxidation was measured by color changes in thiobarbituric acid reactive substances (TBARS) at 532 nm (TBARS@532) and 450 nm (TBARS@450).

RESULTS

Significantly higher (P < 0.05) TBARS@532 was found in mussels packaged in higher OTR film. TBARS@450 in mussels packaged with F-62 and F-40 gradually increased during refrigerated storage (3.5 ± 0.5 °C), but remained constant after 20 days of storage for mussels packaged with F-3. The Eh of pasteurized sauce was not significantly affected (P > 0.05) by OTR and remained negative (< -80 mV) during storage. Negative Eh values can support the growth of anaerobes such as Clostridium botulinum. The headspace oxygen concentration was reduced by about 50% from its initial value during pasteurization, and then further declined during storage. The headspace oxygen concentration was higher in trays packaged with higher OTR film.

CONCLUSION

Mussels packed with high OTR film showed higher lipid oxidation, indicating that high barrier film is required for packaging of mussels. Pasteurized mussels must be kept in refrigerated storage to prevent growth of anaerobic proteolytic C. botulinum spores under temperature abuse. © 2016 Society of Chemical Industry.

Combined effect of ozonation and packaging on shelf life extension of fresh chicken legs during storage under refrigeration

The aim of the present study was to investigate the effect of different ozone doses (2, 5, and 10 mg/L) on shelf life extension of fresh chicken legs, packaged in polyamide/poleyethylene bags and stored at 4 ± 1 °C, for a period of 12 days. Parameters taken into account were: microbiological (Total viable count, Pseudomonas spp., Lactic acid bacteria, Yeasts and molds, and Enterobacteriaceae), physicochemical (pH, colour) and sensory (odor, appearance, texture, and taste) attributes. Results showed that colour parameter values (L*, a*, and b*) were not affected by the gaseous ozone dose, whereas only L* and b* were reduced during storage in all samples. pH was reduced by storage time but was not affected by ozonation dose and packaging. Total viable count and Pseudomonas spp., increased statistically significant with ozonation dose and storage time, but were not affected by packaging. Yeasts, molds, Enterobacteriaceae, and Lactic acid bacteria, were decreased during storage, packaging and ozonation dose. Finally, sensory examination (appearance, texture, odor and taste) showed that samples treated with ozone concentration of 10 mg/L retained the original characteristic features of fresh chicken legs as compared to the control samples. The gaseous ozone treatment of 10 mg/L for 1 h, to chicken legs packaged in plastic containers of polyamide/polyethylene under refrigeration, is appropriate for maintaining freshness and quality of chicken, since their shelf life was extended by 4 days, as compared to the control samples.

Efficacy of Ozonation Treatments of Smoked Fish for Reducing Its Benzo[a]pyrene Concentration and Toxicity

Ozone is widely used in food processing, for example, to decompose mycotoxins or pesticide residues, to extend the shelf life of products, and for sanitation. The objective of this study was to assess the possibility of expanding the application of ozone for oxidative degradation of polycyclic aromatic hydrocarbons (PAHs). The evaluation was conducted by ozonation of a benzo[a]pyrene (BaP) standard solution and smoked fish (sprats) contaminated with PAHs. The effect of ozonation was immediate in the BaP solution; 89% of this toxic compound was decomposed after only 1 min of treatment. However, the impact of ozonation on the smoked sprats was less pronounced, even after prolonged treatment. The final reduction in benzo[b]fluoranthene and BaP concentrations in smoked sprats contaminated with PAHs was 34 and 46%, respectively, after 60 min of ozonation, but no significant decrease of benzo[a]anthracene and chrysene concentrations was observed. To evaluate the safety of ozonation, the toxicity of the ozone-treated BaP standard solution was investigated. In vitro toxicity was evaluated using human hepatocellular carcinoma and mouse embryonic fibroblast cell lines as models. The cytotoxicity of the BaP standard solution significantly increased after ozonation, indicating a pronounced negative effect in terms of food safety.

Emerging Seafood Preservation Techniques to Extend Freshness and Minimize Vibrio Contamination

Globally, the popularity of seafood consumption is increasing exponentially. To meet the demands of a growing market, the seafood industry has increasingly been innovating ways to keep their products fresh and safe while increasing production. Marine environments harbor several species of indigenous microorganisms, some of which, including Vibrio spp., may be harmful to humans, and all of which are part of the natural microbiota of the seafood. After harvest, seafood products are often shipped over large geographic distances, sometimes for prolonged periods, during which the food must stay fresh and pathogen proliferation must be minimized. Upon arrival there is often a strong desire, arising from both culinary and nutritional considerations, to consume seafood products raw, or minimally cooked. This supply chain along with popular preferences have increased challenges for the seafood industry. This has resulted in a desire to develop methodologies that reduce pathogenic and spoilage organisms in seafood items to comply with regulations and result in minimal changes to the taste, texture, and nutritional content of the final product. This mini-review discusses and compares several emerging technologies, such as treatment with plant derived natural compounds, phage lysis, high-pressure processing, and irradiation for their ability to control pathogenic vibrios, limit the growth of spoilage organisms, and keep the desired organoleptic properties of the seafood product intact.

Effects of storage, processing and proteolytic digestion on microcystin-LR concentration in edible clams

Accumulation of microcystin-LR (MC-LR) in edible aquatic organisms, particularly in bivalves, is widely documented. In this study, the effects of food storage and processing conditions on the free MC-LR concentration in clams (Corbicula fluminea) fed MC-LR-producing Microcystisaeruginosa (1×10(5) cell/mL) for four days, and the bioaccessibility of MC-LR after in vitro proteolytic digestion were investigated. The concentration of free MC-LR in clams decreased sequentially over the time with unrefrigerated and refrigerated storage and increased with freezing storage. Overall, cooking for short periods of time resulted in a significantly higher concentration (P<0.05) of free MC-LR in clams, specifically microwave (MW) radiation treatment for 0.5 (57.5%) and 1 min (59%) and boiling treatment for 5 (163.4%) and 15 min (213.4%). The bioaccessibility of MC-LR after proteolytic digestion was reduced to 83%, potentially because of MC-LR degradation by pancreatic enzymes. Our results suggest that risk assessment based on direct comparison between MC-LR concentrations determined in raw food products and the tolerable daily intake (TDI) value set for the MC-LR might not be representative of true human exposure.

Characterisation of the spoilage bacterial microbiota in oyster gills during storage at different temperatures

BACKGROUND

The spoilage bacterial community in oyster gill was investigated during storage at 4, 10 and 20 °C. Aerobic plate counts and pH values were determined. Total bacterial DNA was extracted from oyster gill and bulk cells of plate count media. The major bacterial species during fresh or different temperatures storage were determined by polymerase chain reaction-denaturing gradient gel electrophoresis (PCR-DGGE).

RESULTS

The initial aerobic plate count in oyster gill reached 6.70 log CFU g(-1). PCR-DGGE fingerprinting analysis of the 16S rRNA gene V3 region revealed that most of the strains in fresh oyster gill belonged to the genera Lactococcus and Enterobacter. The major spoilage bacteria at a storage temperature of 20 °C were Leuconostoc pseudomesenteroides, an uncultured bacterium, Cytophaga fermentans, Lactococcus lactis, Pseudoalteromonas sp., Enterococcus mundtii, Clostridium difficile and an uncultured Fusobacteria; those at 10 °C were Lactococcus spp., Lactobacillus curvatus, Weissella confusa and C. difficile; those at 4 °C were Lactococcus, Weissella, Enterobacter and Aeromonas. The other minor species were L. curvatus, Pseudomonas sp. and E. mundtii. Lactococcus spp. was the most common main spoilage bacteria in oyster gill during chilled storage.

CONCLUSION

PCR-DGGE revealed the complexity of the bacterial microbiota and the major bacteria species in oyster gill for fresh and storage.

Comparison of ozone and chlorine in low concentrations as sanitizing agents of chicken carcasses in the water immersion chiller

The aim of this study was to investigate the effects of the use of chlorine or ozone as sanitizing agents in the water of chicken immersion chilling, using the residual levels usually applied in Brazil (1.5 ppm), comparing the effects of these treatments on the microbiological, physicochemical, and sensory characteristics of carcasses. Chicken carcasses were chilled in water (4°C) with similar residual levels of ozone and chlorine until reaching temperatures below 7°C (around 45 min). The stability of carcasses was assessed during 15 days of storage at 2 ± 1°C. Microbiological, surface color (L*, a*, b* parameters), pH value, lipid oxidation (thiobarbituric acid reactive substances index), and sensory evaluation (on a 9-point hedonic scale for odor and appearance) analyses were carried out. The presence of Salmonella was not detected, coagulase-positive staphylococci counts were below 10(2) CFU/ml of rinse fluid, and Escherichia coli and total coliform counts were below 10(5) CFU/ml of rinse fluid until the end of the storage period for both treatments. Psychrotrophic microorganism counts did not differ (P > 0.05) between chlorine and ozone treatments, and both values were near 10(9) CFU/ml of rinse fluid after 15 days at 4 ± 1°C. pH values did not differ between treatments (P > 0.05) or during the storage period (P > 0.05). In addition, neither chlorine nor ozone treatment showed differences (P > 0.05) in the lipid oxidation of carcasses; however, the thiobarbituric acid reactive substances index of both treatments increased (P ≤ 0.05) during the storage period, reaching values of approximately 0.68 mg of malonaldehyde per kg. Samples from both treatments did not differ (P > 0.05) in their acceptance scores for odor and overall appearance, but in the evaluation of color, ozone showed an acceptance score significantly higher (P ≤ 0.05) than that for the chlorine treatment. In general, under the conditions tested, ozone showed results similar to the results for chlorine in the disinfection of chicken carcasses in the immersion chilling, which may indicate its use as a substitute for chlorine in poultry slaughterhouses.

Effect of ozonation and γ-irradiation on post-harvest decontamination of mussels (Mytillus galloprovincialis) containing diarrhetic shellfish toxins

Contamination of shellfish with diarrhetic shellfish poisoning (DSP) toxins readily occurs during algal blooms. Such phenomena raise important public health concerns and thus comprise a constant challenge to shellfish farmers, the seafood industry and health services, considering the increasing occurrence of toxic episodes around the world. To avoid the detrimental effects of such episodes, research has focused on the use of various detoxification methodologies that should be rapid, efficient, easy to apply, and will not alter the quality and sensory properties of shellfish. In the present study, both ozonation (15 mg kg(-1) for 6 h) and γ-irradiation (6 kGy) were utilised in order to reduce the toxin content of contaminated shucked mussels, collected during the DSP episodes of 2007 and 2009 in Greece. DSP toxicity was monitored using the mouse bioassay (MBA) whilst the determination of toxin content of the okadaic acid (OA) group (both free and esterified forms) was carried out by LC/MS/MS analysis. Toxin reduction using γ-irradiation was in the range of 12-36%, 8-53% and 10-41% for free OA, OA esters and total OA, respectively. The appearance and texture of irradiated mussels deteriorated, pointing to a low potential for commercial use of this method. Ozonation of mussels resulted in toxin reduction in the range of 6-100%, 25-83% and 21-66% for free OA, OA esters and total OA, respectively. Reduction of OA content was substantially higher in homogenised mussel tissue compared with that of whole shucked mussels. In addition, differences detected with regard to quality parameters (TBA, sensory attributes) between ozonated and control mussels were not considerable. Even though varying percentage reductions in OA and its derivatives were achieved using ozonation under specific experimental conditions tested, it is postulated that upon optimisation ozonation may have the potential for post-harvest commercial DSP detoxification of shucked mussels.