1
|
Chen SD, Kuo CH, Lin RS. Analysis of the Effects of Microwave Combined Induction Heating on Steamed Pork with Rice Powder. Foods 2024; 13:2026. [PMID: 38998532 PMCID: PMC11241582 DOI: 10.3390/foods13132026] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/12/2024] [Revised: 06/23/2024] [Accepted: 06/24/2024] [Indexed: 07/14/2024] Open
Abstract
This study investigates the application of microwave combined induction heating (MCIH) to steam ready-to-eat pork with rice powder, emphasizing the advantages of rapid and uniform heating. The experimental setup included a mixture of 180 g pork strips, 30 g rice powder, and 10 g water in a CPET tray using MCIH with 1080 W microwave (MW) and 130 °C induction heating (IH) for 150 s. The results showed a quick temperature increase rate of 0.56 °C/s that achieved pasteurization against a variety of pathogenic bacteria, such as Listeria monocytogenes, but not Clostridium botulinum, by lethality calculation. Compared to typical electric cooker steaming, MCIH significantly shortened cooking time (8.6 times faster). To address rice starch gelatinization, two-stage heating techniques to steam pork with rice powder were MCIH: 150 s, and then IH: 60 s (MW1), and MCIH: 180 s, and then IH: 30 s (MW2), with no significant differences seen in color or the nine-point taste scale between treatment groups. MCIH groups had smaller shear forces than control. After MCIH cooking, no microbial counts were detected in the MW1 and MW2 groups initially, and the pork with rice powder had a shelf life of 14 days at 4 °C based on aerobic plate count assay.
Collapse
Affiliation(s)
- Su-Der Chen
- Department of Food Science, National Ilan University, Number 1, Section 1, Shen-Lung Road, Yian City 260007, Yilan County, Taiwan
| | - Chuang-Hsing Kuo
- Department of Food Science, National Ilan University, Number 1, Section 1, Shen-Lung Road, Yian City 260007, Yilan County, Taiwan
| | - Rong-Shinn Lin
- Department of Biotechnology and Animal Science, National Ilan University, Yian City 260007, Yilan County, Taiwan
| |
Collapse
|
2
|
Blanco-Lizarazo CM, Sierra-Cadavid A. Prevalence of Escherichia coli generic and pathogenic in pork meat: systematic review and meta-analysis. World J Microbiol Biotechnol 2023; 39:247. [PMID: 37428340 DOI: 10.1007/s11274-023-03687-0] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/13/2023] [Accepted: 06/24/2023] [Indexed: 07/11/2023]
Abstract
This research aimed to analyze scientific information regarding the prevalence of generic and pathogenic E. coli in the production and supply chain of pork meat, considering different types of samples, places of sampling, and pathotypes using a systematic review and meta-analysis tools. The meta-analysis for the prevalence of generic and pathogenic E. coli was conducted by estimating the effects within subgroups. Data subsets were analyzed using the DerSimonian-Laird method for binary random effects. The average prevalence of generic E. coli in different types of pork meat samples was determined to be 35.6% (95% CI 19.3-51.8), with no significant differences observed between pork meat and carcasses. Conversely, the average prevalence of E. coli pathotypes in samples related to the supply chain of pork meat was found to be 4.7% (95% CI 3.7-5.7). In conclusion, these findings suggest the possibility of establishing an objective threshold for E. coli prevalence as a benchmark for comparison within the meat industry. By utilizing this data, it becomes possible to propose a standardized limit that can serve as a reference point for evaluating and improving processes in the industry.
Collapse
Affiliation(s)
- Carla María Blanco-Lizarazo
- Centro de Investigación y Desarrollo Cárnico CI+D, Industria de Alimentos Zenú, Carrera 64 C # 104-03, Medellín, Colombia.
| | - Andrea Sierra-Cadavid
- Centro de Investigación y Desarrollo Cárnico CI+D, Industria de Alimentos Zenú, Carrera 64 C # 104-03, Medellín, Colombia
| |
Collapse
|
3
|
Dučić M, Barcenilla C, Cobo-Díaz JF, López M, Álvarez-Ordóñez A, Prieto M. High pressure processing at the early stages of ripening enhances the safety and quality of dry fermented sausages elaborated with or without starter culture. Food Res Int 2023; 163:112162. [PMID: 36596111 DOI: 10.1016/j.foodres.2022.112162] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/07/2022] [Revised: 11/03/2022] [Accepted: 11/15/2022] [Indexed: 11/21/2022]
Abstract
To study the quality of chorizo de León dry fermented sausages (DFS), high pressure processing (HPP) applied at the early stages of ripening and the use of a functional starter culture were evaluated as additional safety measures. Furthermore, the ability to control the populations of artificially inoculated Listeria monocytogenes and Salmonella Typhimurium was investigated and the evolution of microbial communities was assessed by amplicon 16S rRNA metataxonomics. The use of HPP and the starter culture, independently or combined, induced a reduction of Listeria monocytogenes of 1.5, 4.3 and > 4.8 log CFU/g respectively, as compared to control. Salmonella Typhimurium counts were under the detection limit (<1 log) in all treated end-product samples. Both additional measures reduced the activity of undesirable microbiota, such as Serratia and Brochothrix, during the production of DFS. Moreover, the starter culture highly influencedthe taxonomic profile of samples.No adverse sensory effects were observed, and panelists showed preference for HPP treated DFS. In conclusion, this new approach of applying HPP at the early stages of ripening of DFS in combination with the use of a defined starter culture improved the safety and quality of the meat product.
Collapse
Affiliation(s)
- Miroslav Dučić
- Department of Veterinary Medicine, Faculty of Agriculture, University of Novi Sad, Novi Sad, Serbia.
| | - Coral Barcenilla
- Department of Food Hygiene and Technology, Universidad de León, León, Spain.
| | - José F Cobo-Díaz
- Department of Food Hygiene and Technology, Universidad de León, León, Spain.
| | - Mercedes López
- Department of Food Hygiene and Technology, Universidad de León, León, Spain; Institute of Food Science and Technology, Universidad de León, León, Spain.
| | - Avelino Álvarez-Ordóñez
- Department of Food Hygiene and Technology, Universidad de León, León, Spain; Institute of Food Science and Technology, Universidad de León, León, Spain.
| | - Miguel Prieto
- Department of Food Hygiene and Technology, Universidad de León, León, Spain; Institute of Food Science and Technology, Universidad de León, León, Spain.
| |
Collapse
|
4
|
Porto-Fett ACS, McCoy A, Shane LE, Henry E, Osoria M, Shoyer BA, Campano SG, Burson D, Luchansky JB. Fate of Listeria monocytogenes and Shiga Toxin-Producing Escherichia coli on Slices of Beef Bresaola During Refrigerated Storage. MEAT AND MUSCLE BIOLOGY 2022. [DOI: 10.22175/mmb.13918] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022] Open
Abstract
The viability of multi-strain cocktails of geneticallymarked strains of Listeriamonocytogenes and Shigatoxin-producing Escherichiacoli (STEC) wereseparately monitored on slices of one brand of a commercially-producedbresaola (ca. pH 6.7 and aw 0.899) during extendedrefrigerated storage. Two slices (ca. 8 g each; ca. 10.2 cm wide, ca. 11 cmlong) of bresaola were layered horizontally within a nylon-polyethylene bag.The outer surface of each slice was inoculated (50 µL total; ca. 3.5 logCFU/package)with a rifampicin-resistant (100 mg/ml)cocktail of either L.monocytogenes (fivestrains) or STEC (eight strains). Bags were vacuum-sealed and then stored at 4°or 10°C for 180 or 90 days, respectively. In each of five trials, three bagswere analyzed for pathogen presence at each sampling interval via the USDA-ARSpackage rinse method. In general, levels of L. monocytogenes and STEC decreased by 3.0and 2.4log CFU/package, respectively, after 180 days when bresaola was stored at 4°C.When bresaola was stored at 10°C for 90 days, levels of L. monocytogenes and STEC decreased by 2.4 and 3.1log CFU/package, respectively. Thus, the (brand of) sliced bresaola evaluatedherein did not provide a favorable environment for either persistence oroutgrowth of surface-inoculated cells of L. monocytogenes or STEC.
Collapse
Affiliation(s)
- Anna C. S. Porto-Fett
- USDA, ARS, Eastern Regional research Center Food Safety and Interventions Technologies
| | - Ashley McCoy
- University of Nebraska Department of Animal Science
| | - Laura E. Shane
- USDA, ARS, Eastern Regional research Center Food Safety and Interventions Technologies
| | - Elizabeth Henry
- USDA, ARS, Eastern Regional research Center Food Safety and Interventions Technologies
| | - Manuela Osoria
- USDA, ARS, Eastern Regional research Center Food Safety and Interventions Technologies
| | - Bradley A. Shoyer
- USDA, ARS, Eastern Regional research Center Food Safety and Interventions Technologies
| | | | | | - John B. Luchansky
- USDA, ARS, Eastern Regional research Center Food Safety and Interventions Technologies
| |
Collapse
|
5
|
ŞİMŞEK A. An evaluation of the physicochemical and microbiological characteristics and the hygienic status of naturally fermented camel sausages (sucuks). FOOD SCIENCE AND TECHNOLOGY 2022. [DOI: 10.1590/fst.81321] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
Affiliation(s)
- Azim ŞİMŞEK
- Isparta University of Applied Sciences, Turkey
| |
Collapse
|
6
|
Mohamed HM, Burroughs S, Emch AW, Waite-Cusic J. Enhancing the reduction of Salmonella and Listeria monocytogenes during traditional salami processing by adding a finishing phase. Food Control 2022. [DOI: 10.1016/j.foodcont.2021.108432] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
7
|
Effect of lysozyme and Chinese liquor on Staphylococcus aureus growth, microbiome, flavor profile, and the quality of dry fermented sausage. Lebensm Wiss Technol 2021. [DOI: 10.1016/j.lwt.2021.112059] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/06/2023]
|
8
|
Mrkonjic Fuka M, Tanuwidjaja I, Zgomba Maksimovic A, Zunabovic-Pichler M, Kublik S, Hulak N, Domig KJ, Schloter M. Bacterial diversity of naturally fermented game meat sausages: Sources of new starter cultures. Lebensm Wiss Technol 2020. [DOI: 10.1016/j.lwt.2019.108782] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/13/2023]
|
9
|
Meloni D. High-Hydrostatic-Pressure (HHP) Processing Technology as a Novel Control Method for Listeria monocytogenes Occurrence in Mediterranean-Style Dry-Fermented Sausages. Foods 2019; 8:E672. [PMID: 31842401 PMCID: PMC6963505 DOI: 10.3390/foods8120672] [Citation(s) in RCA: 17] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/21/2019] [Revised: 12/05/2019] [Accepted: 12/09/2019] [Indexed: 12/30/2022] Open
Abstract
Although conventional microbial control techniques are currently employed and largely successful, their major drawbacks are related to their effects on quality of processed food. In recent years, there has been a growing demand for high-quality foods that are microbially safe and retain most of their natural freshness. Therefore, several modern and innovative methods of microbial control in food processing have been developed. High-hydrostatic-pressure (HHP) processing technology has been mainly used to enhance the food safety of ready-to-eat (RTE) products as a new pre-/post-packaging, non-thermal purification method in the meat industry. Listeria monocytogenes is a pertinent target for microbiological safety and shelf-life; due to its capacity to multiply in a broad range of food environments, is extremely complicated to prevent in fermented-sausage-producing plants. The frequent detection of L. monocytogenes in final products emphasizes the necessity for the producers of fermented sausages to correctly overcome the hurdles of the technological process and to prevent the presence of L. monocytogenes by applying novel control techniques. This review discusses a collection of recent studies describing pressure-induced elimination of L. monocytogenes in fermented sausages produced in the Mediterranean area.
Collapse
Affiliation(s)
- Domenico Meloni
- Department of Veterinary Medicine, University of Sassari, Via Vienna 2, 07100 Sassari, Italy
| |
Collapse
|
10
|
Odai BT, Tano-Debrah K, Addo KK, Saalia FK, Akyeh LM. Effect of gamma radiation and storage at 4°C on the inactivation of Listeria monocytogenes, Escherichia coli and Salmonella enterica Typhimurium in Legon-18 pepper (Capsicum annuum) powder. FOOD QUALITY AND SAFETY 2019. [DOI: 10.1093/fqsafe/fyz026] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/14/2022]
Abstract
Abstract
Objectives
Spices are low moisture foods which have been known to be contaminated with various pathogens and sun-dried Legon-18 pepper powder is not left out. Due to its contamination with various pathogens, a study was conducted to determine the effects of gamma irradiation on the decontamination of Legon-18 pepper powder and on some quality parameters.
Methods
Samples were obtained from a local farmer from the Eastern Region of Ghana. Sterility tests were carried out. The samples were inoculated with known cfu/ml of Escherichia coli, Listeria monocytogenes and Salmonella enterica Typhimurium. Samples were irradiated at 1, 2, 4, and 5 kilogray (kGy). Zero kilogray served as control (unirradiated). All samples were stored at 4oC for 60 days. Enumeration of the various pathogens was done in appropriate media. Some quality parameters were determined after irradiating unsterile samples at 5 kGy and 0 kGy served as control. Capsaicinoids and carotenoids were quantified using a high performance liquid chromatography. The samples were stored at 4oC for 8 weeks.
Results
A dose-dependent effect on the inactivation of the pathogens was observed (P < 0.05). Storage time affected the inactivation of the pathogens as well (P < 0.05). Complete inactivation of the pathogens was observed at 5 kGy at day 0. Capsaicin, dihydrocapsaicin and total capsaicinoid content of the samples irradiated at 5 kGy increased at 23.64%, 14.7 % and 20.95% respectively as compared with the contents of the unirradiated samples. A gamma irradiation dose of 5 kGy caused losses of 8.11%, 8.67% and 26.54% in capsanthin, beta carotene and beta cryptoxanthin respectively. Quality parameters measured reduced with storage (P < 0.05).
Conclusions
Gamma irradiation inactivated pathogens at 5 kGy. Lower doses used during the study could inactivate the pathogens but with time. All quality parameters and carotenoids quantified were affected by gamma irradiation and storage period (P < 0.05).
Collapse
Affiliation(s)
- Bernard Tawiah Odai
- Department of Nutrition and Food Science, University of Ghana, Legon, Accra
- Radiation Technology Centre, Biotechnology and Nuclear Agriculture Research Institute, Ghana Atomic Energy Commission, Kwabenya, Accra
| | - Kwaku Tano-Debrah
- Department of Nutrition and Food Science, University of Ghana, Legon, Accra
| | - Kennedy Kwasi Addo
- Noguchi Memorial Institute for Medical Research, University of Ghana, Legon, Accra
| | - Firibu K Saalia
- Department of Nutrition and Food Science, University of Ghana, Legon, Accra
| | - Lorenzo Moses Akyeh
- Noguchi Memorial Institute for Medical Research, University of Ghana, Legon, Accra
| |
Collapse
|
11
|
Odai BT, Tano-Debrah K, Addo KK, Saalia FK, Akyeh ML, Torgby-Tetteh W, Mills SWNO, Azanu D. The role of gamma irradiation and storage at 28 ± 2 °C on the inactivation of Listeria monocytogenes, Escherichia coli and Salmonella enterica serotype Typhimurium in sun-dried Legon-18 pepper (Capsicum annuum) powder. INTERNATIONAL JOURNAL OF FOOD CONTAMINATION 2019. [DOI: 10.1186/s40550-019-0077-6] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
|
12
|
High hydrostatic pressure processing of sliced fermented sausages: A quantitative exposure assessment for Listeria monocytogenes. INNOV FOOD SCI EMERG 2019. [DOI: 10.1016/j.ifset.2019.01.017] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/14/2023]
|
13
|
Combined effect of NaCl and low temperature on antilisterial bacteriocin production of Lactobacillus plantarum ST202Ch. Lebensm Wiss Technol 2018. [DOI: 10.1016/j.lwt.2017.10.027] [Citation(s) in RCA: 10] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022]
|
14
|
A risk based sampling design including exposure assessment linked to disease burden, uncertainty and costs. Food Control 2018. [DOI: 10.1016/j.foodcont.2017.07.014] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
|
15
|
Van Ba H, Seo HW, Cho SH, Kim YS, Kim JH, Ham JS, Park BY, Pil-Nam S. Effects of extraction methods of shiitake by-products on their antioxidant and antimicrobial activities in fermented sausages during storage. Food Control 2017. [DOI: 10.1016/j.foodcont.2017.03.034] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.1] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/01/2023]
|
16
|
A simple nanostructured biosensor based on clavanin A antimicrobial peptide for gram-negative bacteria detection. Biochem Eng J 2017. [DOI: 10.1016/j.bej.2017.04.013] [Citation(s) in RCA: 34] [Impact Index Per Article: 4.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
|
17
|
Rivera-Reyes M, Campbell JA, Cutter CN. Pathogen reductions associated with traditional processing of landjäger. Food Control 2017. [DOI: 10.1016/j.foodcont.2016.09.047] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
18
|
Evers EG, Pielaat A, Smid JH, van Duijkeren E, Vennemann FBC, Wijnands LM, Chardon JE. Comparative Exposure Assessment of ESBL-Producing Escherichia coli through Meat Consumption. PLoS One 2017; 12:e0169589. [PMID: 28056081 PMCID: PMC5215934 DOI: 10.1371/journal.pone.0169589] [Citation(s) in RCA: 52] [Impact Index Per Article: 7.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/23/2016] [Accepted: 12/19/2016] [Indexed: 02/06/2023] Open
Abstract
The presence of extended-spectrum β-lactamase (ESBL) and plasmidic AmpC (pAmpC) producing Escherichia coli (EEC) in food animals, especially broilers, has become a major public health concern. The aim of the present study was to quantify the EEC exposure of humans in The Netherlands through the consumption of meat from different food animals. Calculations were done with a simplified Quantitative Microbiological Risk Assessment (QMRA) model. The model took the effect of pre-retail processing, storage at the consumers home and preparation in the kitchen (cross-contamination and heating) on EEC numbers on/in the raw meat products into account. The contribution of beef products (78%) to the total EEC exposure of the Dutch population through the consumption of meat was much higher than for chicken (18%), pork (4.5%), veal (0.1%) and lamb (0%). After slaughter, chicken meat accounted for 97% of total EEC load on meat, but chicken meat experienced a relatively large effect of heating during food preparation. Exposure via consumption of filet americain (a minced beef product consumed raw) was predicted to be highest (61% of total EEC exposure), followed by chicken fillet (13%). It was estimated that only 18% of EEC exposure occurred via cross-contamination during preparation in the kitchen, which was the only route by which EEC survived for surface-contaminated products. Sensitivity analysis showed that model output is not sensitive for most parameters. However, EEC concentration on meat other than chicken meat was an important data gap. In conclusion, the model assessed that consumption of beef products led to a higher exposure to EEC than chicken products, although the prevalence of EEC on raw chicken meat was much higher than on beef. The (relative) risk of this exposure for public health is yet unknown given the lack of a modelling framework and of exposure studies for other potential transmission routes.
Collapse
Affiliation(s)
- Eric G. Evers
- Centre for Infectious Disease Control (CIb), National Institute for Public Health and the Environment (RIVM), Bilthoven, The Netherlands
| | - Annemarie Pielaat
- Centre for Infectious Disease Control (CIb), National Institute for Public Health and the Environment (RIVM), Bilthoven, The Netherlands
| | - Joost H. Smid
- Institute for Risk Assessment Sciences (IRAS), Utrecht University, Utrecht, The Netherlands
| | - Engeline van Duijkeren
- Centre for Infectious Disease Control (CIb), National Institute for Public Health and the Environment (RIVM), Bilthoven, The Netherlands
| | - Francy B. C. Vennemann
- Public Health and Health Services Division, National Institute for Public Health and the Environment (RIVM), Bilthoven, The Netherlands
| | - Lucas M. Wijnands
- Centre for Infectious Disease Control (CIb), National Institute for Public Health and the Environment (RIVM), Bilthoven, The Netherlands
| | - Jurgen E. Chardon
- Centre for Infectious Disease Control (CIb), National Institute for Public Health and the Environment (RIVM), Bilthoven, The Netherlands
| |
Collapse
|
19
|
Abstract
Fermented sausages are highly treasured traditional foods. A large number of distinct sausages with different properties are produced using widely different recipes and manufacturing processes. Over the last years, eating fermented sausages has been associated with potential health hazards due to their high contents of saturated fats, high NaCl content, presence of nitrite and its degradation products such as nitrosamines, and use of smoking which can lead to formation of toxic compounds such as polycyclic aromatic hydrocarbons. Here we review the recent literature regarding possible health effects of the ingredients used in fermented sausages. We also go through attempts to improve the sausages by lowering the content of saturated fats by replacing them with unsaturated fats, reducing the NaCl concentration by partly replacing it with KCl, and the use of selected starter cultures with desirable properties. In addition, we review the food pathogenic microorganisms relevant for fermented sausages(Escherichia coli,Salmonella enterica,Staphylococcus aureus,Listeria monocytogenes,Clostridium botulinum, andToxoplasma gondii)and processing and postprocessing strategies to inhibit their growth and reduce their presence in the products.
Collapse
|