1
|
Guo W, Spotti MJ, Portillo-Perez G, Bonilla JC, Bai W, Martinez MM. Molecular changes and interactions of wheat flour biopolymers during bread-making: Implications to upcycle bread waste into bioplastics. Carbohydr Polym 2024; 342:122414. [PMID: 39048204 DOI: 10.1016/j.carbpol.2024.122414] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/23/2024] [Revised: 05/07/2024] [Accepted: 06/16/2024] [Indexed: 07/27/2024]
Abstract
This study aims to understand the molecular and supramolecular transformations of wheat endosperm biopolymers during bread-making, and their implications to fabricate self-standing films from stale white bread. A reduction in the Mw of amylopectin (51.8 × 106 vs 425.1 × 106 g/mol) and water extractable arabinoxylans WEAX (1.79 × 105 vs 7.63 × 105 g/mol), and a decrease in amylose length (245 vs 748 glucose units) was observed after bread-baking. The chain length distribution of amylopectin and the arabinose-to-xylose (A/X) ratio of WEAX remained unaffected during bread-making, suggesting that heat- or/and shear-induced chain scission is the mechanism responsible for molecular fragmentation. Bread-making also resulted in more insoluble cell wall residue, featured by water unextractable arabinoxylan of lower A/X and Mw, along with the formation of a gluten network. Flexible and transparent films with good light-blocking performance (<30 % transmittance) and DPPH-radical scavenging capacity (~8.5 %) were successfully developed from bread and flour. Bread films exhibited lower hygroscopicity, tensile strength (2.7 vs 8.5 MPa) and elastic modulus (67 vs 501 MPa) than flour films, while having a 6-fold higher elongation at break (10.0 vs 61.2 %). This study provides insights into the changes in wheat biopolymers during bread-making and sets a precedent for using stale bread as composite polymeric materials.
Collapse
Affiliation(s)
- Wanxiang Guo
- Center for Innovative Food (CiFOOD), Department of Food Science, Aarhus University, AgroFood Park 48, Aarhus N 8200, Denmark
| | - Maria Julia Spotti
- Center for Innovative Food (CiFOOD), Department of Food Science, Aarhus University, AgroFood Park 48, Aarhus N 8200, Denmark
| | - Guillermo Portillo-Perez
- Center for Innovative Food (CiFOOD), Department of Food Science, Aarhus University, AgroFood Park 48, Aarhus N 8200, Denmark
| | - Jose C Bonilla
- SDU Biotechnology, Faculty of Engineering, University of Southern Denmark, Odense M, DK-5230, Denmark
| | - Wenqiang Bai
- Center for Innovative Food (CiFOOD), Department of Food Science, Aarhus University, AgroFood Park 48, Aarhus N 8200, Denmark
| | - Mario M Martinez
- Center for Innovative Food (CiFOOD), Department of Food Science, Aarhus University, AgroFood Park 48, Aarhus N 8200, Denmark.
| |
Collapse
|
2
|
Lavoignat M, Juhász A, Bose U, Sayd T, Chambon C, Ribeiro M, Igrejas G, Déjean S, Ravel C, Bancel E. Peptidomics analysis of in vitro digested wheat breads: Effect of genotype and environment on protein digestibility and release of celiac disease and wheat allergy related epitopes. Food Chem 2024; 448:139148. [PMID: 38569409 DOI: 10.1016/j.foodchem.2024.139148] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/13/2023] [Revised: 02/26/2024] [Accepted: 03/24/2024] [Indexed: 04/05/2024]
Abstract
Wheat proteins can trigger immunogenic reactions due to their resistance to digestion and immunostimulatory epitopes. Here, we investigated the peptidomic map of partially digested bread samples and the fingerprint of epitope diversity from 16 wheat genotypes grown in two environmental conditions. Flour protein content and composition were characterized; gastric and jejunal peptides were quantified using LC-MS/MS, and genotypes were classified into high or low bread protein digestibility. Differences in flour protein content and peptide composition distinguish high from low digestibility genotypes in both growing environments. No common peptide signature was found between high- and low-digestible genotypes; however, the celiac or allergen epitopes were noted not to be higher in low-digestible genotypes. Overall, this study established a peptidomic and epitope diversity map of digested wheat bread and provided new insights and correlations between weather conditions, genotypes, digestibility and wheat sensitivities such as celiac disease and wheat allergy.
Collapse
Affiliation(s)
- Mélanie Lavoignat
- Université Clermont Auvergne, INRAE, UMR1095 GDEC, F-63000 Clermont-Ferrand, France
| | - Angéla Juhász
- Australian Research Council Centre of Excellence for Innovations in Peptide and Protein Science, Edith Cowan University, School of Science, 270 Joondalup Dr, Joondalup, WA 6027, Australia
| | - Utpal Bose
- Australian Research Council Centre of Excellence for Innovations in Peptide and Protein Science, Edith Cowan University, School of Science, 270 Joondalup Dr, Joondalup, WA 6027, Australia; CSIRO Agriculture and Food, 306 Carmody Rd, St Lucia, QLD 4067, Australia
| | - Thierry Sayd
- INRAE, Plateforme d'Exploration du Métabolisme Composante Protéomique (PFEMcp), F-63122 Saint-Genès Champanelle, France
| | - Christophe Chambon
- INRAE, Plateforme d'Exploration du Métabolisme Composante Protéomique (PFEMcp), F-63122 Saint-Genès Champanelle, France
| | - Miguel Ribeiro
- Chemistry Research Centre-Vila Real (CQ-VR), University of Trás-os-Montes and Alto Douro, 5000-801 Vila Real, Portugal; Department of Genetics and Biotechnology, School of Life Sciences and Environment, University of Trás-os-Montes and Alto Douro, 5000-801 Vila Real, Portugal
| | - Gilberto Igrejas
- Department of Genetics and Biotechnology, School of Life Sciences and Environment, University of Trás-os-Montes and Alto Douro, 5000-801 Vila Real, Portugal; Functional Genomics and Proteomics Unit, University of Trás-os-Montes and Alto Douro (UTAD), Vila Real, Portugal; Associated Laboratory for Green Chemistry (LAQV-REQUIMTE), University NOVA of Lisboa, 1099-085 Lisboa, Portugal
| | - Sébastien Déjean
- Institut de Mathématiques de Toulouse, UMR5219, Université de Toulouse, CNRS, UPS, F-31062 Toulouse Cedex 9, France
| | - Catherine Ravel
- Université Clermont Auvergne, INRAE, UMR1095 GDEC, F-63000 Clermont-Ferrand, France.
| | - Emmanuelle Bancel
- Université Clermont Auvergne, INRAE, UMR1095 GDEC, F-63000 Clermont-Ferrand, France
| |
Collapse
|
3
|
Wang J, Liu C, Yang H, Li X, Hong J, Liu M, Sun B, Guan E, Zheng X. Impact of pre-meal immersion on multi-scale structural changes and starch digestibility of cooked dried noodles. Food Funct 2024; 15:3108-3121. [PMID: 38421019 DOI: 10.1039/d3fo04289h] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/02/2024]
Abstract
Pre-meal immersion is a common process for both the consumption of dried noodles and development of takeaway noodles, but its impact on the structure and digestibility of dried noodles is still unclear. In this study, dried noodles cooked for the optimal time were immersed at 80 °C for different time durations. Multi-scale structural changes, including texture, molecular structure, microstructure, and in vitro starch digestibility were studied using a combination of kinetic (first-order exponential decay function, the Peleg model, and LOS plots), physicochemical, and microscopic analysis. The relationship between multi-scale structural changes and starch digestibility was derived. As the immersion progressed, the hardness first rapidly decayed and then reached equilibrium. The decay rate in the initial stage depended on the gluten content. In most cases, the immersion process caused depolymerization of gluten proteins and further gelatinization of starch granules, which was observed from an increase in the free -SH content and decrease in the short-range ordered structure, although there were fluctuations over immersion time. Structural changes resulted in the corresponding changes in substance migration. However, a high gluten content (∼15% w/w) imparted a denser microstructure to the noodles, weakening the deterioration effects compared with a low gluten content (∼10% w/w). In vitro digestion experiments proved that samples with higher gluten content had higher starch digestion rates and lower starch digestion extent during immersion. Correlation analysis revealed that there was a negative correlation between k1 and the tightness of the gel. This study helps to reveal the structural mechanisms of starch digestibility in cooked noodles during immersion.
Collapse
Affiliation(s)
- Jiasheng Wang
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Chong Liu
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Hanrui Yang
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Xuedong Li
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Jing Hong
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Mei Liu
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Binghua Sun
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Erqi Guan
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| | - Xueling Zheng
- College of Food Science and Engineering, Henan University of Technology, Zhengzhou, 450001, P. R. China.
| |
Collapse
|
4
|
Yan Z, Liu J, Cao S, Wang Z, Li C, Ren J, Zhang R, Zhang M, Liu X. Substitution of sucrose by erythritol in angel cake: Effect on protein foaming, baking performance and digestion properties. Int J Biol Macromol 2023; 253:126759. [PMID: 37678696 DOI: 10.1016/j.ijbiomac.2023.126759] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/07/2023] [Revised: 08/29/2023] [Accepted: 09/04/2023] [Indexed: 09/09/2023]
Abstract
Sugars played an important role in the processing of products such as cakes, however, their high-calorie character often posed a health risk to consumers. Therefore, this paper aimed to better investigate the effect of sugar substitutes on the improvement of egg white foaming properties and angle cake digestibility characteristics. It was demonstrated that the addition of erythritol improved the surface properties of egg whites, thus enhancing their foaming properties. Particularly, when the erythritol substitution was 50 %, the sugar-egg white complex structure unfolded and had the best foaming capacity. On this basis, the baking performance of angel cakes with sucrose replaced by erythritol was analyzed. When the erythritol substitution was lower than 50 %, the specific volume and the baking loss rate of the cakes were basically unchanged, and the texture and sensory taste of the cakes were all excellent. Finally, the gastrointestinal digestive kinetic analysis suggested that erythritol substitution for sucrose was beneficial for reducing blood glucose levels in vivo. Furthermore, for the MgCl2-based samples, both the degree of protein destruction after digestion was weakened and the glucose-lowering effect was better exerted. Overall, this study provided a new theoretical basis for the low-calorie sugar-substituted health food products development in the future.
Collapse
Affiliation(s)
- Zhaohui Yan
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Jingbo Liu
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Sijia Cao
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Zhi Wang
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Chenman Li
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Jianqi Ren
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Renzhao Zhang
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Min Zhang
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China
| | - Xuanting Liu
- Jilin Provincial Key Laboratory of Nutrition and Functional Food, College of Food Science and Engineering, Jilin University, Changchun 130062, China.
| |
Collapse
|
5
|
Ramos Magalhães AE, Landim Neves MI, Dos Reis Gasparetto B, Oliveira Júnior FD, Ribas Fonseca L, Joy Steel C, Lopes da Cunha R. Organic acids in bread-making affecting gluten structure and digestibility. Food Res Int 2023; 174:113520. [PMID: 37986424 DOI: 10.1016/j.foodres.2023.113520] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/30/2023] [Revised: 09/23/2023] [Accepted: 09/26/2023] [Indexed: 11/22/2023]
Abstract
Although wheat gluten has remarkable technological properties, it can induce adverse immune reactions in susceptible individuals, such as wheat allergy and celiac disease. Technological processing and some additives on bread formulation can modify gluten physicochemical structure, but the knowledge about the impacts on the digestibility and immunogenicity of gluten is limited. The present study aimed to study the effect of adding organic acids (acetic or ascorbic) on dough rheological properties and bread technological characteristics. In addition, breads were subjected to in vitro digestion and the digesta were analyzed by confocal microscopy, SDS-PAGE and ELISA immunoassay. Acetic acid resulted in a decrease in dough development time up to 44 % and a reduction in stability up to 20 %. Ascorbic acid, present in vinegar, on the other hand, increased elastic modulus (G') and resistance to extension of dough. After the in vitro digestion, SDS-PAGE indicated that protein degradation started in the gastric phase, with the generation of low molecular weight peptides. Accordingly, ELISA immunoassay suggested a great reduction in immunogenic gliadin content from oral to gastric phase. At the end of the intestinal phase, samples with ascorbic acid did not differ from the control, while vinegar addition indicated a reduction in gluten immunogenicity with a reduction of about 44 % in immunogenic gliadin content compared to the control. Results show a window of opportunity in the modulation of wheat bread formulation with reduced allergenicity, while maintaining the technofunctional properties.
Collapse
Affiliation(s)
- Ana Elisa Ramos Magalhães
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil.
| | - Maria Isabel Landim Neves
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil
| | - Bruna Dos Reis Gasparetto
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil
| | - Fernando Divino Oliveira Júnior
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil
| | - Larissa Ribas Fonseca
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil
| | - Caroline Joy Steel
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil
| | - Rosiane Lopes da Cunha
- Department of Food Engineering and Technology, School of Food Engineering, University of Campinas (UNICAMP), 13083-862 Campinas, SP, Brazil
| |
Collapse
|
6
|
Ye L, Zheng W, Li X, Han W, Shen J, Lin Q, Hou L, Liao L, Zeng X. The Role of Gluten in Food Products and Dietary Restriction: Exploring the Potential for Restoring Immune Tolerance. Foods 2023; 12:4179. [PMID: 38002235 PMCID: PMC10670377 DOI: 10.3390/foods12224179] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/27/2023] [Revised: 11/16/2023] [Accepted: 11/17/2023] [Indexed: 11/26/2023] Open
Abstract
Wheat is extensively utilized in various processed foods due to unique proteins forming from the gluten network. The gluten network in food undergoes morphological and molecular structural changes during food processing, affecting the final quality and digestibility of the food. The present review introduces the formation of the gluten network and the role of gluten in the key steps of the production of several typical food products such as bread, pasta, and beer. Also, it summarizes the factors that affect the digestibility of gluten, considering that different processing conditions probably affect its structure and properties, contributing to an in-depth understanding of the digestion of gluten by the human body under various circumstances. Nevertheless, consumption of gluten protein may lead to the development of celiac disease (CD). The best way is theoretically proposed to prevent and treat CD by the inducement of oral tolerance, an immune non-response system formed by the interaction of oral food antigens with the intestinal immune system. This review proposes the restoration of oral tolerance in CD patients through adjunctive dietary therapy via gluten-encapsulated/modified dietary polyphenols. It will reduce the dietary restriction of gluten and help patients achieve a comprehensive dietary intake by better understanding the interactions between gluten and food-derived active products like polyphenols.
Collapse
Affiliation(s)
- Li Ye
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Wenyu Zheng
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
- School of Food Science and Engineering, South China University of Technology, Guangzhou 510640, China
| | - Xue Li
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Wenmin Han
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Jialing Shen
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Qiuya Lin
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Liyan Hou
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Lan Liao
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
| | - Xin’an Zeng
- Guangdong Key Laboratory of Intelligent Food Manufacturing, Foshan University, Foshan 528225, China; (L.Y.); (W.Z.); (X.L.); (W.H.); (J.S.); (Q.L.); (L.H.)
- Department of Food Science, Foshan University, Foshan 528000, China
- School of Food Science and Engineering, South China University of Technology, Guangzhou 510640, China
| |
Collapse
|
7
|
Schirmer T, Ludwig C, Scherf KA. Proteomic Characterization of Wheat Protein Fractions Taken at Different Baking Conditions. JOURNAL OF AGRICULTURAL AND FOOD CHEMISTRY 2023; 71:12899-12909. [PMID: 37582505 PMCID: PMC10473044 DOI: 10.1021/acs.jafc.3c02100] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/31/2023] [Revised: 06/22/2023] [Accepted: 07/26/2023] [Indexed: 08/17/2023]
Abstract
Food processing conditions affect the structure, solubility, and therefore accurate detection of gluten proteins. We investigated the influence of dough, bread, and pretzel making on the composition of different wheat protein fractions obtained by Osborne fractionation. The albumin/globulin, gliadin, and glutenin fractions from flour, dough, crispbread, bread, and pretzel were analyzed using RP-HPLC, SDS-PAGE, and untargeted nanoLC-MS/MS. This approach enabled an in-depth profiling of the fractionated proteomes and related compositional changes to processing conditions (mixing, heat, and alkali treatment). Overall, heat treatment demonstrated the most pronounced effect. Label-free quantitation revealed significant changes in the relative abundances of 82 proteins within the fractions of bread crumb and crust in comparison to flour. Certain gluten proteins showed shifts or reductions in particular fractions, indicating their incorporation into the gluten network through SS and non-SS cross-links. Other gluten proteins were enriched, suggesting their limited involvement in the gluten network formation.
Collapse
Affiliation(s)
- Tanja
Miriam Schirmer
- Leibniz-Institute
for Food Systems Biology at the Technical University of Munich, Lise-Meitner-Str. 34, 85354 Freising, Germany
| | - Christina Ludwig
- Bavarian
Center for Biomolecular Mass Spectrometry (BayBioMS), Technical University of Munich (TUM), Gregor-Mendel-Straße 4, 85354 Freising, Germany
| | - Katharina Anne Scherf
- Leibniz-Institute
for Food Systems Biology at the Technical University of Munich, Lise-Meitner-Str. 34, 85354 Freising, Germany
- Department
of Bioactive and Functional Food Chemistry, Institute of Applied Biosciences, Karlsruhe Institute of Technology (KIT), Adenauerring 20 a, 76131 Karlsruhe, Germany
| |
Collapse
|
8
|
Schirmer TM, Scherf KA. Influence of baking conditions on the extractability and immunochemical detection of wheat gluten proteins. Curr Res Food Sci 2022; 6:100431. [PMID: 36636725 PMCID: PMC9829696 DOI: 10.1016/j.crfs.2022.100431] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/27/2022] [Revised: 12/21/2022] [Accepted: 12/28/2022] [Indexed: 12/31/2022] Open
Abstract
Food processing conditions affect the accurate detection of gluten by ELISA, which is of importance for proper gluten-free labelling. We prepared different wheat flour-based and incurred baked goods (bread, crispbread, pretzel) to investigate the influence of baking conditions and alkali treatment on gluten quantitation by ELISA using different extraction solvents. Protein composition and extractability were determined (SDS-PAGE, RP-HPLC, GP-HPLC). The extraction solvents showed different performances; none of them could compensate the effect of baking on the detection. Dough preparation, baking and additional alkali treatment decreased protein extractability under reducing and non-reducing conditions. High temperature combined with alkali treatment resulted in the lowest protein extractabilities (<77% for bread crust, <61% for pretzel crust) due to the formation of disulfide and non-disulfide gluten crosslinks. There was no clear correlation between the protein composition and the extractability of alcohol- and SDS-soluble proteins of the baked goods. Thus, this research shows that gluten extractability rather than gluten composition is crucial for detection by ELISA in baked goods.
Collapse
Affiliation(s)
- Tanja Miriam Schirmer
- Leibniz-Institute for Food Systems Biology at the Technical University of Munich, Lise-Meitner-Str. 34, 85354 Freising, Germany
| | - Katharina Anne Scherf
- Leibniz-Institute for Food Systems Biology at the Technical University of Munich, Lise-Meitner-Str. 34, 85354 Freising, Germany,Department of Bioactive and Functional Food Chemistry, Institute of Applied Biosciences, Karlsruhe Institute of Technology (KIT), Adenauerring 20 a, 76131, Karlsruhe, Germany,Corresponding author. Karlsruhe Institute of Technology (KIT), Adenauerring 20 a, 76131, Karlsruhe, Germany. https://bioactivefc.iab.kit.edu
| |
Collapse
|
9
|
Wang R, Mohammadi M, Mahboubi A, Taherzadeh MJ. In-vitro digestion models: a critical review for human and fish and a protocol for in-vitro digestion in fish. Bioengineered 2021; 12:3040-3064. [PMID: 34187302 PMCID: PMC8806420 DOI: 10.1080/21655979.2021.1940769] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/07/2021] [Accepted: 06/04/2021] [Indexed: 10/28/2022] Open
Abstract
Digestive systems in human, animals, and fish are biological reactors and membranes to digest food and extract nutrients. Therefore, static and dynamic models of in-vitro digestion systems are developed to study e.g. novel food and feed before in-vivo studies. Such models are well developed for human, but not to the same extent for animals and fish. On the other hand, recent advances in aquaculture nutrition have created several potential fish meal replacements, and the assessment of their nutrient digestibility is critical in the application as a fish meal replacement. Using an in-vitro method, the assessment of an ingredient digestibility could be faster and less expensive compared to using an in-vivo experiment. An in-vitro method has been widely used to assess food nutrient digestibility for humans; however, its application for fish is still in the early stages. Both the human and fish as monogastric vertebrates share similar gastrointestinal systems; thus, the concept from the application for humans could be applied for fish. This review aims to improve the in-vitro digestion protocol for fish by adapting the concept from then study for humans, summarizing the current available in-vitro digestion model developed for human and fish in-vitro digestion study, identifying challenges specifically for fish required to be tackled and suggesting an engineering approach to adapt the human in-vitro gastrointestinal model to fish. Protocols to conduct in-vitro digestion study for fish are then proposed.
Collapse
Affiliation(s)
- Ricky Wang
- Swedish Centre for Resource Recovery, University of Borås, Borås. Sweden
| | - Mahtab Mohammadi
- Swedish Centre for Resource Recovery, University of Borås, Borås. Sweden
| | - Amir Mahboubi
- Swedish Centre for Resource Recovery, University of Borås, Borås. Sweden
| | | |
Collapse
|