1
|
Corrêa-Filho LC, Santos Junior JRD, Ramos AV, Martinazzo AP, Habert AC, Carvalho CWPD, Soares AG, Tonon RV, Cabral LMC. Chitosan-based nanocomposite films with carnauba wax, rosin resin, and zinc oxide nanoparticles. Food Res Int 2024; 188:114475. [PMID: 38823838 DOI: 10.1016/j.foodres.2024.114475] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/17/2023] [Revised: 03/19/2024] [Accepted: 05/07/2024] [Indexed: 06/03/2024]
Abstract
This work aimed to develop edible emulsion-based barriers in the form of chitosan composite films, with a focus on assessing the impacts of carnauba wax, rosin resin, and zinc oxide nanoparticles on their properties. Six films were produced by casting using chitosan as polymer base and glycerol as plasticizer. Acetic acid and polysorbate 80 were also used to facilitate the dissolution and mixing of the components. The six filmogenic solutions contained chitosan at 1.2% w/v, wax or resin content with 0 or 0.6% m/v and ZnO with 0 or 0.05% m/v. The dried films were characterized according to their chemical, barrier, mechanical, thermal and optical properties. All treatments resulted in flexible films. Chitosan films appeared smoother and more uniform under SEM imaging, while carnauba wax films displayed roughness due to their hydrophobic nature. Wax and resin films were less transparent and water soluble than the chitosan-only films. On the other hand, the addition of ZnO in the formulations increased the solubility of the films. The sorption degree was in line with the solubility results, i.e., films with ZnO presented higher sorption degree and solubility values. All treatments showed low or non-light UV transmission, indicating that the films provide good barrier to UV light. In the visible light region, films of resin with ZnO showed the lowest transmittance values, hence offering a good barrier to visible light. Among the evaluated films, chitosan, and resin films with ZnO nanoparticles were more rigid and resistant to deformation. Overall, films produced with rosin resin and ZnO nanoparticles showed potential improvements in barrier, mechanical, thermal, and optical properties, mainly due to their low water solubility, good UV protection and low permeability to water vapor and oxygen, which are suitable for using in formulations, intended to produce edible films and coatings.
Collapse
Affiliation(s)
| | | | - Andresa Viana Ramos
- Nanotechnology Engineering Program, COPPE, Federal University of Rio de Janeiro, 21941-972 Rio de Janeiro, RJ, Brazil
| | - Ana Paula Martinazzo
- Department of Agribusiness Engineering, Federal Fluminense University, 27255-125 Volta Redonda, RJ, Brazil
| | - Alberto Claudio Habert
- Nanotechnology Engineering Program, COPPE, Federal University of Rio de Janeiro, 21941-972 Rio de Janeiro, RJ, Brazil; Chemical Engineering Program, COPPE, Federal University of Rio de Janeiro, 21941-972 Rio de Janeiro, RJ, Brazil
| | | | | | | | | |
Collapse
|
2
|
de Souza Grilo MM, Schaffner DW, Tavares da Silva R, Saraiva KLA, Carvalho RDSF, Bovo F, de Souza Pedrosa GT, Magnani M. Ozone and photodynamic inactivation of norovirus surrogate bacteriophage MS2 in fresh Brazilian berries and surfaces. Food Microbiol 2024; 119:104453. [PMID: 38225042 DOI: 10.1016/j.fm.2023.104453] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/19/2023] [Revised: 12/13/2023] [Accepted: 12/18/2023] [Indexed: 01/17/2024]
Abstract
This study assessed the efficacy of ozone (bubble diffusion in water; 6.25 ppm) and photodynamic inactivation (PDT) using curcumin (75 μM) as photosensitizer (LED emission 430-470 nm; 33.6 mW/cm2 irradiance; 16.1, 20.2, and 24.2 J/cm2 light dose) against the Norovirus surrogate bacteriophage MS2 in Brazilian berries (black mulberry and pitanga) and surfaces (glass and stainless steel). Contaminated berries and surfaces were immersed in ozonized water or exposed to PDT-curcumin for different time intervals. Transmission electron microscopy was used to assess the effects of the treatments on MS2 viral particles. The MS2 inactivation by ozone and PDT-curcumin varied with the fruit and the surface tested. Ozone reduced the MS2 titer up to 3.6 log PFU/g in black mulberry and 4.1 log PFU/g in pitanga. On surfaces, the MS2 reduction by ozone reached 3.6 and 4.8 log PFU/cm2 on glass and stainless steel, respectively. PDT-curcumin reduced the MS2 3.2 and 4.8 log PFU/g in black mulberry and pitanga and 2.7 and 3.3 log PFU/cm2 on glass and stainless steel, respectively. MS2 particles were disintegrated by exposure of MS2 to ozone and PDT-curcumin on pitanga. Results can contribute to establishing effective practices for controlling NoV in fruits and surfaces, estimated based on MS2 bacteriophage behavior.
Collapse
Affiliation(s)
- Maria Mayara de Souza Grilo
- Laboratory of Microbial Processes in Foods, Department of Food Engineering, Technology Center, Federal University of Paraíba, Campus I, 58051-900, João Pessoa, Brazil
| | - Donald W Schaffner
- Department of Food Science, Rutgers, The State University of New Jersey, 65 Dudley Road, New Brunswick, NJ 08901, USA
| | - Ruthchelly Tavares da Silva
- Laboratory of Microbial Processes in Foods, Department of Food Engineering, Technology Center, Federal University of Paraíba, Campus I, 58051-900, João Pessoa, Brazil
| | | | | | - Fernanda Bovo
- Uniararas - Hermínio Ometto Foundation University Center, Av. Dr. Maximiliano Baruto, 500, 13607-339, Araras, São Paulo, Brazil
| | - Geany Targino de Souza Pedrosa
- Laboratory of Microbial Processes in Foods, Department of Food Engineering, Technology Center, Federal University of Paraíba, Campus I, 58051-900, João Pessoa, Brazil
| | - Marciane Magnani
- Laboratory of Microbial Processes in Foods, Department of Food Engineering, Technology Center, Federal University of Paraíba, Campus I, 58051-900, João Pessoa, Brazil.
| |
Collapse
|
3
|
Chen N, Wei W, Yang Y, Chen L, Shan W, Chen J, Lu W, Kuang J, Wu C. Postharvest Physiology and Handling of Guava Fruit. Foods 2024; 13:805. [PMID: 38472918 DOI: 10.3390/foods13050805] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/02/2024] [Revised: 02/27/2024] [Accepted: 03/04/2024] [Indexed: 03/14/2024] Open
Abstract
Guavas are typical tropical fruit with high nutritional and commercial value. Because of their thin skin and high metabolic rate, guavas are highly susceptible to water loss, physical damage, and spoilage, severely limiting their shelf-life. Guavas can typically only be stored for approximately one week at room temperature, making transportation, storage, and handling difficult, resulting in low profit margins in the industry. This review focuses on the physiological and biochemical changes and their molecular mechanisms which occur in postharvest guavas, and summarizes the various management strategies for extending the shelf-life of these sensitive fruits by means of physical and chemical preservation and their combinations. This review also suggests future directions and reference ideas for the development of safe and efficient shelf-life extension techniques.
Collapse
Affiliation(s)
- Nanhui Chen
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Wei Wei
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Yingying Yang
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Lin Chen
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Wei Shan
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Jianye Chen
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Wangjin Lu
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Jianfei Kuang
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| | - Chaojie Wu
- State Key Laboratory for Conservation and Utilization of Subtropical Agro-Bioresources/Guangdong Provincial Key Laboratory of Postharvest Science of Fruits and Vegetables/Engineering Research Center of Southern Horticultural Products Preservation, Ministry of Education, College of Horticulture, South China Agricultural University, Guangzhou 510642, China
| |
Collapse
|
4
|
Bajaj K, Kumar A, Gill PPS, Jawandha SK, Kaur N. Xanthan gum coatings augmented with lemongrass oil preserve postharvest quality and antioxidant defence system of Kinnow fruit under low-temperature storage. Int J Biol Macromol 2024; 262:129776. [PMID: 38281532 DOI: 10.1016/j.ijbiomac.2024.129776] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/28/2023] [Revised: 01/20/2024] [Accepted: 01/24/2024] [Indexed: 01/30/2024]
Abstract
Kinnow mandarin is an important citrus fruit that undergoes various postharvest qualitative losses. Therefore, the present study aimed to investigate the effect of polysaccharide-based xanthan gum (XG) coatings and lemongrass essential oil (LG) on the nutritive quality of Kinnow mandarins stored at 5-7 °C, 90-95 % RH for 75 days. The results revealed that in comparison to control the coatings maintained the fruit titratable acidity (TA), soluble solid content (SSC), ascorbic acid (AsA) content, total flavonoid content (TFC), and juice content, along with reduced weight loss and spoilage incidence. The coated fruits also exhibited higher sensory quality, total antioxidant activity (TAA), and activities of enzymes; catalase (CAT), peroxidase (POD), and phenylalanine ammonia-lyase (PAL). At the end of storage, the fruits coated with XG 1.0 % + LG 1.0 % exhibited maximum TA (0.69 %), AsA content (203.5 mg L-1), and TFC (0.21 mg g-1) with minimum weight loss (7.57 %) and spoilage (3.01 %) and SSC (11.87 %). The scanning electron microscopic (SEM) images of the coated fruits also exhibited smooth surfaces with closed stomata pores. Overall, XG 1.0 % + LG 1.0 % proved as a potential postharvest treatment for maintaining the nutritive quality of Kinnow under low-temperature storage.
Collapse
Affiliation(s)
- Kashish Bajaj
- Department of Fruit Science, Punjab Agricultural University, Ludhiana, Punjab, India.
| | - Anil Kumar
- Regional Research Station, Abohar, Punjab Agricultural University, Ludhiana, Punjab, India
| | - P P S Gill
- Department of Fruit Science, Punjab Agricultural University, Ludhiana, Punjab, India
| | - S K Jawandha
- Department of Fruit Science, Punjab Agricultural University, Ludhiana, Punjab, India
| | - Nirmaljit Kaur
- Department of Botany, Punjab Agricultural University, Ludhiana, Punjab, India
| |
Collapse
|
5
|
Singh AK. Recent advancements in polysaccharides, proteins and lipids based edible coatings to enhance guava fruit shelf-life: A review. Int J Biol Macromol 2024; 262:129826. [PMID: 38296124 DOI: 10.1016/j.ijbiomac.2024.129826] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/05/2023] [Revised: 01/22/2024] [Accepted: 01/27/2024] [Indexed: 02/13/2024]
Abstract
Fresh fruits are highly needed for the health benefits of human beings because of the presence of high content of natural nutrition in the form of vitamins, minerals, antioxidants, and other phenolic compounds. However, some nutritional fruits such as guava are climacteric in nature with very less post-harvest shelf-life because of the ripening in a very short period and possibility of microbial infections. Thus security of natural nutrients is a serious concern in order to properly utilize guava without generating a huge amount of waste. Among reported various methods for the enhancement of fruits shelf-life, the application of edible coatings with antimicrobial activities on the outer surface of fruits have attracted significant attention because of their eco-friendly nature, easy applicability, high efficacy, and good durability. In recent years, researchers are paying more and more attention in the development of antimicrobial edible coatings to enhance the post-harvest shelf-life of guava using polysaccharides, protein and lipids. In this review, basic approaches and recent advancements in development of antimicrobial and edible coatings on guava fruit by the application of polysaccharides and protein and lipids along with the combination of nanomaterials are summarized. In addition, improvements in basic properties of edible coatings to significantly control the permeation of gases (O2/CO2) by the optimization of coating components as well as delay in ripening process are reviewed and discussed.
Collapse
Affiliation(s)
- Arun K Singh
- Department of Chemistry, M. M. Engineering College, Maharishi Markandeshwar (Deemed to be University), Mullana, Ambala, Haryana 133207, India.
| |
Collapse
|
6
|
Nur Hanani Z, Soo K, Zunairah WW, Radhiah S. Prolonging the shelf life of fresh-cut guava ( Psidium guajaya L.) by coating with chitosan and cinnamon essential oil. Heliyon 2023; 9:e22419. [PMID: 38107314 PMCID: PMC10724538 DOI: 10.1016/j.heliyon.2023.e22419] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/13/2023] [Revised: 11/07/2023] [Accepted: 11/12/2023] [Indexed: 12/19/2023] Open
Abstract
This study investigated the effect of a coating of chitosan (CH) and cinnamon essential oil (CEO; 0-1 %) on the quality attributes of fresh-cut guava (Psidium guajaya L.) during storage at 4 ± 1 °C for 17 days, with uncoated fresh-cut guava used as control. The CH coating significantly (p < 0.05) delayed changes in weight loss, firmness, colour, total soluble solids and titratable acidity compared to the control sample. Furthermore, the effects were more prominent with the incorporation of higher CEO concentrations. The bacterial, yeast and mould counts were also significantly lower (p < 0.05) in the CH-coated samples than in the control, with the coating containing 1 % CEO exhibiting the best quality preservation effect. In addition, CH and CEO coatings extended the shelf life of fresh-cut guava up to 17 days compared to the control sample (shelf life of only 3 days). In conclusion, combining CH and CEO as a coating matrix effectively preserves the quality and enhances fresh-cut guava's shelf life.
Collapse
Affiliation(s)
- Z.A. Nur Hanani
- Department of Food Technology, Faculty of Food Science and Technology, Universiti Putra Malaysia, 43400, UPM, Serdang, Selangor, Malaysia
- Halal Products Research Institute, Universiti Putra Malaysia, 43400, UPM, Serdang, Selangor, Malaysia
| | - K.L. Soo
- Department of Food Technology, Faculty of Food Science and Technology, Universiti Putra Malaysia, 43400, UPM, Serdang, Selangor, Malaysia
| | - W.I. Wan Zunairah
- Department of Food Science, Faculty of Food Science and Technology, Universiti Putra Malaysia, 43400 UPM, Serdang, Selangor, Malaysia
| | - S. Radhiah
- Department of Food Technology, Faculty of Food Science and Technology, Universiti Putra Malaysia, 43400, UPM, Serdang, Selangor, Malaysia
| |
Collapse
|
7
|
Mou L, Lu Y, Zhang J, Bilal M, Li J, Li G. Sodium alginate coating of Ginkgo biloba leaves extract containing phenylpropanoids as an ecofriendly preserving agent to maintain the quality of peach fruit. J Food Sci 2023; 88:3649-3665. [PMID: 37477272 DOI: 10.1111/1750-3841.16708] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/18/2023] [Revised: 06/23/2023] [Accepted: 06/30/2023] [Indexed: 07/22/2023]
Abstract
Plant constituents are of great interest in the food processing industry as potential natural preservative agents for controlling foodborne pathogens. In this study, the 95% EtOH/H2 O extract of Ginkgo biloba leaves was separated using polarity extraction solvents with petroleum ether (PE), ethyl acetate (EA), n-butanol (nB), and water (W) by the principle of similarity and compatibility. Through TLC and NMR analysis of these extracts, it can be concluded that the main component of PE extract were organic acids, for EA extract were flavonoids, for nB extract were phenylpropanoids, and water extract were oligosaccharides. Twelve monomer compounds were separated from the extracts to verify the composition of each extraction stage. Results of morphological and molecular identification revealed that Monilinia fructicola and Rhizopus stolonifer were the main fungi causing peach rot. After evaluating the antifungal activity and peach quality of the four extract/sodium alginate coatings, it was found that the n-butanol extract/sodium alginate coating containing phenylpropanoids had the lowest decay index and the best preservation effect, providing a sustainable alternative to reduce the harm to the environment of synthetic preservatives. PRACTICAL APPLICATION: The abuse of synthetic preservatives poses a threat to the ecological environment and physical health. Therefore, this study developed sodium alginate coating of Ginkgo biloba leaves extract containing phenylpropanoids, which has good effects on the preservation of peaches. The agent is a promising environmentally friendly alternative for synthetic preservatives.
Collapse
Affiliation(s)
- Linyun Mou
- College of Biotechnology, Tianjin University of Science and Technology, Tianjin, P. R. China
- School of Life Sciences, Nanjing University, Nanjing, P. R. China
| | - Ya Lu
- School of Pharmaceutical Science and Technology, Tianjin University, Tianjin, P. R. China
| | - Jin Zhang
- College of Biotechnology, Tianjin University of Science and Technology, Tianjin, P. R. China
| | - Muhammad Bilal
- College of Biotechnology, Tianjin University of Science and Technology, Tianjin, P. R. China
| | - Jianlong Li
- School of Life Sciences, Nanjing University, Nanjing, P. R. China
| | - Ganpeng Li
- Key Laboratory of Chemistry in Ethnic Medicinal Resources, State Ethnic Affairs Commission and Ministry of Education, Yunnan Minzu University, Kunming, P. R. China
| |
Collapse
|
8
|
Peralta-Ruiz Y, Rossi C, Grande-Tovar CD, Chaves-López C. Green Management of Postharvest Anthracnose Caused by Colletotrichum gloeosporioides. J Fungi (Basel) 2023; 9:623. [PMID: 37367558 DOI: 10.3390/jof9060623] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/11/2023] [Revised: 05/14/2023] [Accepted: 05/17/2023] [Indexed: 06/28/2023] Open
Abstract
Fruits and vegetables are constantly affected by postharvest diseases, of which anthracnose is one of the most severe and is caused by diverse Colletotrichum species, mainly C. gloeosporioides. In the last few decades, chemical fungicides have been the primary approach to anthracnose control. However, recent trends and regulations have sought to limit the use of these substances. Greener management includes a group of sustainable alternatives that use natural substances and microorganisms to control postharvest fungi. This comprehensive review of contemporary research presents various sustainable alternatives to C. gloeosporioides postharvest control in vitro and in situ, ranging from the use of biopolymers, essential oils, and antagonistic microorganisms to cultivar resistance. Strategies such as encapsulation, biofilms, coatings, compounds secreted, antibiotics, and lytic enzyme production by microorganisms are revised. Finally, the potential effects of climate change on C. gloeosporioides and anthracnose disease are explored. Greener management can provide a possible replacement for the conventional approach of using chemical fungicides for anthracnose postharvest control. It presents diverse methodologies that are not mutually exclusive and can be in tune with the needs and interests of new consumers and the environment. Overall, developing or using these alternatives has strong potential for improving sustainability and addressing the challenges generated by climate change.
Collapse
Affiliation(s)
- Yeimmy Peralta-Ruiz
- Programa de Ingeniería Agroindustrial, Facultad de Ingeniería, Universidad del Atlántico, Puerto Colombia 081008, Colombia
| | - Chiara Rossi
- Faculty of Bioscience and Technology for Food, Agriculture and Environment, University of Teramo, 64100 Teramo, Italy
| | - Carlos David Grande-Tovar
- Grupo de Investigación de Fotoquímica y Fotobiología, Universidad del Atlántico, Carrera 30 Número 8-49, Puerto Colombia 081008, Colombia
| | - Clemencia Chaves-López
- Faculty of Bioscience and Technology for Food, Agriculture and Environment, University of Teramo, 64100 Teramo, Italy
| |
Collapse
|
9
|
Shan Y, Li T, Qu H, Duan X, Farag MA, Xiao J, Gao H, Jiang Y. Nano‐preservation: An emerging postharvest technology for quality maintenance and shelf life extension of fresh fruit and vegetable. FOOD FRONTIERS 2023. [DOI: 10.1002/fft2.201] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/09/2023] Open
Affiliation(s)
- Youxia Shan
- Guangdong Provincial Key Laboratory of Applied Botany & Key Laboratory of South China Agricultural Plant Molecular Analysis and Genetic Improvement Core Botanical Gardens, South China Botanical Garden, Chinese Academy of Sciences Guangzhou China
| | - Taotao Li
- Guangdong Provincial Key Laboratory of Applied Botany & Key Laboratory of South China Agricultural Plant Molecular Analysis and Genetic Improvement Core Botanical Gardens, South China Botanical Garden, Chinese Academy of Sciences Guangzhou China
| | - Hongxia Qu
- Guangdong Provincial Key Laboratory of Applied Botany & Key Laboratory of South China Agricultural Plant Molecular Analysis and Genetic Improvement Core Botanical Gardens, South China Botanical Garden, Chinese Academy of Sciences Guangzhou China
| | - Xuewu Duan
- Guangdong Provincial Key Laboratory of Applied Botany & Key Laboratory of South China Agricultural Plant Molecular Analysis and Genetic Improvement Core Botanical Gardens, South China Botanical Garden, Chinese Academy of Sciences Guangzhou China
| | - Mohamed A. Farag
- Pharmacognosy Department, College of Pharmacy Cairo University Giza Egypt
| | - Jianbo Xiao
- Department of Analytical and Food Chemistry, Faculty of Sciences Universidade de Vigo Vigo Spain
| | - Haiyan Gao
- Key Laboratory of Postharvest Handing of Fruits of Ministry of Agriculture and Rural Affairs, Food Science Institute Zhejiang Academy of Agricultural Sciences Hangzhou China
| | - Yueming Jiang
- Guangdong Provincial Key Laboratory of Applied Botany & Key Laboratory of South China Agricultural Plant Molecular Analysis and Genetic Improvement Core Botanical Gardens, South China Botanical Garden, Chinese Academy of Sciences Guangzhou China
- College of Advanced Agricultural Sciences University of Chinese Academy of Sciences Beijing China
| |
Collapse
|
10
|
Van PTH, Ngoc LS, Hung TN, Manh TD. Effects of chitosan and nano-SiO2 concentrations on the quality of postharvest guavas (Psidium guajava L.). INTERNATIONAL FOOD RESEARCH JOURNAL 2022. [DOI: 10.47836/ifrj.29.6.20] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
Abstract
Guava (Psidium guajava L.) is a perishable fruit susceptible to postharvest losses at tropical ambient temperature. Therefore, the development of green storage solution such as biodegradable film could be an alternative to increase guavas’ shelf life. The primary objective of the present work was to explore the effects of combining chitosan and nano-SiO2 coating at different concentrations on the external and internal quality parameters of guavas during 12-d storage at 15°C, and 8-d storage at 30°C. Weight loss, skin colour, firmness, ascorbic acid content, total soluble solids (TSS), decay incidence, and sensory taste score during storage were also analysed. Guavas coated with 2% chitosan and 0.02% nano-SiO2 film were economically optimum to maintain the tested postharvest quality parameters, including better skin colour, higher TSS, fruit firmness, ascorbic acid content, and good taste scores, while keeping lower weight loss and decay incidence when compared with those of other treatments at both tested temperatures. Therefore, chitosan and nano-SiO2 as a coating is a promising strategy for improving the postharvest quality of guavas.
Collapse
|
11
|
Valorisation of lemongrass essential oils onto chitosan-starch film for sustainable active packaging: Greatly enhanced antibacterial and antioxidant activity. Int J Biol Macromol 2022; 210:669-681. [PMID: 35513102 DOI: 10.1016/j.ijbiomac.2022.04.223] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/25/2022] [Revised: 04/12/2022] [Accepted: 04/28/2022] [Indexed: 11/20/2022]
Abstract
To meet the global demand for sustainability aspects, the past few decades have witnessed magnificent evidence in the pursuit of sustainable active food packaging. As part of our contribution, herein, we explored the utilization of chitosan (Ch) modified with Dioscorea hispida (Dh) starch and incorporated with lemongrass essential oil (LO) as an attempt to obtain a novel active packaging formulation of Ch/Dh/LO in food. To obtain the optimum formulation of Ch/Dh/LO, 15 experiments were designed using the Box-Behnken design (BBD) with Ch (1-2% w/v), Dh starch (0.5-1.5% w/v) and LO (0.25-0.75% v/v) against E. coli, S. typhi, S. aureus and S. epidermidis bacteria. The presence of LO caused enhancements in physical, mechanical, and thermal stability, along with the antimicrobial, and antioxidant activity. Additionally, molecular docking and molecular dynamic (MD) simulations of the active compounds in LO against the active site of the FtsA enzyme were provided to unveil the mechanism of antibacterial action. Ultimately, this result suggests hydrogen bonds and hydrophobic interactions are involved between the active compounds in LO and FtsA enzymes. In general, this research provides valuable information that sheds light on the pivotal role of LO in enhancing the mechanical, thermal, and biological properties of sustainable active food packaging-based Ch film.
Collapse
|
12
|
Zhang Y, Li C, Fu X, Ma N, Bao X, Liu H. Characterization of a novel starch-based foam with a tunable release of oxygen. Food Chem 2022; 389:133062. [PMID: 35504075 DOI: 10.1016/j.foodchem.2022.133062] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/11/2021] [Revised: 03/11/2022] [Accepted: 04/21/2022] [Indexed: 11/04/2022]
Abstract
Here, we used techniques of extrusion and coating to produce starch-based foams with a combined function of buffering and controlled release of oxygen. The foams presented open-cell structures and showed a compression recovery ratio of 94%. After coating with poly(vinyl alcohol) solution, in which calcium peroxides were loaded, the developed functional foams showed a behavior of controllable oxygen release under a wet condition, as well as a high compression strength (≥2.2 MPa). Also, these foams showed an improved moisture resistance with a reduction in maximum moisture absorption from 25 to 14%. Under a vibrated storage condition to simulate food transportation, guavas packaged with functional foams showed a reduced physical damage, and browning index from 5.00 to 2.97, owing to the foams' superior buffering ability and self-regulation of storage atmosphere. The functional packaging system of the starch-based foams developed in our work is promising for fruit and vegetable preservations.
Collapse
Affiliation(s)
- Yue Zhang
- SCUT-Zhuhai Institute of Modern Industrial Innovation, School of Food Science and Engineering, South China University of Technology, Guangzhou, China
| | - Chao Li
- SCUT-Zhuhai Institute of Modern Industrial Innovation, School of Food Science and Engineering, South China University of Technology, Guangzhou, China
| | - Xiong Fu
- SCUT-Zhuhai Institute of Modern Industrial Innovation, School of Food Science and Engineering, South China University of Technology, Guangzhou, China
| | - Nan Ma
- SCUT-Zhuhai Institute of Modern Industrial Innovation, School of Food Science and Engineering, South China University of Technology, Guangzhou, China
| | - Xianyang Bao
- SCUT-Zhuhai Institute of Modern Industrial Innovation, School of Food Science and Engineering, South China University of Technology, Guangzhou, China; John A. Paulson School of Engineering and Applied Science, Kavli Institute for Nanobio Science and Technology, Harvard University, Cambridge, MA 02138, USA.
| | - Hongsheng Liu
- SCUT-Zhuhai Institute of Modern Industrial Innovation, School of Food Science and Engineering, South China University of Technology, Guangzhou, China; Overseas Expertise Introduction Center for Discipline Innovation of Food Nutrition and Human Health, Guangzhou, China; State Key Laboratory of Pulp and Paper Engineering, South China University of Technology, Guangzhou, China.
| |
Collapse
|
13
|
Wang H, Zhang Z, Dong Y, Wang Y. Effect of chitosan coating incorporated with Torreya grandis essential oil on the quality and physiological attributes of loquat fruit. JOURNAL OF FOOD MEASUREMENT AND CHARACTERIZATION 2022. [DOI: 10.1007/s11694-022-01391-5] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
|
14
|
Yadav A, Kumar N, Upadhyay A, Fawole OA, Mahawar MK, Jalgaonkar K, Chandran D, Rajalingam S, Zengin G, Kumar M, Mekhemar M. Recent Advances in Novel Packaging Technologies for Shelf-Life Extension of Guava Fruits for Retaining Health Benefits for Longer Duration. PLANTS 2022; 11:plants11040547. [PMID: 35214879 PMCID: PMC8879830 DOI: 10.3390/plants11040547] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 01/25/2022] [Revised: 02/12/2022] [Accepted: 02/14/2022] [Indexed: 11/16/2022]
Abstract
Guava (Psidium guajava L.) fruit is also known as the apple of tropics, belongs to the family of genus Psidium, and is widely cultivated in tropical zones of the world. Recently, the importance of guava fruit has increased due to its inherent nutritional content, pleasant aroma, excellent flavor, and delicious taste. It is considered an excellent source of nutrients and phytochemicals. Guava is a climacteric fruit that continues to mature or ripen even after harvest, showing an increase in the rate of respiration and metabolic activities within a short period, leading to rapid senescence or spoilage of fruit. It has limitations in terms of commercialization due to short storage life after harvest and sensitivity to diseases and chilling injury during the storage period. Many postharvest technologies such as edible packaging, modified atmosphere packaging (MAP), composite packaging, controlled atmosphere packaging (CAP), antimicrobial/antifungal packaging, and nano packaging have been used to retard the chilling injury and enhance the keeping quality of guava fruits during the storage period to control respiration rate, reduce weight loss, minimize lipid oxidation, and maintain organoleptic properties. However, these packaging technologies have varied effects on the internal and external quality attributes of guava fruits. This review, therefore, discusses the physiology, mechanism of ripening, oxidation, and ethylene production of guava fruits. The review also discusses the packaging technologies and their effect on the postharvest characteristics of guava fruits during the storage period.
Collapse
Affiliation(s)
- Ajay Yadav
- Agro Produce Processing Division, ICAR—Central Institute of Agricultural Engineering, Bhopal 462038, India;
- Department of Food Science and Technology, National Institute of Food Technology Entrepreneurship and Management, Sonepat 131028, India;
| | - Nishant Kumar
- Department of Food Science and Technology, National Institute of Food Technology Entrepreneurship and Management, Sonepat 131028, India;
| | - Ashutosh Upadhyay
- Department of Food Science and Technology, National Institute of Food Technology Entrepreneurship and Management, Sonepat 131028, India;
- Correspondence: (A.U.); (M.K.); (M.M.)
| | - Olaniyi Amos Fawole
- Postharvest Research Laboratory, Department of Botany and Plant Biotechnology, University of Johannesburg, Auckland Park, Johannesburg P.O. Box 524, South Africa;
| | - Manoj Kumar Mahawar
- Technology Transfer Division, ICAR—Central Institute for Research on Cotton Technology, Mumbai 400019, India;
| | - Kirti Jalgaonkar
- Quality Evaluation and Improvement Division, ICAR—Central Institute for Research on Cotton Technology, Mumbai 400019, India;
| | - Deepak Chandran
- Department of Veterinary Sciences and Animal Husbandry, Amrita School of Agricultural Sciences, Amrita Vishwa Vidyapeetham University, Coimbatore 642109, India;
| | - Sureshkumar Rajalingam
- Department of Agronomy, Amrita School of Agricultural Sciences, Amrita Vishwa Vidyapeetham University, Coimbatore 642109, India;
| | - Gokhan Zengin
- Physiology and Biochemistry Research Laboratory, Department of Biology, Science Faculty, Selcuk University, Konya 42130, Turkey;
| | - Manoj Kumar
- Chemical and Biochemical Processing Division, ICAR—Central Institute for Research on Cotton Technology, Mumbai 400019, India
- Correspondence: (A.U.); (M.K.); (M.M.)
| | - Mohamed Mekhemar
- Clinic for Conservative Dentistry and Periodontology, School of Dental Medicine, Christian-Albrecht’s University, 24105 Kiel, Germany
- Correspondence: (A.U.); (M.K.); (M.M.)
| |
Collapse
|
15
|
Role of plant extracts and essential oils in fighting against postharvest fruit pathogens and extending fruit shelf life: A review. Trends Food Sci Technol 2022. [DOI: 10.1016/j.tifs.2022.01.009] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/24/2022]
|
16
|
Antibacterial chitosan-Dioscorea alata starch film enriched with essential oils optimally prepared by following response surface methodology. FOOD BIOSCI 2022. [DOI: 10.1016/j.fbio.2022.101603] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022]
|
17
|
Fernandes KFD, de Oliveira KÁR, de Souza EL. Application of Potentially Probiotic Fruit-Derived Lactic Acid Bacteria Loaded into Sodium Alginate Coatings to Control Anthracnose Development in Guava and Mango During Storage. Probiotics Antimicrob Proteins 2021; 15:573-587. [PMID: 34755278 DOI: 10.1007/s12602-021-09871-8] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Accepted: 11/02/2021] [Indexed: 11/28/2022]
Abstract
This study evaluated the efficacy of potentially probiotic fruit-derived lactic acid bacteria (LAB) strains loaded into sodium alginate (SA) coatings to control the anthracnose development in guava cv. Paluma and mango cv. Palmer caused by distinct pathogenic Colletotrichum species (C. asianum, C. fructicola, C. tropicale, C. siamense, C. karstii, and C. gloeosporioides) during 15 days of room temperature storage (25 ± 0.5 °C). The effects of the formulated coatings on physicochemical parameters indicative of overall postharvest quality of guava and mango were evaluated. The eight examined LAB strains caused strong inhibition on the mycelial growth of all target Colletotrichum species in vitro. LAB strains with the highest inhibitory effects (Levilactobacillus brevis 59, Lactiplantibacillus pentosus 129, and Limosilactobacillus fermentum 263) on the target Colletotrichum species were incorporated into SA coatings. These strains had viable counts of > 6 log CFU/mL in SA coatings during 15 days of room temperature storage. Application of coatings with SA + L. brevis 59, SA + L. pentosus 129, and SA + L. fermentum 263 delayed the development and decreased the severity of anthracnose lesions in guava and mango artificially contaminated with either of the tested Colletotrichum species. These coatings impacted positively on some physicochemical parameters indicative of postharvest quality and more prolonged storability of guava and mango. The formulated SA coatings loaded with tested fruit-derived potentially probiotic LAB strains could be innovative and effective strategies to control postharvest anthracnose and extend the storability of guava and mango.
Collapse
Affiliation(s)
- Karina Felix Dias Fernandes
- Laboratory of Food Microbiology, Department of Nutrition, Health Sciences Center, Federal University of Paraíba, Campus I, Cidade Universitária, João Pessoa, Paraíba, 58051-900, Brazil
| | - Kataryne Árabe Rimá de Oliveira
- Laboratory of Food Microbiology, Department of Nutrition, Health Sciences Center, Federal University of Paraíba, Campus I, Cidade Universitária, João Pessoa, Paraíba, 58051-900, Brazil
| | - Evandro Leite de Souza
- Laboratory of Food Microbiology, Department of Nutrition, Health Sciences Center, Federal University of Paraíba, Campus I, Cidade Universitária, João Pessoa, Paraíba, 58051-900, Brazil.
| |
Collapse
|
18
|
Jokar A, Barzegar H, Maftoon Azad N, Shahamirian M. Effects of cinnamon essential oil and Persian gum on preservation of pomegranate arils. Food Sci Nutr 2021; 9:2585-2596. [PMID: 34026074 PMCID: PMC8116839 DOI: 10.1002/fsn3.2213] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/18/2020] [Revised: 02/10/2021] [Accepted: 02/19/2021] [Indexed: 01/05/2023] Open
Abstract
Given the high perishability of pomegranate arils, edible antimicrobial coating will enhance their shelf life and maintain their marketability. An antimicrobial coating was prepared using 1% (w/v) soluble part of Persian gum (PG) and different concentrations (0.25%, 0.50%, and 0.75% (v/v)) of cinnamon essential oil (CEO) to extend the shelf life of pomegranate arils. Microbiological, chemical, physical, and sensorial characteristics of coated and uncoated samples were evaluated at 7-day intervals. Total anthocyanin (TAN), titrable acidity (TA), and ascorbic acid showed a decreasing trend, during the whole period of the storage. TAN, TA, and ascorbic acid decreased from 119.8 to 44.5 mg/L, 1.6% to 1.37%, and 682 to 140 mg/L, respectively. Firmness increased during the storage time, while total soluble solids (TSS, around 17.4 °Brix) and total phenolic compounds (TP, around 14.21 mg/100 ml) showed no significant changes with CEO concentrations. Coatings containing 0.5% and 0.75% CEO significantly prevented fungal growth on the samples at least for 3 weeks and 3 months, respectively. Optimization proved that 1-week cold storage and 0.43% CEO could dramatically meet 80% of the research targets including maximum nutritional quality and freshness, as well preventing microbial spoilage. It was concluded that coating the pomegranate arils by PG and selecting an appropriate concentration of the CEO could considerably increase shelf life, marketability, and nutritional quality of pomegranate arils at a suitable and acceptable level.
Collapse
Affiliation(s)
- Akbar Jokar
- Agricultural Engineering Research Department, Fars Agricultural and Natural Resources Research and Education CenterAgricultural Research, Education and Extension Organization (AREEO)ShirazIran
| | - Hasan Barzegar
- Agricultural Sciences and Natural Resources University of KhuzestanMollasaniIran
| | - Neda Maftoon Azad
- Agricultural Engineering Research Department, Fars Agricultural and Natural Resources Research and Education CenterAgricultural Research, Education and Extension Organization (AREEO)ShirazIran
| | - Maryam Shahamirian
- Agricultural Engineering Research Department, Fars Agricultural and Natural Resources Research and Education CenterAgricultural Research, Education and Extension Organization (AREEO)ShirazIran
| |
Collapse
|
19
|
Adiletta G, Di Matteo M, Petriccione M. Multifunctional Role of Chitosan Edible Coatings on Antioxidant Systems in Fruit Crops: A Review. Int J Mol Sci 2021; 22:2633. [PMID: 33807862 PMCID: PMC7961546 DOI: 10.3390/ijms22052633] [Citation(s) in RCA: 21] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/27/2021] [Accepted: 03/02/2021] [Indexed: 12/02/2022] Open
Abstract
Chitosan-based edible coatings represent an eco-friendly and biologically safe preservative tool to reduce qualitative decay of fresh and ready-to-eat fruits during post-harvest life due to their lack of toxicity, biodegradability, film-forming properties, and antimicrobial actions. Chitosan-based coatings modulate or control oxidative stress maintaining in different manner the appropriate balance of reactive oxygen species (ROS) in fruit cells, by the interplay of pathways and enzymes involved in ROS production and the scavenging mechanisms which essentially constitute the basic ROS cycle. This review is carried out with the aim to provide comprehensive and updated over-view of the state of the art related to the effects of chitosan-based edible coatings on anti-oxidant systems, enzymatic and non-enzymatic, evaluating the induced oxidative damages during storage in whole and ready-to-eat fruits. All these aspects are broadly reviewed in this review, with particular emphasis on the literature published during the last five years.
Collapse
Affiliation(s)
- Giuseppina Adiletta
- Department of Industrial Engineering, University of Salerno, Via Giovanni Paolo II, 84084 Fisciano, Italy; (G.A.); (M.D.M.)
| | - Marisa Di Matteo
- Department of Industrial Engineering, University of Salerno, Via Giovanni Paolo II, 84084 Fisciano, Italy; (G.A.); (M.D.M.)
| | - Milena Petriccione
- CREA-Centre for Olive, Fruit and Citrus Crops, Via Torrino 3, 81100 Caserta, Italy
| |
Collapse
|