Evaluation of aqueous and alcohol-based quaternary ammonium sanitizers for inactivating Salmonella spp., Escherichia coli O157:H7, and Listeria monocytogenes on peanut and pistachio shells

Use of a Novel Sanitizer To Inactivate Salmonella Typhimurium and Spoilage Microorganisms during Flume Washing of Diced Tomatoes

ABSTRACT

As demand for fresh-cut produce increases, minimizing the risk of salmonellosis becomes critical for the produce industry. Sanitizers are routinely used during commercial flume washing of fresh-cut produce to minimize cross-contamination from the wash water. This study assessed the efficacy of a novel sanitizer blend consisting of peracetic acid (PAA; OxypHresh 15) with a sulfuric acid-surfactant (SS) antimicrobial (PAA-SS; ProduceShield Plus) against Salmonella during simulated commercial washing of diced tomatoes. Triplicate 9.1-kg batches of Roma tomatoes were dip inoculated in a two-strain avirulent Salmonella cocktail (Salmonella Typhimurium LT2 and MHM112) to achieve 5 to 6 log CFU per tomato and air dried for 2 h. After mechanical dicing, the tomatoes were washed in a pilot-scale processing line for 60 s with or without an added organic load in 90 ppm of PAA-SS (pH 1.8), SS at pH 1.8, 90 ppm of PAA, 5 or 10 ppm of free chlorine or sanitizer-free water as the control. Overall, PAA-SS (1.75 ± 0.75 log CFU/g) was significantly (P ≤ 0.05) more effective than water (0.69 ± 0.42 log CFU/g), chlorine (0.35 ± 0.36 log CFU/g), or SS (0.36 ± 0.19 log CFU/g) in reducing Salmonella. After washing for 20 s, PAA-SS was the only sanitizer to show a significant (P ≤ 0.05) reduction (1.93 ±0.59 log CFU/g) in Salmonella. All wash water samples were negative for Salmonella, except for 5 and 10 ppm of chlorine and the water control. Using PAA-SS with an organic load, yeast and mold populations were below the limit of detection (1.40 log CFU/g) and significantly (P ≤ 0.05) lower on diced tomatoes after 14 days of refrigerated storage compared with the other treatments (8.37 ± 0.08 log CFU/g), with SS at pH 1.8 (3.91 ± 0.93 log CFU/g) most effective against yeast and mold in the absence of an organic load. On the basis of these findings, the safety and shelf life of commercially washed diced tomatoes can be improved with PAA-SS.

HIGHLIGHTS

Salt content dependent dielectric properties of pistachios relevant to radio-frequency pasteurization

This study was conducted to investigate the effect of salt content during radio-frequency (RF) heating on rate of temperature increase, dielectric properties (DPs), and reduction of pathogens in pistachios. Also, the effect of RF heating on pistachio quality of varying salt content was determined. Pistachios of different salt content (0, 100, and 330 mg sodium/serving) were inoculated with Salmonella enterica and treated in a 27.12-MHz RF heater. The RF heating rate increased when salt content was in the range of 0–100 mg sodium/serving, but there were no significant (P > 0.05) differences in the rate of temperature rise after salt content reached to 100 mg sodium/serving. Both dielectric constant and dielectric loss factor of pistachios increased with rising salt content. Along with increased salt content, RF treatment time required to reduce this pathogen by 4 log CFU/g decreased first and then remained the same above an upper limit of salt content corresponding to the peak heating rate. RF treatment did not significantly (P > 0.05) cause changes in the color and level of lipid oxidation of pistachios. The results of the current study imply that RF heating may be a potential intervention for inactivating foodborne pathogens in pistachios and that the effect of pasteurization is influenced by dielectric loss factor relative to salt content.