Stability and kinetics of leaching of deoxynivalenol, deoxynivalenol-3-glucoside and ochratoxin A during boiling of wheat spaghettis

Occurrence of Types A and B Trichothecenes in Cereal Products Sold in Romanian Markets

In view of the frequent occurrences of mycotoxins in cereals, this study assessed the presence of trichothecenes in 121 samples from Romanian markets. These samples were divided into five groups based on product type: (1) bread and bakery products containing white flour, (2) half-brown bread with whole wheat flour, (3) brown bread containing rye flour, (4) pasta, and (5) raw wheat. Gas Chromatography-Mass Spectrometry was used to detect 13 different mycotoxins, which included the Type A compounds HT-2 toxin and T-2 toxin, as well as the Type B compounds deoxynivalenol and nivalenol. Results indicated trichothecene contamination in 90.08% of our samples, with deoxynivalenol predominating by at least 78% in each examined group. Co-occurrence of three or four trichothecenes were found in 23.85% of our samples. Our study underscores the necessity of consistent monitoring of staple foods to prevent the intake of harmful trichothecenes by consumers.

Pasta cooking influence on in vitro bioaccessibility of type B trichothecenes, acrylamide and hydroxymethylfurfural

The study evaluated the effect of cooking time on the levels of type B trichothecenes (TCT_B), acrylamide (AA) and hydroxymethylfurfural (HMF) in semolina pasta and their bioaccessibilities in order to propose strategies to reduce the daily exposure of these natural and processing contaminants. Three brands of commercial pasta were submitted to different cooking times (7, 10 and 13 min). Subsequently, the in vitro bioaccessibility trials, permeation across the intestinal membrane and estimation of daily exposure were carried out. The lowest cooking time (7 min) resulted in high reductions of TCT_B (88%) and AA + HMF (76.7%) contents found on the raw pasta. The concentrations of deoxynivalenol (DON) and AA were higher after the digestion (bioaccessibilities >100%) than after the pasta cooking. About 25.6% of DON and 100% of AA found in the small intestine digestible fraction were able to permeate the intestinal membrane. The risk of exposure was below the recommended safe limits since the estimated daily exposure values were 0.22 µg/kg per body weight/day for DON and 0.26 µg/kg per body weight/day for AA. Therefore, cooking pasta for 7 min at a pasta:water ratio of 1:10 (w/v) mitigates the contaminants and promotes the greater formation of resistant starch.

Environmental Conditions After Fusarium Head Blight Visual Symptom Development Affect Contamination of Wheat Grain with Deoxynivalenol and Deoxynivalenol-3-Glucoside

Fusarium head blight (FHB) of wheat, caused by the fungus Fusarium graminearum, is associated with grain contamination with mycotoxins such as deoxynivalenol (DON). Although FHB is often positively correlated with DON, this relationship can break down under certain conditions. One possible explanation for this could be the conversion of DON to DON-3-glucoside (D3G), which is typically missed by common DON testing methods. The objective of this study was to quantify the effects of temperature, relative humidity (RH), and preharvest rainfall on DON, D3G, and the D3D/DON relationship. D3G levels were higher in grain from spikes exposed to 100% RH than to 70, 80, or 90% RH at 20 and 25°C across all tested levels of mean FHB index (percentage of diseased spikelets per spike). Mean D3G contamination was higher at 20°C than at 25 or 30°C. There were significantly positive linear relationships between DON and D3G. Rainfall treatments resulted in significantly higher mean D3G than the rain-free check and induced preharvest sprouting, as indicated by low falling numbers (FNs). There were significant positive relationships between the rate of increase in D3G per unit increase in DON (a measure of conversion) and sprouting. As FN decreased, the rate of D3G conversion increased, and this rate of conversion per unit decrease in FN was greater at relatively low than at high mean DON levels. These results provide strong evidence that moisture after FHB visual symptom development was associated with DON-to-D3G conversion and constitute valuable new information for understanding this complex disease-mycotoxin system.

Deoxynivalenol: An Overview on Occurrence, Chemistry, Biosynthesis, Health Effects and Its Detection, Management, and Control Strategies in Food and Feed

Mycotoxins are fungi-produced secondary metabolites that can contaminate many foods eaten by humans and animals. Deoxynivalenol (DON), which is formed by Fusarium, is one of the most common occurring predominantly in cereal grains and thus poses a significant health risk. When DON is ingested, it can cause both acute and chronic toxicity. Acute signs include abdominal pain, anorexia, diarrhea, increased salivation, vomiting, and malaise. The most common effects of chronic DON exposure include changes in dietary efficacy, weight loss, and anorexia. This review provides a succinct overview of various sources, biosynthetic mechanisms, and genes governing DON production, along with its consequences on human and animal health. It also covers the effect of environmental factors on its production with potential detection, management, and control strategies.

Mechanisms of deoxynivalenol (DON) degradation during different treatments: a review

Deoxynivalenol (DON) is one of the main trichothecenes, that causes health-related issues in humans and animals and imposes considerable financial loss to the food industry each year. Numerous treatments have been reported in the literature on the degradation of DON in food products. These treatments include thermal, chemical, biological/enzymatic, irradiation, light, ultrasound, ozone, and atmospheric cold plasma treatments. Each of these methods has different degradation efficacy and degrades DON by a distinct mechanism, which leads to various degradation byproducts with different toxicity. This manuscript focuses to review the degradation of DON by the aforementioned treatments, the chemical structure and toxicity of the byproducts, and the degradation pathway of DON. Based on the type of treatment, DON can be degraded to norDONs A-F, DON lactones, and ozonolysis products or transformed into de-epoxy deoxynivalenol, DON-3-glucoside, 3-acetyl-DON, 7-acetyl-DON, 15-acetyl-DON, 3-keto-DON, or 3-epi-DON. DON is a major problem for the grain industry and the studies focusing on DON degradation mechanisms could be helpful to select the best method and overcome the DON contamination in grains.

Impact of experimental thermal processing of artificially contaminated pea products on ochratoxin A and phomopsin A

Fungi of Aspergillus and Penicillium genus can infect peas (Pisum sativum), leading to a contamination with the nephrotoxic and carcinogenic ochratoxin A (OTA). Under unfavourable conditions, a fungus primarily found on lupines, Diapothe toxica, may also grow on peas and produce the hepatotoxic phomopsin A (PHOA). To study the effect of processing on OTA and PHOA content, two model products-wheat/rye-mixed bread with pea flour addition and pea pasta-were manufactured at small-business scale from artificially contaminated pea flour. The decrease of OTA and PHOA contents were monitored along the production process as indicators for toxin transformation. Pea bread dough was subjected to proofing for 30-40 min at 32 °C and baked at 250 °C to 230 °C for 40 min. OTA content (LODs < 0.1 μg/kg) showed a reduction in the bread crust (initially 17.0 μg/kg) to 88% and no reduction in the crumb (110%). For PHOA (LODs < 3.6 μg/kg), a decrease to approximately 21% occurred in the bread crust (initially 12.5 μg/kg), whilst for crumb, a less intense decrease to 91% was found. Pea pasta prepared with two toxin levels was extruded at room temperature, dried and cooked for 8 min in boiling water. In pea pasta, OTA was reduced from 29.8 to 13.9 μg/kg by 22% each after cooking, whilst 15% and 10% of the initial toxin amounts were found in the cooking water, respectively. For PHOA, 60% and 78% of initially 14.3 μg/kg and 7.21 μg/kg remained in the cooked pasta. As only the decrease of the initial content was measured and no specific degradation products could be detected, further research is needed to characterise potential transformation products. Heat treatment reduces the initial PHOA content stronger than the OTA content during pasta cooking and bread making. However, significant amounts of both toxins would remain in the final products.

Exposure assessment to ochratoxin A through the intake of three cereal derivatives from the Moroccan market

Previous studies reported the contamination of cereals products with OTA in Morocco. Given bread, pasta and semolina are staple consumed food in the country, this study aims to assess the OTA exposure levels for the adult consumers in the country through cereal derivatives intake, by using a deterministic model based on the crossover of consumption and contamination data of 457 cereals products samples. The study also set out to determine under what conditions the OTA contributions from these 3 cereal derivatives alone were enough to cause a real public health problem in the country. The Estimated Weekly Intake EWI (ng/kg b.w./week) was used as an indicator of exposure for each cereal derivative. The global exposure (Total EWI) was determined by the summation of the EWI obtained for each cereal derivative for different consumers groups and at different OTA levels and nine scenarios were elaborated. Results showed that the total average OTA intake from the three cereal derivatives was estimated at 13.5 ng/kg b.w./week. Despite its low contamination levels, bread has been shown to be the main vector of exposure to OTA because of the high consumption levels by Moroccan adults. Its contribution to the total OTA intake was between 81 and 84% depending on the scenario. The contribution of the other investigated cereal products to total OTA intake seems to be modest and does not exceed 10% and 7% for semolina and pasta, respectively. The predominance of cereal derivatives in Moroccan food thus constitutes a potential risk factor for OTA exposure. Indeed, the risk of occurrence of potential adverse effects of OTA is real in three scenarios discussed in the study since the PTWI established by JECFA (100 ng/kg b.w./week) was exceeded. Moreover, the Maximum limit (3 ng/g) set by Moroccan regulations in 2016, seems to be less protective for the Moroccan consumers compared to other countries due to the high consumption level of cereal products. This situation is likely to cause a public health problem by the occurrence of specific pathologies at highly OTA exposed adults, especially high bread consumers.

Mycotoxin exposure assessments in a multi-center European validation study by 24-hour dietary recall and biological fluid sampling

The European Food Consumption Validation (EFCOVAL) project includes 600 men and women from Belgium, the Czech Republic, France, the Netherlands, and Norway, who had given serum and 24-hour urine samples, and completed 24-hour dietary recall (24-HDR) interviews. Consumption, according to 24-HDR, was matched against the European Food Safety Authority (EFSA) databases of mycotoxin contaminations, via the FoodEx1 standard classifications, producing an indirect external estimate of dietary mycotoxin exposure. Direct, internal measurements of dietary mycotoxin exposure were made in serum and urine by ultra-performance liquid chromatography coupled to tandem mass spectrometry. For the first time, mycotoxin exposures were thoroughly compared between two 24-HDRs, and two 24-hour urine samples collected during the same days covered by the 24-HDRs. These measurements were compared to a single-time point serum measurement to investigate evidence of chronic mycotoxin exposure. According to 24-HDR data, all 600 individuals were exposed to between 4 and 34 mycotoxins, whereof 10 found to exceed the tolerable daily intake. Correlations were observed between two time points, and significant correlations were observed between concentrations in serum and urine. However, only acetyldeoxynivalenol, ochratoxin A, and sterigmatocystin were found to have significant positive correlations between 24-HDR exposures and serum, while aflatoxin G1 and G2, HT-2 toxin, and deoxynivalenol were associated between concurrent 24-HDR and 24-hour urine. Substantial agreements on quantitative levels between serum and urine were observed for the groups Type B Trichothecenes and Zearalenone. Further research is required to bridge the interpretation of external and internal exposure estimates of the individual on a time scale of hours. Additionally, metabolomic profiling of dietary mycotoxin exposures could help with a comprehensive assessment of single time-point exposures, but also with the identification of chronic exposure biomarkers. Such detailed characterization informs population exposure assessments, and aids in the interpretation of epidemiological health outcomes related to multi-mycotoxin exposure.

Stability of Mycotoxins in Individual Stock and Multi-Analyte Standard Solutions

Standard solutions of mycotoxins prepared in RP HPLC solvents from neat standards are usually used for analytical method development. Multi-mycotoxin HPLC-MS/MS methods necessitate stability estimation for the wide spectrum of fungal metabolites. The stability of individual diluted stock standard solutions of mycotoxins in RP-HPLC solvents and multi-analyte HPLC-MS/MS calibrants was evaluated under standard storage and analysis conditions. Individual stock standard solutions of aflatoxins, sterigmatocystin, A- and B-trichothecenes, zearalenone and its analogues, ochratoxin A, fumonisins, Alternaria toxins, enniatins and beauvericin, moniliformin, citrinin, mycophenolic, cyclopiazonic acids and citreoviridin were prepared in RP-HPLC solvents and stored at -18 °C for 14 months. UV-spectroscopy was utilized to monitor the stability of analytes, excluding fumonisins. The gradual degradation of α-, β-zearalenol and α-, β-zearalanol in acetonitrile was detected. Aflatoxins and sterigmatocystin, zearalenone, Alternaria toxins, enniatins and beauvericin, citrinin, mycophenolic, cyclopiazonic acids and citreoviridin can be referred to as stable. The concentration of the majority of trichothecenes should be monitored. Diluted multi-mycotoxin standard in water/methanol (50/50 v/v) solutions acidified with 0.1% formic acid proved to be stable in silanized glass at 23 °C exposed to light for at least 75 h (CV≤10%). An unexpected manifestation of MS/MS signal suppression/enhancement was discovered in the course of multi-mycotoxin standard solution stability evaluation.

Fusarium head blight and mycotoxins in wheat: prevention and control strategies across the food chain

With 744 million metric tons produced in 2017/2018, bread wheat (Triticum aestivum) and durum wheat (Triticum durum) are the second most widely produced cereal on a global basis. Prevention or control of wheat diseases may have an enormous impact on global food security and safety. Fusarium head blight is an economically debilitating disease of wheat that reduces the quantity and quality of grain harvested, and may lead to contamination with the mycotoxin deoxynivalenol, which affects the health of humans and domesticated animals. Current climate change scenarios predict an increase in the number of epidemics caused by this disease. Multiple strategies are available for managing the disease including cultural practices, planting less-susceptible cultivars, crop rotation, and chemical and biological controls. None of these strategies, however, is completely effective by itself, and an integrated approach incorporating multiple controls simultaneously is the only effective strategy to limit the disease and reduce deoxynivalenol contamination in human food and animal feed chains. This review identifies the available tools and strategies for mitigating the damage that can result from Fusarium head blight.

Fate of Fusarium mycotoxins during processing of Nigerian traditional infant foods (ogi and soybean powder)

The influence of processing methods used to produce traditional Nigerian infant foods (ogi and processed soybean powder) on four European Union regulated Fusarium mycotoxins using naturally and artificially contaminated raw materials was studied using liquid chromatography-tandem mass spectrometry. Generally, there was a significant reduction of all the mycotoxins when compared to the initial concentration of the raw materials. Reduction in concentrations of the mycotoxins during ogi-processing started immediately after 36 h' steeping/fermentation for all the mycotoxins (fumonisin B1, zearalenone, deoxynivalenol, and T-2 toxin), and proceeded along the process chain (milling and sieving). In addition, deoxynivalenol-3-glucoside (16 ± 3.2 μg/kg) and 3-acetyl-deoxynivalenol (9 ± 5.5 μg/kg) initially absent in the raw maize were detected in the final ogi product. β-zearalenol, hydrolysed fumonisin B1, and HT-2 toxin were also detected at varying concentrations. Regarding soybean processing, a similar trend was observed with fumonisin B1, zearalenone, deoxynivalenol, and T-2 toxin, irrespective of the method used or the initial concentration. Other mycotoxins detected in soybean product include 3-acetyl-deoxynivalenol, 15-acetyl-deoxynivalenol, deoxynivalenol-3-glucoside, HT-2 toxin, neosolaniol, α-zearalenol, β-zearalenol, and zearalenone-14-glucoside. Although there was a reduction in the concentration of the free mycotoxin because of processing, other mycotoxins were detected in the products and thus, may present an additional health risk on consumers.

The Fate of Mycotoxins During the Processing of Wheat for Human Consumption

Mycotoxins are a potential health threat in cereals including wheat. In the European Union (EU), mycotoxin maximum levels are laid down for cereal raw materials and final food products. For wheat and wheat-based products, the EU maximum levels apply to deoxynivalenol (DON), zearalenone, aflatoxins, and ochratoxin A. This review provides a comprehensive overview on the different mycotoxins and their legal limits and on how processing of wheat can affect such contaminants, from raw material to highly processed final products, based on relevant scientific studies published in the literature. The potential compliance with EU maximum levels is discussed. Of the four mycotoxins regulated in wheat-based foods in the EU, most data are available for DON, whereas aflatoxins were rarely studied in the processing of wheat. Furthermore, available data on the effect of processing are outlined for mycotoxins not regulated by EU law-including modified and emerging mycotoxins-and which cover DON derivatives (DON-3-glucoside, mono-acetyl-DONs, norDONs, deepoxy-DON), nivalenol, T-2 and HT-2 toxins, enniatins, beauvericin, moniliformin, and fumonisins. The processing steps addressed in this review cover primary processing (premilling and milling operations) and secondary processing procedures (such as fermentation and thermal treatments). A special focus is on the production of baked goods, and processing factors for DON in wheat bread production were estimated. For wheat milling products derived from the endosperm and for white bread, compliance with legal requirements seems to be mostly achievable when applying good practices. In the case of wholemeal products, bran-enriched products, or high-cereal low-moisture bakery products, this appears to be challenging and improved technology and/or selection of high-quality raw materials would be required.

Fate of deoxynivalenol and deoxynivalenol-3-glucoside during cereal-based thermal food processing: a review study

Deoxynivalenol (DON), the most commonly occurring trichothecene in nature, may affect animal and human health through causing diarrhea, vomiting, gastrointestinal inflammation, and immunomodulation. DON-3-glucoside (DON-3G) as a major plant metabolite of the mycotoxin is another "emerging" food safety issue in recent years. Humans may experience potential health risks by consuming DON-contaminated food products. Thus, it is crucial for human and animal health to study also the degradation of DON and DON-3G during thermal food processing. Baking, boiling, steaming, frying, and extrusion cooking are commonly used during thermal food processing and have promising effects on the reduction of mycotoxins in food. For DON, however, the observed effects of these methods, as reported in numerous studies, are ambiguous and do not present a clear picture with regard to reduction or transformation. This review summarized the influence of thermal processing on the stability of DON and the formation of degradation/conversion products. Besides this, also a release of DON and DON-3G from food matrix as well as the release of DON from DON-3G during processing is discussed. In addition, some conflicting findings as reported from the studies on thermal processing as well as cause-effect relationships of the different thermal procedures are explored. Finally, the potential toxic profiles of DON degradation products are discussed as well when data are available.